text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
Control Measures
*
Cage: WACKE
Country: MX
Proprietary Ind: Y
*
Contractor Summary
*
Cage: WACKE
Country: MX
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE:IRRIT. SKIN:IRRIT, MAY CAUSE DEFAT. INHAL:RESP TRACT
IRRIT. INGEST:NO TOX EFTS EXPECTED. ACUTE/CHRONIC:NOT KNOWN. HUMAN HLTH HAZS
APPLY ONLY TO PROD AS PACKAGED & IN ITS COMPLETELY CURED FORM. HAZ S OF
CURE BY-PRODS ARE DESCRIBED AS FOLLOWS. MATL RELSES CYCLOHEXYLAMINE UPON
MOISTURE CURING. EXPOS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:TO CYCLOHEXYLAMINE VAPS MAY
CAUSE IRRIT OF EYES, MUCOUS MEMBRANES & SKIN. DIRECT CONT W/EYES &
SKIN WILL CAUSE BURNS & MAY CAUSE PERM DMG. REVERSIBLE NARCOTIC EFT WAS
NOTED IN THREE CASES OF ACUTE HUMAN EXPOS. POSITIVE MUTAGENIC RSLTS WERE
NOTED IN TWO EXPERS. UPON COMPLETION OF CURING PROCESS, (SUP DAT)
Medical Cond Aggravated By Exposure: THERE ARE NOT DATA AVAILABLE WHICH ADDRESS
MEDICAL CONDITIONS WHICH ARE GENERALLY RECOGNIZED AS BEING AGGRAVATED BY
EXPOSURE TO THIS PRODUCT.
EYELIDS APART TO INSURE RINSING OF ENTIRE SURF OF EYE & LIDS W/WATER. GET
MED ATTN IMMED. SKIN:REMOVE EXCESS MATL W/WATERLESS SKIN CLE ANER. FLUSH WELL
W/WATER & WASH WELL W/WATER & SOAP. REMOVE CONTAM CLTHG & SHOES.
GET MED ATTN IMMED. INGEST:GIVE SEVERAL GLASSES OF WATER & INDUCE VOMIT
BY PLACING FINGER ON BACK OF VICTIM'S
*
Handling and Disposal
*
Spill Release Procedures: MAKE SURE ALL PERS INVOLVED IN SPILL CLEANUP FOLLOW
GOOD INDUST HYGIENE PRACT (REFER TO HYGIENE PRACT). ANY PERSON ENTERING
SIGNIFICANT SPILL AREA OR AN UNKNOWN CONCENTRATION OF VAPOR OR AEROSOL SHOUL
D USE A NIOSH/MSHA POSITIVE-PRESSURE SCBA
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF EMPTY CONTAINERS ACCORDING TO ANY APPLICABLE
REGUFEDERAL, STATE AND LOCAL REGULATIONS UNDER THE RESOURCE CONSERVATION AND
RECOVERY ACT. NOTE:STATE AND LOCAL REGULATIONS MAY BE MORE STRINGEN T THAN
FEDERAL.
Handling And Storage Precautions: STORE IN A COOL, DRY, WELL VENTILATED AREA.
EXERCISE DUE CAUTION TO PREVENT DAMAGE TO THE CONTAINER. THIS PROD IS
CONSIDERED FLAM LIQ & IS FIRE HAZ.
Other Precautions: IT SUPPORTS COMBUST & DECOMPOSES UNDER FIRE CNDTNS TO
GIVE OFF TOX MATLS. DO NOT USE WELDING/CUTTING TORCH ON/NEAR ANY CNTNR OF
MATL, EVEN IF EMPTY, BECAUSE AN EXPLO CAN OCCUR. DO NOT POUR, SPILL/STOR E
NEAR HEAT, SPK SOURCES/OPEN
*
Fire and Explosion Hazard Information
*
Flash Point Method: PMCC
Extinguishing Media: USE STANDARD FIRE FIGHTING TENIQUES TO EXTINGUISH FIRES
INVOLVING THIS MATL:USE WATER SPRAY, DRY CHEM OR CARBON DIOXIDE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). AS IN ANY FIRE, PVNT HUMAN EXPOS TO FIRE, SMK, FUMES/PRODS OF COMBUST.
EVAC NON-ESSNTL PERS FROM (SUP DAT)
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL ALONG GROUND,
BE MOVED BY VENT SYS, SETTLE IN PITS/LOW AREAS, & BE IGNITED BY IGNIT
SOURCES DIST FROM HNDLG PT. TO PVNT (SUP DAT)
*
*
Respiratory Protection: IF USE CNDTNS GENERATE AIRBORNE CONTAM, MATL SHOULD BE
HNDLD IN AN OPEN (E.G., OUTDOOR)/WELL VENT AREA. WHERE ADEQ VENT IS NOT
AVAIL, USE NIOSH/MSHA APPRVD ORG VAP RESPS W/DUST, MIST & FUME FILTER TO
REDUCE EXPOS. WHERE EXPOS POTNTL
Ventilation: IN THOSE CASES WHERE ENGINEERING CONTROLS ARE INDICATED BY USE
CNDTNS, FOLLOWING TRADITIONAL EXPOS CONTROL
Other Protective Equipment: EYEWASH STATIONS & SFTY SHOWERS SHOULD BE EASILY
ACCESSIBLE. SKIN CONT SHOULD BE MINIMIZED THRU USE OF
Work Hygienic Practices: ALL FOOD SHOULD BE KEPT IN A SEPARATE AREA AWAY FROM
STOR/USE LOCATION. EATING, DRINKING & SMKNG SHOULD BE
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). FIRE FIGHT PROC:FIRE AREA. EXPLO
HAZS:FIRE/EXPLO FROM STATIC ACCUM & DISCHARGE, EFTIVELY GROUND MATL
TRANSFER SYS. CNDTNS T O AVOID:CLSD TO PVNT EXPOS TO MOISTURE.EFTS OF
OVEREXP:CYCLOHEXYLAMINE WILL NO LONGER BE RELSD.
*
Physical/Chemical Properties
*
Vapor Pres: <1
Vapor Density: 3.4
Solubility in Water: NEGLIGIBLE
Appearance and Odor: VARIOUS COLORED LIQUIDS AMMONIACAL ADOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: REACTS W/ATM MOISTURE TO FORM CURED SEALANT,
RELSNG CYCLOHEXYLAMINE UNTIL CURING PROCESS IS COMPLETE. KEEP CNTNR(SUPDAT)
Materials To Avoid: UNCURED MATL:AVOID CONT W/WATER, ACIDS, ALCOHOL, STRONG
ALKALIES, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: SIO*2, CO, CO*2 AND VARIOUS HYDROCARBON
FRAGMENTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: WACKE
Company Name: WACKER MEXICANA
Country: MX
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: Slight
Hazard And Precautions: EXTREMELY FLAMMABLE. AVOID WATER. ACUTE:EYE:IRRITATION.
SKIN:IRRITATION, MAY CAUSE DEFATTING. INHAL:RESPIRATORY TRACT IRRITATION.
CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR
Ventilation:CHEMICAL FUME HOOD
Other Protective Equipment:SAFETY SHOWER & EYE BATH, OTHER PROTECTIVE
CLOTHING. FACESHIELD (8-INCH MINIMUM), RUBBER BOOTS
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHES BEFORE
REUSE. DISCARD CONTAMINATED SHOES. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NITRIC ACID, HYDROGEN NITRATE
OSHA PEL:5 MG/CUM
ACGIH TLV:5.2 MG/CUM
Ingred Name:MERCURY, QUICKSILVER
Other REC Limits:INORGANIC 0.1 MG/CUM
OSHA PEL:0.1 MG/CUM (SKIN)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANE & UPPER
RESPIRATORY TRACT TISSUE DESTRUCTION.
COUGHING/WHEEZING/LARYNGITIS/SHORTNESS OF BREATH/HEADACHE/NAUSEA &
VOMITING. SKIN: FATAL ABSORPTION/BURNING SENSATION/DESTRUCT IVE TO
TISSUE. EYES: BURNING SENSATION/DESTRUCTIVE TO TISSUE. INGESTION:
FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: FATAL AS A RESULT OF SPASM,
INFLAMMATION & EDEMA OF THE LARYNX & BRONCHI, CHEMICAL PNEUMONITIS
& PULMONARY EDEMA.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION:
WASH OUT MOUTH PROVIDED PERSON IS CONSCIOUS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL POWDER, ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS,
PLACE IN CLOSED CONTAINER S FOR DISPOSAL. VENTILATE AREA & WASH
SPILL SITE AFTER MATERIAL P ICKUP IS COMPLETE. EVACUATE AREA.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
Other Precautions:DON'T BREATH VAPORS. DON'T GET IN EYES, ON SKIN, OR
CLOTHES. AVOID REPEATED OR PROLONGED EXPOSURE.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR, COLORLESS, LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
* Disposal Considerations *
Waste Disposal Methods:EVAPORATE LIQUID & BAG RESIDUAL SOLID FOR BURIAL
IN A LANDFILL SITE APPROVED FOR HAZARDOUS-WASTE DISPOSAL.
CORROSIVE. HIGHLY TOXIC. NEUTRALIZE SOLUTION & ADD FILTERING AGENT
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPER RESPIRATOR SELECTION SHOULD BE DETERMINED
BY ADEQUATELY TRAINED PERSONNEL, BASED ON THE CONTAMINANTS, THE
DEGREE OF POTENTIAL EXPOSURE AND PUBLISHED RESPIRATORY PROTECTION
FACTORS. THIS SHOULD BE AVAILABLE FOR ROUTINE AND NONROUTINE
Ventilation:USE IN WELL VENTILATED AREA. IN CONFINED SPACE, MECHANICAL
VENTILATION MAY BE NECESSARY TO KEEP BELOW PEL/TLVS
Other Protective Equipment:IMPERVIOUS CLOTHING/BOOTS, EMERGENCY
EYEWASH/SHOWER. NOTTE: DO NOT CONTACT LENSES WHEN WORKING AROUND
THIS PRODUCT.
Work Hygienic Practices:LEATHER GOODS CONTAMINATED WITH THIS PRODUCT
SHOULD BE DISCARDED. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VAPORS MAY ACCUMULATE IN LOW AREAS. VAPORS MAY CONCENTRATE IN CONFINED
AREAS. USE ADEQUATE GROUNDING TO PREVENT STATIC BUILDUP. RUNOFF TO
SEWER MAY CAUSE FIRE OR EXPLOSION HAZARD. CONTAMINATED CLOTHIN G,
RAGS OR SIMILAR ORGANIC MATERIAL STORED IN CLOSED SPACE MAY
SPONTANEOUSLY IGNITE.
* Product Identification *
Product ID:CRUDE OIL
Preparer's Name:SUE BOTTOM
* Composition/Information on Ingredients *
Ingred Name:BENZENE (SARA III)
Fraction by Wt: 0.1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:BUTANE
Fraction by Wt: 1-7% %
Other REC Limits:NONE SPECIFIED
Ingred Name:CYCLOHEXANE (SARA III)
Fraction by Wt: <1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:CYCLOPENTANE
Fraction by Wt: <1-2% %
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL BENZENE (SARA III)
Fraction by Wt: <1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-HEPTANE
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXANE (N-HEXANE)
Fraction by Wt: 2-8% %
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HYDROGEN SULFIDE (SARA III)
Fraction by Wt: <0.1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYLCYCLOHEXANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:NONANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:OCTANE
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
Ingred Name:PENTANE
Fraction by Wt: 1-6% %
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:SULFUR
Fraction by Wt: <0.1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: <1-2% %
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: <1-3% %
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXANE (ISOMERS OTHER THAN N-HEXANE)
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE IRRITATION,
CONJUNCTIVITIS, MAY CAUSE MODERATE SKIN IRRITATION, DEFATTING,
DERMATITIS, NASAL AND RESPIRATORY TRACT IRRITATION, CENTRAL NERVOUS
SYSTEM EFFECTS, POSSIBLE SECONDARY I NFECTION, ANEMIA, IRREGULAR
HEART RHYTHM, BEHAVIORAL CHANGES, HARMFUL OR FATAL IF SWALLOWED,
GASTROINTESTINAL DISTURBANE
Explanation of Carcinogenicity:BENZENE, A COMPONENT OF CRUDE OIL, IS
LISTED AS A CARCINOGEN BY NTP, IARC AND OSHA.
Effects of Overexposure:EYE IRRITATION, REDNESS, TEARING, BLURRED
VISION, SKIN IRRITATION, CRACKING, REDNESS, ITCHING, INFLAMMATION,
EXCITATION, EUPHORIA, CONTRACTED EYE PUPILS, DIZZINESS, DROWSINESS,
FATIGUE, NAUSEA, HEADAC HE, LOSS OF REFLEXES, TREMORS, CONVULSIONS,
SEIZURES, LOSS OF CONSCIOUSNESS, COMA, DEPRESSION, DIARRHEA,
VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, HEART,
CENTRAL NERVOUS SYSTEM AND RESPIRATORY DISORDERS MAY BE AGGRAVATED
BY EXPOSURE TO THIS PRODUCT. IMPAIRED KIDNEY, LIVER AND BLOOD
DISORDERS MAY BE AGGRAVATED.
* First Aid Measures *
First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
WATER. REMOVE CONTAMINATED CLOTHING PROMPTLY. HIGH PRESSURE SKIN
INJECTION S ARE SERIOUS MEDICAL EMERGENCIES! GET IMMEDIATE MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY.
INGESTION: DO NOT INDUCE VOMITING. GIVE VEGETABLE OIL. GET MEDICAL
ATTENTION
* Fire Fighting Measures *
Lower Limits:0.4 %
Extinguishing Media:DRY CHEMICAL, HALON, FOAM AND CARBON DIOXIDE ARE
PREFERRED. FOAM AND WATER FOG CAN CAUSE FROTHING.
Fire Fighting Procedures:PRODUCT WILL RELEASE FLAMMABLE VAPORS WHICH
CAN BURN IN OPEN OR BE EXPLOSIVE IN CONFINED SPACE. PUMP CONTENTS
FROM TANK AND COOL TANKS WITH WATER.
