ChemTEB Classification Datasets
Collection
Chemical Classification Datasets for Evaluating Text Embedding Models
•
19 items
•
Updated
text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
% Wt: <0.1
OSHA PEL: C 0.1 MG(CRO3)/M3
ACGIH TLV: 0.5 MG(CR)/M3, A4
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
GUIDELINES ARE BASED ON FEDERAL REGS &
-----------------------------
PLEASE CONSULT LOCAL ENVIRONMENTAL
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EYE CONTACT, SKIN CONTACT, SKIN ABSORP: NO EFFECTS
ANTICIPATED. INGESTION: PRACTICALLY NON-TOXIC. INHALATION: NO EFFECTS
ANTICIPATED. POTASSIUM DICHROMATE: CARCINOGEN. EXPERMENTAL MUTAGEN. EXPE
RIMENTAL TERATOGEN. CAUSES BURNS. OXIDIZER. TOXIC. MAY CAUSE ALLERGIC
REACTION. CHRONIC EFFECTS: NO EFTS ANTICIPATED.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: NONE REQUIRED. REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
CALL PHYSICIAN IF IRRITATION DEVELOPS. SKIN CONTACT: WA SH WITH PLENTY OF
WATER. INGESTION: GIVE 1-2 GLASSES OF WATER. CALL PHYSICIAN IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: ONLY PERSONS PROPERLY QUALIFIED TO RESPOND TO EMER
GUIDELINES/PROC. DIKE SPILL TO CNTN MATL FOR LATER DISP.(SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
OF MATL IN E.P.A. APPRVD HAZ WASTE FACILITY. EMPTY CNTNRS: RINSE 3 TIMES
W/APPROP SOLV. DISPOSE OF EMPTY CNTNR AS NORM TRASH. RINSATE FROM EMPTY
CNTNRS IS HAZ WASTE & SHOULD BE DISPOSED
Handling And Storage Precautions: KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN
USE.
Other Precautions: AVOID CONTACT WITH EYES. WASH THOROUGHLY AFTER HANDLING.
MAINTAIN GENERAL INDUSTRIAL HYGIENE PRACTICES WHEN USING THIS PRODUCT.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: USE MDEDIA APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). EVACUATE AREA AND FIGHT FIRE FROM A SAFE DISTANCE.
Unusual Fire/Explosion Hazard: THIS PRODUCT WILL NOT BURN OR EXPLODE.
*
*
Respiratory Protection: ADEQUATE VENTILATION. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: MAINTAIN GENERAL HYGIENE PRACTICES WHEN USING THIS PRODUCT.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: KEEP AWAY FROM: EYES. WASH THOROUGHLY AFTER HANDLING.
CR+6. SPILL PROC: RELEASES OF MATL MAY CONTAMINATE ENVIRONMENT. ABSORB
SPILLED LIQ W/NON-REACTIVE SORBENT MATL. PLACE MATL IN PLASTIC BAG. DISPOSE
OF MATL IN E.P.A. APPRVD HAZ WASTE FACILITY. DECONTMINATED AREA W/BLEACH
SOLN. EVACUATE AS NEEDED TO PERFORM SPILL CLEAN-UP.
*
Physical/Chemical Properties
*
PH: 4.9
Solubility in Water: MISCIBLE
Appearance and Odor: CLEAR AMBER LIQUID. NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: STABLE WHEN STORED UNDER PROPER CONDITIONS.
EXTREME TEMPERATURES.
Materials To Avoid: NONE REPORTED.
Hazardous Decomposition Products: NO HAZARDOUS DECOMPOSITION PRODUCTS KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: HACH COMPANY
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INGESTION: PRACTICALLY NON-TOXIC. POTASSIUM
DICHROMATE: CARCINOGEN. EXPERMENTAL MUTAGEN. EXPERIMENTAL TERATOGEN. CAUSES
BURNS. OXIDIZER. TOXIC. MAY CAUSE ALLERGIC REACTION. CHRONIC: CANCER HAZA RD.
CONTAINS POTASSIUM DICHROMATE WHICHLISTED AS A HUMAN LUNG CARCINOGEN (FP N).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR RECOMMENDED/APPROVED FOR ORGANIC
VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBSERVE
OSHA REGULATIONS FOR RESPIRATOR USE. IF TLV CAN BE MAINTAINED &
DOCUMENTED BELOW PEL/TLV, O THER OSHA/NIOSH RESPIRATOR MAY BE USED.
Ventilation:PROVIDE EXHAUST VENT TO KEEP EXPOSURE BELOW PEL/TLV. REMOVE
ALL IGNITION SOURCES (HEAT, SPARKS, FLAME, HOT SURFACES).
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: 5%
Ingred Name:ANTISETTLING AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTI-FLOAT AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <5%
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.1 MG/M3
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE; VAPORS IRRITATING TO EYES,
NOSE, THROAT. INHALATION: HEADACHES, DIZZINESS, STAGGERING,
CONFUSION, DIFFICULT BREATHING, UNCONSCIOUSNESS, COMA. VOMITING MAY
CAUSE ASPIRATION RESULTING IN CHEMICAL PNEUMONITIS. SKIN:
IRRITATION (SWELLING, REDNESS, RASH). EYES: IRRITATING (TEARING,
REDNESS, SWELLING W/STINGING.
Effects of Overexposure:CHRONIC; PROLONGED CONTACT WILL CAUSE DRYING
AND CRACKING OF THE SKIN DUE TO DEFATTING ACTION. SKIN
SENSITIZATION, ASTHMA OR OTHER ALLERGIC REACTIONS MAY DEVELOP.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO AREA FREE FROM RISK OF FURTHER EXPOSURE.
RESTORE BREATHING. GET MED AID. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AFFECTED AREA THOROUGHLY WITH SOAP & WATER. WASH CONTAMINATED
CLOT HING BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER (LOW
INDUCE VOMITING. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS PERSON. GET
MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNRS CLSD. KEEP FROM HEAT,
IGNITION SOURCE. CLOSED CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT
SRFCS REQ SPECIAL CAUTIONS. DECOMP PRODUCTS MAY BE HEALTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY WITH OSHA
SOURCES. STORE IN CLOSED CNTNRS IN VENTED AREA.
Other Precautions:KEEP CNTNRS TIGHT & UPRIGHT (PREVENT LEAK). PREVENT
PROLONGED BREATHING. PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC
REACTION. AVOID CONTACT W/SKIN & EYES. DONT INGEST. DONT HANDLE
UNTIL MFR PRECAUTIONS READ/UNDERSTOOD. SMOKE IN SMOKING AREAS
* Physical/Chemical Properties *
Vapor Density:> AIR
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY LIQUID WITH SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURES: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:HIGH TEMPERATURES, SPARKS, OR OPEN
FLAMES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS MUST BE
HANDLED WITH CARE DUE TO PRODUCT RESIDUE & FLAMMABLE VAPOR. DONT
IGNITABLE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR IF EXPOSED
TO PARTICULATE MATTER. USE A NIOSH/MSHA APPROVED RESPIRATOR FOR
PROTECTION AGAINST TOXIC GASEOUS IGNITION BYPRODUCTS.
Ventilation:GENERAL MECHANICAL: MODERATE FLOW FOR PARTICULATE/IGNITION
BYPRODUCT REMOVAL. EXPLOSION PROOF EQUIPMENT IS REQUIRED.
FULL-BODY COVERALLS, CONDUCTIVE SHOES, SAFETY
SHOWER/EYEWASH/LAUNDRY FACILITIES
Supplemental Safety and Health
SPILL CONT': LARGE: SOIL-REMOVE ALL CONTAMINATED SOIL, DISPOSE OF AS
HAZARDOUS WASTE. WATER: FLUSH W/COPIOUS AMOUNTS OF WATER. COLLECT
TO DISPOSE OF AS HAZARDOUS WASTE.
* Product Identification *
Preparer's Name:JOEL GEVING
* Composition/Information on Ingredients *
Ingred Name:LEAD AZIDE
Fraction by Wt: <1%
Ingred Name:ZIRCONIUM
Fraction by Wt: <1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:POTASSIUM PERCHLORATE
Fraction by Wt: <1%
Ingred Name:GRAPHITE
Fraction by Wt: <0.1%
Other REC Limits:2.5MG/CUM
ACGIH TLV:2 MG/CUM RESP IC
Ingred Name:1,1-DIFLUOROETHENE, TETRAFLUOROETHENE,
1,1,2,3,3,3-HEXAFLUORO-1-PROPANE POLYMER
Fraction by Wt: <0.1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IF PRODUCT SEAL RUPTURES,
MAY CAUSE IRRITATION. INHALATION: RESPIRATORY IRRITANT. INGESTION:
POISONOUS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY DISEASES
SUCH AS EMPHYSEMA, ASTHMA.
* First Aid Measures *
First Aid:EYES: IF EXPOSED TO FRAGMENTATION, BANDAGE EYES. IGNITION
MINS. SKIN: WASH OFF ANY RESIDUE W/SOAP & WATER. INHALATION: REMOVE
TO FRE SH AIR. GIVE CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES. NOTE TO PHYSICIAN: USE SUPPORTIVE CARE.
TREATMENT SHOULD BE BASED ON JUDGEMENT OF PHYSICIAN & REACTIONS OF
THE PATIENT.
* Fire Fighting Measures *
Extinguishing Media:PERMANENTLY-INSTALLED: AUTOMATIC WATER
SPRINKLER/DELUGE SYSTEM IS RECOMMENDED.
Fire Fighting Procedures:DON'T ATTEMPT TO MANUALLY FIGHT FIRES.
IMMEDIATELY EVACUATE AREA, USING AS MUCH PROTECTIVE COVER AS
POSSIBLE & ACTIVATE DELUGE & ALARM SYSTEMS.
Unusual Fire/Explosion Hazard:SENSITIVE TO SHOCK/IMPACT/FRICTION/STATIC
DISCHARGE/HIGH PRESSURE/TEMP. MAY DEFLAGRATE/DETONATE IF EXPOSED
RELEASING TOXIC FUMES/HEAT/SHOCK WAVES & FRAGMENTS.
* Accidental Release Measures *
Spill Release Procedures:SMALL: IF SEAL RUPTURES, BARRICADE AREA,
ELIMINATE IGNITION SOURCES. USE A SOFT BRISTLE BRUSH & A CONDUCTIVE
RUBBER PAN/RUBBER SHOVEL TO CLEAN UP. USE CONDUCTIVE CONTAINERS &
GROUND ALL CONTAINERS WHE N TRANSFERRING MATERIAL. (SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:STORE IN APPROVED STORAGE MAGAZINES
ONLY. STORAGE & HANDLING MUST CONFORM TO APPROPRIATE
QUANTITY/DISTANCE REQUIREMENTS, BARRICADING/GROUNDING/LIMITS.
Other Precautions:KEEP PRODUCT COOL & DRY IN STORAGE. HANDLING & USE OF
EXPLOSIVES & RELATED DANGEROUS MATERIALS MUST BE LIMITED TO
PERSONNEL AUTHORIZED/TRAINED IN THIS AREA. REFER TO ON INSTRUCTIONS
TO HANDLING, STORA GE, USE & DISPOSAL OF EXPLOSIVES.
* Physical/Chemical Properties *
Spec Gravity:>1
Solubility in Water:<0.1%
Appearance and Odor:METALLIC ORDNANCE HARDWARE; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OTHER HAZARDOUS MATERIALS
Stability Condition to Avoid:SHOCK, IMPACT, FRICTION, ELECTROSTATIC
DISCHARGE, HIGH PRESSURE, HIGH TEMPS, OPEN FLAME, CHEMICAL/PHYSICAL
CONTAMINATION
Hazardous Decomposition Products:LEAD, ZIRCONIUM & FLUORINE COMPOUNDS,
HYDROGEN FLUORIDE GAS, POTASSIUM CHLORIDE
* Disposal Considerations *
Waste Disposal Methods:EXPLOSIVES/DANGEROUS MATERIAL SHOULD BE
DESTROYED BY OPEN BURNING/OPEN DETONATION IN AN APPROVED
INCINERATOR. BY CHEMICAL TREATMENT/DESTRUCTION. CONTAMINATED
PROPERTY MUST NOT BE BURIED. DISPOSE OF IA W/LOCAL, STATE & FEDERAL
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ANY NIOSH APPROVED AIR-SUPPLIED RESPIRATOR OR
SELF-CONTAINED BREATHING APPARATUS. ONLY NIOSH APPROVED EQUIPMENT
SHOULD BE USED.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER.
IMPERVIOUS APRONS, BOOTS & FSHLD (5-INCH MINIMUM) WHERE SPLASHING
CAN OCCUR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: INCL DIZZINESS, VISUAL IMPAIRMENT, NAUSEA, RESPIRATORY
FAILURE, MUSCULAR INCOORDINATION & NARCOSIS. PRLNGD/RPTD SKIN
CONTACT MAY CAUSE DERMATITIS, ERYTHMA, SCALING & POSSIBLY SYSTEMIC
COUGH, OTHER CHANGES TO LUNGS, THROAT OR RESPIRATION.
* Product Identification *
Product ID:AIRBRAKE ANTIFREEZE, HDAABA
CAGE:0KDB2
CAGE:0KDB2
* Composition/Information on Ingredients *
Fraction by Wt: 1-3%
OSHA PEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:FIRST AID PROC: SKIN: REMOVE CONTAM CLTHG. WASH AFFECTED
AREA W/SOAP & WATER; APPLY SKIN LOTIONS. IF SKIN IRRIT (ING 5)
Ingred Name:ING 4: PERSISTS, GET MED ATTN.
Ingred Name:SPILL PROC: SUITABLE COMBUST CHAMBER. SPILLS IN SENSITIVE
AREAS MAY BE DILUTED & FLUSHED TO GROUND W/WATER SPRAY.(ING 7)
Ingred Name:ING 6: DO NOT FLUSH TO SEWER OR OTHER CONFINED SPACE.
ENVIRONMENTAL RESPONSE, COMPENSATION & LIABILITY ACT. WARN (ING 9)
Ingred Name:ING 8: OCCUPANTS OF DOWNWIND AREAS.
Ingred Name:WASTE DISP METH: RECLAIM VIA FILTRATION & DISTILLATION
WASTE.
Ingred Name:HNDLG/STOR PRECS: OF VAPOR OR CONTACT W/SKIN. AVOID CONTACT
OF HEAT, OPEN FLAME & IGNITION.
Ingred Name:VENT: CONTROLS MUST BE SPARKPROOF & EXPLOSION PROOF.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:METHANOL IS A POISONOUS, NARCOTIC
CHEMICAL THAT CAN AFFECT BODY THRU INHALATION, INGESTION & PERHAPS
PRLNGD/RPTD SKIN CONTACT. ABSORPTION BY INHALATION OR INGESTION IS
RAPID & EXCRETION IS MUCH SLOWER THAN FOR ETHYL ALCOHOL, RESULTING
IN DELAYED EFFECT OR COMPOUNDING OF EFFECTS BY RPTD EXPOS. IT IS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IMPORTANT TO BE AWARE THAT AFTER
INGESTION OR INHALATION, INITIAL SYMPTOMS MAY BE ONLY THAT OF MILD
ARE EXERTED UPON THE CNS , ESPECIALLY THE OPTIC NERVE. INGESTIONCAN
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: GET MED ATTN IMMED. INDUCE VOMITING WITH 1 TABLESPOON
OF IPECAC OR BY TOUCHING BACK OF THROAT (ONLY IF CONSCIOUS). ONCE
VOMIT HAS OCCURRED, HAVE PATIENT DRINK MILK, WATER OR SOLN OF
SODIUM BIC ARBONATE IN WATER (1 HEAPING TEASPOON PER QUART). INHAL:
REMOVE VICTIM TO FRESH AIR AT ONCE. RESTORE &/OR SUPPORT BRTHG AS
REQUIRED. KEEP VICTIM WARM & AT REST. GET MED ATTN AS SOON AS POSS.
(ING 4)
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:6%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM AND
WATER MIST OR FOG. USE A BLANKETING EFFECT TO SMOTHER FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE EXPLOSION HAZARD AND DANGEROUS
FIRE HAZARD WHEN EXPOSED TO HEAT, SPARKS OR FLAMES AND CAN REACT
VIGOROUSLY WITH OXIDIZING AGENTS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNIT SOURCES. PROVIDE ADEQ VENT.
SMALL QTYS MAY BE ABSORBED ON PAPER TOWELS. EVAP IN SAFE PLACE
(SUCH AS FUME HOOD). BURN PAPER IN APPRVD INCINERATOR OR OPEN PIT
AWAY FROM BLDGS & PEOPLE. LARGE QTYS CAN BE COLLECTED & ATOMIZED
IN (ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:GROUND & ELECTRICALLY INTERCONNECT
CNTNRS FOR TRANSFER. USE SPARKPROOF TOOLS. NO SMOKING IN AREAS OF
Other Precautions:PROVIDE PREPLACEMENT MEDICAL EXAMS FOR INDUSTRIALLY
EXPOSED WORKERS W/EMPHASIS ON NEUROLOGICAL & VISUAL FUNCTIONS,
LIVER & KIDNEY SYSTEMS. PROVIDE SUITABLE TRAINING TO THOSE WORKING
W/METHANOL. MONITO R THE WORKPLACE. KEEP RECORDS.
* Physical/Chemical Properties *
Vapor Density:1.1
Evaporation Rate & Reference:5.9 (BUTYL ACETATE=1)
Solubility in Water:TOTALLY MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH A CHARACTERISTIC
PUNGENT, ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRATES, PERCHLORATES OR SULFURIC
ACID.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, OXIDIZING
CONDITIONS.
Hazardous Decomposition Products:TOXIC GASES AND VAPORS (IE, CARBON
MONOXIDE, FORMALDEHYDE) MAY BE RELEASED IN A METHANOL FIRE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FED, STATE & LOCAL REGS .
ABSORB IN VERMICULITE, DRY SAND, EARTH OR SIMILAR MATL & DISPOSE IN
APPRVD SANITARY LANDFILL. ATOMIZE IN SUITABLE COMBUST CHAMBER;
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
SOLUTION)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
ALCOHOLS)
% Wt: < 5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: < 5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MATERIAL CAN BE IRRITATING TO EYES. SKIN: CAN BE
IRRITATING TO THE SKIN. INGEST: MAY BE IRRITATING TO THE GASTROINTESTINAL
TRACT. INHAL: VAPORS MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
IRRIT PERSISTS, SEE A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, SEEK A PHYSICIAN. INGEST: DO NOT INDUCE VOMI TING. GIVE
AT LEAST 2 GLASSES OF WATER AND SEEK MEDICAL ATTENTION. INHAL: REMOVE TO
FRESH AIR. IF SYMPTOMS PERSISTS, SEEK MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: MOP/WIPE UP AND FLUSH AREA WITH WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: IN ACCORDANCE WITH FEDERAL, EPA, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: ROOM TEMPERATURE STORAGE. PROTECT FROM
FREEZING.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE TO BOILING
Extinguishing Media: EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FPN).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NORMAL ROOM VENTILATION.
Other Protective Equipment: RUBBER APRON.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
B.V.
*
Physical/Chemical Properties
*
PH: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: GREEN LIQUID WITH MILD ODOR.
Percent Volatiles by Volume: SUPDAT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: ACIDS AND OXIDIZING AGENTS.