Unusual Fire/Explosion Hazard:IMPROPER USE OF WATER MAY CAUSE FROTHING
AND SPREAD FIRE OVER LARGER AREA. VAPOR OR GAS MAY SPREAD TO
DISTANT IGNITION SOURCES AND FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. DO NOT ENTER
OR STAY IN AREA UNLESS MONITORING INDICATES OK. ISOLATE HAZARD
AREA; RESTRICT ENTRY. RECOVER AS MUCH AS POSSIBLE. THEN ABSORB AND
HANDLE IAW ENVIRONMENTAL REGULATIONS. KEEP OUT OF
SEWERS/WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARK AND FLAMES.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL ON OR NEAR THIS
CONTAINER. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:SPECIAL H2S WARNING: CARE MUST BE TAKEN BY THOSE WHO
ARE RENDERING AID TO THE VICTIM BECAUSE H2S MAY BE IN AREA AND MAY
ALSO OVERCOME RESCUERS UNLESS IT HAS BEEN DETERMINED THAT THE AREA
IS FREE OF HY DROGEN SULFIDE.
* Physical/Chemical Properties *
HCC:F2
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Density:> 1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:DARK BROWN/BLACK LIQUID WITH HYDROCARBON/SULFIDE
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS (PEROXIDE, DICHROMATE, PERMANGANATE,
CHLORINE, ETC), STRONG ACIDS, CAUSTICS AND HALOGENS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, STATIC
ELECTRICITY OR OTHER POTENTIAL IGNITION SOURCES SHOULD BE AVOIDED.
DO NOT SWITCH LOAD.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
REACTIVE HYDROCARBONS (ALDEHYDES, AROMATICS, ETC) COMPOUNDS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF MATERIAL IN ACCORDANCE WITH LOCAL,
COUNTY, STATE AND FEDRAL REGULATIONS. CONTACT STATE AND FEDERAL
REGULATORS TO DETERMINE WASTE CLASSIFICATION. USE LICENSED
TRANSPORTER AND DISPOSAL FACILI TY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Other Protective Equipment:FOR USE OTHR THAN NORM CUSTOMER-OPERATING
PROC (SEE SUPP DAT
Supplemental Safety and Health
EQUIPMENT. OTHER PROT:(SUCH AS IN BULK TONER PROCESSING
XEROX.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CARBON BLACK
OSHA PEL:3.5 MG/M3
Ingred Name:SILICA, AMORPHOUS, DUST
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
Fraction by Wt: <5%
* Hazards Identification *
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRIT MAY OCCUR AS
W/EXPOS TO LRG AMTS OF ANY NONTOXIC DUST.(SEE OTHR PREC
* First Aid Measures *
H*2O. INHALATION:REMOVE FROM EXPOSURE. INGESTION:DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF H*2O.
* Fire Fighting Measures *
Extinguishing Media:WATER,FOAM,DRY CHEMICAL
Fire Fighting Procedures:AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR,IT FORMS EXPLOSIVE MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:LOOSE TONER CAN BE REMOVED USING A VACUUM
CLEANER. RESIDUE CAN BE REMOVED W/SOAP & COLD WATER. AFTER REMOVAL
OF LOOSE TONER,GARMENTS MAY BE WASHED OR DRY CLEANED.
*Handling and Storage *
Handling and Storage Precautions:NONE
Other Precautions:MFR:MATL HAS BEEN TESTED&EVALUATED BY ZEROX CORP.WHEN
USED AS INTENDED,DOES NOT REPRESENT A HEALTH/SAFETY
ENTRY ROUTE:INHALATION
OTHER PROT:(SUCH AS IN BULK TONER PROCESSING
* Physical/Chemical Properties *
Spec Gravity:1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER/FAINT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.AVOID
BREATHING SMOKE.
* Disposal Considerations *
Waste Disposal Methods:DO NOT INCINERAATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. INSURE CONFORMITY W/FEDERAL,STATE OR LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
APPLICABLE LIMITS, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING THE DRIED
FILM, WEAR A DUST/ MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE TO
MAINTAIN BELOW APPLICABLE EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
HLTH HZRD CONT'D: METHYL ETHYL KETONE MAY INCREASE THE NERVOUS SYSTEM
EFFECTS OF OTHER SOLVENTS. OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. PREC CONT'D: CONTENTS
EXTRE MELY FLAMMABLE & UNDER PRESSURE. AVOID BREATHING VAPOR/SPRAY
MIST. AVOID CONTACT W/SKIN & EYES.
* Product Identification *
* Composition/Information on Ingredients *
ACGIH TLV:SIMPLE ASPHYXIANT
Fraction by Wt: 4%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
Fraction by Wt: 5.3%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
Fraction by Wt: 3%
Ingred Name:ZINC COMPOUND
Fraction by Wt: 3%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION & POSSIBLE DEATH.
PROLONGED OVEREXPOSURE TO SOLVENT MAY CAUSE ADVERSE EFFECTS TO THE
LIVER/URINARY/BLOOD FORMING/CARD IOVASCULAR & REPRODUCTIVE SYSTEM.
HEXANMAY CAUSE DAMAGE TO NERVE TISSUE OF THE ARMS & LEGS(PERIPHERAL
NEUROPATHY).(SUPP
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
MOUTH T O AN UNCONSCIUOS PERSON. DON'T INDUCE VOMITING. GIVE
SEVERAL GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:0.7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
EXTREME HEAT. APPLICATION TO HOT SURFACES NEEDS SPECIAL PRECAUTION.
OVEREXPOSURE TO DECOMPOSITION MAY CAUSE A HEALTH HAZARD
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE AREA &
REMOVE W/INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
KEEP AREA VENTILATED. USE APPROVED BONDING/GROUNDING PROCEDURES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T TAKE INTERNALLY.
DON'T SMOKE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL/FATAL. VAPORS WILL ACCUMULATE
READILY & MAY I GNITE EXPLOSIVELY. (SEE SUPP)
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME, HOT SURFACES.
Hazardous Decomposition Products:BY FIRE: CO2, CO.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. WASTE MAY BE HAZARDOUS UNDER THE RCRA & MUST BE TESTED
FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE
NUMBERS. WASTE FROM METHYL ET HYL KETONE MAY REQUIRE TESTING FOR
EXTRACTABILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AMMONIA (SARA III)
Fraction by Wt: <0.5%
Ingred Name:2-BUTOXYETHOXYETHANOL
Fraction by Wt: <5%
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:VAPORS: ANESTHETIC,RESP TRACT
IRRIT,LIGHTHEADEDNESS,STAGGER GAIT. EYE/SKIN: IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE,RESTORE BREATHING,CONSULT
WASH WITH SOAP AND WATER,REMOVE CONTAMINATED CLOTHING.
* Fire Fighting Measures *
Lower Limits:0.9
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM.
Fire Fighting Procedures:SELF-CONTAIN BREATH APP,WATER FOG TO COOL
EXPOSED CONTAINERS
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE FROM
PRESSURE BUILD UP WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER. AVOID
EYE/SKIN CONTACT & BREATH OF VAPOR/SPRAY MIST. GROUND CONTAINER
WHEN POURING. USE WITH ADEQUATE VENTILATION.
Other Precautions:DO NOT TAKE INTERNALLY.KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:<1 (ETHER)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH LOCAL,STATE AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESTRICT VENT:CHEM-MECH FLTR.CLSD:AIR-LINE TYPE
Ventilation:GENDILTN/LOCA EXHST TO KEEP TLV/LEL BELOW LIMIT, REMV FUME
Other Protective Equipment:AVOID LONG EXPOSURE TO CONTAM CLOTHING
Supplemental Safety and Health
DENSITY:HEAVIER THAN AIR;WT PER GALLON:7.8 LBS
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: <5.0%
Ingred Name:ETHYL BENZENE (SARA III)
Fraction by Wt: <5.0%
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
Fraction by Wt: <5.0%
* Hazards Identification *
Effects of Overexposure:INH:ANESTHETIC, IRRIT OF RESP TRACT OR ACUTE
CNS DEPRSSN W/HDACHE,DIZ,UNCON,COMA. SKIN & EYE:IRRIT
* First Aid Measures *
First Aid:IN CASE OF CONTACT, FLUSH SKIN & EYES W/PLENTY OF WATER WHILE
REMOVING CONTAMINATED CLOTHING. IF INHALED, REMOVE TO FRESH AIR.
CAL A PHYSCIAN IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Lower Limits:0.9
Extinguishing Media:SM FIRES:CO*2,DRY CHEM. LG FIRES:POLYMER FOAM
PREFERRED
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:CLOSED CONTANERS EXPOSED TO HEAT MAY
EXPLODE DUE TO PRESSURE BUILD-UP.
* Accidental Release Measures *
Spill Release Procedures:REMOVE AL SOURCES OF IGNITION (FLAE,HOT
SURFACES&ELECTRICAL, STATIC, OR FRICTIONAL SPARKS).AVOID BREATING
VAPORS. VENTILATE AREA.REOVE W/INERT ABSORBENT & NON-SPARKING
TOOLS.
*Handling and Storage *
IN BLDG DESIGNED TO STORE NFPA CLASS ONE FLAM LIQ DO NOT TAKE
INTERNALLY.ADD LABEL WARNING.
Other Precautions:GROUND CONTANERS WHEN POURISNG. AVOID FREE FAL OF LIQ
IN EXCESS OF FEW IN DO NOT FLAME CUT,BRAZE OR WELD COATED MATERIAL
W/O APPROVED RESPIRATOR OR APROPRIATE VETLATION. DOT:FLAM LIQUID.
* Physical/Chemical Properties *
HCC:F2
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID FIRES HEAT & HOT SURFACES
* Disposal Considerations *
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTANER.DISPOSE IN
ACCORDANCE W/FED.,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN IN
ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN APPROVED FUME
HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST/INHAL: TOXIC. INGEST CAN
PRODUCE BLINDNESS. SKIN: ABSORP CAN BE TOXIC. AFFECTS CNS,
ESPECIALLY OPTIC NERVE. MARKED IMPAIRMENT OF VISION & ENLARGEMENT
OF LIVER HAS BEEN REPORTED W/ CHRONIC EXPOS . CAUSES DIZZ, NAUS,
MUSCLE WEAKNESS, NARCOSIS, RESP FAILURE. SKIN: PRLNG/RPTD CONTACT
MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN CONDITIONS, EYE PROBLEMS, OR
IMPAIRED LIVER OR KIDNEY FUNCTION.
* First Aid Measures *
First Aid:GET MD ASSIST FOR ALL CASES OF OVEREXP. SKIN: WASH THORO
W/SOAP & WATER. EYES: IMMED FLUSH THORO W/LARGE AMOUNTS OF WATER
BREATHING H AS STOPPED. INGEST: GET IMMED MD ATTN. IF MD ATTEN IS
NOT IMMED AVAILABLE , INDUCE VOMITING. DO NOT INDUCE VOMITING IF
PATIENT IS UNCONSCIOUS. REMOVE CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:6.7%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, CO2, WATER MIST.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPOR CAN TRAVEL DISTANCES TO IGNITION
SOURCES AND FLASH BACK. CLOSED CONTAINERS MAY EXPLODE UPON HEATING.
* Accidental Release Measures *
Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT;
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR CLOSED. STORE IN COOL AREA
AWAY FROM IGNIT SOURCES & OXIDIZERS. DO NOT BREATHE VAPOR/SOLN
MIST. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING.
Other Precautions:ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING THIS
PRODUCT.
* Physical/Chemical Properties *
HCC:F5
Vapor Density:1.1
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID, CHARACTERISTIC ALCOHOLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, REACTIVE METALS.
Stability Condition to Avoid:HEAT; CONTACT WITH IGNITION SOURCES.
Hazardous Decomposition Products:COX, FORMALDEHYDE.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF FUMES ARE >TLV, USE A NIOSH APPROVED
RESPIRATOR SUCH AS AN AIR PURIFYING RESPIRATOR FOR ORGANIC VAPORS
OR A SUPPLIED AIR RESPIRATOR.
Ventilation:PROVIDE AMBIENT VENTILATION.
Other Protective Equipment:LONG SLEEVE SHIRT & LONG PANTS
Work Hygienic Practices:IN OUTDOOR APPLICATIONS WHERE MATERIAL IS
HEATED, KEEP KETTLE DOWNWIND OF WORKERS.
Supplemental Safety and Health
THIS PETROLEUM BASED PRODUCT CONTAINS A SMALL AMOUNT OF POLYAROMATIC
HYDROCARBONS WHICH HAVE BEEN SHOWN TO CAUSE CANCER & RESPIRATORY
DAMAGE IN LABORATORY ANIMALS. MOUSE SKIN PAINTING STUDIES GIVE EVI
DENCE OF SKIN CANCER.
* Product Identification *
Product ID:BUR ASPHALT
* Composition/Information on Ingredients *
Ingred Name:ASPHALT (PETROLEUM)
Other REC Limits:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY TRACT
(NOSE & THROAT) IRRITATION, NAUSEA, & DIZZINESS. SKIN: DERMATITIS,
CONTACT W/HOT MATERIAL WILL CAUSE THERMAL BURNS, & INCREASE
SENSITIVITY TO SUNBURN. EYES/INGESTIO N: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: ASPHALT CAUSES RESPIRATORY DAMAGE,
NAUSEA, & DIZZINESS. SKIN: DERMATITIS, CONTACT W/HOT MATERIAL
CAUSES THERMAL BURNS, & ASPHALT FUMES INCREASES SENSITIVITY TO
SUNBURN. EYES/INGESTION: IRR ITATION. HYDROGEN SULFIDE IS A HIGHLY
TOXIC GAS, AT LOW CONCENTRATIONS CAN CAUSE RAPID UNCONSCIOUSNESS &
DEATH.
* First Aid Measures *
First Aid:EYE: FLUSH W/WATER. SKIN: IF HOT ASPHALT STRIKES AREA, DRENCH
W/COLD WATER. APPLY ICED WATER/ICE PACKS TO BURNED AREA IF BURN
REMOVE AS PHALT FROM BURN AREA. WASH COOL ASPHALTW/HOT SOAPY WATER.