Hazardous Decomposition Products: NONE KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
*
Detail DOT Information
*
DOT PSN Code: XXX
*
Detail IMO Information
*
IMO PSN Code: XXX
*
Detail IATA Information
*
IATA PSN Code: XXX
*
Detail AFI Information
*
AFI PSN Code: XXX
*
HAZCOM Label
*
Assigned IND: Y
Company Name: L & R MANUFACTURING COMPANY
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: Moderate
Hazard And Precautions: ACUTE:EYES:MATERIAL CAN BE IRRITATING TO EYES. SKIN:CAN
BE IRRITATING TO THE SKIN. INGEST:MAY BE IRRITATING TO THE GI TRACT.
INHAL:VAPORS MAY CAUSE IRRITATION. CHRONIC:NONE SPECIFIED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNDER NORMAL USE-NOT REQUIRED. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:ONLY NEEDED IF PRODUCT IS HEATED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHLORINATED PARAFFIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMATES
Fraction by Wt: <6.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ANTIMONY (SARA III)
Fraction by Wt: <1%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:MOLYBDENUM
Fraction by Wt: <1.6%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY PRODUCE MILD TRANSIENT
IRRITATION. SKIN:MAY PRODUCE MILD IRRITATION WHICH IS READILY
REVERSIBLE. ACUTE:MAY PRODUCE MILD REVERSIBLE SKIN AND EYE
IRRITATION. CHRONIC:SLIGHT HAZARD TO THOSE CHRON ICALLY EXPOSED TO
REPRO HAZARDS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SEEK CONSULTATION FROM APPROP HLTH
PROFS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS RECS .
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MD. SKIN:WASH EXPOSED AREAS WELL WITH SOAP & WATER. INHAL:UNDER
FIRE CONDITIONS, MOVE PERSON TO FRESH AIR. IF NECESSARY,
RESUSCITATE AND ADM INISTER OXYGEN. SEE MD. INGEST:SEE MD. DO NOT
INDUCE VOMITING.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:AT VERY HIGH TEMPERATURES, HYDROGEN
CHLORIDE GAS IS RELEASED.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL TO PREVENT DISCHARGE TO STREAMS
OR SEWER SYSTEMS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BRIGHT ORANGE PASTE WITH CHARACTERISTIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS PROMOTE DECOMPOSITION.
HYDROGEN CHLORIDE GAS.
Hazardous Decomposition Products:HYDROGEN CHLORIDE GAS.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED FUME OR AIR SUPPLIED
RESPIRATOR WHEN WELDING.
Ventilation:LOCAL.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CAVITIES. ANIMAL:PULM FIBROSIS (BLOOD EFTS). EYE PROT: FACESHIELD
W/PROT LENS .
* Product Identification *
Product ID:PREMIUM TICONIUM WIRE
* Composition/Information on Ingredients *
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
OSHA PEL:0.1 MG/M3
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TUNGSTEN
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:1 MG/M3/3 STEL
Fraction by Wt: 1.5%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:SHORT-TERM OVEREXPOSURE TO
WELDING FUMES MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
OR DRYNESS OR IRRITATION OF NOSE, THROAT, OR EYES.
Explanation of Carcinogenicity:NICKEL CMPDS:IARC MONO ON EVAL OF CARCIN
RPT (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY BE CAUSE OF
DERMATITIS OR ALLERGIES. AGGRAVATION OF PREEXISTING RESPIRATORY
ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH W/POTABLE
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . INHAL:REMOVE
VICTIM FROM WELDING AREA, ADMINISTER FIRST AID AND OBTAIN PROMPT
MEDICAL ATTENTION. IF UNCONSCIOUS, ADMINISTER OXYGEN. IF NOT
BREATHING, BEGIN RESUSCITATION IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:NOT APPLICABLE. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:IN SOLID FORM THIS MATERIAL POSES NO SPECIAL
CLEAN-UP PROBLEMS. REMOVE DUST BY VACUUMING OR WET SWEEPING TO
AVOID AIR CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Spec Gravity:7-9 (H*2O=1)
Solubility in Water:INSOLUBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS & STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:VARIOUS ELEMENTAL METAL OXIDES MAY BE
GENERATED FROM WELDING.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OUTDOORS: APPROVED PARTICULATE FILTER TO REMOVE
ANY AIRBORNE OVERSPRAY. IN RESTRICTED AREAS W/POOR VENTILATION &
CLOSE TO THE TLV USE A NIOSH APPROVED RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE.
Ventilation:ADEQUATE TO KEEP BELOW TLV
Other Protective Equipment:EYE WASH FOUNTAIN, SAFETY SHOWER, IMPERVIOUS
APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:PWC POLYURETHANE AEROSOL COLORS
* Composition/Information on Ingredients *
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE)
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
Ingred Name:PROPANE
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
Ingred Name:BUTANE, N-BUTANE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC, RESPIRATORY
TRACT IRRITATION, NERVOUS SYSTEM DEPRESSION, POSSIBLE
UNCONSCIOUSNESS. SKIN: PRIMARY IRRITANT, DERMATITIS. EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA,
POSSIBLE UNCONSCIOUSNESS. EYES/SKIN: BURNING SENSATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHINGIF
NECESSARY. SKIN: WASH AFFECTED AREA. REMOVE CONTAMINATED CLOTHING.
CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.7%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT WATER
SPRAY MAY BE USED TO COOL CONTAINERS EXPOSED TO HEAR/FIRE TO
PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
BUILD UP OF PRESSURE FROM EXTREME HEAT/FIRE. AEROSOL SPRAY IS
EXTREMELY FLAMMABLE. FLAMMABLE LIQUID
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA & SOAK
UP W/INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.
*Handling and Storage *
NEAR HEAT, SPARKS OR FLAME.
Other Precautions:AVOID CONTACT W/EYES, SKIN & BREATHING OF VAPORS.
DON'T TAKE INTERNALLY. DON'T SMOKE WHILE USING THIS PRODUCT. DUST
FORM SANDING THE DRY PAINT FILMS SHOULD BE TREATED AS A NUISANCE.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:0.7
Evaporation Rate & Reference:FASTER THAN N-BU AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID W/SOLVENT BASED ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, EXTREME HEAT OR OTHER
SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, & POSSIBLY
TRACES OF PHOSGENE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. FLAMMABLE
LIQUID
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED FULL-FACEPIECE
AIRLINE RESPIRATOR IN THE POSITIVE PRESSURE MODE W/EMERGENCY ESCAPE
PROVISIONS.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PEL.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:3-CHLOROBENZYL CHLORIDE
* Hazards Identification *
Health Hazards Acute and Chronic:LACHRYMATOR.
Effects of Overexposure:LACHRYMATOR.
* First Aid Measures *
VOMITING. RINSE MOUTH & THEN GIVE TO DRINK 2-4 CUPFULS OF WATER.
INHALA TION: REMOVE TO FRESH AIR IMMEDIATELY. OBTAIN MEDICAL
ATTENTION IN ALL CASES. NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:DON'T USE WATER DIRECTLY ON FIRE. USE FOAM, DRY
CHEMICAL/CO2
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
ABSORB W/INERT MATERIAL; DRY SAND/EARTH, THEN PLACE INTO A CHEMICAL
WASTE CONTAINER.
*Handling and Storage *
Other Precautions:PREVENT SKIN EXPOSURE.
* Physical/Chemical Properties *
Solubility in Water:IMMISCIBLE
Appearance and Odor:CLEAR, COLORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, AMINES, OXIDIZING AGENTS, ALCOHOLS, STEEL
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:US DOT SHIPPING NAME: CHLOROBENZYLCHLORIDES UN
* Regulatory Information *
INVENTORY.
AQUATIC ORGANISMS; MAY CAUSE LON G-TERM ADVERSE EFFECTS IN THE
W/EYES, RINSE IMMEDIATELY W/PLENTY OF WATER & SEEK MEDICAL ADVICE.
RELEASE TO TH E ENVIRONMENT. REFER TO SPECIAL INSTRUCTIONS/SAFETY
DATA SHEETS.
* Other Information *
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
% Wt: 0.1-1
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
------------------------------
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
% Wt: 1-5
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
(TEXANOL)
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
(BUTYL ACRYLATE-METHYL METHACRYLATE POLYMER)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
-----------------------------
WATER OR FOAM MAY CAUSE FROTHING OR ERUPTION.
-----------------------------
BROMINE PENTAFLUORIDE.
-----------------------------
LAB TESTS RSLTS HAVE SHOWN ETHYLENE
-----------------------------
CAUSE MECH IRRIT OF EYES, SKIN & RESP TRACT.
-----------------------------
RINSE WATER OUT OF SEWERS & WATER COURSES.
-----------------------------
PROPERLY.
-----------------------------
AS DIRECTED UNDER SPECIAL PROTECTION INFO.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:IRRIT OF RESP TRACT. PRLNG INHAL MAY LEAD TO MUC
MEMB IRRIT, DROW, DIZZ &/OR LT HEAD, HDCH, GI DISTURBS, COUGH, APATHY,
CNS DEPRESS, ANESTH EFT/NARCOS, BLOOD ABNORMS, KIDNEY DMG, PNEUMOCONIOSIS,
LOSS OF CONSCIOUSNESS. SKIN CONT:IRRIT. CONT MAY RSLT IN DERMAL ABSORPTION OF
COMPONENT(S) OF THIS (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZ:PROD WHICH MAY CAUSE APATHY. EYE
CONT:IRRIT. INGEST:MAY CAUSE DIZZ &/OR LT HEAD, HDCH, VOMIT, GI DISTURBS,
SEV ABDOM PAIN, APATHY, CNS DEPRESS, RESP PROBS, INTOX, LIVER DMG, KIDNEY
DMG, PULM EDEMA, LOSS OF CONSCIOUSNESS, ACUTE POIS, RESP FAILURE, CARDIAC
FAILURE, BRAIN DMG, DEATH. OTHER EFTS OF OVEREXP
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS, KIDNEY
DISORDERS.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERS GIVE OXYG IF NEC. GET MED HELP FOR ANY
BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSES EYE WATERING , HDCHS,
DIZZ/OTHER DISCOMFORT. GET MEDATTN IF DISCOMFORT/IRRIT PERSISTS. SKIN:FLUSH
W/WATER. THEN WASH THORO W/SOAP & WATER. REMOVE & WASH CONTAM CLTHG
BEFORE RE-USE. IF IRRIT OCCURS, (SUPDAT)
*
Handling and Disposal
*
Spill Release Procedures: COMPLY W/ALL APPLIC HLTH & ENVIRON REGS. ELIM ALL
SOURCES OF IGNIT. VENT AREA. EVACUATE ALL UNNEC PERS. PLACE COLLECTED MATL IN
PROPER CNTNR. LG SPILLS:SHUT OFF LEAK IF SAFE TO DO SO. DIKE & CONTAIN S
PILL. PUMP TO STORAGE/SALVAGE VESSELS. USE
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DISPOSE I/A/W ALL APPLICABLE REGULATIONS. AVOID DISCHARGE
TO NATURAL WATERS.
& OPEN FLAME. KEEP FROM FREEZING. USE ONLY W/ADEQ VENT. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH RSLT IN
FORM OF INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING (SANDING) PAINTED
SURFS. IF SUCH CNDTNS CANNOT BE
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL, FOAM, WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL LONG DISTS TO
SOURCE OF IGNIT & FLASH BACK. CLSD CNTNRS MAY BURST IF EXPOS TO EXTREME
HEAT/FIRE. MAY DECOMPOSE UNDER FIRE
*
*
Respiratory Protection: WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). IMPERVIOUS CLOTHING.
Work Hygienic Practices: WASH HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO:SATIN HOUSE PAINT UH
EATMENT. INGEST:OBTAIN MED TREATMENT IMMEDIATELY.
*
Physical/Chemical Properties
*
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT W/OXIDIZING AGENT,
ALUMINUM OR ZINC, STORAGE NEAR ACIDS, FREEZING, SPARKS, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, REDUCING AGENTS, ALUMINUM, ZINC,
HYPOCHLORITES, HYDRAZIDES, HALOGENATED CMPDS, MAGNESIUM,
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXYGEN,
TOXIC GASES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: ICI PAINTS/GLIDDEN PAINT CO
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHAL:IRRIT OF RESP TRACT. PROLONGED
INHAL MAY LEAD TO MUCOUS MEMBRANE IRRIT, DROWSINESS, DIZZINESS &/OR LT
HEAD, HDCH, GI DISTURBANCES, COUGHING, APATHY, CNS DEPRESSION, ANESTHETIC
EFFECT OR NARCOSIS, BLOOD ABNORMS, KIDNEY DAMAGE, PNEUMOCONIOSIS, LOSS OF
CONSCIOUSNESS. SKIN CONT:IRRITATION. CONTACT MAY RESULT IN DERMAL ABSORPTION
OF COMPONENT(S) OF THIS PRODUCT WHICH MAY CAUSE APATHY. EYES:IRRITATION.
INGESTION:SEVERE PAIN, CENTRAL NERVOUS SYSTEM DEPRESSION, POISONING, BRAIN,
LIVER, KIDNEY DAMAGE, HEART FAILURE, DEATH. CHRONIC:CANCER HAZARD. CONTAINS
CARBON BLACK WHICH IS L ISTED AS AN ANIMAL LUNG CARCINOGEN (FP N).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
Product ID:CE PROCESS BLACK PREMIX TONER
* Composition/Information on Ingredients *
Fraction by Wt: <5%
Ingred Name:CARBON BLACK
Fraction by Wt: <5%
OSHA PEL:3.5 MG/M3
* Hazards Identification *
Effects of Overexposure:SKIN,EYES:MILD IRRIT;INGEST:RESP.DISTRESS &
CENTRAL NERVOUS DEPRESSION;INHAL:RESP.ARREST,HEART ARYTH
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RMV CONTAM CLTHG & SHOES. INGEST:DO NOT INDUCE
VOMIT. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
CONTR.
Unusual Fire/Explosion Hazard:DO NOT STORE WITH STRONG OXIDANTS
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES, RECOVER FREE LIQUID
WITH VERMICULITE, SAWDUST, ETC.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. AVOID
STORING/HANDLING NEAR HEAT,STRONG LIGHT,SPARKS,OPEN FLAMES,STRONG
OXIDANTS.
Other Precautions:AVOID BREATHING VAPORS AND PROLONGED OR REPEATED SKIN
CONTACT.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:IMM
Vapor Density:5.0
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID, SLIGHT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:IGNITION SOURCES,HIGH TEMPERATURES
Hazardous Decomposition Products:CO,CO*2
* Disposal Considerations *
Waste Disposal Methods:APPROVED DISPOSAL SITE I/A/W FEDERAL,STATE,LOCAL
REGULATIONS
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED FOR FUMES & GASES
Ventilation:ADEQUATE
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE, ESPECIALLY
BEFORE EATING, DRINKING OR SMOKING
Supplemental Safety and Health
* Product Identification *
CAGE:0AES5
CAGE:0AES5
* Composition/Information on Ingredients *
Ingred Name:TIN (AS SN)
Fraction by Wt: 0-3%
OSHA PEL:2.0 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:SILVER
Fraction by Wt: 0-0.7%
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
Ingred Name:ZINC
Ingred Name:IRON
Fraction by Wt: 0-1.5%
Ingred Name:MANGANESE, MN COMPOUNDS
Fraction by Wt: 0-1.5%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
Ingred Name:SILICON
Fraction by Wt: 0-3.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: METAL FUME FEVER, FATIGUE,
DRYNESS OF THROAT, FEVER, HEAD & BODY ACHE, CHILL, CENTRAL NERVOUS
SYSTEM LEADING TO EMOTIONAL DISTURBANCES, GAIT, BALANCE
DIFFICULTIES & PARALYSIS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:COPPER: SKIN & HAIR DISCOLORATION. NICKEL:
CANCER CAUSING. SILVER: GREYISH-BLUE DISCOLORATION OF THE SKIN.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:NEVER USE WATER. WATER WILL REACT VIOLENTLY W/ANY
MOLTEN METAL
Unusual Fire/Explosion Hazard:THE ALLOY IS STABLE, NONHAZARDOUS SOLID
AT ROOM TEMPERATURES
* Accidental Release Measures *
Spill Release Procedures:NON-HAZARDOUS MATERIAL. SCRAP METAL CAN BE
RECLAIMED FOR REUSE.
*Handling and Storage *
Handling and Storage Precautions:WET MATERIAL SHOULD NEVER BE CHARGED
INTO A MOLTEN BATH.
* Physical/Chemical Properties *
Spec Gravity:8.3-8.5
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER OR YELLOW TO RED SOLID AT ROOM TEMPERATURE &
EXHIBITS NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, BASES, OR OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE POSITIVE PRESSURE AIR LINE W/MASK/SCBA
SHOULD BE AVAILABLE FOR EMERGENCY USE.
Ventilation:LOCAL EXHAUST TO PREVENT ACCUMULATION OF > CONCENTRATIONS
Other Protective Equipment:SAFETY SHOES.
Supplemental Safety and Health
NEON IS NONCORROSIVE & MAY BE USED W/ANY COMMON STRUCTURAL MATERIAL.
DON'T DRAG, SLIDE/ROLL CYLINDERS. USE A SUITABLE HAND TRUCK FOR
CYLINDER MOVEMENT. DON'T HEAT CYLINDER TO INCREASE THE DISCHARGE RA
TE OF PRODUCT FROM CYLINDER. USE A CHECK VALVE/TRAP IN DISCHARGE
LINE TO PREVENT HAZARDOUS BACK FLOW INTO THE CYLINDER.
* Product Identification *
Product ID:NEON
* Composition/Information on Ingredients *
Ingred Name:NEON
ACGIH TLV:SIMPLE ASPHYXIANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NEON IS NONTOXIC, A LARGE AMOUNT IN A
CONFINED AREA COULD DISPLACE THE AMOUNT OF OXYGEN IN AIR NECESSARY
TO SUPPORT LIFE. NEON IS DEFINED AS A SIMPLE ASHYXIANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ASPHYXIANT, HEADACHE, DIZZINESS, LABORED
BREATHING, UNCONSCIOUSNESS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF CONSCIOUS, GIVE MOUTH TO
MOUTH/OXYGEN IF NEEDED. TREATMENT SHOULD BE SYMPTOMATIC &
SUPPORTIVE. OBTAIN MEDICAL ATTENTION IN ALL CASES. PROMPT MEDICAL
ATTENTION IS MA NDATORY IN ALL CASES OF OVEREXPOSURE TONEON.
* Fire Fighting Measures *
Fire Fighting Procedures:RESCUE PERSONNEL SHOULD BE EQUIPPED W/SCBA.
Unusual Fire/Explosion Hazard:NONFLAMMABLE, INERT GAS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE PERSONNEL FROM AREA. USE APPROPRIATE
PROTECTIVE EQUIPMENT. IF LEAK IS IN CONTAINER/CONTAINER VALVE,
CONTACT YOUR LOCAL SUPPLIER LOCATION.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTILATED
AREA AWAY FROM HEAVILY TRAFFICKED AREAS & EMERGENCY EXITS. PROTECT
CYLINDERS FROM PHYSICAL DAMAGE.
Other Precautions:DON'T ALLOW THE TEMP WHERE CYLINDERS ARE STORED TO
PREVENT FALLING/BEING KNOCKED OVER. FULL & EMPTY CYLINDERS SHOULD
BE SEGREGATED. (SEE SUPP)
* Physical/Chemical Properties *
Spec Gravity:0.7
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS GAS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DON'T ATTEMPT TO DISPOSE OF WASTE/UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY LABELED W/ANY
VALVE OUTLET PLUGS/CAPS SECURED & PROTECTION CAP IN PLACE TO YOUR
SUPPLIER IAW/FEDERAL, STA TE & LOCAL REGULATIONS. NONFLAMMABLE GAS
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS IF VAPOR
CONCENTRATIONS EXCEED PERMISSIBLE EXPOSURE LIMITS.
Ventilation:USE LOC EXHST/DILUTION VENT AS REQUIRED TO CONTROL VAP
CONCS BELOW PERMISSIBLE EXPOSURE LIMITS. MECH EXHST IF(SUPP DATA)
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH SKIN AND CLOTHING THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC:SHOULD BE USED FOR COOLING ONLY. FIRST AID PROC:
WITHOUT MED ADVICE AS ASPIR CAN CAUSE ASPHY. TETRAHYDROFURAN CAN BE
ABSORBED WITH AN ACTIVATED CHARCOAL SLURRY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. VENT: REQUIRED. SHOULD BE REMOVED
FROM THE VAP CONC OR BE OF AN EXPLO PROOF DESIGN.
* Product Identification *
Product ID:PURPLE PRIMER
* Composition/Information on Ingredients *
Ingred Name:ACETONE (SARA III)
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III)
Ingred Name:FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: SEVERE IRRIT & DISCOMFORT.
OVEREXP TO THE LIQ MAY CAUSE EYE CORROSION WITH CORNEA OR
CONJUCTIVAL ULCERATION. SKIN: MODERATE IRRITATION & DISCOMFORT
POSSIBLE. DEFATTING, REDNESS & CHEMICAL DERMATITIS POSSIBLE.
RECURRENT OVEREXP MAY CAUSE TOXIC SYSTEMIC EFTS. INHAL: NAUS, HDCH,
DIZZ, IMPAIRED(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: COORDINATION. SEVERE OVEREXP MAY
CAUSE LOSS OF CONSCIOUSNESS & RESPIRATORY TRACT IRRIT. TOXIC
SYSTEMIC EFFECTS ARE POSSIBLE W/RECURRENT OVEREXPOSURE. INGEST:
IRRIT & DISCOMFORT IS POSSIBLE.
Medical Cond Aggravated by Exposure:NO DATA FOUND.
* First Aid Measures *
First Aid:EYE: REMOVE CONTACT LENSES IF APPROP. FLUSH W/PLENTY OF WATER
WITH MILD SOAP AND WATER. GET MED ATTN IF IRRIT DEVELOPS OR
PERSISTS. INH AL: REMOVE TO FRESH AIR. IF UNCON, GIVEOXYGEN. IF NOT
BRTHG, APPLY ARTF RESP. GET IMMED MED ATTN. INGEST: GIVE 1-2
GLASSES OF WATER TO DILUTE & GET IMMED MED ATTN. DO NOT INDUCE
VOMIT (SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2%
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CO2, WATER FOG. USE
WATER SPRAY FOR COOLING EXPOSED CONTAINERS.
Fire Fighting Procedures:EVAC AREA. FIRE FIGHTERS SHOULD WEAR NIOSH/
MSHA APPROVED SCBA AND FULL PROT EQUIP . WATER IN A STRAIGHT HOSE
STREAM MAY CAUSE FIRE TO SPREAD & (SUPP DATA
Unusual Fire/Explosion Hazard:FUMES ARE HEAVIER THAN AIR AND MAY TRAVEL
ALONG THE GROUND TO IGNITION SOURCES.
* Accidental Release Measures *
Spill Release Procedures:AVOID CONTACT WITH LIQUID & VAPORS. EXTING ALL
POSSIBLE SOURCES OF IGNITION. VENTILATE AREA. SOAK UP ON ABSORBENT
MATERIAL FOR DISPOSAL. FLUSH SMALL SPILLS WITH LARGE AMOUNTS OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:GOOD GENERAL VENT SHOULD BE PROVIDED
TO KEEP VAP CONCS BELOW FLAMM & EXPOSURE LIMITS. KEEP FROM HEAT,
SPARKS & FLAME.
Other Precautions:KEEP CNTNRS TIGHTLY CLSD WHEN NOT IN USE. STORE IN A
COOL, DRY, VENT AREA AWAY FROM IGNIT SOURCES. DO NOT STORE
W/OXIDIZING AGENTS. DO NOT INGEST. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN.
* Physical/Chemical Properties *
HCC:F2
Evaporation Rate & Reference:9.9 (BUTYL ACETATE=1)
Appearance and Odor:PURPLE LIQUID WITH ODOR OF KETONES.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:PEROXIDES MAY FORM UPON AGING. DO NOT
DISTILL TO DRYNESS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE AND VARIOUS HYDROCARBONS FROM INCOMPLETE
COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. IF PERMITS AND REGULATIONS ALLOWED, MAY BE
INCINERATED, ALLOWED TO EVAPORATE OR DEEP WELL INJECTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUBSTRATE (CYLINDER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM
Ingred Name:COATING
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ARSENIC SELENIDE
ACGIH TLV:0.2 MG/M3 MFR
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE PRODUCT HAS BEEN EXTENSIVELY
TESTED AND EVALUATED BY KONICA CORPORATION. WHEN USED AS INTENDED,
IT DOES NOT REPRESENT ANY KNOWN HEATH OR SAFETY HAZARD. PRODUCTS OF
COMBUSTION ARE TOXIC. AVOID BREA THING SMOKE. ALL INORGANIC ARSENIC
COMPOUNDS ARE CLASSIFIED AS A CARCINOGEN BY OSHA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WITH WATER FOR
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WHEN IN A MACHINE, TREAT AS ELECTRICAL FIRE
AND DO NOT USE WATER OR FOAM.
Unusual Fire/Explosion Hazard:EXPOSURE TO HIGH TEMPERATURES CAN RESULT
IN MELTING AND PYROLYSIS. FUMES MAY CAUSE RESPIRATORY SYMPTOMS.
* Accidental Release Measures *
Spill Release Procedures:PARTICLES OF COATING DETACHED THROUGH PHYSICAL
DAMAGE MUST BE COLLECTED AND DISPOSED OF AS A CHEMICAL WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE WET PUMICING AND POLISHING
PROCEDURES. AVOID EXPOSURE TO HIGH TEMPERATURES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SUPP DATA
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:N/A (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GLASSY BLACK FILM IS COATED ON METALLIC CYLINDER.
AND ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND ALKALIS.
Hazardous Decomposition Products:OXIDES OF SELENIUM AND ARSENIC. (THE
OXIDES ARE TOXIC.)
* Disposal Considerations *
Waste Disposal Methods:MAY USED/DMGD PHOTORECEPTOR BE DISP BY SPECIAL
TREATING TRADER. UNDER PRESENT EPA REGS, IT IS NOT CLASSIFIED AS A
HAZ WASTE. HOWEVER, DISP IN A CHEM WASTE LANDFILL IS RECOMMENDED.
INSURE CONFORMITY WI TH FEDERAL, STATE OR LOCAL REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAP/PARTICULATE RESP APPRVD BY NIOSH FOR PROT AGAINST MATLS LISTED
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
OF BARRIER CREAM ON EXPOSED SKIN IS RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: HEAVY DUTY MARINE & INDUSTRIAL COATING. FIRE
FIGHT PROC: CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO
WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ: SURFS REQS SPECIAL PREC S.
DURING EMER CNDTNS OVEREXP TO DECOMPPRODS MAY CAUSE HEALTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 3%
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT
AROMATIC HYDROCARBONS) VP: 3.8
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
Fraction by Wt: 4%
Fraction by Wt: 7%
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (EPOXY POLYMER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WASTE DISP METH: FEDERAL, STATE & LOCAL REGULATIONS
REGARDING POLLUTION.
Ingred Name:HNDLG/STOR PRECS: DO NOT SMOKE - EXTINGUISH ALL FLAMES,
Ingred Name:ING 9: APPLIANCES & ANY OTHER SOURCES OF IGNITION. CONSULT
Ingred Name:OTHER PRECS: USE ONLY W/ADEQ VENTILATION. AVOID BRTHG VAPOR
(RESPIRABLE FRACTION).
Ingred Name:RESP PROT: ABRADING, BURNING OR WELDING DRIED FILM, WEAR A
SECTION.
Ingred Name:VENT: MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS. REFER TO
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRIT OF EYES, SKIN & RESP SYS. MAY
CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON & POSS
DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF EXCESS
EXPOS TO VAP/SPRAY MISTS. REDN ESS & ITCH OR BURNING SENSATION MAY
INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC: PRLNGD OVEREXP TO SOLVS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: LISTED IN INGRED SECTION MAY CAUSE
ADVERSE EFTS TO LIVER, URINARY & REPRO SYS. RPTS HAVE ASSOC RPTD &
PRLNGD OVEREXP TO SOLVS W/PERM BRAIN & NERVOUS SYS DMG. WARNING:
CONTAINS CHEMS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER &
BIRTH DEFECTS OR OTHER REPRO HARM.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION IN
SUSCEPTIBLE PERSONS.
* First Aid Measures *
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE RE-USE. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
ATTENTION.
* Fire Fighting Measures *
Lower Limits:0.7%
Upper Limits:7.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE
PREFERABLE. WATER MAY BE USED TO COOL CLSD (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT & OPEN FLAME. VAPS
WILL ACCUMULATE & MAY IGNITE EXPLOSIVELY. DURING USE & UNTIL VAPS
ARE GONE: KEEP AREA VENTILATED - (ING 9)
Other Precautions:THESE PRODS MUST BE MIXED WELL W/OTHER COMPONENTS
BEFORE USE. BEFORE OPENING THE PACKAGES, READ & FOLLOW WARNING
LABELS ON ALL COMPONENTS. INTENTIONAL MISUSE BY DELIBERATELY
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF NITROGEN, OXIDES OF METALS LISTED IN INGREDIENT
SECTION.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZ AS DEFINED
DETERMINE THE APPLICABLE EPA HAZ WASTE NUMBER. INCINERATE IN APPRVD
FACILITY. DO NOT INC INERATE CLOSED CNTNR. DISPOSE OF I/A/W (ING 8)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:GENERAL DILUTION.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: IMMEDIATELY. INHAL: REMOVE TO FRESH AIR. SUPPORT
* Product Identification *
Kit Part:Y
Preparer's Name:HENRY B CASTANEDA
* Composition/Information on Ingredients *
Ingred Name:NITRIC ACID (SARA III)
Fraction by Wt: 3.4%
OSHA PEL:2 PPM/4 STEL
Ingred Name:SODIUM DIHYDROGEN PHOSPHATE
Fraction by Wt: 4.6%
Ingred Name:DEIONIZED WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY CAUSE DERMATITIS. EYE: MAY
CAUSE CONJUNCTIVITIS. INGEST: PAIN IN THE MOUTH, THROAT AND
STOMACH. MAY BE FOLLOWED BY VOMITING. ROUTE OF ENTRY: EYE, MUCOUS
MEMBRANE, AND SKIN IRRITANT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: WASH AFFECTED AREAS W/SOAP/MILD DETERGENT & LG AMTS OF
WATER. EYE: FLUSH CONTINUOUSLY W/COPIOUS AMTS OF WATER FOR AT LEAST
LID TISS. GET MD IMMED. INGEST: IF VICTIM IS CONSCIOUS & NOT
CONVULSIVE, IMMED GIVE LG QTYS OF WATER. DO NOT ATTEMPT TO INDUCE
SUPP DATA)
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:KEEP COMBUST AWAY FROM SPILLED MATERIAL. DO
NOT TOUCH SPILLED MATERIAL. TAKE UP WITH SAND OR OTHER ABSORBENT
MATERIAL AND PLACE IN SMALL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
BREATHING (GIVE O*2/ARTF RESP) .
* Physical/Chemical Properties *
HCC:C1
Spec Gravity:1.0
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID WITH NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN OR NEAR A FIRE, MATERIAL MAY EMIT
NO*X AS GASES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF BY MEANS AS TO COMPLY WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LICENSED
DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR W/AN ORGANIC VAPOR
CARTRIDGE/CANISTER WHERE AIRBORNE CONCENTRATIONS EXCEED EXPOSURE
LIMITS. USE A POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR FOR
UNCONTROLLED RELEASES/WHERE EXPOSURE LEVELS ARE UNKNOWN/WHERE AIR
PURIFYING RESPIRATORS MAY NOT GIVE ADEQUATE PROTECTION.
Ventilation:PROCESS ENCLOSURES, LOCAL EXHAUST/OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE
LIMITS. OPEN DOORS & WINDOWS.
LIQUIDS.
Work Hygienic Practices:WASH THOROUGHLY W/SOAP & WATER BEFORE EATING,
DRINKING/SMOKING. REFER TO SAFETY SUPERVISOR/INDUSTRIAL HYGIENIST
FOR FURTHER INFORMATION REGARDING PERSONAL PROTECTIVE EQUIPMENT &
ITS APPLICATION.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT
Ingred Name:TITANIUM DIOXIDE
Ingred Name:1,2,4-TRIMETHYLBENZENE
< Wt:5.
Ingred Name:1,3,5-TRIMETHYLBENZENE
< Wt:5.
Ingred Name:XYLENE
< Wt:5.
Ingred Name:COBALT DRIER
< Wt:1.
Ingred Name:ETHYLBENZENE
< Wt:1.
Ingred Name:ALKYD RESIN
> Wt:3.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INHALATION: HARMFUL, MAY BE IRRITATING TO EYES & RESPIRATORY TRACT.
INGESTION: HARMFUL IF SWALLOWED. ASPIRATION HAZARD; CAN ENTER LUNGS
& CAUSE DAMAGE. REPEATED/PROLON GED OVEREXPOSURE TO SOLVENTS MAY
CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. MAY CAUSE LIVER &
CARDIAC ABNORMALITIES.
Effects of Overexposure:IRRITATION
* First Aid Measures *
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: DON'T INDUCE VOMITING/GIVE ANYTHING BY MOUTH
BECAUSE THI S MATERIAL CAN ENTER THE LUNGS & CAUSE SEVERE LUNG
DAMAGE. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:0.9
Upper Limits:6.6
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT BUILDUP & POSSIBLE AUTOIGNITION/EXPLOSION. EVACUATE AREA &
FIGHT FIRE FROM A SAFE DISTANCE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN LIQUID W/SAND/EARTH. DON'T USE
COMBUSTIBLE MATERIALS SUCH AS SAWDUST. DON'T ALLOW TO ENTER STORM
DRAINS/SEWER SYSTEMS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN AFTER
CONTAINER IS EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUE. AVOID
BREATHING VAPOR/MIST. AVOID CONTACT W/EYES.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID W/SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG ALKALIES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, ELECTRICAL
EQUIPMENT, & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:BY OPEN FLAME: CO, CO2
* Ecological Information *
Ecological:PRODUCT IS A MIXTURE OF LISTED COMPONENTS.
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:NO TRANSPORTATION INFORMATION IS AVAILABLE.
* Regulatory Information *
SARA Title III Information:THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO
CONSIDERED, UNDER APPLICABLE DE FINITIONS, TO MEET THE FOLLOWING
CATEGORIES: IMMEDIATE HEALTH HAZARD, CHRONIC HEALTH HAZARD, FIRE
Federal Regulatory Information:OSHA: HAZARDOUS BY DEFINITION OF HAZARD
State Regulatory Information:NEW JERSEY RIGHT-TO-KNOW: THE FOLLOWING
MATERIALS ARE NON-HAZARDOUS, BUT ARE AMONG THE TOP FIVE COMPONENTS
IN THIS PRODUCT: ALKYD RESIN. PENNSYLVANIA RIGHT-TO-KNOW: THE
FOLLOWING NON-HAZARDOUS INGREDI ENTS ARE PRESENT IN THE PRODUCT AT
GREATER THAN 3%: ALKYD RESIN.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
USE NIOSH/MSHA APPROVED RESPIRATOR IF CONCENTRATION OF VAPOR IS
EXTREME.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
MAINTAIN EXPOSURE LEVELS BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER. NOTE:MERCURY COMPOUNDS(PHENYLMERCURIC
ACETATE) APPEARS ON THE NAVY LISTING OF OCCUP REPRO HAZ. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERN LATEST HAZ LIST
INFO AND SAFE HANDLING & EXPOSURE RECOMMENDATIONS .
* Product Identification *
Product ID:LATEX ENAMEL UNDERCOAT
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: 3%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MERCURY, (ACETATO) PHENYL; (PHENYLMERCURIC ACETATE)
ACGIH TLV:0.1 MG/M3 (MFR)
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
Fraction by Wt: 0.9%
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Ingred Name:AMMONIA (SARA III)
Ingred Name:FORMALDEHYDE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES, SKIN, MUCOUS
MEMBRANE, RESPIRATORY TRACT: MAY PRODUCE SYMPTOMS OF HEADACHE,
NAUSEA IN POORLY VENTILATED AREA. INGESTION CAUSES DRUNKENNESS,
PASSING TO COMA W/SEVERE OR FATAL KIDNEY INJURY. ANIMAL STUDIES
CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS,
HEMATOPOIETIC (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TISSUES, BLOOD, KIDNEYS AND THE
LIVER, ASSOCIATED WITH THE ADMINISTRATION OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUBLICATION
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
PERSISTS, CONSULT MD. SKIN: WASH THOROUGHLY WITH SOAP & WATER.
REMOVE CONTAMINATED CLOTHING & WASH BEFORE RE-USE. INHAL: REMOVE TO
FRESH A IR. INGEST: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. IF
CONSCIOUS, INDUCE VOMITING. CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD UP OF PRESSURE) WHEN EXPOSED TO THE EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN AND REMOVE WITH INERT ABSORBENT. AVOID
BREATHING VAPORS. VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Other Precautions:FORMALDEHYDE IS AN ANIMAL CARCINOGEN; HOWEVER,
OBJECTIVE DATA INDICATES THAT UNDER TYPICAL CONDITIONS OF USE FOR
THIS PRODUCT, THE TLV OF 1 PPM WILL NOT BE EXCEEDED.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:>1
Evaporation Rate & Reference:SLOWER/N-BUTYL ACETATE
Solubility in Water:DILUTABLE
Appearance and Odor:WHITE COLORED LIQUID WITH AMMONIACAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE IN CLOSED CONTAINERS. ABSORB LARGE SPILLS WITH SAND,
CLAY, OR DIATOMACEOUS EARTH.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH APPROVED SELF-
CONTAINED BREATHING APPARATUS IF TLV IS EXCEEDED OR WHEN
SPRAYING/MISTING OR USING IN CONFINED SPACES.
Ventilation:GENERAL
Other Protective Equipment:WORKCLOTHES, BOOTS, EYEWASH.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE WHILE WORKING WITH
THIS PRODUCT.
Supplemental Safety and Health
MFR IS OUT OF BUSINESS AND IS UNLISTED. INFORMATION PRESENTED HEREIN IS
ACCURATE AND RELIABLE TO THE BEST OF OUR KNOWLEDGE AND BELIEF BUT
IS NOT GUARANTEED TO BE SO. IT IS THE USER'S RESPONSIBILITY TO
TAKE ALL SAFETY PRECAUTIONS.