USE WATERLESS HAND CLEANER. INGESTION: DON'T INDUCE VOMITING.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN. SEEK MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL. WATER FOG MAY BE USED ON
FLAT SURFACES SUCH AS ROADS.
Fire Fighting Procedures:DON'T ENTER CONFINED SPACE W/O FULL TURNOUT
GEAR INCLUDING SELF-CONTAINED BREATHING APPARATUS. WATER MAY BE
USED TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HOT ASPHALT MAY IGNITE FLAMMABLE MATERIAL
ON CONTACT. DON'T USE WATER ON ASPHALT FIRE IN TANK/CONTAINERS,
CAUSES VIOLENT ERUPTION/SPREADING OF BURNING ASPHALT.
* Accidental Release Measures *
Spill Release Procedures:DIKE STORAGE TANKS TO PREVENT MATERIAL FROM
ENTERING SEWERS OR WATERWAYS. USE APPROPRIATE CONTAINMENT (BOOMS,
ETC.) TO PREVENT DISPERSION WHEN A SPILL IS OUT OF DIKED AREA OR
HAS REACHED A WATERWAY.
*Handling and Storage *
Handling and Storage Precautions:HYDROGEN SULFIDE IS EMITTED FROM
HEATED ASPHALT & MAY ACCUMULATE IN STORAGE TANKS & BULK TRANSPORT
COMPARTMENTS.
Other Precautions:THE ODOR OF HYDROGEN SULFIDE CANNOT BE USED AS AN
INDICATOR OF CONCENTRATION OF THE GAS. ALWAYS EXERCISE CAUTION WHEN
WORKING AROUND CLOSED BULK CONTAINERS OF ASPHALT. USE VENTILATION
OR WORK UPWIND F ROM SOURCE OF FUMES OR VAPORS.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN TO BLACK SEMISOLID/FAINT PETROLEUM ODOR
Percent Volatiles by Volume:0%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HOT MOLTEN PRODUCT IN CONTACT W/WATER OR LIQUIDS
Hazardous Decomposition Products:CO, CO2, OXIDES OF SULFUR & VARIOUS
HYDROCARBONS, HYDROGEN SULFIDE (HIGHLY TOXIC GAS & EXTREMELY
FLAMMABLE)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. PRIMARY DISPOSAL IS IN A MUNICIPAL OR
INDUSTRIAL LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR WHEN VAPOR/MIST EXPOSURE IS LIKELY.
Ventilation:GENERAL MECHANICAL AND LOCAL EXHAUST IN ACCORDANCE WITH
ACGIH RECOMMENDATIONS.
Supplemental Safety and Health
* Product Identification *
Product ID:PUR-FECT TOOL I HARDENER
Kit Part:Y
Preparer's Name:PETER HENIGE
CAGE:CIBAG
CAGE:CIBAG
* Composition/Information on Ingredients *
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
Other REC Limits:NONE SPECIFIED
Ingred Name:BARIUM SULFATE
Other REC Limits:NONE SPECIFIED
Ingred Name:GLASS, OXIDE *(5 MG/M3 RESPIRABLE)
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 RDUST *
Ingred Name:SOLVENT NAPHTHA, (PETROLEUM) HEAVY AROMATIC
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES ALLERGIC SKIN AND EYE
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTIONS.
Effects of Overexposure:CAUSES ALLERGIC SKIN AND EYE IRRITATION. MAY
CAUSE ALLERGIC SKIN REACTIONS.
Medical Cond Aggravated by Exposure:SKIN AND EYE CONDITIONS.
* First Aid Measures *
DOCTOR.SKIN:WASH WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING &
LAUNDER BEFORE RE-USE.INGESTION:IF CONSCIOUS,GIVE PLENTY OF WATER
TO DRINK.DO NOT INDUCE VOMITING.CALL A PHYSICIAN.INHALATION:REMOVE
TO FRESH AIR.GIVE OXYGEN AND/OR ARTIFICIAL RESPIRATION,IF
NEEDED.CALL A DOCTOR.OTHER:REFERRAL TO A DOCTOR IS RECOMMENDED IF
THERE ARE QUESTIONS.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, OR WATER.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SPILLAGE BY ABSORBING IN ABSORBENT
MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:NUISANCE DUST MAY BE GENERATED WHEN
SANDING OR SAWING CURED MATERIAL. WARNING!CAUSES SKIN AND EYE
IRRITATION.MAY CAUSE ALLERGIC SKIN REACTION.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. WASH THOROUGHLY AFTER
HANDLING.
* Physical/Chemical Properties *
Solubility in Water:SLIGHT
Appearance and Odor:DARK GREY, AROMATIC SOLVENT ODOR
Percent Volatiles by Volume:NEG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND BASES.
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:COMBUSTION MAY FORM TOXIC MATERIALS
SUCH AS CARBON DIOXIDE, CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CONSULT QUALIFIED LOCAL OR CORPORATE PERSONNEL
FOR METHOD THAT WILL COMPLY WITH LOCAL, STATE AND FEDERAL HEALTH
AND ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR CASUAL/OCCAS USE:TO AVOID BRTHG VAPS/SPRAY
MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE FRESH AIR
ENTRY DURING APPLICATN & DRYING. IF YOU EXPER EYE WATERING,
HDCHS/DIZZ, INCR FRESH AIR, WE AR NIOSH/MSHA APPRVD RESP PROT
(SUPDAT)
Ventilation:FOR REGULAR/CONTINUOUS USE:PROVIDE SUFFICIENT MECH
(GENERAL) &/OR LOC EXHST VENT TO MAINTAIN EXPOS BELOW TLV'S.
Other Protective Equipment:WHERE SPECIAL OR UNUSUAL CONDITIONS EXIST
THE EXPERT ASSISTANCE OF AN INDUSTRIAL HYGIENIST SHOULD BE SOUGHT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM. AS
W/ALL CHEMICALS, MINIMIZE PERSONAL CONTACT & BREATHING OF VAPORS.
Supplemental Safety and Health
FIRE FIGHT PROC:AUTOIGNITION OR EXPLO WHEN EXPOSED TO EXTREME HEAT. IF
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPHATIC; (ALIPHATIC
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 0-5%
Ingred Name:CHROMATE (1-), HYDROXYOCTAOXODIZINCATEDI-, POTASSIUM; (ZINC
POTASSIUM CHROMATE)
OSHA PEL:0.1 (CRO*3)MG/M3, C
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE MIXTURE) (PROPELLANT). EVAP
Ingred Name:SIGNS & SYM:SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERN LATEST HAZ LIST INFO & SAFE HNDL & EXPOS (
ING 8)
Other REC Limits:NONE SPECIFIED
Ingred Name:ING 8:RECOMMENDATIONS
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:EXCESS INHAL OF VAPS CAN
CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON
& EVEN ASPHYX. EYE:CAN CAUSE SEV IRRIT, REDNESS, TEARING, BLURRED
VISION. INGEST:CAN CAUSE GI IR RIT, NAUS, VOMIT, DIARR. SKIN:CAN
CAUSEIRRIT FOR SOME PERSONS. CHRONIC:REPORTS HAVE ASSOC RPTD &
PRLNG(EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC POTASSIUM CHROMATE:GROUP 1(NTP),
GROUP 1(IARC).
Effects of Overexposure:HLTH HAZ:OCCUP OVEREXP TO SOLVS W/PERM BRAIN &
NERV SYS DMG. SEV OVEREXP IN LAB ANIMALS HAS ALSO CAUSED LIVER
ABNORM & DMG TO KIDNEYS, LUNGS & SPLEEN, HEART & ADRENALS. INTENT
MISUSE BY DELIB CONC & I NHAL CONTENTS MAY BE HARMFUL OR
REPRO HAZ.ING 7)
Medical Cond Aggravated by Exposure:CAN CAUSE ALLERGIC RESPIRATORY &/OR
SKIN REACTION.
* First Aid Measures *
First Aid:INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG DFCLT, ADMIN
O*2. IF BRTHG STOPPED, GIVE ARTF RESP & SEE MD. EYES:FLUSH W/H*2O
INGEST:DO NOT INDUCE VOMIT (ASPIR OF MATL INTO LUNGS CAN CAUSE
CHEM PNEUM, WHICH CAN BE FATAL). KEEP PERS WARM, QUIET & GET
MD/POIS CTL CTR. SKIN:WASH W/SOAP & H*2O/VARIOUS HAND CLEANERS &
WASH CLTHG BEFORE REUSE.
* Fire Fighting Measures *
Lower Limits:1%
Extinguishing Media:"ALCOHOL" FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. H*2O SPRAY MAY BE INEFT. H*2O MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILD-UP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE &/OR AUTOIGNITE
WHEN EXPOSED TO EXTREME HEAT. VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
AREA. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER
ABSORBENT MATERIAL & TRANSFER TO CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
DIRECT SUNLIGHT OR NEAR HEAT OR OPEN FLAMES. DO NOT PUNCTURE OR
INCINERATE.
Other Precautions:STORE LARGE QUANTITIES IN BUILDINGS PROTECTED FOR
STORAGE OF NFPA CLASS IC FLAMMABLE LIQUIDS.
H*2O IS USED, FOG NOZZ PREF. EXPLO HAZ:LIGHTS, OTHER FLAMES, SPKS,
HEATERS, SMOKING, ELEC MOTORS OR OTHER IGNIT SOURCES AT LOCATI ONS
AREA.
* Physical/Chemical Properties *
HCC:V3
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS & HEAT.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CO*2, CO,
VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS, ETC, WHEN BURNED.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN POSTED TOXIC SUBSTANCE LANDFILL I/A/W LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN NORMAL VENTILATION IS
AVAILABLE.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:A SOURCE OF CLEAN WATER SHOULD BE NEARBY IN
CASE OF ACCIDENTAL EYE CONTACT.
Work Hygienic Practices:CONTACT LENSES SHOULDN'T BE WORN WHEN WORKING
W/THIS PRODUCT.
Supplemental Safety and Health
* Product Identification *
Product ID:SFR
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
Fraction by Wt: 7%
Ingred Name:2-AMINOETHANOL, ETHANOLAMINE, MONOETHANOLAMINE
Fraction by Wt: 9%
Other REC Limits:3 PPM
OSHA PEL:3 PPM
ACGIH TLV:7.5 MG/CUM
Fraction by Wt: 1%
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:BUTANE, N-BUTANE
Fraction by Wt: 4%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION.
INHALATION: RESPIRATORY TRACT IRRITANT. MAY CAUSE NERVOUS SYSTEM
DEPRESSION. SKIN: ABSORPTION OF 2-BUTOXYETHANOL MAY RESULT IN BLOOD
ABNORMALITIES, KIDNEY & LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:ASTHMA & OTHER PULMONARY DISEASES.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPLY CPR IF BREATHING HAS
MINS. SKIN: FLUSH WELL W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN
ALL CASES .
* Fire Fighting Measures *
Flash Point:<0F PROPELLANT
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP CONTAINER COOL
* Accidental Release Measures *
Spill Release Procedures:ABSORB EXCESS MATERIAL W/ABSORBENT/RAG. RINSE
RESIDUE W/WATER.
*Handling and Storage *
Handling and Storage Precautions:DON'T STORE/USE NEAR HEAT, OPEN
ONLY IN UPSIDE DOWN POSITION.
Other Precautions:READ & FOLLOW ALL LABEL DIRECTIONS & PRECAUTIONS
BEFORE USING THE PRODUCT. PRODUCT IS FOR INDUSTRIAL & INSTITUTIONAL
USE ONLY. NOT FOR HOUSEHOLD USE/RESALE. KEEP OUT OF REACH OF
CHILDREN. DON'T USE IN CONFINED AREAS W/O VENTILATION.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:AN AEROSOL SPRAY W/FRESH CLEAN ODOR
Percent Volatiles by Volume:(SUPP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:CO2, CO
* Disposal Considerations *
Waste Disposal Methods:GIVE TO WASTE DISPOSAL COMPANY EQUIPPED TO
HANDLE PRESSURIZED CONTAINERS. DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:ADEQUATE
Supplemental Safety and Health
* Product Identification *
Product ID:RAPID E-6 COLOR DEVELOPER A
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Ingred Name:SODIUM PHOSPHATE MONOBASIC, MONOSODIUM PHOSPHATE
Ingred Name:POTASSIUM HYDROXIDE
Other REC Limits:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
Ingred Name:DIMETHYLAMINE BORANE
Fraction by Wt: 0-1%
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD. EYES:
IRRITATION. SKIN: ALLERGIC REACTION.
Explanation of Carcinogenicity:NONE
* First Aid Measures *
First Aid:INGESTION: INDUCE VOMITING. EYES: FLUSH W/PLENTY OF WATER FOR
W/NON-ALKALINE SKIN CLEANER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:MAY CAUSE PRODUCTION OF HAZARDOUS
DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER W/PLENTY OF WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:STORE AWAY FROM CHILDREN.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SLIGHT YELLOW SOLUTION W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
USE SOLUTION PH = 7.0
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE
Fraction by Wt: 6.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIDECYLDIMETHYL AMMONIUM CHLORIDE
Fraction by Wt: 9.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:OCTYLAMINE, N,N-DIMETHYL-, N-OXIDE
Fraction by Wt: 3.0%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION/BURNS. EYES:
IRRITATION/BURNS. INGESTION: BURNS.
* First Aid Measures *
First Aid:EYES: FLUSH IMMED W/COOL RUNNING WATER. REMOVE CONTACTS/KEEP
THOROUGHLY W/SOAP & WATER. INGESTION: RINSE MOUTH. DRINK 1-2 LARGE
GLASSES WAT ER. DON'T INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH
TO UNCONSCIOUS PERSON. CALL POISON CONTROL OR DR IMMEDIATELY.
* Fire Fighting Measures *
Fire Fighting Procedures:PRODUCT DOES NOT SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:DIKE/DAM LARGE SPILLS. PUMP TO CONTAINERS OR
SOAK UP ON ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTAMINATING FOOD/FOOD
PRODUCTS. DON'T STORE W/FOOD.
Other Precautions:KEEP AWAY FROM CHILDREN.
* Physical/Chemical Properties *
Spec Gravity:1.0
pH:8.0
Solubility in Water:COMPLETE
Appearance and Odor:RED LIQUID, NON-DESCRIPT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DON'T MIX W/ANYTHING BUT WATER.
* Disposal Considerations *
Waste Disposal Methods:CONSULT STATE/LOCAL AUTHORITIES FOR RESTRICTION
ON DISPOSAL OF CHEMICAL WASTE. RINSE EMPTY CONTAINER THOROUGHLY
W/WATER BEFORE DISCARDING.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR W/ADEQUATE VENTILATION.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
SPILL PROC: COMPLY WITH FEDERAL, STATE, AND LOCAL REGULATIONS ON
REPORTING RELEASES. REFER TO REGULATORY INFORMATION FOR REPORTABLE
QUANTITY AND OTHER REGULATORY DATA.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM CARBONATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POSSIBLY HARMFUL IF SWALLOWED.
IRRITATING TO EYES, SKIN, RESPIRATORY TRACT; MAY CAUSE EYE BURNS.
INGESTION CAN SEVERELY DAMAGE MUCOUS MEMBRANES AND CAUSE PAIN,
VOMITING, DIARRHEA AND CIRCULATORY COLLA PSE. AVOID SIMULTANEOUS
PRESENCE OF SODA ASH AND LIME DUST; THE COMBINATION IN THE PRESENCE
OF PERSPIRATION OR MOISTURE WILL CAUSE FORMATION OF CORROSIVE
CAUSTIC SODA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY
REMOVE TO FRESH AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED. INGESTION: DO NOT INDUCE VOMITING; IF CONSCIOUS, GIVE
WATER FREELY AND GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:EVACULATE THE AREA OF ALL UNNECESSARY
PERSONNEL. WEAR SUITABLE PROTECTIVE EQUIPMENT LISTED UNDER
EXPOSURE/PERSONAL PROTECTION. ELIMINATE ANY IGNITION SOURCES UNTIL
THE AREA IS DETERMINED TO BE FREE FR OM EXPLOSION OR FIRE HAZARDS.
CONTAIN THE RELEASE AND ELIMINATE ITS SOURCE, IF THIS CAN BE DONE
WITHOUT RISK. TAKE UP AND CONTAINERIZE FOR PROPER DISPOSAL AS
DESCRIBED UNDER DISPOSAL. (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED TIGHTLY. STORE
IN A COOL, DRY, WELL-VENTILATED AREA. STORE AWAY FROM MINERAL AND
ORGANIC ACIDS. DO NOT GET IN EYES. AVOID SKIN CONTACT.
* Physical/Chemical Properties *
HCC:T6
Boiling Pt:B.P. Text:DECOMPOSES
Evaporation Rate & Reference:NOT AVAILABLE
Appearance and Odor:WHITE GRANULAR POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, ALUMINUM, FLUORINE, PHOSPHORUS PENTOXIDE, SULFURIC ACID.
Stability Condition to Avoid:CONTACT WITH STRONG ACID MAY RESULT IN
Hazardous Decomposition Products:CO*2, NA*2O.
Conditions to Avoid Polymerization:DOES NOT OCCUR.
* Toxicological Information*
LABORATORY ANIMALS INDICATE MATERIAL MAY PRODUCE ADVERSE
REPRODUCTIVE EFFECTS. CITED IN REGISTRY O F TOXIC EFFECTS OF
CHEMICAL SUBSTANCES (RTECS).
* Disposal Considerations *
Waste Disposal Methods:TREATMENT: MATERIAL DOES NOT HAVE AN EPA WASTE
NUMBER AND IS NOT A LISTED WASTE, HOWEVER CONSULTATION WITH A
PERMITTED WASTE DISPOSAL SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS
CONTACT A PERMITTED WAST E DISPOSER (TSD) TO ASSURE COMPLIANCE WITH
ALL CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: NON-REGULATED. DOT ID
NUMBER: NONE.
* Regulatory Information *
Federal Regulatory Information:TSCA STATEMENT: THE CAS NUMBER OF THIS
PRODUCT IS LISTED ON THE TSCA INVENTORY.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR W/PESTICIDE & SOLVENT
VAPORS CANISTER IN CONFINED AREAS.
Ventilation:IN CONFINED AREAS/ABOVE TLV: LOCAL EXHAUST W/FACE VELOCITY
Other Protective Equipment:RUBBER PROTECTIVE CLOTHING IF SKIN CONTACT
LIKELY.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
& SMOKING. REMOVE & WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:NIX NON-SELECTIVE VEGETATION KILLER
* Composition/Information on Ingredients *
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
Ingred Name:PROMETON; 2-METHOXY-4,6-BIS ISOPROPYLAMINO!-S-TRIAZINE
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
Fraction by Wt: 5%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
Fraction by Wt: 5%
Ingred Name:NAPTHALENE; MOTH FLAKES; MOTH BALLS; NAPHTHALIN; CAMPHOR
TAR; WHITE TAR
Fraction by Wt: 3%
Ingred Name:ETHYL BENZENE
Fraction by Wt: 1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, TOXIC EFFECTS. EYES:
IRRITATION, TISSUE DAMAGE. INHALATION: EXCESSIVE EXPOSURE TO
VAPORS/SPRAY MIST MAY CAUSE NOSE & RESPIRATORY IRRITATION, CNS
EFFECTS. LONG TERM EXCESSIVE OVEREXPO SURE TO SOLVENT COMPOUNDS MAY
CAUSE LIVER, KIDNEY, BLOOD CELL & CNS EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, BLURRED
VISION, NAUSEA, UNCONSCIOUSNESS, VOMITING, ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS, DERMATITIS
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH IMMEDIATELY W/WATER
INDUCE VOMITING. IF CONSCIOUS, DILUTE BY DRINKING WATER.
RESUSCITATE IF NEEDED . ASPIRATION HAZARD. OBTAIN MEDICAL ATTENTION
IN ALL CASES. NOTE TO PHYSICIAN: PROMETON IS AN S-TRIAZINE
HERBICIDE. FOR INGESTION, NO SPECIFIC ANTIDOTE; TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA/RUBBER PROTECTIVE CLOTHING. USE FINE
SPRAY WATER TO COOL UNBROKEN CONTAINERS/PREVENT BURSTING. FIGHT
FIRE FROM UPWIND. EVACUATE PEOPLE DOWNWIND.
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE GEAR. DIKE LARGE
SPILLS. PICK UP REMAINDER/SMALL SPILLS W/INERT ABSORBENT & PLACE IN
APPROPRIATE CONTAINER. WASH AREA W/DETERGENT, ABSORB/PLACE IN
CONTAINER. FLUSH AREA W/W ATER.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN WELL-VENTILATED AREA. DON'T
USE, POUR, SPILL/STORE NEAR HEAT/OPEN FLAME. STORE AT TEMPS BETWEEN
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. DON'T
CONTAMINATE WATER, FOOD/FEED BY HANDLING, STORAGE/DISPOSAL. DON'T
GET IN EYES. AVOID REPEATED/PROLONGED CONTACT W/SKIN. AVOID
BREATHING VAPORS/SPRAY MISTS. READ & FOLLOW LABEL DIRECTIONS.
* Physical/Chemical Properties *
Vapor Pres:3
Vapor Density:>1
pH:7.2
Evaporation Rate & Reference:(BU AC=1): <0.1
Solubility in Water:EMULSIFIES
Appearance and Odor:LIGHT AMBER LIQUID, MILD PETROLEUM ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALIS
Hazardous Decomposition Products:PHOSGENE, CHLOROFORM
* Disposal Considerations *
Waste Disposal Methods:DON'T ALLOW WASH TO CONTAMINATE WATER SUPPLIES.
DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
Product ID: ROCK MIRACLE LIQUIFIER
Cage: PYRCK
Proprietary Ind: Y
*
Contractor Summary
*
Cage: PYRCK
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES AND SKIN IRRITATION, MAY BE ABSORBED BY SKIN.
OVEREXPOSURE: NARCOSIS, NAUSEA AND IRRITATION TO RESPIRATORY SYSTEM. CHRONIC:
DERMATITIS, ALLERGIES, AND RESPIRATORY AILMENTS.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
SKIN: WASH WITH MILD SOAP AND WATER. INGEST: SEE A DOCTOR ORMEDICAL HELP AT
ONCE!!!!! FIRST AID: IN ALL CASES ABOVE SEEK MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: MATL IS CLASSIFIED AS COMBUST LIQUID. REMOVE ALL
IGNIT SOURCES. VENTILATE AREA & AVOID BREATHING VAPORS. FOR LG SPILLS,
ISOLATE AREA AND DENY ENTRY. ABSORB W/COMPAT ABSORBENT MATL. WEAR PROT
EQUIPMENT . CONTAIN AWAY FROM SURFACE WATERS & SEWERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE MADE IN ACCORDANCE WTIH APPLICABLE
FEDERAL, STATE AND LOCAL REGUALTIONS.
Handling And Storage Precautions: KEEP IN COOL PLACE AWAY FROM IGNITION SOURCES
AND MAKE SURE ITS COVER IS ON TIGHT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: DRY CHEMICAL, FOAM, CARBON DIOXIDE, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER SPRAY TO PROTECT PERSONNEL AND COOL DOWN
FIRE--EXPOSED SURFACES.
Unusual Fire/Explosion Hazard: VAPORS CAN EXPLODE WHEN MIXED WITH AIR AND
IGNITED. CONTAINERS COULD RUPTURE FROM EXCESSIVE HEAT DUE TO FIRE. USE
EXPLOSION PROOF EQUIPMENT.
*
*
Respiratory Protection: USE NIOSH APPRVD RESP PROT EQUIP WHEN CONC OF
VAPS/MISTS EXCEEDS APPLIC EXPOS LIMIT. DEPENDING ON AIRBORNE CONC, USE NIOSH
APPRVD FULL-FACE RESP/GAS MASK W/APPROP CARTRIDGES & CANISTERS. A NIOSH
APPRV D SCBA IS REQD FOR LG SPILL (SUPDAT)
Ventilation: PROVIDE LOC EXHAUST/GEN DILUTION VENT NEEDED TO MAINTAIN CONCS OF
VAPS/MISTS BELOW APPLIC EXPOS LIMITS. WHERE (SUPDAT)
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). WEAR
APPROP SOLV-RESIST BOOTS, APRON/OTHER PROT CLTHG WHERE SPILL
Work Hygienic Practices: WASH HANDS BEFORE STARTING A NEW TASK.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). RESP PROT: & EMERGENCIES. SELECTION &
PRESENT, SYSTEMS SAFE FOR SUCH LOCATIONS SHOULD BE USED.
*
Physical/Chemical Properties
*
Appearance and Odor: PASTE.
Percent Volatiles by Volume: 2.0
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG ACIDS, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: OXIDES OF NITROGEN - CARBON DIOXIDE, CARBON
MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: ROCK MIRACLE LIQUIFIER
Cage: PYRCK
Company Name: PYROCK CHEMICALS CORP
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES AND SKIN IRRITATION, MAY BE ABSORBED BY
SKIN. OVEREXPOSURE: NARCOSIS, NAUSEA AND IRRITATION TO RESPIRATORY SYSTEM.
CHRONIC: DERMATITIS, ALLERGIES, AND RESPIRATORY AILMENTS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNDER NORMAL CONDITIONS NO RESPIRATORY
PROTECTION IS REQUIRED. SCBA IS REQUIRED IF A SPILL OCCURS.
Ventilation:NORMAL VENTILATION IS O.K. FOR NORMAL PROCEDURE. USE LOCAL
EXHAUST FOR LARGE AMOUNTS & MECHANICAL FOR USE IN LOW PLACES.
OR REPEATED EXPOSURE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NOTE TO PHYSICIAN: BECAUSE OF POSSIBLE DISTURBANCE OF CARDIAC RHYTHM,
CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD BE CONSIDERED ONLY
AS A LAST RESORT IN LIFE-THREATENING EMERGENCIES.
* Product Identification *
CAGE:0UFA8
CAGE:0UFA8
CAGE:0KDP7
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS: INHALATION OF HIGH
CONCENTRATIONS OF VAPOR IS HARMFUL & MAY CAUSE HEART
IRREGULARITIES, UNCONSCIOUSNESS & DEATH. INTENTIONAL MISUSE CAN BE
FATAL. VAPOR REDUCES OXYGEN AVAILABLE FOR BRE ATHING & IS HEAVIER
THAN AIR. LIQUID CONTACT CAN CAUSE FROSTBITE.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: NONSPECIFIC DISCOMFORT, SUCH AS
NAUSEA, HEADACHE OR WEAKNESS; OR TEMPORARY CNS DEPRESSION WITH
EFFECTS SUCH AS DIZZINESS, HEADACHE, CONFUSION, INCOORDINATION &
LOSS OF CONSCIOUSNESS. HIGHE R EXPOSURES BY INHALATION MAY CAUSE
TEMPORARY ALTERATION OF THE HEART'S ELECTRICAL ACTIVITY WITH
IRREGULAR PULSE, PALPITATIONS, OR INADEQUATE CIRCULATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING DISEASES
OF THE CENTRAL NERVOUS OR CARDIOVASCULAR SYSTEM MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURE.
* First Aid Measures *
CALL A DOCTOR. SKIN: FLUSH WITH WATER. TREAT FOR FROSTBITE IS
NECESSARY. INHALE: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE CPR.
IF BREATHIN G IS DIFFICULT, GIVE OXYGEN & CALL A DOCTOR. INGEST:
INGESTION IS NOT CONSIDERED A POTENTIAL ROUTE OF EXPOSURE.
* Fire Fighting Measures *
Flash Point:WILL NOT BURN
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:USE WATER SPRAY OR FOG TO COOL CONTAINERS.
SELF-CONTAINED BREATHING APPARATUS IS REQUIRED IF CYLINDERS RUPTURE
OR RELEASE UNDER FIRE.
Unusual Fire/Explosion Hazard:CYLINDERS ARE EQUIPPED WITH TEMPERATURE
AND PRESSURE RELIEF DEVICES BUT MAY STILL RUPTURE UNDER FIRE
CONDITIONS. DECOMPOSITION MAY OCCUR.