* Product Identification *
Preparer's Name:DSCR-VBA
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, HYDROTREATED (MILD), HEAVY NAPHTHENIC
DISTILLATE, PETROLEUM
Other REC Limits:5 MG/M3 OIL MIST
Ingred Name:ADDITIVES
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INGESTION:LOW TOXICITY. MAY
CAUSE GI TRACT IRRITATION. INHALATION:INHALATION OF
MIST/VAPORS/FUMES MAY CAUSE RESPIRATORY TRACT IRRITATION. SMALL
AMOUNT ASPIRATED INTO LUNGS MAY CAUSE CHEMICAL PNE UMONITIS.
EYE:IRRITATION. SKIN:REPEATEDCONTACT MAY CAUSE IRRITATION.
CHRONIC:DERMATITIS, OIL ACNE OR FOLLICULITIS.
Effects of Overexposure:IRRITATION OF EYES, SKIN, COUGHING, NAUSEA,
DIARRHEA, VOMITING.
Medical Cond Aggravated by Exposure:SKIN ALLERGIES.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION:GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. KEEP HEAD DOWN DURING
VOMITING.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICALS, CARBON DIOXIDE, WATER
SPRAY(FOG) . WATER STREAM MAY NOT BE EFFECTIVE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR PROTECTIVE CLOTHING
AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL: WIPE UP WITH RAGS OR ABSORB WITH
INERT MEDIA. LARGE SPILLS: EVACUATE AREA. WEAR PROTECTIVE
EQUIPMENT. VENTILATE AREA. DIKE TO RETAIN FLUID. PUMP UP FREE
LIQUID. WASH RESIDUE WITH SOAP ANDWATER. DO NOT FLUSH TO SEWER OR
WATERWAYS.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORAGE-STORE IN A DRY AREA AWAY FROM
OXIDIZERS AND OPEN FLAMES.
Other Precautions:DO NOT CREATE OR INHALE MIST. AVOID OVEREXPOSURE.
EMPTY CONTAINERS RETAIN RESIDUE. DO NOT PRESSURIZE, CUT, WELD OR
EXPOSE TO HEAT, FLAME, STATIC ELECTRICITY, OR OTHER SOURCES OF
IGNITION; THEY MAY EXP LODE AND CAUSE INJURY.
* Physical/Chemical Properties *
HCC:V6
Boiling Pt:B.P. Text:NOT KNOWN
Evaporation Rate & Reference:>1 (BU ACETATE=1)
Solubility in Water:NEGIGIBLE
Appearance and Odor:OILY LIQUID, BLAND ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAMES, SOURCES OF IGNTION.
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE,
ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN DUSTY ATMOSPHERES, USE AN APPROVED DUST
RESPIRATOR.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST
CONDITIONS. LOCAL EXHAUST: NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:CLEAN, LONG-SLEEVED, BODY-COVERING CLOTHING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM (SARA III)
Fraction by Wt: 6.5%
Ingred Name:ZINC (SARA III)
Fraction by Wt: 1%
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:MAGNESIUM
Fraction by Wt: BALANCE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MECHANICAL INJURY. INHALATION:
DUST MAY CAUSE IRRITATION TO UPPER RESPIRATORY TRACT, SHAVER'S
DISEASE, WEAKNESS, FATIGUE, RESPIRATORY DISTRESS, FIBROSIS, DUST
MAY CAUSE CENTRAL NERVOUS SYSTEM &DEVELOPMENTAL EFFECTS.
INGESTION: SERIOUS INJURY & DEATH. EYES: MECHANICAL INJURY &
DISCOMFORT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: MECHANICAL INJURY. INHALATION: DUST MAY
CAUSE IRRITATION TO UPPER RESPIRATORY TRACT, SHAVER'S DISEASE,
WEAKNESS, FATIGUE, RESPIRATORY DISTRESS, FIBROSIS, DUST MAY CAUSE
CENTRAL NERVOUS SYSTEM & DEVELOPMENTAL EFFECTS. INGESTION: SERIOUS
INJURY & DEATH. EYES: MECHANICAL INJURY & DISCOMFORT.
* First Aid Measures *
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 5 MINS. SKIN: WASH OFF DUST
IN FLOWING WATER/SHOWER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: INDUCE VOMITING, IF LARGE AMOUNTS OF DUST ARE INGESTED.
OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN: NO
SPECIFIC ANTIDOTE FOR DUST INHALATION. SUPPORTIVE CARE. TREATMENT
BASED ON PHYSICIAN IN RESPONSE TO REACTIONS OF THE PATIENT.
* Fire Fighting Measures *
Extinguishing Media:AN EXTINGUISHING POWDER APPROVED FOR USE ON
MAGNESIUM FIRE SUCH AS G1, MET-L-X. CONSULT NFPA FOR OTHER TYPES OF
MEDIA.
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS.
MAGNESIUM ALLOYS IGNITE/BURN W/A WHITE FLAME. USE OF WATER ON
BURNING MAGNESIUM WILL PRODUCE HYDROGEN GAS/CAUSE EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:CLEAN OFF & USE.
*Handling and Storage *
Handling and Storage Precautions:PRACTICE REASONABLE CARE IN HANDLING
MAGNESIUM & MAGNESIUM ALLOY PRODUCTS FORMS TO AVOID PRODUCT DAMAGE
OR PERSONAL INJURY. STORE IN DRY LOCATION.
Other Precautions:WET, MOIST, OR HIGH HUMIDITY STORAGE MAY LEAD TO
CORROSION OF THE PRODUCT. STORE AWAY FROM OTHER COMBUSTIBLE
MATERIALS. PREVENT DUST CLOUDS AROUND OPERATIONS SUCH AS WHEN
MACHINING. STORE DUST/POWDER/ CHIPS/TURNINGS ACCORDING TO NFPA
REGS.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:SILVER SOLID, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACID & WATER.
Stability Condition to Avoid:HEAT, WETNESS, MOISTURE, & HIGH HUMIDITY.
Hazardous Decomposition Products:HYDROGEN GAS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIM BY VENT, WEAR A NIOSH/MSHA APPRVD PROPERLY FITTED ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS. WHEN SAND/ABRADING
DRIED FILM, WEAR NIOSH/MSH A APPRVD DUST/MIST RESP FOR (ING 5)
Ventilation:LOC EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO MATLS
IS MAINTAINED BELOW APPLIC EXPOS LIM. REFER TO OSHA (ING 6)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIGHT PROC: CONTRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLOS
WHEN EXPOS TO EXTREME HEAT. OTHER PREC: WHICH MAY BE PRESENT @ HAZ
LEVELS ONLY DURING SAND/ABRADING OF DRIED FILM. IF NO SPEC DUSTS
ARE LISTED, APPLIC LIM FOR NUISANCE DUST ARE (ING 4)
* Product Identification *
Product ID:STYLE PERFECT SEMI-GLOSS LATEX ENAMEL PURE
* Composition/Information on Ingredients *
Ingred Name:ETHANOL,2-(2-BUTOXYETHOXY). VP: 0.1
Fraction by Wt: 0-5%
Ingred Name:ETHYLENE GLYCOL. VP: 0.1
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
(TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
Ingred Name:RESP PROT: DUST WHICH MAY BE GENERATED FROM THIS PRODUCT,
UNDERLYING PAINT, OR THE ABRASIVE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES/SKIN & UPPER RESP
SYS. IN A CONFINED AREA VAPS IN HIGH CONC MAY CAUSE HDCH/NAUS/DIZZ.
CHRONIC: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL TERATOGEN. IT HAS
BEEN SHOWN TO CAUSE BIRTH D EFECTS IN RATS & MICE @ HIGH DOSES
WHENGIVEN IN DRINKING WATER/BY GAVAGE. THERE IS NO EVIDENCE TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INDICATE IT CAUSES BIRTH DEFECTS IN
HUMANS. PROLNGD OVEREXP TO SOLV INGRED MAY CAUSE ADVERSE EFTS TO
DEVELOPED LUNG CANCER, HOWEVER , SUCH EXPOS LEVELS ARE NOT
ATTAINABLE IN WORKPLACE. RED & ITCH OR BURNING SENSATION MAY
INDICATE EYE/EXCESS SKIN EXPOS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN: WASH AFFECTED AREA THORO WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH WITH
INGEST: CALL MD IMMED .
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR CLSD WHEN NOT IN USE.
TRANSFER ONLY TO APPRVD CONTRS W/COMPLETE & APPROP LBLG. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST.
AVOID CONT W/SKIN/EYES. COATING MAY CNTN MATLS CLASSIFIED AS
NUISANCE PARTICULATES, SUCH AS TITANIUM DIOXIDE OR CALCIUM
CARBONATE (SEE ACGIH TLV LIS T, PREFACE & APPENDIX D), (SUPP DATA)
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER RESOURCE CONSERVATION AND RECOVERY ACT (RCRA)
DISPOSE OF I/A/W FED, ST, & LOC REG S REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR DUST IF PEL IS
EXCEEDED.
Ventilation:ADEQ VENT SHOULD BE PROVIDED AT POINTS WHERE PROD IS HNDLD.
SKIN CONT SHOULD BE MINIMIZED THRU PROCESS DESIGN (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Product ID:CARBON FIBER, F3(C)
* Composition/Information on Ingredients *
Ingred Name:CARBON; (CARBON FIBERS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYMERS, UNSPECIFIED; (POLYMER SIZING TYPE
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN HANDLING AND FABRICATING
CARBON FIBER PRODUCTS, POTENTIAL MINOR RISK TO HEALTH IS ASSOCIATED
WITH: 1) BREATHING, OR INHALING OF CARBON FIBER DUST PARTICLES. 2)
IRRITATION OF THE SKIN (RASH) O R OTHER EXPOSED MEMBRANES BY
AIRBORNE DUST PARTICLES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:WASH WITH SOAP AND WATER.
INHAL:REMOVE TO FRESH AIR. TREAT ANY IRRITATION SYMPTOMATICALLY,
CONTACT A PH YSICIAN.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:NOT APPLICABLE. USE NIOSH APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CARBON FIBER MAY BE RELEASED IN A FIRE
SITUATION, AND THE FIBERS ARE SUFFICIENTLY CONDUCTIVE TO CAUSE
SEVERE ELECTRICAL PROBLEMS.
* Accidental Release Measures *
Spill Release Procedures:SPILLED PROD SHOULD BE PLACED IN SEALED
PLASTIC BAGS. ACTUAL CLEANUP OF SPILL SHOULD BE ACCOMPLISHED WITH
DUE REGARD TO ELECTRICALLY CONDUCTIVE NATURE OF PRODUCT.
CONTAMINATION OF ELECTRICAL EQUIPMENT SHOULD BE AVOIDED. IF A
VACUUM SYSTEM (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN MANNER WHICH REDUCES
AIRBORNE DUST.
Other Precautions:MATERIAL IS ELECTRICALLY CONDUCTIVE. ELECTRICAL
SYSTEMS SHOULD BE PROTECTED FROM EXPOSURE TO AIRBORNE FIBER.
CLEANUP, IT SHOULD BE FULLY CAPABLE OF HANDLING CONDUCTIVE MATERIAL
WITH NO RISK OF ELECTRICAL SHOCK TO THE OPERATOR. VENT:OR THE US E
* Physical/Chemical Properties *
Spec Gravity:1.8
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SUPP DATA
Appearance and Odor:RESIN-COATED BLACK FIBER IN CONTINUOUS, CHOPPED OR
MILLED FORM.
Percent Volatiles by Volume:<1(WT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
EXPOSURE TO ELECTRICAL EQUIPMENT AND CIRCUITRY. STRONG OXIDIZERS,
EXCESSIVE OR LOCALIZED HEATING.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:CARBON FIBERS ARE NOT LISTED AS HAZ WASTES NOR
DO THEY EXHIBIT ANY OF HAZ CHARACTERISTICS CONTAINED IN FEDERAL
DISPOSED IN APPRVD LANDFI LL I/A/W EXISTING FEDERAL, STATE, & LOCAL
REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PREPARED TUBED AND MYCOFLASK MEDIA - CLASSIFIED AS GENERAL
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT CONTAINS NO HAZARDOUS
MATERIALS AS DEFINED BY THE OSHA HAZARD COMMUNICATION STANDARD. IN
THE EVENT OF A SPILL/ACCIDENT INVOLVING THIS MATERIAL, GOOD
PERSONAL HYGIENE SHOULD BE PRACTICED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:THIS PRODUCT CONTAINS NO HAZARDOUS MATERIALS AS
DEFINED BY THE OSHA HAZARD COMMUNICATION STANDARD. IN THE EVENT OF
A SPILL/ACCIDENT INVOLVING THIS MATERIAL, GOOD PERSONAL HYGIENE
SHOULD BE PRACTICED.
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATERSPRAY
Fire Fighting Procedures:PRODUCT WILL NOT BURN. IF PRODUCT BECOMES
INVOLVED IN A FIRE SITUATION EXTINGUISHING MEDIA FOR SURROUNDING
MATERIAL SHOULD BE APPROPRIATE.
* Accidental Release Measures *
Spill Release Procedures:USE PAPER TOWELS TO PICK UP LIQUID &/GELLED
MATERIAL. WASH AREA W/SOAP & WATER AFTER CLEANUP IS COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE ASEPTIC TECHNIQUES &
ESTABLISHED PRECAUTIONS AGAINST MICROBIOLOGICAL HAZARDS THROUGHOUT
ALL PROCEDURES.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR TO TRACE HAZY LIQUID OF VARYING COLORS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:AFTER USE, PREPARED TUBED MEDIA, SPECIMEN
CONTAINERS & OTHER CONTAMINATED MATERIALS MUST BE STERLIZED BY
AUTOCLAVING. DIRECTIONS FOR USE SHOULD BE READ & FOLLOWED CARFULLY.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
< Wt: 1.
OSHA PEL: see Table Z-2
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: C2.6 MG/M3;C3 PPM
------------------------------
< Wt: 1.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Effects of Exposure: POLYTETRAFLUOROETHYLENE: INHALATION: MAY CAUSE PERSISTENT
PULMONARY EFFECTS IN SOME INDIVIDUALS. HYDROGEN FLUORIDE: SEVERE EYE/NOSE
& THROAT IRRITATION. PULMONARY EDEMA. OVEREXPOUSRE CAN INJURE THE L IVER
& KIDNEYS. CARBONYL FLUORIDE: IRRITATION, EYE CORROSION
W/CORNEAL/CONJUNCTIVAL ULCERATION. IRRITATION OF THE UPPER RESPIRATORY
PASSAGES/TEMPORARY LUNG IRRITATION EFFECTS.
Signs And Symptions Of Overexposure: POLYTETRAFLUOROETHYLENE: FEVER, FLU-LIKE
ILLNESS, CHILLS, COUGH. HYDROGEN FLUORIDE: CHOKING, COUGHING, IRRITATION,
FEVER, CHILLS, DIFFICULTY IN BREATHING, CYANOSIS, CARBONYL FLUORIDE:
IRRITATION, DISC OMFORT, RASH, COUGH, DIFFICULTY BREATHING, SHORTNESS OF
BREATH.
Medical Cond Aggravated By Exposure: INDIVIDUALS W/PREEXISTING DISEASES OF THE
LUNGS.
First Aid: INHALATION: REMOVE TO FRESH AIR. SKIN: IF MOLTEN POLYMER GETS ON
SKIN, COOL RAPIDLY W/COLD WATER. DON'T ATTEMPT TO PEEL POLYMER FROM SKIN.
*
Handling and Disposal
*
Spill Release Procedures: USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. SPILLED MATERIAL IS A SLIPPING HAZARD. RECOVER UNDAMAGED &
MINIMALLY CONTAMINATED MATERIAL FOR REUSE & RECLAMATION. SHOVEL/SWEEP UP.
Waste Disposal Methods: DISPOSE OF BY RECYCLING/LANDFILL. INCINERATE ONLY IF
INCINERATOR IS CAPABLE OF SCRUBBING OUT HYDROGEN FLUORIDE & OTHER ACIDIC
COMBUSTION PRODUCTS. TREATMENT, STORAGE, TRANSPORTATION & DISPOSAL MUST
BE IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED TO AVOID
CONTAMINATION. DON'T USE A TORCH TO CLEAN THIS MATERIAL FROM EQUIPMENT W/O
LOCAL EXHAUST VENTILATION & RESPIRATOR.
Other Precautions: AVOID BREATHING DUST. AVOID CONTAMINATION OF
CIGARETTES/TOBACCO W/DUST FROM THE MATERIAL.
*
Fire and Explosion Hazard Information
*
Flash Point Method: CC
Extinguishing Media: WATER, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS. WEAR FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard: HYDROGEN FLUORIDE FUMES EMITTED DURING A FIRE
HANDLING REFUSE FROM FIRE.
*
*
PURIFYING RESPIRATOR W/DUST/MIST CARTRIDGE/CANISTER MAY PROVIDE PROTECTION
FROM AIRBORNE PARTICULATES. HIGHER PROCESSING TEMPS & IF VENTILATION IS
INADEQUATE TO MAINTAIN CONCENTRATIONS BELOW EXPOSURE LIMITS, USE A POSITIVE
PRESSURE AIR SUPPLIED RESPIRATOR.
Ventilation: LOCAL EXHAUST
Other Protective Equipment: HEAT RESISTANT CLOTHING & FOOTWEAR.
Work Hygienic Practices: CLEANSING THE SKIN AFTER USE IS ADVISABLE.
Supplemental Safety and Health: REVIEW FIRE FIGHTING MEASURES & HANDLING
(PERSONNEL) SECTIONS BEFORE PROCEEDING W/CLEAN-UP.
*
Physical/Chemical Properties
*
Spec Gravity: 2.1-2.3
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE GRANULES W/NO ODOR
*
Reactivity Data
*
Stability Indicator: YES
Materials To Avoid: ALUMINUM, MAGNESIUM, POTENT OXIDIZERS LIKE FLUORINE,
CHLORINE TRIFLUORIDE
Hazardous Decomposition Products: EVOLUTION OF PARTICULATE MATTER
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
Ecological: AQUATIC TOXICITY: TOXICITY IS EXPECTED TO BE LOW BASED ON
INSOLUBILITY IN WATER.
*
*
Transport Information: NOT REGULATED.
*
Regulatory Information
*
State Regulatory Information: STATE RIGHT-TO-KNOW: NO LISTED.
*
Other Information
*
Other Information: MEDICAL USE: CAUTION: DON'T USE IN MEDICAL APPLICATIONS
INVOLVING PERMANENT IMPLANTATION IN THE HUMAN BODY. FOR OTHER MEDICAL
ERIAL SAFETY DATA SHEET RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNED HEREIN
& DOES NOT RELATE TO USE IN COMBINATION W/ANY OTHER MATERIAL/IN ANY
PROCESS.
*
HAZCOM Label
*
Assigned IND: Y
Company Name: DUPONT FLUOROPRODUCTS
Label Required IND: Y
Status Code: A
Origination Code: G
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS I N SECTION II.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION II IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
FOR PROTECTION.
Other Protective Equipment:USE ONLY WITH ADEQUATE VENTILATION. AVOID
BREATHING VAPORS AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
WASH HANDS AFTER USING.