* Accidental Release Measures *
Spill Release Procedures:SPILL-VENTILATE AREA, ESPECIALLY LOW PLACES
WHERE HEAVY VAPORS MIGHT COLLECT. REMOVE OPEN FLAMES. USE SELF
CONTAINED BREATHING APPARATUS FOR LARGE SPILLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORAGE-STORE IN A CLEAN, DRY AREA. DO
Other Precautions:AVOID BREATHING VERY HIGH CONCENTRATIONS OF VAPORS.
AVOID CONTACT OF EYES OR SKIN WITH LIQUID. PYROLYSIS PRODUCTS MAY
PRODUCE IRRITATING & CORROSIVE GASES.
* Physical/Chemical Properties *
HCC:G3
NRC/State Lic Num:NONE
pH:NEUTRAL
Appearance and Odor:COLORLESS, LIQUIFIED GAS, SLIGHT ETHEREAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS-POWDERED AL, ZN, BE, ETC.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
TEMPERATURES (OPEN FLAMES, ETC) FORMING FREE BROMINE AND POSSIBLY
CARBONYL HALIDES.
* Toxicological Information*
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. RECLAIM BY DISTILLATION OR
REMOVE TO PERMITTED WASTE DISPOSAL FACILITY.
* MSDS Transport Information *
Transport Information:DOT/IMO PROPER SHIPPING NAME:
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
EXPLOSION PROOF EQUIPMENT.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:J.I. GREENBERG
* Composition/Information on Ingredients *
Ingred Name:HYDROTREATED LIGHT DISTILLATE, PETROLEUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY HAVE RESULTS MILD
DEPRESSION TO RESPIRATORY IRRITATION. SKIN: PROLONGED CONTACT MAY
LEAD TO EXTRACTION OF NATURAL OILS W/RESULTANT IRRITATION. EYE:
WILL CAUSE IRRITATION. INGESTION: MA Y AFFECT KIDNEYS. HEALTH RISKS
WHICH VARY FROM PERSON TO PERSON.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MAY HAVE RESULTS MILD DEPRESSION TO
RESPIRATORY IRRITATION. SKIN: PROLONGED CONTACT MAY LEAD TO
EXTRACTION OF NATURAL OILS W/RESULTANT IRRITATION. EYE: WILL CAUSE
IRRITATION. INGESTION: MA Y AFFECT KIDNEYS.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE. ADMINISTER ARTIFICIAL
MIN. INGESTION: DON'T INDUCE VOMITING. GIVE PLENTY OF WATER. IF
CONTACTED, REMOV E CONTAMINATED CLOTHES/WASH AREA WITH PLENTY OF
WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:FOAM, DRY CHEMCIAL, CO2, WATER SPRAY/FOG
Fire Fighting Procedures:USE AIR SUPPLIED RESCUE EQUIPMENT FOR ENCLOSED
AREA. COOL EXPOSED CONTAINRS W/WATER.
Unusual Fire/Explosion Hazard:DON'T STORE & MIX WITH STRONG OXIDANTS.
COMBUSTION LIQUID.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. RECOVER FREE LIQUID &
ADD ABSORBENT TO SPILL AREA. AVOID BREATHING VAPORS. VENTILATE
ENCLOSED SPACES.
* Physical/Chemical Properties *
HCC:V4
Vapor Pres:<2
Vapor Density:>5
Evaporation Rate & Reference:(N-BU AC = 1): 0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE-ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQUID CHLORINE, CONCENTRATED OXYGEN
SODIUM/CALCIUM HYPOCHLORITE.
Hazardous Decomposition Products:FUMES, SMOKE & CO IN CASE OF
INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/ALL LOCAL, STATE, &
FEDERAL REGULATIONS, DISPOSAL RECOMMENDATIONS APPLY TO THE ORIGINAL
MATERIAL & ITS CONTAINER, NOT ANY MATERIALS WHICH AREA WASTE BY
PRODUCTS OF THE USER' S OPERATION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A NIOSH/MSHA APPROVED RESPIRATOR FOR PESTICIDE
DUST.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAI
PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A LOCAL EYE WASH STATION AND
SAFETY SH
Work Hygienic Practices:OWER.
WASH HANDS.SEPERATE WORK CLOTHES FROM STREET CLOTHES.LAUNDER WORK
CLOTHES BE
Supplemental Safety and Health
FORE REUSE.KEEP FOOD OUT OF THE WORK AREA. HMIS WAS NOT ABLE TO FIND
THE EPA REGISTRATION NUMBER ON THE MFR'S MSDS.
* Product Identification *
Preparer's Name:REGISTRATION ®UL AFFR
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM SULFAMATE (CERCLA)
Other REC Limits:NONE RECOMMENDED
Ingred Name:INERT INGREDIENTS(TYPE NOT SPECIFIED)
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION.INGEST:MAY CAUSE GI TRACT IRRITATION.INHAL:MAY
CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES/INHAL:IRRITATION.
Medical Cond Aggravated by Exposure:NOT REPORTED&
0 #/ X@D@@@D??< A H N # #! & 0 A???>< 3H
B
* First Aid Measures *
First Aid: BL L'N @O O LN H II L @ I @
L L LH@ @ I @ L LH 'H @ L N @O CIA
AN.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIALRESPIRATION IF NEEDED.CALL PHYSICIAN.INGEST:GET PROMPT
QUALIFIED MEDICAL ATTENTION.IF CONSCIOUS,GIVE 2 GLASSES OF WATER
AND INDUCE VOMITING BY STICKING FINGER DOWN THROAT.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY FOG,DRY CHEMICAL,CARBON
DIOXIDE,FOAM.THIS ITEM HAS FIRE RETARDANT PROPERTIES.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER RESPIRATORY AND PROTECTIVE
EQUIPMENT.VENTILATE AREA.SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT(CLAY,SAND);PLACE IN PROPER CONTAINER FOR DISPOSAL.PREVENT
CONTAMINATION OF GROUND AND WATE RWAYS.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DO NOT STORE WITH OTHER PESTICIDES,FERTILIZERS,FOOD
OR FEED.
* Physical/Chemical Properties *
HCC:T5
Solubility in Water:APPRECIABLE
Appearance and Odor:SOLID;YELLOW;ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DECOMPOSES WITH HEAT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN IN
THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH EQUIVALENT VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY. EYE WASH AND SAFETY EQUIPMENT SHOULD BE READILY
AVAILABLE.
Supplemental Safety and Health
HNDLG/STOR PREC: HANDLE EMPTY CONTAINERS WITH CAUTION. ADD ACID
CAUTIOUSLY TO WATER WHEN DILUTING - NEVER ADD WATER TO ACID. EYE
PROT: FACESHIELD .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)
OSHA PEL:C 5 PPM
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT CAUSES SEVERE BURNS AND
PERMANENT EYE DAMAGE. SKIN CONTACT CAUSES SEVERE BURNS; POSSIBLE
DEEP ULCERATION. INHAL CAUSES DAMAGE TO NASAL AND RESPIRATORY
PASSAGES PULMONARY EDEMA. TEST IN LAB ANIMALS INDICATE MATERIAL
MAY PRODUCE ADVERSE MUTAGENIC & REPRODUCTIVE EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:SKIN: IMMED FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER.
REMOVE TO FRESH AIR; GIVE ARTF RESP IF BREATHING HAS STOPPED.
INGEST: DO NO T INDUCE VOMIT; GIVE WATER OR MILK IF CONSCIOUS; GET
MED ATTN. GET MED ASSISTANCE FOR ALL CAOSES OF OVEREXPOSURE.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:CONTACT WITH METAL PRODUCES HYDROGEN.
* Accidental Release Measures *
Spill Release Procedures:NEUTRALIZE WITH SODA ASH/SLAKED LIME MIXTURE.
TAKE UP AND CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:SODA ASH/SLAKED LIME MIXTURE.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR TIGHTLY CLOSED. STORE IN
COOL, WELL-VENTD AREA SEPARATED FROM INCOMP MATL. DO NOT BREATHE
VAP. DO NOT GET IN EYES, ON SKIN/CLTHG.(SUPDAT)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:C1
Evaporation Rate & Reference:2.9(BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID ACRID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, ALKALIES AND AMINES; CONTACT WITH METAL PRODUCES HYDROGEN.
Stability Condition to Avoid:HEAT; CONTACT WITH METALS.
Hazardous Decomposition Products:TOXIC HYDROGEN CHLORIDE GAS.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN CONFINED AREAS USE NIOSH/MSHA APPRVD MASK
WITH CHEMICAL CANNISTER OR SUPPLIED AIR.
Ventilation:LOCAL EXHAUST VENT:EXPLOSION PROOF VENTILATOR KEEPING VAPOR
BELOW ALLOWABLE LIMITS.
Other Protective Equipment:PROTECTIVE APRON & FOOTWEAR. ANSI APPRVD
EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SHOULD BE CONSIDERED HAZ UNLESS THORO CLEANED. EFTS OF
OVEREXP:ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS &
LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE).
WARM WATER & OBTAIN MED ATTN IMMED. DO NOT (ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DI-GLYCOL ETHER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-DIMETHYLAMINO-; (N,N-DIMETHYLETHANDLAMINE)
Fraction by Wt: 5%
OSHA PEL:5 PPM (MFR)
ACGIH TLV:5 PPM (MFR)
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (N-METHYL-2-PYRROLIDONE)
Ingred Name:SUPDAT:INDUCE VOMIT BECAUSE BRTHG INTO LUNGS WILL INCR THE
RISK OF CHEM PNEUMONIA.
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:DMEA-EXTREMELY IRRIT.
BUTOXYETHANOL-POSS IRRITANT. SKIN:CAN BE ABSORBED THRU SKIN.
DMEA-CORR. BUTOXYETHANOL-PENETRATES SKIN READILY. INHAL:MAY AFFECT
BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS & COULD RSLT IN MILD
DEPRESS, CONVL & POSS LOSS OF CONSCIOUSNESS. SOLV TOX-RPTS HAVE
ASSOC RPTD & PRLNGD(EFTS OF OVEREX)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OCCUP OVEREXP TO SOLV W/PERM BRAIN &
NERV SYS DMG. BUTOXYETHANOL-POSS IRRITANT TO LUNGS. MAY CAUSE NOSE
& THROAT IRRIT. INGEST:BUTOXYETHANOL-MOD TOX-MAY CAUSE RED BLOOD
ML/KG (RAT). ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING EYELIDS. OBTAIN IMMED ATTN. SKIN:IMMED REMOVE CONTAMD
CLTHG. WASH AFFECTED AREAS W/SOAP & WATER. IF STICKY, USE WATERLESS
CLEANER F IRST. CLEAN CLTHG THORO BEFORE REUSE. INHAL:IMMED MOVE
VICTIM TO FRESH AIR. ADMIN OXYG/ARTF RESP AS NEEDED OBTAIN MED ATTN
IMMED. PROMT ACTION ESSNTL. INGEST:IF QTY OF THIS MATL IS
SWALLOWED, (SUPDAT)
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALCOHOL FOAM-DRY CHEMICAL-CO*2-WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL EXPOSED CNTNRS.
NOTIFY AUTH IF LIQUID ENTERS SEWERS/PUBLIC WATERS.
Unusual Fire/Explosion Hazard:VAPS ARE OFTEN HVR/AIR. MAY TRAVEL ALONG
GROUND. KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT. MAY EXPLODE IF
EXPOSED TO EXTREME HEAT. "EMPTY" CNTNRS (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP PEOPLE AWAY.
RECOVER FREE LIQUID & SPREAD ABSORBENT IN SPILL AREA. VENTILATE
AREA. OPEN ALL WINDOWS AND DOORS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTIANERS TIGHTLY CLOSED. KEEP
AWAY HEAT-HEAT COULD CAUSE PRESSURE BUILDUP. AVOID PROLONGED OR
REPEATED BREATHING OR SKIN CONTACT.
Other Precautions:DO NOT INCINERATE CONTAINERS. EMPTY CONTAINERS ARE
HAZARDOUS. DO NOT CUT OR WELD.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOW/BUTYL
Solubility in Water:NOT KNOWN
Appearance and Odor:BLACK
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METHYLPYRROLIDONE-STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMP/OPEN FLAMES.
METHYLPYRROLIDONE-MOISTURE-COMPOUND IS HYGROSCOPIC.
Hazardous Decomposition Products:AS WITH ANY OTHER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CARBON DIOXIDE AND PROBABLY CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:TREAT AS HAZARDOUS WASTE AND DISPOSE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED.
Other Protective Equipment:IMPERVIOUS SYNTHETIC RUBBER BOOTS, APRON, &
CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH BEFORE EATING, DRINKING, SMOKING, OR USING TOILET.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DAVE BURGESS
* Composition/Information on Ingredients *
Ingred Name:LIGHT NAPHTHALIC DISTILLATE, HYDROTREATED LIGHT NAPHTHENIC
DISTILLATE
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
Ingred Name:PETROLEUM OIL, HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
(PETROLEUM), PETROLEUM DISTILLATES, MINERAL OIL
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
Ingred Name:SODIUM NITRITE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: SLIGHT IRRITATION. INHALATION:
NOT EXPECTED TO PRESENT HAZARD UNDER NORMAL CONDITIONS. INGESTION:
LAXATIVE EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: OIL ACNE WHICH IS CHARACTERIZED BY
BLACKHEADS W/POSSIBLE SECONDARY INFECTION. ALLERGIC DERMATITIS,
USUALLY PRECEDED BY CONTACT DERMATITIS MAY OCCUR & SPREAD BEYOND
AREAS OF DIRECT CONTACT.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER & CONTINUE
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, SAND/EARTH. WATER FOG MAY
BE USED TO COOL EXPOSED CONTAINERS.
Fire Fighting Procedures:PRODUCES DENSE SMOKE, USE APPROPRIATE
SELF-CONTAINED BREATHING APPARATUS.
* Accidental Release Measures *
Spill Release Procedures:SCRAPE OR SHOVEL UP. ABSORB RESIDUE W/MATERIAL
SUCH AS CLAY OR DIATOMACEOUS EARTH.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
Other Precautions:DON'T INGEST. AVOID CONTACT W/SKIN.