Supplemental Safety and Health
* Product Identification *
Product ID:INVERTED MARKING PAINTS-4
Preparer's Name:ERNEST CARTER
* Composition/Information on Ingredients *
Ingred Name:PROPANE
Ingred Name:BUTANE
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM)
= Wt:7.
Ingred Name:TOLUENE
OSHA PEL:SEE TABLE Z-2
Ingred Name:ACETONE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION, AND
PERSONAL PROTECTIVE EQUIPMENT.
Effects of Overexposure:IRRITATION OF EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH. HEADACHE,
DIZZINESS, NAUSEA, AND LOSS OF CO ORDINATION ARE INDICATIONS OF
EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MISTS. REDNESS AND ITCHING OR
BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN
EXPOSURE.CHRONIC HEALTH HAZARD: NO INGREDIENT IN THESE PRODUCTS IS
AN IARC, NTP OR OSHA LISTED CARCINOGEN. PROLONGED AND REPEATED
EXPOSURE TO MAY CAUSE DAMAGE TO NERVOUS TISSUE OF THE AREAS AND
LEGS RESULTING IN MUSCULAR WEAKNESS AND LOSS OF SENSATI ON. THIS
EFFECT MAY BE IN
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE USE. IF IN EYES: FLUSH EYES WITH LARGE AMOUNTS OF
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE
VOMITING. GIVE SEVERAL GLASSES OF WATER. GET MEDICALATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE,, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SELF
CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY BE
INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. APPLICATIONS TO
HOT SURFACES REQUIRES SPEC IAL PRECAUTIONS. DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE EXTREMELY FLAMMABLE. KEEP
AWAY FROM HEAT, SPARKS, AND OPEN FLAME. VAPORS WILL ACCUMULATE
READILY AND MAY IGNITE EXPLOSIVELY. DURING USE AND UNTIL VAPORS ARE
GONE: KEEP AREA VENTILATED. D O NOT SMOKE EXTINGUISH ALL FLAMES,
PILOT LIGHTS, AND HEATERS TURN OFF STOVES, ELECTRIC TOOLS AND AP
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
AND INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. CONTENTS UNDER
PRESSURE. DO NOT PUNCTURE, INCINERATE, OR EXPOSE TO TEMPARATURE
HEAT SOURCES CAN CAUSE CONTAINERS TO BURST. TO NOT T AKE
INTERNALLY.
* Physical/Chemical Properties *
Vapor Density:HEAVIER
Evaporation Rate & Reference:FASTER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION RECOVERY ACT (RCRA) (<CFR
APPLICABLE EPA HAZARDOUS W ASTE NUMBERS. DO NOT INCINERATE.
DEPRESSURIZE CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STAT
E, AND LOCAL REGULATIONS REGARDING POLLUTION.
* Regulatory Information *
PRODUCTS
CONTAIN CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS AND
OTHER REPRODUCTIVE HARM.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN INGR EDIENT SECTION.
Ventilation:LOC EXHST PREF. GEN EXHST ACCAPTABLE IF THE EXPOS TO MATLS
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:TOUCH UP SPRAY COLORS. FIRE FIGHT PORC:POSS
AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT. EXPLO
HAZ:PREC. DURING EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE HLTH
HAZ. S YMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. EFTS OF
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 7%
Fraction by Wt: 2%
Fraction by Wt: 1%
Fraction by Wt: 8%
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (HEXONE)
Fraction by Wt: 1%
Ingred Name:ACETIC ACID,2-METHOXY-1-METHYLETHYL ESTER;
(1-METHOXY-2-PROPANOL ACETATE) VP: 1.8
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 3%
Ingred Name:SUPDAT:REPORTS HAVE ASSOCIATED REPEATED & PROLONGED
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYS DMG.
Ingred Name:WASTE DISP METH:DO NOT INCINERATE. DEPRESSURIZE CNTNR.
DISPOSE OF I/A/W/FED, STATE, & LOCAL REGS REGARDING POLLUTION.
Ingred Name:OTHER PREC:DO NOT PUNCTURE, INCINERATE/EXPOSE TO TEMP ABOVE
CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL/FATAL. (ING
VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HDCH, DIZZ, NAUSEA, & LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCHING/BURNING SENSATION MAY INDICATE
EYE/EXCESSIVE SKIN EXPOS. ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN
UNCONSCIOUSNESS & POSS DEATH. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHRONIC:PRLNG OVEREXP TO SOLV INGREDS
IN INGRED SECTION MAY CAUSE ADVERSE EFFECTS TO THE LIVER, URINARY,
BLOOD-FORMING, CVS, & REPROD SYS. METHYL ETHYL KETONE MAY INCR THE
NERVOUS SYS EFFECTS OF OTHER SOLVS. RATE EXPOSED TO TITANIUM
EXPOS (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTIONS.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . IF
H*2O IS USED, FOG NOZZLES ARE PREF. H*2O MAY BE USED TO COOL CLSD
CNTNRS TO PVNT PRESS BUILD-UP & (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, &
OPEN FLAMES. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATN TO HOT SURFS REQUIRES SPECIAL (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FRON HEAT, SPARKS, AND OPEN
FLAME. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE EXPLOSIVELY.
DURING USE AND UNTIL ALL VAPORS ARE GONE.
Other Precautions:KEEP AREA VENT-DO NOT SMOKE-EXTING ALL FLAMES, PILOT
LIGHTS, & HEATERS-TURN OFF STOVES, ELECTRIC TOOLS & APPLICANCES, &
ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING &
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZS AS DEFINED
DETERM THE APPLIC EPA HAZ WASTE NUMBER. WASTE FROM PROD CNTNG
METHYL ETHYL KETONE/COPPPE R MAY REQ TESTING FOR EXTRACTABILITY.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED.
Ventilation:REQUIRED.
Other Protective Equipment:USE BODY PROTECTION TO AVOID CONTACT
W/PRODUCT.
Supplemental Safety and Health
NK
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:SYNTHETIC HYDROCARBON RESIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:EPOXY RESIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIMETHYL BENZENE
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEPTAN-2-1
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC HYDROCARBONS
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: BRAIN/NS DAMAGE (DIZZY,
HEADACHE, NAUSEA). NOSE/THROAT IRRITATION. EYE: IRRITATION. SKIN:
ORGAN DAMAGE, IRRITATION, ALLERGIC REACTION. INGEST: FATAL, ORGAN
DAMAGE. CHRONIC: CANCER HAZARD, SILIC OSIS.
Explanation of Carcinogenicity:SILICA CRYSTALLINE IS LISTED BY IARC &
NTP.
* First Aid Measures *
MINUTES, GET MED AID. SKIN: WASH W/SOAP & WATER. REMOVE
CLOTHES/SHOES, WASH BEFORE REUSE, GET MED AID. INGEST: DONT INDUCE
VOMIT. KEEP AT R EST, GET PROMPT MED AID.
* Fire Fighting Measures *
Lower Limits:1.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:REMOVE ALL IGNITS. CLOSED CONTAINERS MAY
EXPLODE W/HIGH TEMPS. USE WATER SPRAY (FOG NOZZLES PREFERRED) TO
COOL CONTAINERS. DECOMP PRODUCTS MAY BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL W/SAND/EARTH. DONT USE
COMBUSTIBLE MATERIAL SUCH AS SAWDUST. ABSORB SPILL W/INERT
MATERIAL. PLACE IN CHEMICAL WASTE CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN COOL, VENTED AREA AWAY FROM
INCOMPATIBLE MATERIALS.*
Other Precautions:* KEEP AWAY FROM IGNITS & DIRECT SUNLIGHT.
GROUND/BOND CONTAINERS WHEN TRANSFERRING. EMPTY CNTNRS MAY BE
HAZARDOUS. READ ALL LABELS/WARNINGS.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:<ETHER
Appearance and Odor:LIGHT GRAY LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. DONT INCINERATE UNOPENED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
APPROPRIATE OSHA/MSHA APPROVED SAFETY EQUIPMENT.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC: ADMIN ARTF RESP. IF IN CARD ARREST ADMIN CPR. CONTINUE
LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS ARRIVED.
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:0.3 MG/M3, S
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS - AVOID DIRECT PHYSICAL CONTACT! CAN BE HARMFUL IF
ABSORBED THROUGH THE SKIN. CAN BE HARMFUL IF INHALED. CAN CAUSE EYE
IRRITATION. CAN CAUSE SKIN IRRITATIO N. CAN BE HARMFUL IF
SWALLOWED. CAN BE IRRITATING TO MUCOUS MEMBRANES. CAN CAUSE NERVOUS
SYSTEM INJURY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POISON.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. EYES:FLUSH CONTINUOUSLY W/WATER FOR AT
HAVE OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. INHAL: REMOVE TO
FRESH AIR. ADMIN OXYGEN IF HAVING DFCLTY BRTHG. IF BRTHG HAS
STOPPED (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. SWEEP UP AND PLACE IN AN APPROPRIATE
CONTAINER. HOLD FOR DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE
ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HANDLE THIS CHEM OR ITS CNTNR. THIS PROD IS FURNISHED FOR LAB
USE ONLY! PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES OR AS HOUSEHOLD
CHEMS.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CRYSTALLINE SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG BASES. INCOMPATIBLE WITH STRONG ACIDS.
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DECOMPOSED BY MOISTURE. AIR SENSITIVE. MAY
POLYM UPON STANDING. SENSITIVE TO LIGHT - DARK COLOR DOES NOT
AFFECT PURITY.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BURN IN A CHEMICAL INCINERATOR
EQUIPPED WITH AN AFTERBURNER AND SCRUBBER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO RESPIRATOR IS REQUIRED IF INGREDIENT EXPOSURE
DEPT. OF LABOR), AIR PURIFYING, HALF-FACE RESPIRATOR WITH THE
APPROPRIATE CARTRIDGE SHOU LD BE USED IF EXPOSURE LIMITS ARE
EXCEEDED.
Ventilation:USE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:A SAFETY SHOWER AND EYE WASH STATION SHOULD
BE WITHIN RESONABLE DISTANCE OF THE WORK AREA.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:ERNEST CARTER
* Composition/Information on Ingredients *
Ingred Name:TETRAETHYLENEPENTAMINE
Ingred Name:2,4,6-TRIS.(.(DIMETHYLAMINO)METHYL.).PHENOL
Ingred Name:.(.(DIMETHYLAMINO)METHYL.).PHENOL
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE CONTACT:SEVERELY IRRITATING. MAY
CAUSE BURNS, REDNESS, TEARING, PAIN OR DIFFICULTY SEEING. SKIN
CONTACT: MODERATELY IRRITATING. PROLONGED CONTACT MAY CAUSE BURNS.
REPEATED EXPOSURE MAY CAUSE ALLER GIC SKIN REACTIONS. ONCE AN
ALLERGY DEVELOPS, EVEN AN EXPOSURE TO A VERY SMALL AMOUNT CAN
TRIGGER AN ALLERGIC REACTION. INHALATION: MODERATELY IRRITATING TO
EYES, NOSE, THROAT AND LUNGS. REPEATED EXPO SURE MAY CAUSE AN
ALLERGIC REACTION OF THE RESPIRATORY SYSTEM. ONCE AN ALLERGY
DEVELOPS, EVEN AN EXPOSURE TO A VERY SMALL AMOUNT CAN TRIGGER AN
ALLERGIC REACTION. INGESTION: SEVERELY IRRITATING TO THE MOUTH,
THROAT AND STOMACH.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MINUTES. BLINK EYES FREQUENTYL. REPEAT FLUSHING IF BURNING OR PAIN
PERSISTS. GET IMMEDIATE MEDICAL ATTENTION. SKIN CONTACT: RINSE
IMMEDIATELY WI TH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING. IF
PROBLEMS PERSIST GET IMMEDIATE MEDICAL ATTENTION. INHALATION:
REMOVE VICTIM TO FRESH AIR. IF BREATHING IS DIFFICULT GET IMMEDIATE
MEDICAL ATTENTION . INGESTION: DO NOT INDUCE VOMITING. RINSE MOUTH
WITH WATER AND ALLOW PATIENT TO DRINK AS MUCH WATER AS DESIRED.
CONTACT A POISON CENTER OR GET PROMPT MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:USE CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
(PRESSURE DEMAND MSHA/NIOSH OR EQUIVALENE) AND FULL FIRE FIGHTING
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:HEAT IN EXCESS OF FLASHPOINT, OPEN FLAME,
OR STORAGE WITH INCOMPATIBLE MATERIALS AS LISTED IN STABILITY AND
REACTIVITY.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION AND/OR PERSONAL PROTECTIVE EQUIPMENT ABSORB SPILL WITH
INERT MATERIAL (E.G. DRY SAND OR EARTH). THEN PLACE IN A CHEMICAL
WASTE CONTAINER. PREVENT RUNOFF TO STORM SEWERS, DITCHES AND OTHER
PATHWAYS TO SOLI AND WATERWAYS.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING FUMES. DO NOT SPLASH
OR SPILL. DO NOT STORE WITH INCOMPATIBLE MATERIALS. STORE
CONTAINERS UPRIGHT. KEEP AWAY FROM HEAT AND FLAME.
* Physical/Chemical Properties *
HCC:C1
Appearance and Odor:AMBER LIQUID WITH AMINE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
* Ecological Information *
Ecological:DEXTER HAS NOT CONDUCTED SPECIFIC STUDIES ON THE ECO
TOXICITY OR ENVIRONMENTAL FATE OF THIS PRODUCT. COMMONLY AVAILABLE
DATA ON OPERATION INGREDIENTS INDICATE THAT ACUTE OR CHRONIC
EFFECTS COULD RESU LT FROM UNCONTROLLED RELEASES TO SOIL, GROUND
WATER, STORM WATERS, OR AIR. APPROPRIATE MEASURES SHOULD BE TAKEN
TO PREVENT UNCONTROLLED RELEASES. PROMPT CONTAINMENT AND CLEAN UP
SHOULD BE PERFORMED IF RELEASES DO OCCUR.
* Disposal Considerations *
Waste Disposal Methods:LEGAL DISPOSITION OF WASTES IS THE
RESPONSIBILITY OF THE OWNER/GENERATOR OF THE WASTE. APPLICABLE
FEDERAL, STATE AND/OR LOCAL REGULATIONS MUST BE FOLLOWED DURING
TREATMENT, STORAGE, OR DISPOSAL OF WAS TE CONTAINING THIS PRODUCT.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION:IRRITATION OF RESPIRATORY TRACT, LUNGS.
PROLONGED INHALATION MAY LEAD TO COUGHING, RESPIRATORY PROBLEMS. SKIN
CONTACT:IRRITATION. PROLONGED OR REPEATED CONTACT CAN CAUSE DERMATITIS. EYE
CON TACT:IRRITATION. INGESTION:MAY CAUSE NAUSEA, VOMITING, DIARRHEA,
GASTROINTESTINAL DISTURBANCES, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CENTRAL NERVOUS SYSTEM
DEPRESSION, KIDNEY DAMAGE.
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS,
ASTHMA-LIKE CONDITIONS.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERS GIVE OXYG IF NEC. GET MED HELP FOR ANY
BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSES EYE WATERING , HDCHS,
DIZZ/OTHER DISCOMFORT. SKIN:FLUSH W/WATER. THEN WASH THORO W/SOAP &
WATER. REMOVE CONTAM CLTHG. IF IRRIT OCCURS, CONSULT MD. EYES:FLUSH IMMED
W/LG AMTS OF WATER, ESP UNDER LIDS FOR AT
*
Handling and Disposal
*
Spill Release Procedures: COMPLY W/ALL APPLIC HLTH & ENVIRON REGS. ELIM ALL
SOURCES OF IGNIT. VENT AREA. EVACUATE ALL UNNEC PERS. PLACE COLLECTED MATL IN
PROPER CNTNR. LG SPILLS:SHUT OFF LEAK IF SAFE TO DO SO. DIKE & CONTAIN S
PILL. PUMP TO STORAGE/SALVAGE VESSELS. USE
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DISPOSE I/A/W ALL APPLICABLE REGULATIONS. AVOID DISCHARGE
TO NATURAL WATERS.
& OPEN FLAME. KEEP FROM FREEZING. USE ONLY W/ADEQ VENT. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH RSLT IN
FORM OF INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING (SANDING) PAINTED
SURFS. IF SUCH CNDTNS CANNOT BE
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL, FOAM, WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME
HEAT/FIRE. VAPS ARE HVR/AIR & MAY TRAVEL LONG DISTS TO SOURCE OF IGNIT
& FLASH BACK. VAPS CAN FORM EXPLO (SUPDAT)
*
*
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices: WASH HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR'S TRADE NAME/PART NO:INTERIOR LATEX FLAT
MAY BURST IF EXPOS TO EXTREME HEAT/FIRE. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION.
*
Physical/Chemical Properties
*
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT W/OXIDIZING AGENT,
ALUMINUM OR ZINC, FREEZING, SPARKS, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, ALUMINUM, ZINC, METALS, NITRIC ACID,
HYDROFLUORIC ACID, HYDROGEN FLUORIDE, MAGNESIUM, SODIUM,
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXYGEN,
TOXIC GASES. PROPIONALDEHYDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: ICI PAINTS/GLIDDEN PAINT CO
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHALATION:IRRITATION OF RESPIRATORY
TRACT, LUNGS. PROLONGED INHALATION MAY LEAD TO COUGHING, RESPIRATORY
PROBLEMS. SKIN CONTACT:IRRITATION. PROLONGED OR REPEATED CONTACT CAN CAUSE
DERMATITIS. EYE CONTACT:IRRITATION. INGESTION:MAY CAUSE NAUSEA, VOMITING,
DIARRHEA, GASTROINTESTINAL DISTURBANCES, CENTRAL NERVOUS SYSTEM DEPRESSION,
KIDNEY DAMAGE. CHRONIC:NONE LISTED BY MANUFACTURER .
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTIL DOES NOT MAINTAIN INHALE EXPOS BELOW
UNITS OK.
Ventilation:SUFFICIENT VENTILATION TO KEEP EXPOS BELOW CURRENT EXPOS
LIM & AREAS BELOW FLAMM VAPOR CONC. LOCAL EXHST/CONFINED AREA.
Other Protective Equipment:WEAR RESISTANT PROTECTIVE GARMENTS SUCH AS
HEAD/NECK COVER, APRONS, JACKETS, PANTS, COVERALLS, BOOTS, ETC FOR
CONDITIONS
Work Hygienic Practices:WASH AFTER SKIN CONTACT & BEFORE EATING,
DRINKING, USING TOBACCO OR RESTROOMS. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.
Supplemental Safety and Health
EMPTY CONTAINERS MAY RETAIN PRODUCT RESIDUE INCLUDING FLAMMABLE
EXPLOSIVE VAPORS. DO NOT CUT, DRILL, GRIND OR WELD ON OR NEAR
PRODUCT CONTAINERS. AIRBORNE PARTICULATE MAY BE GENERATED DURING
REMOVAL O PERATIONS INCLUDING ABRASIVE BLASTING, SANDING OR
GRINDING. READ AND UNDERSTAND MANUFACTURER'S PRECAUTIONS BEFORE
USING.
* Product Identification *
Kit Part:Y
Preparer's Name:C. A. HOPE
* Composition/Information on Ingredients *
Ingred Name:TALC (CONTAINING NO ASBESTOS)
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:2-BUTOXYETHANOL
Other REC Limits:NONE SPECIFIED
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT. SKIN: PROLONG/REPEAT
CONTACT-DEFATTING. ABSORPTION: SYSTEMIC EFFECTS. INHALE HIGH CONCNS
MAY CAUSE RESPIRATORY IRRIT & CENTRAL NERVOUS SYSTEM DEPRESSION.
REPEAT/PROLONG INHALE HIGH CONC OFMATTER:LUNG CHANGES. INGEST:
GASTROINTEST DISTURBANCES. LUNG ASPIRATION. POSS ANEMIA,LIVER,
KIDNEY, LUNG,BLOOD DAMAGE.
Effects of Overexposure:SKIN: REDNESS, CRACKING, BLISTERING, IRRITATION
AND DERMATITIS, SENSITIZATION. INHALATION: HEADACHE, WEAKNESS,
DIZZINESS, INCOORDINATION AND POSSIBLE COLLAPSE. INGESTION: NAUSEA,
VOMITING AND DIARRHEA . MANY EFFECTS SAME AS INHALATION.
ASPIRATION: CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXIST DISEASE OR
HISTORY OF AILMENTS INVOLVING THE SKIN, EYE, RESPIRATORY TRACT,
LIVER, KIDNEY, CENTRAL NERVOUS STSTEM ARE AT GREATER RISK TO
DEVELOP ADVERSE EFFECTS WITH THIS PRODUCT.
* First Aid Measures *
WATER. WASH CONTAMINATED CLOTHES BEFORE REUSE. INHALE:REMOVE FROM
EXPOSURE. IF BREATHING STOPPED OR DIFFICULT ADMIN CPR OR OXYGEN AS
NEEDE D. INGEST: DO NOT INDUCE VOMITING. GIVE1 GLASS OF MILK OR 1
TO 2 OZ ACTIVATED CHARCOAL IN WATER AS TOLERATED.
EMERGENCY/PERSISTANCE: GET IMMEDIATE MEDICAL AID. NOTHING BY MOUTH
TO UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,WATER SPRAY,ALCOHOL OR
UNIVERSAL TYPE FOAMS AS PER MFR RECOMMENDS. WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures:FULL FIRE PROTECTIVE CLOTHES, INCL FULL-FACE
MSHA/NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS. USE WATER
TO COOL CONTAINERS/STRUCTURES & PROTECT PERSONNEL
Unusual Fire/Explosion Hazard:VAPORS:FLAM/EXPLOS MIX IN AIR. VAPOR
HEAVY/TRAVEL TO IGNITE SOURCE-FLASH. CNTNRS MAY HOLD FLAM VAPOR.
CLOSED CNTNRS MAY EXPLODE W/HEAT. EMITS IRRIT/TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:STOP SPILL/LEAK IF NO RISK. AVOID: BREATHING
VAPOR, HOT LIQUIDS,FUMES,&HEAT/SPARKS. TURN OFF IGNITE SOURCES.
VENTILATE AREA. INERT ABSORB TO FINISH CLEAN-UP. REACTS W/OXIDIZING
RESPONSE CNTR.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONG/REPEAT:BREATHING
VAPOR/MIST/FUMES, CONTACT W/SKIN/EYES. STORE: COOL,DRY,VENTED AREA.
Other Precautions:GROUND & BOND DRUMS. DO NOT USE PRESSURE TO EMPTY
DRUMS. DO NOT WEAR CONTAMINATED CLOTHING. DISCARD CONTAMINATED
FOOTWEAR. KEEP AWAY FROM HEAT AND OPEN FLAME. DO NOT WEAR CONTACT
* Physical/Chemical Properties *
Vapor Density:> 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID WITH A TYPICAL SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID OXIDIZING AGENTS, HEAT, SPARKS AND OPEN FLAMES.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE UPON
THERMAL DECOMPOSITION.
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT IS A US EPA DEFINED IGNITABLE
HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE HAZARDOUS WASTE IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. DOT
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED RESPIRATOR IF REQUIRED IF TLV
OF ANY INGREDIENT IS EXCEEDED. IN CONFINED AREAS, WORKMEN MUST WEAR
NIOSH APPROVED FRESH AIR LINE RESPIRATORS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . COVER AS MUCH EXPOS SKIN AREA AS POSS W/APPROP CLTHG.
(SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:GLASS OF MILK/WATER. DO NOT GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. GET MED ATTN. SPILL PROC:MAY BE ABSORBED
W/SAND, CLAY, EARTH/FLOOR ABSORB. EYE PROT:FULL LGTH FSHLD . OTHER
PROT EQUIP:HYPERSENSITIVE PERS SHOULD USE PROT CREAM. IN AREAS
WHERE EXPLO HAZS EXIST, WORKMENT SHOULD BE (ING 2)
* Product Identification *
Preparer's Name:D. EDWARD BLAKE
CAGE:0VKU9
CAGE:0VKU9
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
Ingred Name:SUPP DATA:REQUIRED TO USE NONFERROUS TOOLS & TO WEAR
CONDUCTIVE & NONSPARKING SHOES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CONTACT CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:CONTACT MAY
CAUSE IRRITATION, DEFATTING AND DERMATITIS. INHALATION:CAN CAUSE
NASAL AND RESPIRATORY IRRITATION, DIZZINES S, WEAKNESS, FATIGUE,
NAUSEA AND HEADACHE. INGESTION:CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VOMITING AND DIARRHEA. ASPIRATION OF
MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
UPPER & LOWER LIDS OCCAS. GET MED ATTN PROMPTLY. SKIN:THORO WASH
EXPOS AREA W/SOAP & WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE
REUSE. INHAL: REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT,
ADMIN OXYG. IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERS WARM,
QUIET & GET MED ATTN. INGEST:DO NOT INDUCE VOMIT. GIVE CONSCIOUS
INDIVIDUAL (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:SEE ING 1
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE COLD WATER TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID - FLAMM CLASS:OSHA II.
KEEP CONTAINERS TIGHTLY CLOSED. KEEP AWAY FROM HEAT, SPARKS,
ELECTRICAL EQUIPMENT & OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE NON-ESSNTL PERS. ELIM ALL IGNIT
SOURCES. VENT AREA. EQUIP CLEAN-UP CREW W/APPROP PROT EQUIP. STOP
SPILL AT SOURCE, DIKE AREA OF SPILL TO PVNT SPREADING. NOTIFY
APPROP AUTHS IF NEC. PUMP/SCOOP LIQ TO SALVAGE TANK/DRUM.
REMAINING LIQ (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT & OPEN FLAME.
Other Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO PREVENT
LEAKAGE. CAUTION:CONTAINS FLAMMABLE SOLVENTS. KEEP AWAY FROM SPARKS
& OPEN FLAMES. ALL ELECTRIC EQUIPMENT & INSTALLATIONS SHOULD BE
MADE & GROUNDED I/ A/W THE NATIONAL ELECTRIC CODE.
* Physical/Chemical Properties *
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, ELECTRICAL
EQUIPMENT & OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO*2, CO & VARIOUS
HYDROCARBONS.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATL MUST BE DISPOSED OF I/A/W FED, STATE
& LOC ENVIRON CONTROL REGS. INCIN IS PREF METHOD. EMPTY CNTNRS MUST
BE HNDLD W/CARE DUE TO PRODUCT RESIDUE. DECONTAMINATE CNTNRS PRIOR
TO DISP. DO NOT H EAT/CUT EMPTY CNTNR W/ELECTRIC OR GAS TORCH.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED POSITIVE PRESSURE
SUPPLIED AIR RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
Other Protective Equipment:IMPERVIOUS COVERALLS, APRON, & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM CARBONATE, POTASH
Ingred Name:SODIUM SULFITE
Other REC Limits:5 MG/CUM (DUST)
Ingred Name:HYDROQUINONE (SARA III)
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL. INHALATION: MUCOUS
MEMBRANE & RESPIRATORY IRRITATION. EYES: SEVERE IRRITATION &
PERMANENT DAMAGE. SKIN: IRRITATION & DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: HARMFUL. INHALATION: MUCOUS MEMBRANE
& RESPIRATORY IRRITATION. EYES: SEVERE IRRITATION & PERMANENT
DAMAGE. SKIN: IRRITATION & DERMATITIS.
* First Aid Measures *
QUANTITIES OF WATER. INDUCE VOMITING. INHALATION: REMOVE VICTIM TO
FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM, CO2
Fire Fighting Procedures:USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL & TO DISPERSE UNIGNITED VAPORS. USE NIOSH/MSHA
APPROVED POSITIVE PRESSURE SCBA.
Unusual Fire/Explosion Hazard:VAPORS MAY BE IGNITED.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE AREA BY DIKING. STOP SOURCE OF LEAK.
ADD DRY ABSORBENT. CLEAN UP, PLACE IN APPROVED DOT CONTAINER, &
SEAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN, &
CLOTHING. AVOID INHALATION OF MIST OR VAPOR. STORE IN COOL, DRY,
WELL-VENTILATED PLACE.
Other Precautions:AVOID CONTACT W/STRONG ACIDS & OXIDIZING AGENTS.
* Physical/Chemical Properties *
Vapor Pres:6
Vapor Density:6
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW, ODORLESS SOLUTION.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:SULFUR DIOXIDE FUMES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER APPROVED FOR THIS
MATERIAL. CONSULT APPROPRIATE FEDERAL, STATE, & LOCAL REGULATORY
AGENCIES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM FLUORIDE, ULTRAPURE
Code:F
< Wt:1.
Ingred Name:OTHER COMPONENT
< Wt:.1
Ingred Name:DEMINERALIZED WATER
Code:F
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PRACTICALLY NON-TOXIC. CHRONIC:
PRACTICALLY NON-TOXIC.
Explanation of Carcinogenicity:CARCIOGENICITY TESTING IN PROGRESS FOR A
COMPONENET OF THIS PRODUCT.
Effects of Overexposure:NO EFFECTS ANTICIPATED.
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
First Aid:EYE AND SKIN CONTACT: FLUSH WITH PLENTY OF WATER. INGESTION:
GIVE LARGE QUANTITIES OF WATER. CALL PHYSICIAN IMMEDIATELY.
INHALATION: NOT APPLICABLE.
* Fire Fighting Measures *
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:DILUTE WITH WATER. POUR DOWN THE DRAIN WITH
EXCESS WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL, DRY
PLACE. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:N/D
Vapor Density:N/D
pH:7
Viscosity:NP
Solubility in Water:MISCIBLE
Appearance and Odor:LIQUID, CLEAR, COLORLESS. ODOR: NONE.
Percent Volatiles by Volume:NP
Corrosion Rate:NOT DETERMINED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME TEMPERATURES, EVAPORATION.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: 0FTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: ENAMEL
Type/Grade/Class: TYPE I
Unit of Issue: PT
UI Container Qty: 0
Type of Container: METAL
*
Ingredients
*
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: 5 PPM
ACGIH TLV: 5 PPM
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
-----------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
-----------------------------
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE; CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. HIGH CONCENTRATIONS ARE ANESTHETIC. IRRITATION TO SKIN &
RESPIRATORY TRACT. OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS, STAGGERING,
GIDD INESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. IRRITATION
TO EYES & THROAT. HEADACHES, NAUSEA, & VOMITING.
Signs And Symptions Of Overexposure: CHRONIC; REPORTS HAVE ASSOCIATED REPEATED
& PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES WASH WITH SOAP & WATER; WASH
& CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWALLOW ED, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NECESSARY & GET MEDICAL AID. NEVER
GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE & LOCAL
PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TRA SH
PICK-UP. DO NOT PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN! CAUTION -
MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH EYES OR SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CON TENTS MAY
BE HARMFUL OR FATAL.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NR
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO KEEP FIRE EXPOSED
CNTNR COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST BURSTING,
RUPTURING OR VENTING OF CNTNR.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
*
*
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
*
Physical/Chemical Properties
*
HCC: V3
Vapor Density: >1.5
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE/PAINT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
Type Of Container: METAL
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
*
HAZCOM Label
*
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: ACUTE; CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. HIGH CONCENTRATIONS ARE ANESTHETIC. IRRITATION TO SKIN &
RESPIRATORY TRACT. OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS, STAGGERING,
GIDD INESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. IRRITATION
TO EYES & THROAT. HEADACHES, NAUSEA, & VOMITING. CHRONIC; REPORTS
HAVE ASSOCIATED REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNLESS NORMAL VENTILATION IS
INADEQUATE.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:EYEWASH SHOWER
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DA POSINELLI
* Composition/Information on Ingredients *
Ingred Name:METHYLTRIACETOXYSILANE
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPRIETARY COMPONENT
Other REC Limits:NONE SPECIFIED
Ingred Name:DIMETHYL POLYSILOXANE SILANOL/ST
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA DIOXIDE (AMORPHOUS)
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC COMPOUND; <5 G/L
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL IF SWALLOWED.
UNCURED PRODUCT CONTACT MAY WILL IRRITATE LIPS, GUMS,TONGUE, SKIN
AND EYES. INHALATION OF VAPOR FROM UNCURED PRODUCT MAY IRRITATE
RESPIRATORY SYSTEM. CHRONIC EFFECT S: NONE KNOWN.
Explanation of Carcinogenicity:NO INGREDIETNT OF A CONCENTRATION OF
0.1% IS LISTED AS A CARCINOGEN BY NTP, IARC OR REGULATED AS SUCH BY
OSHA.
Effects of Overexposure:INHALED: COUGHING, SHORTNESS OF BREATH. EYES:
REDNESS, TEARING, DISCOMFORT. SKIN: REDNESS, DISCOMFORT. SWALLOWED:
NAUSEA, STOMACH DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:INHALED: MOVE TO FRESH AIR. EYES: FLUSH WITH LOTS OF WATER
WASH WITH SOAP AND WATER. INGESTED: RINSE MOUTH WITH WATER SEVERAL
TIMES. IF SYMPTOMS DEVELOP. SEE DOCTOR.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MATERIAL IS COMBUSTIBLE.
* Accidental Release Measures *
Spill Release Procedures:WIPE, SCRAPE, OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES WITH
DETERGENT AND WATER TO REDUCE SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:ACETIC ACID VAPOR WILL BE LIBERATED
DURING APPLICATION AND CURING. ADEQUATE VENTILATION IS REQUIRED TO
MAINTAIN BELOW TLV.
Other Precautions:AVOID SKIN/EYES CONTACT. USE IN WELL VENTILATED AREA.
REMOVE CONTACT LENSES BEFORE USING SEALANT. DO NOT HANDLE LENSES
UNTIL ALL SEALANT HAS BEEN CLEANED FORM FINGERS.
* Physical/Chemical Properties *
HCC:V4
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE LIQUID, WITH ACETIC ACID ODOR
Percent Volatiles by Volume:5
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, AND FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
SILICON DIOXIDE, ACETIC ACID.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF LOCAL, STATE AND FEDERAL REGULATIONS.
MANUFACTURER SUGGESTS INCINERATION OR SANITARY LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PRODUCT DOES NOT CONTAIN LEAD OR CHROMATE PIGMENTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: 0.5-2.8%
Ingred Name:CYCLOHEXANONE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION & DAMAGE. SKIN:
IRRITATION, RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS,
KIDNEY, LIVER, & CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION & DAMAGE. SKIN: IRRITATION,
RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS, KIDNEY, LIVER,
& CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION: IRRITATION.
* First Aid Measures *
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR IF NEEDED. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN A LL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2, & DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR IS >AIR, IT MAY TRAVEL & IGNITE OR
FLASHBACK. EMPTY CONTAINERS STILL COULD IGNITE EXPLOSIVELY. KEEP
AREA CLEAR OF SOURCES OF IGNITION.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/SAND. REMOVE ALL SOURCES OF IGNITION.
DIKE AREA W/SAND TO CONTAIN SPILLED LIQUID. OPEN ALL WINDOWS &
DOORS. PUMP INTO SALVAGE TANK.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY & AWAY FROM
IGNITION SOURCES. CHECK ALL CONTAINERS FOR LEAKS.
Other Precautions:OVERHEATING MAY CAUSE CONTAINER TO RUPTURE & EMPTY
CONTAINERS CONTAINING RESIDUE MAY CAUSE A HAZARD. AVOID BREATHING
FUMES & CONTACT W/SKIN. DON'T TAKE INTERNALLY. WASH THOROUGHLY
AFTER HANDLING.
* Physical/Chemical Properties *
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:<0.1%
Appearance and Odor:CLEAR & COLORED PASTE W/PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES, & ACIDS.
Stability Condition to Avoid:EXTREME HEAT, COLD, & ELEVATED TEMPS.
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, & VARIOUS
HYDROCARBONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. KEEP MATERIAL OUT OF SEWERS & STREAMS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER ORDINARY CONDITIONS OF USE.
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:MECHANICAL EXHAUST, FUME HOOD.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
ODOR:ING 4:COLORLESS LIQ, PUNGENT ODOR. FIRST AID
PROC:FORMALDEHYDE. DO NOT USE GASTRIC LAVAGE/EMETICS. CALL MD
IMMED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, SOLIUM SALT; (SODIUM ACETATE)
Fraction by Wt: 1.5%
Fraction by Wt: 2%
Fraction by Wt: N/K4%
Ingred Name:FORMALDEHYDE (SARA III). VD:1.0 (GAS). EVAP RATE:>1
Fraction by Wt: 4%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:DANGER! POISON, MAY BE HARMFUL OR
FATAL IF SWALLOWED. HARMFUL IF INHALED OR ABSORBED THROUGH SKIN.
SENSITIZER, EXPOSURE MAY CAUSE HYPERSENSITIVITY TO SKIN, EYES AND
RESPIRATORY TRACT. SUSPECT CANCER H AZARD. CONTAINS MATERIAL WHICH
MAY CAUSE CANCER. AVOID BREATHING VAPOR AND EYE/SKIN CONTACT.
Explanation of Carcinogenicity:FORMALDEHYDE:ANTICIPATED TO BE A
CARCINOGEN (NTP), GROUP 2B (IARC), OSHA REGULATED.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE, SKIN
OR RESPIRATORY DISORDERS MAY BE MORE SUSCEPTIBLE TO EFFECTS OF THIS
SUBSTANCE.
* First Aid Measures *
First Aid:INHAL:NOT APPLICABLE UNDER NORMAL CONDITIONS OF USE. SEEK MD
ASSIST IF NEC. EYES:FLUSH IMMED W/COPIOUS AMTS OF WATER FOR AT
LRG AMTS OF WATER, ACTIVATED CHARCOAL/MILK IF AVAILABLE & INDUCE
VOMIT BY STICKING FINGER DOWN THROAT. ANY ORGANIC MATL WILL
INACTIVATE (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:SEE INGS
Upper Limits:SEE INGS
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COMBUSTIBLE, KEEP AWAY FROM HEAT AND FLAME.