* Physical/Chemical Properties *
Spec Gravity:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN SEMI SOLID W/MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:CO, CO2, & OTHER OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED
Ventilation:MECHANICAL (GENERAL): RECOMMENDED
Other Protective Equipment:EYEWASH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
Product ID:STRAWS/WHITE POWDER
* Composition/Information on Ingredients *
Ingred Name:SODIUM PYROPHOSPHATE PEROXIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION:
HARMFUL. INHALATION: MUCOUS MEMBRANES IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INGESTION: HARMFUL.
INHALATION: MUCOUS MEMBRANES IRRITATION.
* First Aid Measures *
First Aid:EYES/SKIN: FLUSH W/WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:CO2 OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. IF
FIRE CANNOT BE SMOTHERED, FLOOD W/PLENTY OF WATER.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PROTECTIVE EQUIPMENT. SWEEP UP &
COLLECT FOR DISPOSAL.
*Handling and Storage *
Other Precautions:AVOID CONTACT W/SKIN & EYES.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE POWDER, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, ACIDS.
Hazardous Decomposition Products:PHOSPHOROUS OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST, FUME & MIST RESPIRATOR
OR SELF-CONTAINED BREATHING APPARATUS FOR EMERGENCY USE.
Other Protective Equipment:LAB COAT, APRON, FLAME RESISTANT COVERALLS,
EYEWASH, SAFETY SHOWER & HYGIENIC FACILITIES FOR WASHING.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
MATERIALS TO AVOID CON'T: BORON DIIDOPHOSPHATE & OXYGEN.
* Product Identification *
CAGE:0JVJ1
CAGE:0JVJ1
* Composition/Information on Ingredients *
Ingred Name:MERCURY, QUICKSILVER
Other REC Limits:INORGANIC 0.1 MG/CUM
OSHA PEL:0.1 MG/CUM (SKIN)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: ABSORPTION, CAUSING EFFECTS
SIMILAR TO THOSE OF INHALATION. INHALATION: DYSPNEA, COUGH, FEVER,
NAUSEA, VOMITING, DIARRHEA, STOMATITIS, SALIVATION, METALLIC TASTE,
PULMONARY DISTURBANCES, ANURIA, CNS DAMAGE. INGESTION: POISONING,
METALLIC TASTE, THIRST, ABDOMINAL PAIN, VOMIT, DIARRHEA, UREMIA &
DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: ABSORPTION/INHALATION:
STOMATITIS/TREMORS/SALIVATION/LOOSENING OF THE TEETH/BLUE GUM
LINE/PERIPHERAL
NEUROPATHY/NEPHRITIS/DIARRHEA/ANXIETY/HEADACHE/WEIGHT LOSS/ANOREXIA
& PSYCHIC DISTURBANCES. I NGESTION: SKIN
DISORDER/SALIVA/DIARRHEA/ANEMIA/LEUKOPENIA/LIVER & KIDNEY DAMAGE.
* First Aid Measures *
INHALATION/INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, CO2, DRY CHEMICAL, EXTINGUISHING AGENTS, DRY
SAND OR DRY GROUND DOLOMITE
Unusual Fire/Explosion Hazard:WHEN HEATED EMITS HIGHLY TOXIC FUMES OF
MERCURY. TAKE FULL PRECAUTIONARY MEASURES TO GUARD THESE FUMES.
* Accidental Release Measures *
Spill Release Procedures:SPILL MAY BE A TOXIC HAZARD DUE TO DROPLET
PROLIFERATION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY/VENTILATED AREA.
* Physical/Chemical Properties *
Vapor Density:7
Solubility in Water:INSOLUBLE
Appearance and Odor:BRIGHT, MIRROR LIKE, SILVERY LIQUID W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETYLENIC COMPOUNDS/AMMONIA/ETHYLENE/METAL OXIDES/METHYL SILANE/STRONG
OXIDANTS/METAL CARBONYLS/METHYL AZIDE, SEE SUPP.
Hazardous Decomposition Products:TOXIC MERCURY FUMES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATORY EQUIPMENT MUST BE
USED WHEN VAPOR OR MIST CONCENTRATIONS ARE UNKNOWN OR EXCEED THE
TLV.
Ventilation:VENT REQD & EQUIP MUST BE EXPLOSION PROOF. USE AWAY FROM
ALL IGNIT SOURCES. USE IN WELL VENTED AREA W/LOCAL EXHST VENT.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
HUMAN:MYELOID LEUKEMIA, HODGKINS DISEASE, LYMPHOMA. EFTS OF
OVEREXP:PERIO D OF TIME (2 YR LIFE TIME STUDIES) CAUSED KIDNEY DMG
* Product Identification *
CAGE:0AHK0
* Composition/Information on Ingredients *
Ingred Name:GASOLINE (CONTAINING ING 2)
Fraction by Wt: 2%
OSHA PEL:1 PPM (MFR)
Ingred Name:LEAD ALKYL; (LEAD ALKYL COMPOUNDS) (FOR MOBIL REGULAR
GASOLINE ONLY)
ACGIH TLV:0.1 MG/M3, S (MFR)
Ingred Name:PLUMBANE, TETRAETHYL-; (TETRAETHYL LEAD (LEADED GASOLINE
ACGIH TLV:0.1 MG/M3, S (PB)
Fraction by Wt: 9%
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
Fraction by Wt: 3%
Fraction by Wt: 2%
Ingred Name:ETHER, TERT-BUTYL METHYL-; (METHYL TERT-BUTYL ETHER) (SARA
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT:GENRLY, HUMAN EXPOS TO GAS VAPS ARE CONSIDERABLY
PARAFFINIC, OLEFINIC, NAPHTHENIC & AROMATIC HYDROCARBONS WHICH (ING
MULTIFUNCTIONAL ADDITIVES. RPTD EXPOS TO LOW LEVELS OF BENZENE (ING
INFO & SAFE HANDLING & EXPOSURE INFORMATION .
DISP. RUNOFF MAY CREATE FIRE/EXPLO HAZARD IN SEWER SYSTEM.
Ingred Name:OTHER PREC:AUTOMATIC SPRINKLING SYS. FOR USE AS MOTOR FUEL
PUNCTURE/WELD ON/NEAR CNTNR. ALL LBL WARNINGS & PRECS MUST BE(ING
DESTROYED. FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MOD SKIN IRRIT. SLIGHT EYE IRRIT. RESP
IRRIT, DIZZ, NAUS, LOSS OF CONSCIOUSNESS. PRLNG EXPOS TO HIGH CONCS
HAS CAUSED KIDNEY DMG & KIDNEY CANCER IN RATS & LIVER CANCER IN
MICE. ACUTE TOX:ORAL/DERMAL T OX:NO MORE THAN SLIGHTLY TOX BASED ON
SINGLE DOSE LEVEL TESTING. INHAL TOX(RATS):MOD TOX BASED ON (EFTS
OF OVEREXP)
OSHA(SUPDAT)
Effects of Overexposure:HLTH HAZ:TESTING OF SIMILAR PRODS &/OR
COMPONENTS. EYE IRRIT(RABBITS):MAY CAUSE SLIGHT IRRIT BASED ON
TESTING OF SIMILAR PRODS &/OR COMPONENTS. SKIN IRRIT(RABBITS):MOD
IRRIT. MAY CAUSE IRRIT ON PRLNG/ RPTD CONT. CHRONIC TOX:RECENT
STUDIES W/LAB ANIMALS HAVE SHOWN THAT GASOLINE VAPS ADMIN IN HIGH
CONCS OVER PRLNG(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
AREAS W/SOAP & WATER. LAUNDER CONTAM CLTHG BEFORE REUSE.
INHAL:REMOVE FROM EXPOS. IF UNCON OCCURS, SEEK IMMED MED ASSISTANCE
& CALL MD. IF BRTH G HAS STOPPED, USE MOUTH-TO-MOUTH RESUSCITATION.
INGEST:DO NOT INDUCE VOMIT. ADMIN VEGETABLE OIL. GET MED
ASSISTANCE. NOTE TO MD:MATL, IF ASPIRATED INTO LUNGS MAY CAUSE CHEM
PNEUM WHICH CAN DMG LUNGS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.1%
Upper Limits:7.6%
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL OR WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . COOL
STOR DRUMS W/WATER SPRAY. EVACUATE AREA. PVNT RUNOFF FROM FIRE
CONTROL/DILUTION FROM ENTERING (SUPP DATA)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE LIQUID. VAPOR
ACCUMULATION COULD FLASH &/OR EXPLODE IF IN CONTACT W/OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:REPORT SPILLS AS REQD TO APPROP AUTHS. IN CASE
GUARD REGS REQ IMMED REPORTING OF SPILLS THAT COULD REACH ANY
WATERWAY INCL INTERMITTEN T DRY CREEKS. COAST GUARD TOLL FREE
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID SKIN CONT & BRTHG MISTS/VAPS.
USE IN WELL VENTED AREA AWAY FROM ALL IGNIT SOURCES.
OUTSIDE/DETACHED STOR PREF. EXTREMELY FLAMM LIQ. VAP HARMFUL.
Other Precautions:AVOID SPARKING CNDTNS; GROUND & BOND ALL TRANSFER &
STOR EQUIP. DRUMS MUST BE GROUNDED & BONDED & EQUIPPED
W/SELF-CLOSING VALVES, PRESS VACUUM BUNGS & FLAME ARRESTERS. STORE
* Physical/Chemical Properties *
Vapor Pres:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR TO YELLOW/ORANGE LIQUID; HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HALOGENS, STRONG ACIDS, ALKALIES & OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME & BUILD UP OF STATIC
ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE FROM INCOMPLETE
COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . PROD IS SUITABLE FOR BURNING FOR FUEL VALUE IN
COMPLIANCE W/APPLIC LAWS & REGS. DISP OF UNUSED PROD MAY BE SUBJECT
BEREGULATED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED WHEN USED AS INTENDED. IN
CONCENTRATIONS EXCEEDING THE RECOMMENDED SAFE EXPOSURE LIMIT, SUCH
AS DURING A MAJOR SPILL, USE A NIOSH APPROVED CHEMICAL CARTRIDGE
RESPIRATOR EFFECTIVE FOR ORGA NIC VAPORS.
Ventilation:LOC EXHST TO MAINTAIN BELOW TLV. NORM OFFICE VENT
CONFORMING TO AMERICAN SOCIETY OF HEATING, AIR CONDITIONING, (ING
6)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
WEAR CHEM RESIST APRON WHEN CLEANING MACHINES AS PROD MAY STAIN
CLTHG.
Work Hygienic Practices:KEEP CONTRS CLSD WHEN NOT IN USE. DO NOT SMOKE
Supplemental Safety and Health
FIRST AID PROC: INDUCE VOMIT DUE TO ASPIR HAZ. CALL MD. WASTE DISP
METH: ENVIRON CTL AGENCY FOR ASSIST. OTHER PREC: PVNT VAP ACCUM.
THE PROD IS TO BE STORED IN COOL DRY PLACE TO PVNT DETERIORATION.
DU RING FIRE, PROD CAN ESCAPE & PRESENT ANADDNL FIRE HAZ. THERE IS
NO KNOWN HLTH HAZ TO USERS WHEN USED & STORED AS REC.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACRYLIC POLYMER/RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK; (PIGMENT)
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:MINERAL SPIRITS; (ISOPARAFFINIC PETROLEUM SOLVENT)
Ingred Name:MED CNDTNS: AILMENTS MAY NOTICE PHYSICAL REACTIONS WHEN
EXPOSED TO SMALL AMOUNTS OF PRODUCT OR VAPOR. (ING 5)
Ingred Name:ING 4: CONSULT THEIR TREATING PHYSICIAN FOR PROPER ACTION
AFTER EXPOSURE.
UNDER NORM CNDTNS OF USE. UNDER SOME CNDTNS OF USE OR (ING 7)
Ingred Name:ING 6: COMBINATIONS OF EQUIP, OFFICE VENT MAY NOT BE ADEQ.
USERS SHOULD ASSURE THAT VENT IS SUFFICIENT TO PVNT (ING 8)
Ingred Name:ING 7: EXCEEDING EXPOSURE LIMITS. USERS SHOULD CONSULT A
QUALIFIED VENTILATION ENGINEER AND/OR INDUSTRIAL (ING 9)
Ingred Name:ING 8: HYGIENIST IF A CONCERN REGARDING EXPOSURE ARISES.
Ingred Name:HYGIENE PRACT: AVOID PROLONGED OR REPEATED SKIN CONTACT.
USING PRODUCT.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITANT TO EYES. MAY
CAUSE CONJUNCTIVITIS. SKIN: PROLONGED CONTACT CAUSES DEFATTING,
DRYING, CRACKING, DERMATITIS. INHALATION: NOT NORMALLY AN
INHALATION HAZARD. INGESTION: NAUSEA AND PO SSIBLE GASTROINTESTINAL
IRRITATION.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
GROUP 2B.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE HEADACHE, NAUSEA, AND
RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:DERM. RPTD INHAL EXPOS TO RATE OF
CAUSED LOW GRADE (MILD) ANEMIA & KIDNEY EFTS. PERS W/PREEXISTING
HLTH CNDTNS OF DERM & RESP (ING 4)
* First Aid Measures *
IRRIT SUBSIDES, INCL UNDER EYELIDS. IF IRRIT PERSISTS, CONT MD.
SKIN: REMOVE CONTAM CLTHG. WASH SKIN THORO W/SOAP & WATER. DO NOT
REUSE CONTAM CLTHG UNTIL SOLVS HAVE BEEN REMOVED. INHAL: MOVE
VICTIM TO FRESH AIR. CALL MD IMMED. IF BRTHG IS IRREGULAR/STOPPED,
START RESUSCITATION IF TRAINED. ADMIN OXYGEN IF AVAIL. INGEST: DO
NOT (SUP DAT)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8%
Upper Limits:7.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID WATER, IT TENDS TO SPREAD HYDROCARBON FIRES.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID, CAN FORM COMBUSTIBLE
MIXTURES AT OR ABOVE THE FLASH POINT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. COLLECT ON INERT
ABSORBENT MATERIAL. PLACE IN WASTE CONTAINER APPROVED FOR
COMBUSTIBLE WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLSD, COOL, WELL-VENTD AREA,
AWAY FROM HEAT & FLAME. READ & FOLLOW LABEL PREC. DO NOT REUSE
CONTR.