Unusual Fire/Explosion Hazard:EMITS HIGHLY TOXIC FUMES OF FORMALDEHYDE
GAS.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROT EQUIP AS SPECIFIED. WEAR PROT CLTHG
& NIOSH/MSHA APPROVED SCBA/RESP W/APPRVD CARTRIDGE IF NEC. REMOVE
ALL SOURCES OF IGNIT. CONTAIN SPILL & ABSORB W/INERT MATL. SCOOP UP
& PLACE IN APPRVD HA Z WASTE CONTR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. STORE
AT ROOM TEMPERATURE. KEEP AWAY FROM HEAT AND FLAME.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:F4
Boiling Pt:B.P. Text:SUPDAT
Melt/Freeze Pt:M.P/F.P Text:SUPDAT
Vapor Pres:SUPDAT
Vapor Density:SEE INGS
Spec Gravity:SUPDAT
Evaporation Rate & Reference:SEE INGREDIENTS
Appearance and Odor:SODIUM ACETATE:COLORLESS CRYSTALS. ACETIC
ACID:COLORLESS LIQ. (SUPDAT)
Percent Volatiles by Volume:INGRED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROCHLORIC ACID, PERCHLORIC ACID, ALKALIES, AMINES AND STRONG
OXIDIZERS.
Stability Condition to Avoid:IMCOMPATIBLE SUBSTANCES.
Hazardous Decomposition Products:HIGHLY TOXIC FUMES OF FORMALDEHYDE
GAS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE BY MEANS WHICH COMPLY WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LISCENSED
DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT APPLICABLE. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:FORMULA-INSTITUTIONAL.
* Product Identification *
CAGE:DRACK
CAGE:DRACK
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) (SARA III)
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
MINUTES. SKIN:FLUSH WITH WATER. INGEST:DRINK MILK OR WATER FREELY.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:IF INVOLVED IN FIRE, USE WATER, DRY
ALCOHOL-TYPE/ALL PURPOSE FOAM, DRY CHEM, CO2 OR OTHER CLASS B
EXTING AGENTS.
Fire Fighting Procedures:FULL PROT EQUIP, INCLDG NIOSH/MSHA PRESS
DEMAND SCBA & TURNOUT EQUIP SHOULD BE WORN BY FIREFIGHTERS & OTHERS
EXPOSED TO COMBUSTION BY-PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH AREA WITH WATER. KEEP OUT OF WATERSHEDS
AND WATER SYSTEMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:UNPLUG ELECTRICAL APPLIANCES BEFORE
USING PRODUCT ON THEM.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:1.2
Evaporation Rate & Reference:0.3 (BUAC =1)
Appearance and Odor:CLEAR, BLUE LIQUID WITH SLIGHT AMMONIA ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE ONLY IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GENERAL ROOM VENTILATION IS SATISFACTORY FOR STORAGE AND
HANDLING AT ROOM TEMPERATURE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC: AND INCREASE FIRE INTENSITY.
* Product Identification *
CAGE:KAYIN
CAGE:KAYIN
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM OIL; (LIGHT PARAFFINIC DISTILLATE)
Ingred Name:GREASE, PETROLEUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST/SKIN ABSORPTION/INHAL: NO
EVIDENCE OF ADVERSE EFFECTS FROM AVAILABLE INFORMATION. SKIN
CONTACT: UNLIKELY TO PRODUCE ANY SIGNIFICANT EFFECTS. EYE CONTACT:
MAY CAUSE PAIN W/EXCESS TEAR FORMATION AND MILD REDDENING.
OVEREXPOSURE TO VAPORS GENERATED AT HIGH TEMPERATURE MAY RESULT IN
EYE AND (EFTS OF OVEREXP)
AN IARC GROUP 1 CARCINOGENS.
Effects of Overexposure:HLTH HAZ: RESPIRATORY TRACT IRRITATION AND IN
THE INHALATION OF HARMFUL AMOUNTS OF MATERIAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER FOR A
MAY BE INDUCED. CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:ALL PURPOSE TYPE FOAM. USE CO*2 OR DRY CHEMICAL FOR
SMALL FIRES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. DO NOT DIRECT A SOLID STREAM OF H*2O/FOAM INTO HOT BURNING POOLS,
AS THIS MAY CAUSE FROTHING (SUPP DATA)
Unusual Fire/Explosion Hazard:DURING A FIRE, NO*X MAY BE PRODUCED.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL, ADVISE EPA, STATE AGENCY IF
REQUIRED. ABSORB ON INERT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
THOROUGHLY AFTER HANDLING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Evaporation Rate & Reference:NIL TO NONE
Solubility in Water:NIL
Appearance and Odor:COLOR VARIES, DEPENDING OF MICROSCOPIC GRADE
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS. NOT
A RCRA HAZARDOUS WASTE IF UNCONTAMINATED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED IN WELL VENTILATED AREA. IF TLV IS
EXCEEDED A NIOSH APPROVED BREATHING APPARATUS IS RECOMMENDED.
Ventilation:LOCAL EXHAUST: NECESSARY. MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
PROTECTIVE CLOTHING IS RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE WASHROOM.
SMOKE----IN SMOKING AREAS O N L Y.
Supplemental Safety and Health
EXPLO HAZ: FLAME SHOULD BE COOLED W/WATER TO ELIMINATE STRUCTURAL
WEAKENING ON CNTNR'S WALL & POSSIBLE RUPTURE.
* Product Identification *
Preparer's Name:HEATHER BUCK
* Composition/Information on Ingredients *
Ingred Name:KEROSENE; (PETROLEUM DISTILLATES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA; (HEAVY AROMATIC NAPHTHA)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPYLENE GLYCOL T-BUTYL ETHER
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIPENTENE
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1-5%
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE CONTACT MAY CAUSE PAIN,
TEARING, REDDENING AND SWELLING. SKIN CONTACT MAY CAUSE REDDENING,
SWELLING, RASH AND REDNESS. INHALATION MAY CAUSE RUNNY NOSE, SORE
THROAT, COUGHING, CHEST DISCOMFO RT, SHORTNESS OF BREATH AND
REDUCED LUNG FUNCTION. EXPOSURE TO HIGH CONCENTRATIONS MAY CAUSE
CENTRAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: NERVOUS SYSTEM DEPRESSION. INGESTION
MAY CAUSE SORE THROAT, ABDOMINAL PAIN, NAUSEA, VOMITING, AND
DIARRHEA. TARGET ORGANS AFFECTED: KIDNEYS AND LIVER.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
* First Aid Measures *
PERSISTS, SEEK MEDICAL ATTENTION. EYES: FLUSH WITH PLENTY OF WATER
TO F RESH AIR. SEEK MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WARNING. EXTREMELY FLAMMABLE. CLEAR FIRE AREA OF
UNPROTECTED PERSONNEL.
Unusual Fire/Explosion Hazard:CNTNRS EXPOS TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILDUP WHICH COULD RSLT
IN CNTNR RUPTURE. CNTNRS EXPOS TO DIRECT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING. TAKE UP
WITH AN ABSORBENT SUCH AS CLAY, SAND, OR OTHER SUITABLE MATERIAL.
PLACE IN NON-LEAKING CONTAINERS AND SEAL TIGHTLY FOR PROPER
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN A COOL, DRY AREA AWAY FROM IGNITION SOURCES. USE WITH
ADEQUATE VENTILATION.
Other Precautions:CONTAINERS, EVEN IF EMPTY, CAN CONTAIN EXPLOSIVE
VAPORS OR RESIDUES. KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE
LABEL BEFORE USE.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, GREN LIQUID WITH A CHLORINATED ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS AND CHLORINATED COMPOUNDS.
Stability Condition to Avoid:HEAT, SPARKS, AND FLAMES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE &
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED
Ventilation:REQUIRED
Other Protective Equipment:LAB COAT.
Work Hygienic Practices:WASH AFFECTED AREAS W/SOAP & WATER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AURAMINE HYDROCHLORIDE
Ingred Name:ETHYLENE GLYCOL
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: CNS DEPRESSION, CEREBRAL
EDEMA, PULMONARY EDEMA, RENAL FAILURE, TOXICITY TO LIVER/KIDNEYS,
DEATH. INHALATION: IRRITATION TO THROAT.SKIN: IRRITATION,
ABSORPTION/HARMFUL.
Effects of Overexposure:IRRITATION, METABOLIC ABNORMALITIES,
ETHANOL-LIKE INEBRIATION, ATAXIA, SLURRED SPEECH, SEIZURES, COMA,
ACIDOSIS, TACHYPENIA, ANURIA, UREMIA, HEADACHE, BACKACHE, NAUSEA,
VOMITING, DIZZINESS, LOSS OF BR EATH/UNCONSCIOUSNESS,
DISCOLORATION.
* First Aid Measures *
First Aid:INGESTION: GIVE 4 TO 8 OUNCES OF WATER/MILK TO DILUTE.
DON'T INDUCE VOMITING. INHALATION: MOVE PATIENT TO FRESH AIR.
SKIN: WASH AREA W/SOAP & WATER. EYES: WASH W/COPIOUS AMOUNT OF
TEPID WATER, LIFTING LOWER/UPPER LIDS UNTIL ALL TRACES OF
IRRITATION IS REMOVED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. DO NOT EXPOSE TO
OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:SMALL: WIPE UP W/PAPER TOWEL MOISTENED
W/HOUSEHOLD BLEACH TO DECOMPOSE THE DYE. LARGE: CONTAIN & ABSORB
W/NEUTRAL MINERAL ABSORBENT (VERMICULITE).
Neutralizing Agent:NEUTRAL MINERAL ABSORBENT (VERMICULITE).
*Handling and Storage *
Handling and Storage Precautions:STORE AT CONTROLLED ROOM TEMPERATURE
TO ENSURE REAGENT PERFORMANCE.
* Physical/Chemical Properties *
Vapor Density:2.1
Solubility in Water:COMPLETE
Appearance and Odor:BRIGHT YELLOW, VISCOUS LIQUID, FAINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, & POLYMERIZATION CATALYSTS.
Stability Condition to Avoid:OPEN FLAME.
* Disposal Considerations *
Waste Disposal Methods:PLACE ABSORBED SPILL IN A CLOSED CONTAINER FOR
DISPOSAL. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THE TLV IS EXCEEDED, A NIOSH APPROVED
DUST/MIST RESPIRATOR MAY BE WORN UP TO TEN TIMES THE TLV. CONSULT
RESPIRATOR SUPPLIER FOR DETAILS.
Ventilation:SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS
BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GENRLY PREF(SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR CLEAN BODY-COVERING CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:DRY SAND, EARTH/SIMILAR MATL FOR DISP AS HAZ WASTE IN A RCRA
APPRVD FACILITY. DO NOT FLUSH TO SEWER! VENT:BECAUSE IT CAN CONTROL
EMISSIONS OF CONTAM AT IS SOURCE, PREVENTING DISPERSION OF I T INTO
GEN WORK AREA. PLEASE REFER TO ACGIH DOCUMENT, "INDUSTRIAL
VENTILATION, A MANUAL OF RECOMMENDED (ING 2)
* Product Identification *
Product ID:PARAFFIN OIL
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3 (MIST)
Ingred Name:SUPP DATA: PRACTICES", MOST RECENT EDITION, FOR DETAILS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:INHALATION OF MIST
MAY PRODUCE RESPIRATORY DIFFICULTIES. FUMES MAY BE CHOKING IF
STRONG. INGESTION:MATERIAL IS A CATHARTIC AND CAN CAUSE SERIOUS
DIARRHEA. SKIN CONTACT:NOT EXPECTED TO BE A HEALTH HAZARD. EYE
CONTACT:NOT EXPECTED TO BE A HEALTH HAZARD. CAN CAUSE DISCOMFORT
SIMILAR TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MOTOR OIL. CHRONIC:NO INFORMATION
FOUND. TOXICITY DATA:TUMORIGENIC EFFECTS CITED.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. GET MEDICAL ATTENTION FOR ANY
BREATHING DIFFICULTY. INGEST:GIVE SEVERAL GLASSES OF WATER TO DRINK
TO DILUTE. IF LARGE AMOUNTS WERE SWALLOWED, GET MEDICAL ADVICE.
SKIN:WASH E XPOSED AREAS W/SOAP & WATER. GET MEDICAL ADVICE IF
IRRITATION DEVELOPS. EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA OF LEAK/SPILL. REMOVE ALL SOURCES OF
IGNIT. CLEAN-UP PERS REQ PROT CLTHG & NIOSH APPRD RESP PROT FROM
VAPS. CNTN & RECOVER LIQ WHEN POSS. COLLECT AS HAZ WASTE & ATOMIZE
IN SUITABLE RCRA APPR VD COMBUST CHAMBER/ABSORB W/VERMICULITE,
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTAINER.
STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM SOURCES OF
HEAT OR IGNITION. PROTECT AGAINST PHYSICAL DAMAGE.
Other Precautions:WARNING! MISTS MAY BE HARMFUL IF INHALED. AVOID
BREATHING MIST. USE W/ADEQUATE VENTILATION.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS OILY LIQUID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE &
STORAGE.
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE MAY
FORM WHEN HEATED TO DECOMPOSITION.
* Disposal Considerations *
Waste Disposal Methods:ENSURE COMPLIANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NUISANCE DUST MASK RECOMMENDED WHILE GRINDING
FIRED PORCELAIN.
Ventilation:MECHANICAL EXHAUST
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
Fraction by Wt: <5%
Ingred Name:BARIUM (SOLUBLE COMPOUNDS)
Fraction by Wt: <5%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:BORON OXIDE, TRIOXIDE
Fraction by Wt: <5%
Ingred Name:CALCIUM OXIDE; LIME
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
Fraction by Wt: <5%
Ingred Name:SILICA, CRYSTALLINE - FUSED
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
Ingred Name:TIN (AS SN)
Fraction by Wt: <5%
OSHA PEL:2.0 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM(IV) OXIDE, TIO2
Fraction by Wt: <5%
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
Fraction by Wt: <5%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT
Fraction by Wt: <5%
OSHA PEL:0.1 MG/M3;AS CO
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
Fraction by Wt: <5%
Ingred Name:MANGANESE, MN COMPOUNDS
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL (SOLUBLE)
INTENDED CHANGE (IC)
Fraction by Wt: <5%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
Ingred Name:VANADIUM
Fraction by Wt: <5%
OSHA PEL:C,0.5 MG/M3
Ingred Name:ZINC OXIDE
Fraction by Wt: <5%
Ingred Name:ZIRCONIUM
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Explanation of Carcinogenicity:CHROMIUM IS A SUSPECTED A1 HUMAN
CARCINOGEN BY ACGIH.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP SPILLED MATERIAL.
*Handling and Storage *
Other Precautions:AVOID BREATHING CERAMIC DUST. AVOID LICKING CERAMIC
APPLICATION BRUSH.
* Physical/Chemical Properties *
Evaporation Rate & Reference:0
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE OR LIGHT PASTEL COLORED PORCELAIN POWDER W/NO
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID
* Disposal Considerations *
Waste Disposal Methods:DISPOSE AS SOLID WASTE IN ACCORDANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESP APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. USE GERMICIDAL
SOAP TO WASH SKIN. AVOID EYE AND SKIN CONTACT.
Supplemental Safety and Health
CAUTION! CONTAINS NON-STERILE HUMAN SERUM. THE POTENTIAL FOR HUMAN
DISEASE TRANSMISSION EXISTS. HANDLE AS A BIOHAZARD, CLASS II
(CDC/NIH GUIDELINES).
* Product Identification *
Preparer's Name:KEN WOODLIN
CO.
* Composition/Information on Ingredients *
Ingred Name:HUMAN SERUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY PROVOKE RESP ALLERGY(HAY
INF W/INFECTIOUS DISEASE AGENTS IS POSS FROM INHAL OF THIS
MATL.SKIN:SENSIT CAN OCCUR.ALLERGIC RXN CAN PROD CONT
DERM/ECZEMA(INFLAM CHARACT BY REDNESS,ITCHING,WEEPING,OOZING,AND
CRUSTING OF SKIN).(SEE SIGNS&SYMPTOMS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SKIN:INFECTION W/INFECTIOUS DISEASE AGENTS POSS
IF CONT W/OPEN CUTS.EYE:SENSIT CAN OCCUR.ALLERGIC RXN CAN PROD
ITCHING,REDNESS/SWELLING OF TISS AROUND EYES IN SENSITIVE
INDIVIDUALS.LYOPOHILIZED PROD C OULD CAUSE MECH IRRIT.INFECTION
W/INFECTIOUS DISEASE AGENTS IS POSS.INGEST:DEVELOP ALLERGIC RASH IN
SENSIT INDIVIDUALS.
Medical Cond Aggravated by Exposure:SENSITIZER. SOME SENSITIVE
INDIVIDUALS MAY DEVELOP ALLERGY WITH SYMPTOMS OF HAY FEVER, ASTHMA,
AND TIGHTNESS OF CHEST; RASH OR DERMATITIS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHING, GIVE ARTF RESP,
PREF MOUTH-TO-MOUTH. IF BRTHING IS DFCLT, GIVE O*2. CALL MD.
SKIN:IMMED WASH SKIN W/ SOAP & PLENTY OF H*2O. EYE:IMMED FLUSH EYES
INGEST OF MATL.
* Fire Fighting Measures *
Extinguishing Media:WATER, WATER SPRAY, WATER FOG, CHEMICAL FOAM,
"ALCOHOL" FOAM, DRY POWDER (SAND OR MET-L-X), DRY CHEMICAL, CO2.
Fire Fighting Procedures:NO INFORMATION AVAILABLE.
Unusual Fire/Explosion Hazard:DUST FORMS EXPLOSIVE MIXTURE WITH AIR.
* Accidental Release Measures *
Spill Release Procedures:USE APPROP PERSONAL PROT EQUIP DURING CLEAN
ABSORBENT USED TO WIPE UP MATL. DISPOSE PER LOCAL GUIDELINES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM HEAT,SPARKS&FLAMES IF
LYOPHILIZED PROD IS REMOVED FROM VIAL,AVOID DUST GENERATION&TREAT
AS RESP SENSIT.FOR MORE INFO SEE PROD INSERT SHEET.
Other Precautions:DO NOT BREATHE DUST. IF THE LYPHOLIZED PRODUCT IS
REMOVED FROM THE VIAL, AVOID DUST GENERATION AND TREAT AS A
RESPIRATORY SENSITIZER.
* Physical/Chemical Properties *
pH:7-8
Solubility in Water:SOLUBLE
Appearance and Odor:NO ODOR, WHITE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSES WITH HEAT.
* Disposal Considerations *
AUTOCLAVE. DISPOSE PER LOCAL GUIDELINES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT RELEVANT
PERCENT.
Other Protective Equipment:SAFETY SHOES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING CYLINDERS.
Supplemental Safety and Health
OXYGEN SHOULD NOT BE USED AS A SUBSTITUTE FOR COMPRESSED AIR IN
PNEUMATIC EQUIPMENT SINCE THIS TYPE GENERALLY CONTAINS FLAMMABLE
LUBRICANTS. EQUIPMENT TO CONTAIN OXYGEN MUST BE "CLEANED FOR OXYGEN
SER VICE". COMPRESSED GAS CYLINDERS SHOULD NOT BE REFILLED EXCEPT
BY QUALIFIED PRODUCERS OF COMPRESSED GASES.
* Product Identification *
Product ID:OXYGEN
CAGE:0JNF3
* Composition/Information on Ingredients *
Ingred Name:OXYGEN
Other REC Limits:NONE RECOMMENDED
Ingred Name:FEDERAL SPECIFICATION INDICATES TY I, OXYGEN GAS SHALL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-BREATHING HIGH CONCENTRATIONS
INCLUDE CRAMPS, NAUSEA, DIZZINESS, HYPOTHERMIA, AMBYLOPIA,
RESPIRATORY DIFFICULTIES, FAINTING SPELLS AN D CONVULSIONS CAPABLE
INFLAMMATION. CHRONIC- NOT KNOWN.