Other Precautions:EXPOS TO VAPS & FIRE HAZ SHOULD BE MINIMIZED WHEN
STORED PROPERLY & USED AS DIRECTED W/MFR EQUIP. THE PROD WILL STAIN
CLTHG & SKIN, PREC SHOULD BE TAKEN BY USERS TO PVNT CONT. PROPER
VENT OF ROOM WHER E PLOTTERS ARE OPERATING WILL (SUP DAT)
* Physical/Chemical Properties *
Vapor Density:5
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID WITH SLIGHT PETROLEUM HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
VERY STRONG OXIDANTS LIKE CHROMIC ACID OR LIQUID CHLORINE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
TREAT AS HAZ WASTE & DISP I/A/W ALL APPLIC FED, STATE, & LOC REGS.
DO NOT POUR DOWN COMMON DRAI N. CONT LICENSED HAZ WASTE DISP
COMPANY/ (SUP DAT)
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Preparer Co. when other than Responsible Party Co.
*
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: S9G
Item Name: FLUID,COOLANT
Unit of Issue: DR
UI Container Qty: 1
Type of Container: DRUM
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE/ACUTE SKIN/INGEST:NOT NORMALLY EXPECTED TO CAUSE ANY
ILL EFFECTS EXCEPT IN VERY SENS INDIVIDUALS.INHAL:NO SIGNIF ADVERSE HEALTH
EFFECTS EXPECTED TO OCCUR ON SHORT TERM EXPO.CHRONIC SKIN CONTACT:PR OL
&/OR REPEATED CONTACT MAY PRODUCE MILD IRRIT,INFLAMM.
Explanation Of Carcinogenicity: PER MSDS:CARCINOGENIC
INGREDIENTS/OSHA/NTP/IARC:NONE.
Signs And Symptions Of Overexposure: MILD SKIN IRRITATION, INFLAMMATION UPON
PROL/REP CONTACT.
Medical Cond Aggravated By Exposure: PERSONNEL W/PRE-EXISTING SKIN DISORDER
SHOULD AVOID CONTACT.
First Aid: INGEST:DON'T INDUCE VOMIT.CONSULT PHYSICIAN.INHAL:REMOVE FROM CONTAM
AREA.APPLY ART RESP.UNCONSC CONSULT PHYSICIAN.EYE:FLUSH W/COPIOUS AMTS OF
WATER.IRRIT DEVELOPS CONSULT PHYSICIAN.ACUTE SKIN CONTACT :WASH
W/SOAP/WATER.IRRIT/INFLAMM DEVELOPS CONSULT PHYSICIAN.CHRONIC SKIN
CONTACT:WEAR PROTECITVE CLOTH TO AVOID SKIN CONTACT.IRRIT/INFLAMM DEVELOPS
CONSULT PHYSICIAN.
*
Handling and Disposal
*
Spill Release Procedures: STOP FLOW.WIPE/MOP UP/ABSORB W/DIATOMACEOUS
EARTH/OTHER INERT MATL.STORE IN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.EMPTY CNTNR SHOULD BE COMPLETELY DRAIN/PROPERLY CLSD/PROMPTLY
RETURN TO DR RECONDITIONER TO BE COMMERCIALLY CLEANED.ALL OTHER SHOULD BE
DISPO OF IN ENVIRO SAFE MANNER,IAW GOVT REGS.
Handling And Storage Precautions: AVOID STORAGE NEAR OPEN FLAME/OTHER IGN
SOURCES.EXCESSIVE MIST MAY CAUSE SLIPPERY FLOORS.PROPER FOOTWEAR REQUIRE.SEE
Other Precautions: WASH/TAKE SHOWER IF GENERAL CONTACT OCCURS.REMOVE OIL-SOAKED
RETAIN RESIDUE-CAN BE DANGEROUS.DON'T PRESSURIZE/CUT/WELD/BRAZE/S
OLDER/DRILL/GRINDK/EXPO EMPTY CNTNR TO HEAT/FLAME/SPARKS/OTHER IGN
SOURCES.THEY MAY EXPLO/CAUSE INJU RY/DEATH. (SUP DAT)
*
Fire and Explosion Hazard Information
*
Flash Point Method: COC
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATERFOG.
Fire Fighting Procedures: DO OT ENTER ANY ENCLOSED/CONFINED AREA W/O PROPER
PROTECTIVE EQPMT & SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: SLIGHTLY COMBUSTIBLE WHEN HEATED >FLASH
POINT.WILL RELEASE FLAMM VAP WHICH CAN BURN IN OPEN OR BE EXPLO IN CONFINED
SPACES IF EXPO TO SOURCE OF IGNITION.
*
*
Respiratory Protection: NONE NORMALLY REQUIRED.
Ventilation: SUFFICIENT TO MAINTAIN ATMOSPHER BELOW TLV LIMIT.
Other Protective Equipment: CHEMICALLY RESISTANT BOOTS & APRONS RECOMMENDED.
Work Hygienic Practices: WASH HANDS W/SOAP/WATER BEFORE
EATING/DRINKING/SMOKING.
Supplemental Safety and Health: OTHER PRECAUT: ALL PRECAUT DETAILED ON CNTNR
LABEL APPLIES TO PARTIALLY FULL/EMPTY CNTNRS.DON'T ATTEMPT TO CLEAN SINCE
RESIDUE DIFFICULT TO REMOVE.
*
Physical/Chemical Properties
*
HCC: V6
Vapor Density: >AIR
PH: N/DETR
Evaporation Rate & Reference: LESS THAN ETHER.
Solubility in Water: SLIGHT
Appearance and Odor: SLIGHTY YELLOW OILY LIQUID. PETROLEUM ODOR.
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: DO NOT HEAT ABOVE FLASH POINT.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE & ASPHYXIANTS.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 1
Type Of Container: DRUM
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: TECHNOLUBE PRODUCT COMPANY
Label Required IND: Y
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: EYE/ACUTE SKIN/INGEST:NOT NORMALLY EXPECTED TO CAUSE
ANY ILL EFFECTS EXCEPT IN VERY SENS INDIVIDUALS.INHAL:NO SIGNIF ADVERSE
HEALTH EFFECTS EXPECTED TO OCCUR ON SHORT TERM EXPO.CHRONIC SKIN CONTACT:PR
OL &/OR REPEATED CONTACT MAY PRODUCE MILD IRRIT,INFLAMM.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN CASE OF DUST CONDITIONS,USE NIOSH APPROVED
RESPIRATOR FOR METAL DUST.
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:STANDARD PRACTICE
Supplemental Safety and Health
HEALTH HAZARDS,CONT'D:LEAVE A METALLIC TASTE IN THE MOUTH;RESULT IN
METAL FUME FEVER (FLU-LIKE SYMPTOMS).
* Product Identification *
Product ID:SC-B (GUIDE SHOE)
Preparer's Name:TERRY HEILER
* Composition/Information on Ingredients *
Ingred Name:IRON
ACGIH TLV:5 MG/CUM(OXIDE FUME)
Ingred Name:COPPER (SARA III)
OSHA PEL:0.1MG/M3 FUME/1 DUST
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
Ingred Name:TIN
OSHA PEL:2 MG/M3
Ingred Name:GRAPHITE, SYNTHETIC
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:ALUMINUM (SARA III)
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM
Ingred Name:NICKEL (SARA III)
OSHA PEL:1 MG/M3
Ingred Name:SILICON
Other REC Limits:5MG/CUM(RESP.DUST)
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:OPERATIONS SUCH AS
ABRADING,MELTING,WELDING,CUTTING OR PROCESSING IN ANY OTHER FASHION
MAY PRODUCE POTENTIALLY HAZARDOUS DUST OR FUMES WHICH CAN BE
INHALED,SWALLOWED,OR COME IN CONTACT WITH THE SKIN O R EYES. DUST
OR FUME MAY CAUSE IRRITATION TO THE EYES,NOSE OR THROAT; -CONTINUES
IN SUPPLEMENTAL SAFETY & HEALTH DATA-
Explanation of Carcinogenicity:NICKEL IS A CARCINOGEN AND CERTAIN
COMPOUNDS OF CHROMIUM AND COBALT HAVE BEEN IDENTIFIED AS SUSPECT
HUMAN CARCINOGENS.
Effects of Overexposure:SEE HEALTH HAZARDS AND MEDICAL CONDITIONS
AGGRAVATED BY EXPOSURE.
Medical Cond Aggravated by Exposure:OVEREXPOSURE SYMPTOMS MAY BE
AGGRAVATED FOR SENSITIVE INDIVIDUALS WITH RESP.CONDITION (SUCH AS
EMPHYSEMA). PERSON WITH LG SKIN,SENSITIVE SKIN OR LG AMTS OF BODY
HAIR MAY EXPERIENCE SKIN DISORDERS.
* First Aid Measures *
First Aid:EYES:FLUSH WITH WATER.SEEK MEDICAL ATTENTION;SKIN:WASH WITH
SOAP & WATER;INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING GIVE
CPR.SEEK MEDICAL ATTENTION;INGESTION:SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Unusual Fire/Explosion Hazard:DUST HAZARDS EXIST UNDER FAVORING
CONDITIONS OF SMALL PARTICLE SIZE. DISPERSION IN AIR AND STRONG
IGNITION SOURCE MAY RESULT IN AN EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:PICK UP AND PLACE IN APPROPRIATE DISPOSAL
CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL PROCEDURE REQUIRED.
Other Precautions:REMOVE TRACES OF MATERIAL DUST IF
SOLDERING,WELDING,BRAZING,CUTTING OR OTHER PROCESS INVOLVING
INGITION SOURCES TO PREVENT A FIRE HAZARD.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:7.8
Solubility in Water:NOT SOLUBLE
Appearance and Odor:SOLID METAL OBJECT. ANTI-RUST COATING HAS ODOR OF
KEROSENE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS,BASES OR STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:METAL FUMES IF HEATED. ANTI-RUST
COATING IS COMBUSTIBLE AND WILL PRODUCE OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR WITH FULL FACEPIECE AND ORGANIC VAPOR CARTRIDGES. FOR
HIGH CONCENTRATIONS OR PROLONGED EXPOSURE, USE A SELF-CONTAINED
BREATHING APPARATUS IN TH E POSITIVE PRESSURE MODE.
Ventilation:MECHANICAL VENTILATION MAY BE SUFFICIENT TO KEEP PRODUCT
VAPOR BELOW TLV. USE SUPPLEMENTAL LOCAL EXHAUST AS REQUIRED.
Other Protective Equipment:WEAR INDUSTRIAL WORK CLOTHING. USE RUBBER
APRON IS RECOMMENDED. EYE BATH AND SAFETY SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING RO SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPOR OR MIST. DO NOT INGEST. READ PRECAUTIONS ON LABEL
BEFORE USE.
* Product Identification *
Product ID:PRIMARY AMYL ACETATE
Preparer's Name:PAUL PFEIFER
* Composition/Information on Ingredients *
Ingred Name:N-AMYL ACETATE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIQUID IS IRRITATING TO EYES. VAPOR
MAY CAUSE EYE IRRITATION. LIQUID IS SLIGHTLY IRRITATING TO SKIN.
PROLONGED OR REPEATED CONTACT CAN RESULT IN DERMATITIS. VAPORS MAY
BE IRRITATING TO NOSE, THROAT & RESPIRATORY TRACT. INGESTION OF
PRODUCTMAY RESULT IN VOMITING. ASPIRATION OF VOMITUS INTO LUNGS MAY
CAUSE PNEUMONITIS.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP
OR OSHA AS A CARCINOGEN, MUTAGEN, TERATOGEN OR NEUROTOXIN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY ALSO CAUSE HEADACHE, DIZZINESS AND NAUSEA.
ASPIRATION PNEUMONITIS MAY CAUSE COUGHING, LABORED BREATHING,
CYANOSIS, AND IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE SKIN MAY BE AT
INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATIO N: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL
ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.1
Upper Limits:7.5
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL: WIPE/SOAK UP WITH PAPER TOWEL OR
INERT ABSORBENT. PUT IN DISPOSAL CONTAINER. LARGE SPILL: ELIMINATE
ALL SOURCES OF IGNITION. VENTILATE AREA. DIKE TO CONTAIN. VACUUM UP
OR PUMP FREE LIQUID INTO DOT SALVAGE CONTAINER AND SEAL
FORDISPOSAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS CLOSED WHEN MATERIAL IS NOT IN USE. KEEP AWAY FROM
IGNITION SOURCES. AVOID PROLONGED OR REPEATED CONTACT.
Other Precautions:PERSONNEL SHOULD AVOID INHALATION OF VAPORS. PERSONAL
CONTACT WITH THE PRODUCT SHOULD BE AVOIDED. SHOULD CONTACT BE MADE,
REMOVE SATURATED CLOTHING AND FLUSH AFFECTED AREAS WITH WATER. USE
AND STORE T HIS PRODUCT WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:5
Vapor Density:4.5
Evaporation Rate & Reference:0.6 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH A PERSISTENT
BANANA-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, AND STRONG ALKALIES.
Stability Condition to Avoid:HIGH HEAT OR OPEN FLAME
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AN APPROPRIATE NIOSH-APPROVED RESPIRATOR FOR
DUST SHOULD BE WORN
CHG
Other Protective Equipment:AS NECESSARY TO PREVENT PROLONGED & REPEATED
SKIN CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:PER MFR,THE TOXICOLOGICAL PROPERTIES OF THIS
MATL HAVE NOT BEEN INVESTIGATED.