Explanation of Carcinogenicity:OXYGEN IS NOT LISTED AS A CARCINOGEN BY
THE IARC, NTP OR OSHA.
Effects of Overexposure:SYMPTOMS OF HYPEROXIA WHICH INCLUDE CRAMPS,
NAUSEA, DIZZINESS, HYPOTHERMIA, AMBYLOPIA, RESPIRATORY
DIFFICULTIES, BRADYCARDIA, FAINTING SPELLS AND CONVULSIONS CAPABLE
OF LEADING TO DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF
OVEREXPOSURE TO OXYGEN. RESCUE PERSONNEL SHOULD BE AWARE OF EXTREME
FIRE HAZARD ASSOCIATED WITH OXYGEN-RICH ATMOSPHERES. CONSCIOUS
PERSONS SHOULD BE MOVED TO FRESH AIR. THEY SHOULD BE KEPT WARM AND
QUIET. UNCONSCIOUS PERSONS SHOULD BE MOVED TO FRESH AIR AND GIVEN
ASSISTED RESPIRATION. TREATMENT SHOULD BE SYMPTOMATIC AND
SUPPORTIVE.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. MOVE CONTAINERS AWAY IF POSSIBLE. STOP FLOW OF OXYGEN
WHICH IS SUPPORTING THE FIRE.
Unusual Fire/Explosion Hazard:VIGOROUSLY ACCELERATES COMBUSTION.
CONTACT WITH EASILY OXIDIZABLE ORGANIC/COMBUSTIBLE MATERIALS MAY
RESULT IN IGNITION, VIOLENT COMBUSTION OR EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE PERSONNEL FROM AFFECTED AREA. USE
APPROPRIATE PROTECTIVE EQUIPMENT. STOP LEAK IF YOU CAN DO IT
WITHOUT RISK. ISOLATE AREA UNTIL GAS HAS DISPERSED. KEEP
COMBUSTIBLE MATERIALS AWAY FROM SPILLED MATERIAL. STAY UPWIND.
VENTILATE CLOSEDSPACES.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTILATED
AREA AWAY FROM HEAVILY TRAFFICKED AREAS AND FULL/EMPTY CYLINDERS
CONTAINING FLAMMABLE PRODUCTS.
Other Precautions:STORE CYLINDERS IN UPRIGHT POSITION AND FIRMLY
CYLINDERS. USE "FIRST-IN-FIRST-OUT" INVENTORY SYSTEM. USE ONLY IN
WELL VENTILATED AREA . DO NOT DRAG, SLIDE OR ROLL CYLINDERS.
* Physical/Chemical Properties *
HCC:G4
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:SLIGHTLY
Appearance and Odor:COLORLESS, ODORLESS GAS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALL FLAMMABLE MATERIALS.
Stability Condition to Avoid:AVOID HEATING CYLINDERS TO INCREASE FLOW
RATE.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF WASTE OR UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY LABELED, WITH
ANY VALVE OUTLET PLUGS OR CAPS SECURED AND VALVE PROTECTION CAP IN
SUPPLIER/MFR.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
CANISTER
Other Protective Equipment:BODY COVERING CLOTHING.
Supplemental Safety and Health
* Product Identification *
Product ID:PARADICHLOROBENZENE
* Composition/Information on Ingredients *
Ingred Name:P-DICHLOROBENZENE (1,4-DICHLOROBENZENE) (SARA III)
* Hazards Identification *
Effects of Overexposure:IRRITATES EYES & RESPIRATORY TRACT.CENTRAL
NERVOUS SYS.DEPRESSION,POSSIBLE LIVER & KIDNEY INJURY
* First Aid Measures *
First Aid:CALL PHYSICIAN.NEVER GIVE FLUIDS OR INDUCE VOMITING IF
PATIENT IS UNCONSCIOUS OR HAVING CONVULSIONS.
* Fire Fighting Measures *
Lower Limits:2.2
Upper Limits:9.2
Extinguishing Media:WATER,FOG,FOAM,ALCOHOL FOAM,CARBON DIOXIDE,DRY
CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL.SHOVEL SPILLED MATERIAL BACK
INTO CONTAINERS
*Handling and Storage *
Handling and Storage Precautions:AVOID BOTH SKIN & EYE CONTACT &
INHALATION OF VAPORS
* Physical/Chemical Properties *
HCC:T4
Vapor Pres:1
Vapor Density:5.1
Evaporation Rate & Reference:WHITE CRYSTALS,PEN
Solubility in Water:INSOLUBLE
Appearance and Odor:ETRATING ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALUMINUM & ALUMINUM ALLOYS
Hazardous Decomposition Products:HYDROGEN CHLORIDE & CHLORINE NO
* Disposal Considerations *
Waste Disposal Methods:PLACE CONTAMINATED MATERIAL INTO CONTAINERS
SUITABLE FOR SHIPPING TO DISPOSAL AREA.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SUPPLIED-AIR RESPIRATOR IN CONFINED OR
ENCLOSED AREAS.
Ventilation:USE SUFFICIENT VENTILATION TO KEEP <TLV OR BUILDUP OF
EXPLOSIVE CONCENTRATIONS OF VAPOR IN AIR. EXPLOSION-PROOF EQUIP.
Other Protective Equipment:CHEMICAL RESISTANT APRON OR OTHER CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES
BEFORE REUSE. WASH AFTER CONTACT/BEFORE BREAKS/MEALS/END OF DAY. NO
SMOKING.
Supplemental Safety and Health
* Product Identification *
Product ID:LPGAS PROPANE W/ODORANT
* Composition/Information on Ingredients *
Ingred Name:PROPANE
Ingred Name:ODORANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ASPHYXIATION. SKIN:
FROSTBITE, REMOVE OILS, IRRITATION, & DERMATITIS. EYES: IRRITATION.
INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: ASPHYXIATION. SKIN: FROSTBITE,
REMOVE OILS, IRRITATION, & DERMATITIS. EYES: IRRITATION. INGESTION:
HARMFUL.
* First Aid Measures *
First Aid:SKIN: TREAT FOR FROSTBITE. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR OR OXYGEN IF NEEDED. INGESTION: DON'T INDUCE VOMITING.
EYES: OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:<0F
Lower Limits:2.1%
Upper Limits:9.5%
Extinguishing Media:FOLLOW THE NFPA, FIRE PROTECTION GUIDE ON HAZARDOUS
MATERIALS.
Fire Fighting Procedures:STOP FLOW OF GAS. USE WATER TO KEEP
FIRE-EXPOSED CONTAINERS COOL/PROTECT PERSONNEL. USE WATER SPRAY TO
DISPERSE GAS/VAPOR. USE SCBA IN ENCLOSED/CONFINED AREAS.
LIQUID.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF & ELIMINATE IGNITION SOURCES.
EVACUATE AREA. VENTILATE CONFINED SPACES. OPEN ALL WINDOWS & DOORS.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/PILOT
LIGHTS/STATIC ELECTRICITY/OPEN FLAME/KEEP CLOSED WHEN NOT IN USE.
AVOID BREATHING GASESVAPORS/FUMES & CONTACT W/SKIN.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE/BE DANGEROUS. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND, MAY EXPLODE/CAUSE
INJURY/DEATH. WORK ON TANKS REFER TO OSHA/GOVT/INDUSTRIAL
REFERENCES FOR CLEANING/RE PAIRING/WELDING/CONTEMPLATED OPERATIONS.
* Physical/Chemical Properties *
Vapor Density:1.5
pH: 7
Solubility in Water:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM OR
CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:HEAT, FLAME, SPARKS, PILOT LIGHTS, STATIC
ELECTRICITY, OR OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:FUMES, SMOKE, CO, ALDEHYDES, & OTHER
PRODUCTS OF INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:HIGH VOLATILITY OF MATERIAL WILL CAUSE EXTREMELY
RAPID EVAPORATION, NO DISPOSAL METHOD IS NEEDED OR SHOULD BE
ATTEMPTED. CONTAINERS SHOULD BE DISPOSED OF IN AN ENVIRONMENTALLY
MANNER IN ACCORDANCE W/L OCAL/STATE/FED REGS. FLAMMABLE LIQUID.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:FUME HOOD
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
Product ID:DISSOLVED OXYGEN 3 REAGENT POWDER PILLOWS
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE TO EYES, WET SKIN, &
RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CAUSES BURNS.
* First Aid Measures *
VOMITING. GIVE PLENTY OF WATER. GIVE AT LEAST 1 OZ OF MILK OF
MAGNESIA IN AN EQUAL AMOUNT OF WATER OR THE WHITES OF 3 EGGS. NEVER
GIVE ANY THING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION:
REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER OR DRY CHEMICAL.
Unusual Fire/Explosion Hazard:REACTS VIOLENTLY W/CHLORINE, FUMING
NITRIC ACID. MAY EMIT TOXIC FUMES IN FIRE.
* Accidental Release Measures *
Spill Release Procedures:COVER CONTAMINATED SURFACES W/NEUTRALIZER.
MIX/ADD WATER IF NECESSARY. USE LITMUS PAPER TO MAKE SURE PH OF
SLURRY IS NEUTRAL OR ADD NEUTRALIZER UNTIL MIXTURE STOPS BUBBLING.
SCOOP UP THE SLURRY & WASHTHE NEUTRAL WASTE DOWN DRAIN W/EXCESS
WATER.
Neutralizing Agent:SODA ASH OR SODIUM BICARBONATE
*Handling and Storage *
Handling and Storage Precautions:STORE TIGHTLY IN A DRY PLACE. KEEP
AWAY FROM HEAT, SPARKS, & OPEN FLAME.
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING & BREATHING OF
CHEMICALS.
* Physical/Chemical Properties *
HCC:C1
pH:SUPP
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE POWDER, SOLID, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHLORINE, FUMING NITRIC ACID
Stability Condition to Avoid:EXTREME HEAT OR FLAME, EXCESS MOISTURE
Hazardous Decomposition Products:TOXIC FUMES OF SULFUR OXIDES, NITROGEN
OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. MONITOR THE AIR QUALITY INSIDE THE
WELDER'S HELMET, IF WORN, AND/OR THE WORKER'S BREATHING ZONE TO
DETERMINE IF A RESPIRATOR IS REQUIRED AND THE TYPE NEEDED.
Ventilation:USE ENOUGH VENTILATION TO KEEP DUST, FUMES AND GASES FROM
WORKER'S BREATHING ZONE AND GENERAL USE. KEEP EXPOSURE BELOW
LIMITS.
CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN
HOT CUTTING OR WELDING. PROVIDE PROTECTIVE SCREENS TO SHIELD
OTHERS.
Work Hygienic Practices:DO NOT EXPOSE SKIN TO RADIATION WHEN NOT
CUTTING OR WELDING.
Supplemental Safety and Health
RESPIRATORY PROTECTION: USE ONLY NIOSH APPROVED RESPIRATORS. EYE
WHEN CUTTING, GRINDING OR WELDING. IN ADDITION, WHEN HOT CUTTING OR
WEL DING, WEAR WELDING HELMET OR FACE SHIELD WITH FILTER LENS.
SELECT WELDING LENS SHADE FROM AWS PUBLICATION F2.2.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NICKEL
= Wt:.6
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:IRON
Fraction by Wt: BALANCE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:CHROMIUM
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Health Hazards Acute and Chronic:ACUTE: SHORT TERM EXPOSURE TO WELDING
FUMES, GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS,
NAUSEA, FEVER, DRYNESS AND OR IRRITATION OF NOSE, THROAT, EYES.
SKIN SENSITIVITY MAY ALSO BE NOTE D. ACUTE EXPOSURE CAN RESULT IN
THE SAME SYMPTOMS EXCEPT TO A GREATER DEGREE AS WELL AS WATERY
EYES, HEADACHE, BRATHING DIFFICULTY, FREQUENT COUGHING AND/OR CHEST
PAINS. SOME GASES MAY CAUSE PULMONARY EDEMA, ASPHYXIATION AND
EXCESSIVE EXPOSURE CAN BE FATAL. CHRONIC: MAY RESULT IN
NEUROLOGICAL DAMAGE, LUNG FIBROSIS, PNEUMONICOCIS AND OTHER LUNG
DISORDERS.
Explanation of Carcinogenicity:NICKEL AND CHROMIUM ARE CONSIDERED
Effects of Overexposure:***THIS PRODUCT POSES NO HEALTH HAZARD AS
SHIPPED*** BUT MAY POSE A HEALTH HAZARD DURING USE. ELECTRIC ARC
WELDING RAYS CAN INJURE EYES & BURN SKIN. DUST, FUMES AND GASES CAN
BE DANGEROUS TO YOUR HEAL TH. LUNG DAMAGE MAY RESULT FROM
OVEREXPOSURE.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PREEXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
* First Aid Measures *
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN.
IF NOT BR EATHING BEGIN ARTIFICIAL RESPIRATION. IF NO DETECTABLE
PULSE BEGIN EXTERNAL HEART MASSAGE. SKIN: WASH AFFECTED AREA WITH
SOAP AND WATER. EYES: FLUSH WITH LARGE AMOUNTS OF FRESH AIR FOR AT
SEEK MEDICAL ATTENTION FOR FIRST AID.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Unusual Fire/Explosion Hazard:NONFLAMMABLE, HOWEVER, ARCS, SPARKS AND
MOLTEN METAL CAN IGNITE FLAMMABLES AND COMBUSTIBLES OR CAUSE
EXPLOSIONS.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DEPARTMENT OF TRANSPORTATION APPROVED
CONTAINERS AND DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. AVOID I NHALATION AND SKIN EXPOSURE.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:COVERED WELDING ELECTRODES ARE SOLID WIRE WITH A
FLUX COATING.
* Stability and Reactivity Data *
Hazardous Decomposition Products:GASEOUS REACTION PRODUCTS MAY INCLUDE
CARBON MONOXIDE, OZONE AND NITROGEN OXIDES. CHLORINATED SOLVENTS
MAY BE DECOMPOSED INTO TOXIC GASES SUCH AS PHOSGENE.
* Toxicological Information*
Toxicological Information:THE STUDIES FORMING THE BASIS FOR THIS
CLASSIFICATION WERE FROM OPERATIONS OTHER THAN WELDING OF CHROMIUM
OR NICKEL. THERE IS CONSIDERABLE CONTROVERSY ON THE EXTENT OF THE
RESPIRATORY CANCER PROBLEMS DUE TO NICKEL & CHROMIUM. IN ADDITION
A SMALL AMOUNT OF SILICA IS ALSO PRESENT & IT IS A PROBABLE
CARCINOGEN. NEVERTHELESS EXPOSURES MUST BE MAINTAINED BELOW THE
LEVELS SPECIFIED IN THE INGREDIENTS SE CTION. *THE LIMIT FOR
WELDING FUMES NOT OTHERWISE CLASSIFIED IS 5 MG/M3. SOME ELEMENTS OR
COMPONENTS WILL EXCEED THEIR PELS/TLVS BEFORE THE TOTAL FUMES
EXCEED 5 MG/M3.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS
* MSDS Transport Information *
Transport Information:NOT PROVIDED
* Regulatory Information *
SARA Title III Information:WELDING PRODUCTS LISTED IN THE INGREDIENTS
SECTION OF THIS MATERIAL SAFETY DATA SHEET CONTAIN TOXIC CHEMICALS
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED, AIR PURIFYING, HALF MASK OR FULL
FACEPIECE RESPIRATOR WITH APPROPRIATE FILTER PAD OR CARTRIDGE(S).
Ventilation:LOCAL EXHAUST/MECHANICAL
Other Protective Equipment:LONG SLEEVE, LOOSE FITTING CLOTHING &
BARRIER CREAM.
Supplemental Safety and Health
THIS PART MANUFACTURED BY: BABCOCK & WILCOX, INSULATING PRODUCTS
* Product Identification *
Product ID:KAOWOOL STANDARD BLANKET (NF OR NON-NF)
* Composition/Information on Ingredients *
Ingred Name:ALUMINOSILICATE
OSHA PEL:2 F/CC
ACGIH TLV:2 F/CC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN IRRITATION. REPEATED INHALATION
OF RESPIRABLE FREE CRYSTALLINE SILICA DUST MAY CAUSE DELAYED LUNG
INJURY (SILICOSIS). REMOVAL OF THIS PRODUCT AFTER USE MAY RESULT IN
THE GENERATION OF DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN IRRITATION
* First Aid Measures *
First Aid:TERMINATE EXPOSURE
*Handling and Storage *
Handling and Storage Precautions:THIS PRODUCT AS MANUFACTURED IS AN
ALUMINOSILICATE WHICH COULD TRANSFORM UPON HEATING TO MULLITE &
CRISTOBALITE (A FORM OF CRYSTALLINE SILICA).
Other Precautions:REMOVAL OF PRODUCT MAY GENERATE DUST.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:WOOL-LIKE FIBROUS MATERIAL. NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:ROUTINE HOUSEKEEPING
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION AS REQUIRED
Ventilation:LOCAL EXHAUST IS ADEQUATE
Other Protective Equipment:PROTECTIVE CLOTHING AND EQUIPMENT
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Ingred Name:LIQUIFIED PETROLEUM GAS, SWEETENED
Ingred Name:TOLUENE (SARA III)
Ingred Name:ACETONE (SARA III)
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
* Hazards Identification *
Effects of Overexposure:INHALATION:
DIZZINESS/HEADACHES/UNCONSCIOUSNESS/IRRITATION/DERMATITIS.
* First Aid Measures *
SOAP/WATER. REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE FROM
EXPOSURE. IF BREATHING IS IRREGULAR/STOPPED, START ARTIFICIAL
RESP/OXYGEN. INGESTI ON: DON'T INDUCE VOMITING. DRINK WATER.
* Fire Fighting Measures *
Lower Limits:1.8%
Upper Limits:9.5%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Unusual Fire/Explosion Hazard:TREAT AS CYLINDERS OF COMPRESSED GAS
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. CLEAN UP WITH INERT MATERIALS AND DIOSE OF IN ACCORDANCE
WITH ALL LOCAL, STATE AND FEDERAL LAWS.
*Handling and Storage *
Handling and Storage Precautions:DON'T STORE IN DIRECT SUNLIGHT, NEAR
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING VA
ORS AND INHALING CONTENTS CAN BE HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:>1
Evaporation Rate & Reference:(ETHER = 1): <1
Solubility in Water:NEG.
Appearance and Odor:YELLOW/ETHEREAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI METALS, MINERAL ACIDS
Stability Condition to Avoid:OPEN FLAMES, SPARKS, ELECTRICAL SPARK
SOURCES.
Hazardous Decomposition Products:HALOGEN ACIDS/CO/OTHER TOXIC CHEMICALS
* Disposal Considerations *
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE. EMPTY CONTAINERS
MAY BE DISPOSED OF THROUGH NORMAL CHANNELS. FULL OR PARTIALLY
FILLED CONTAINERS ARE CONSIDERED HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
End of preview. Expand
in Dataset Viewer.
Safety Data Sheets Eyes Protection Classification
This dataset is a smaller version of the SDS-Eyes-Protection-Classification dataset.
- Downloads last month
- 30
Size of downloaded dataset files:
12.2 MB
Size of the auto-converted Parquet files:
12.2 MB
Number of rows:
8,000