* First Aid Measures *
First Aid:INHAL:RMV FROM EXPOSURE,TREAT SYMPTOMATICALLY & GET MEDICAL
GET MED A TTN IF SYMPTOMS APPEAR;INGEST:GET MED ATTN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY,DRY CHEMICALS,CO*2
Fire Fighting Procedures:WEAR SCBA & PROTECTV CLOTHG TO PREVENT
SKIN/EYE CONTACT.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSEVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:AVOID INHALATION & SKIN CONTACT.WEAR SUITABLE
PROTECTIVE EQUIPMENTS;SM AMT:SWEEP MATL ONTO PAPER & PLACE IN FIBER
CARTON;LG AMT- PACKAGE APPROPRIATELY FOR SAFE FEED TO AN
INCINERATOR OR DISSOLVE IN CO MPATIBLE WASTE SOLVENT PRIOR TO
INCINERATION.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:THE ROUTINE USE OF NON-ALKALINE(ACID)TYPE OF HAND
CLEANER WILL HELP MINIMIZE THE POSSIBILITY OF ALLERGIC SKIN
REACTION.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE TO OFF-WHITE CRYSTALLINE SOLID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE OXIDES OF
CARBON
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN AN APPROVED INCINERATOR.CONTRACT WITH
LICENSED CHEMICAL WASTE DISPOSAL SVC.WASH CONTAMINATED AREA WELL
WITH SOAP & WATER.FED, STATE & LOCAL REGULATIONS TAKE PRECEDENCE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER NORMAL & INTENDED USE.
Ventilation:GENERAL ROOM VENTILATION
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:EYES: FLUSH W/FLOWING WATER. DON'T RUB. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR, AID IN BREATHING IF
NECESSARY. INGESTION: DILUTE W/WATER & INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, FOAM/CO2
Fire Fighting Procedures:WEAR SCBA IN POSITIVE-PRESSURE MODE W/FULL
FACEPIECE.
Unusual Fire/Explosion Hazard:IF SPILL/LEAK HASN'T IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS/FLUSH AWAY FROM FIRE.
* Accidental Release Measures *
Spill Release Procedures:SHOULD BE CONTAINED, ASBORBED & PLACED IN
SUITABLE CONTAINERS FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE & HANDLE ACCORDING TO PACKAGED
INSTRUCTIONS, PROTECT FROM PHYSICAL DAMAGE.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER GEL W/MILD ESTER ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING TO DECOMPOSITION.
Hazardous Decomposition Products:ORGANIC MATERIALS, CO2, CO, SMALL
AMOUNTS OF ALDEHYDES & KETONES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. INCINERATE/BURY AT A LICENSED FACILITY. DON'T
DISCHARGE INTO WATERWAYS/SEWER SYSTEMS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DSGC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SPECIFIC RESP SELECTED MUST BE BASED ON CONTAM
LEVELS FOUND IN WORK PLACE, MUST BE BASED ON SPECIFIC OPERATION,
MUST NOT EXCEED WORKING LIMS OF RESP & MUST BE NIOSH APPRVD. RECOMD
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION AND/OR GENERAL DILUTION
VENTILATION TO MEET PUBLISHED EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
APPROPRIATE IMPERVIOUS CLOTHING & EQUIPMENT TO PREVENT POSS SKIN
CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 1.2 @ 0.1M SOLN. FIRE FIGHT PROC: FLAMES UNTIL WELL AFTER FIRE IS
OUT. STAY AWAY FROM ENDS OF TANKS. USE AGENTS SUITABLE FOR TYPE OF
FIRE. USE WATER IN FLOODING AMTS AS FOG. COOL CNTNRS W/FLOODING
QTYS OF WATER. APPLY FROM AS FAR A DIST AS POSS. AVOID BRTHG CORR
VAPS. KEEP UPWIND. HAZ DECOMP PRODS:& CHLOROFORM.
* Product Identification *
Product ID:TRICHLOROACETIC ACID, SOLID
CAGE:0G9K0
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, TRICHLORO-; (TRICHLOROACETIC ACID)
OSHA PEL:1 PPM
ACGIH TLV:1 PPM
Ingred Name:EFTS OF OVEREXP:SHARP EDGES & HEAL SLOWLY W/SCAR TISS FORM.
EYES:PAIN, LACRIM, PHOTOPHOBIA & BURNS. W/MILD BURNS (ING 3)
Ingred Name:ING 2:EPITHELIUM REGENERATES RAPIDLY & EYE RECOVERS
COMPLETELY. W/SEV CASES, EXTENT OF INJURY MAY NOT BE APPARENT(ING
4)
Ingred Name:ING 3: FOR SEVERAL WKS. WHOLE CORNEA MAY BECOME DEEPLY
VASCULARIZED & OPAQUE RSLTG IN BLINDNESS. IN WORST CASES, (ING 5)
Ingred Name:ING 4: EYE MAY BE TOTALLY DESTROYED. INGEST:MAY CAUSE
CIRCUMORAL BURNS W/DISCOLORATION & CORR OF MUC MEMBS OF (ING 6)
Ingred Name:ING 5:MOUTH, THROAT & ESOPHAGUS. MAY BE IMMED PAIN &
DFCLTY/INABILITY TO SWALLOW/SPEAK. EPIGLOTTAL EDEMA MAY RSLT(ING 7)
Ingred Name:ING 6: IN RESP DISTRESS & POSS ASPHYXIA. MARKED THIRST,
NAUS, VOMIT & DIARR. DEPENDING ON AREA & DEGREE OF CORR, (ING 8)
Ingred Name:ING 7: VOMITUS MAY CNTN FRESH/DARK BLOOD & LG SHREDS OF
MUCOSA. SHOCK POSS W/MARKED HYPOTENSION, WEAK & RAPID (ING 9)
Ingred Name:ING 8: PULSE, SHALLOW RESP & CLAMMY SKIN. CIRCULATORY
Ingred Name:ING 9:FAILURE. IN SEV CASES, GASTRIC & ESOPHAGEAL
PERFORATION MAY OCCUR W/PERITONITIS W/FEVER & ABDOM RIGIDITY. (ING
ATTACKS. GI DISTURBS. SKIN:DERM/EFTS SIMILAR TO ACUTE EXPOS.(ING
ULCERATIVE CHGS IN MOUTH MUC MEMBS & EFTS AS IN ACUTE INGEST.
Ingred Name:FIRST AID PROC:AREA W/STERILE, DRY DRESSING. BANDAGE
ATTN IMMED. KEEP HEAD BELOW HIPS TO PVNT ASPIR IF VOMIT OCCURS.
Ingred Name:RESP PROT: FACEPIECE OPERATED IN PRESS-DEMAND OR OTHER POS
FACEPIECE OPERATED IN PRESS-DEMAND OR OTHER POS PRESS MODE.
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE RESPIRATORY
TRACT IRRIT WITH COUGHING, CHOKING & POSSIBLE BURNS OF MUC MEMBS.
ALSO, DIZZ, HDCH, NAUS & WEAK. PULM EDEMA MAY DEVELOP; IMMEDIATELY
TIGHTNESS IN CHEST, DYSPNEA, FROTHY SPUTUM & CYANOSIS. PHYSICAL
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: FINDINGS MAY INCLUDE HYPOTENSION,
WEAK, RAPID PULSE & MOIST RALES. RECOVERY MAY BE PRLNGD & RELAPSES
POSS. IN SEVERE EXPOSURES, DEATH DUE TO ANOXIA MAY OCCUR W/IN FEW
HRS AFTER ONSET OF SYMP S OR FOLLOWING RELAPSE. SKIN: SEVERE PAIN,
BURNS & POSSIBLE BROWNISH OR YELLOWISH STAINS. BURNS MAY BE DEEP
WITH (ING 2)
Medical Cond Aggravated by Exposure:PERSONS WITH SKIN, EYE OR
RESPIRATORY DISORDERS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG HAS STOPPED, GIVE
ARTF RESP. MAINTAIN AIRWAY & BLOOD PRESS & ADMIN O*2 IF AVAIL BY
QUALIFIED PERS. KEEP WARM & @ REST. TREAT SYMP & SUPPORTIVELY. GET
MED ATTN IMMED. SKIN:REMOVE CONTAMD CLTHG & SHOES IMMED. WASH
AFFECTED AREA W/SOAP OR MILD DETERGENT & LG AMTS OF WATER UNTIL NO
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOIXDE, WATER SPRAY OR
REGULAR FOAM. FOR LARGER FIRES, USE WATER SPRAY, FOG OR REGULAR
FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
MOVE CONTAINER FROM FIRE AREA IF W/OUT RISK. APPLY COOLING WATER TO
SIDES OF CONTAINERS EXPOSED TO (SUPDAT)
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:DO NOT TOUCH SPILL MATL. STOP LEAK IF W/OUT
RISK. USE H*2O SPRAY TO REDUCE VAPS. SM SPILL:TAKE UP W/SAND OR
OTHER ABSORB MATL & PLACE INTO CNTNRS FOR LATER DISP. LG SPILL:DIKE
SPILL FOR LATER DISP. KE EP UNNEC PERS AWAY. ISOLATE HAZ AREA, DENY
ENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE; KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. STORE AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:MAY IGNITE COMBUSTIBLES (WOOD, PAPER, OIL, ETC).
* Physical/Chemical Properties *
Vapor Density:5.6
pH:SUPDAT
Appearance and Odor:COLORLESS, DELIQUESCENT CRYSTALS WITH A SHARP,
PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES: POSSIBLE VIOLENT RXN. COPPER + DIMETHYLSULFOXIDE: INTENSE
EXOTHERMIC RXN. METALS: CORR IN PRESENCE OF MOISTURE.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES.
Hazardous Decomposition Products:THERMAL DECOMP PRODS MAY INCL TOX
FUMES OF PHOSGENE, TOX & CORR FUMES OF HYDROGEN CHLORIDE, TOX
OXIDES OF CARBON(SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS
WHEN STORING OR DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE,
CONTACT DISTRICT DIRECTOR OF THE ENVIRONMENTAL PROTECTION AGENCY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CONC-IN-AIR DETERMS PROT NEEDED. USE ONLY
NIOSH/MSHA APPRVD RESP PROT. USUALLY NOT NEEDED UNLESS PROD IS
HEATED/MISTED. HALF-MASK AIR PURIFYING RESP W/DUST/MIST
LIM. (ING 9)
Ventilation:VENTILATE AS NEEDED TO COMPLY WITH EXPOSURE LIMIT. GENERAL
DILUTION VENTILATION ACCEPTABLE.
Other Protective Equipment:WEAR CHEM RESISTANT CLTHG; FOLLOWING MATLS
ARE ACCEPTABLE: PVA, PVC, NEOPRENE, NITRILE, VITON, POLYURETAHNE.
Work Hygienic Practices:LAUNDER SOILED CLOTHES.
Supplemental Safety and Health
OVEREXP: INGEST: LOW ACUTE TOX. PULM ASPIR HAZ-HARMFUL/FATAL IF
SWALLOWED &/OR VOMIT OCCURS BECAUSE IT CAN ENTER LUNGS & CAUSE DM
G. ING 4: NO DATA AVAIL FOR ALL ROUTES OF EXPOS. ING 5: INHAL:
OVEREXP TO MIST/VAPS MAY CAUSE EYE, NOSE, THROAT (ING 6)
* Product Identification *
Preparer's Name:STEVEN MCDANIEL
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (HYDROTREATED LIGHT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED MIDDLE; (HYDROTREATED
MIDDLE DISTILLATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BORATED POLYISOBUTENYL SUCCINIC ANHYDRIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES; (LIGHT HYDROCRACKED
DISTILLATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: RESP TRACT IRRIT, CNS (BRAIN) EFTS, DIZZ, UNCON.
SKIN: LOW ACUTE TOX. PRLNG/RPTD CNTCT MAY CAUSE MOD (ING 7)
Ingred Name:ING 6: IRRIT. EYES: MINIMAL IRRIT ON CNTCT. INGEST:
HARMFUL/FATAL IF SWALLOWED &/OR VOMIT OCCURS BECAUSE IT CAN (ING 8)
Ingred Name:ING 7: ENTER LUNGS & CAUSE DAMAGE - PULM ASPIR HAZ.
Ingred Name:RESP PROT: FULL-FACE AIR PURIFYING RESP W/DUST/MIST FILTERS
Ingred Name:ING 9: EXPOS LIM. PROT BY AIR PURIFYING RESPS IS LIMITED.
Ingred Name:MINERAL OIL, PETRO DISTILLATES, SOLV-REFINED (SEV) HEAVY
PARAFFINIC; (SEV SOLV REFINED HEAVY PARAFFINIC PETRO OIL)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FOR PROD: INHAL: LOW ACUTE TOX. NO
EFTS EXPECTED. SKIN: PRACTICALLY NON-TOX IF ABSORBED. MAY CAUSE
MILD IRRIT WITH PRLNG/RPTD CNTCT. EYES: CNTCT MAY CAUSE MILD IRRIT.
INGEST: PRACTICALLY NON-TOX. ING 1: INHAL: LOW ACUTE TOX. SKIN:
PRACTICALLY NON-TOX BY ABSORPTION. MAY CAUSE MOD IRRIT W/PRLNG &
RPTD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CNTCT. EYE:MINIMALLY IRRIT ON CNTCT.
INGEST:PRACTICALLY NON-TOX. INGS 2 & 3:INHAL: OVEREXP MAY CAUSE
EYE, NOSE, THROAT & RESP TRACT IRRIT, CNS (BRAIN) EFTS, HDCH, NAUS,
DIZZ, INCOORDINATION, UNCON, COMA/DEATH. SKIN: LOW ACUTE TOX.
PRLNG/RPTD CNTCT MAY CAUSE MOD IRRIT. EYES: MINIMALLY IRRIT ON
CNTCT. (SUPDAT)
Medical Cond Aggravated by Exposure:SKIN DISORDERS.
* First Aid Measures *
First Aid:INHAL: MOVE TO FRESH AIR. SKIN: WASH WITH SOAP AND WATER
UNTIL NO ODOR REMAINS. WASH CLOTHING BEFORE REUSE. EYES: FLUSH WITH
MEDICAL ASSIS TANCE. INGEST: INDUCTION OF VOMITING NOT REQUIRED.
OBTAIN EMERGENCY MEDICAL ATTENTION. SMALL AMOUNTS WHICH
ACCIDENTALLY ENTER MOUTH SHOULD BE RINSED OUT UNTIL TASTE OF IT IS
GONE.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:WATER SPRAY, REGULAR FOAM, DRY CHEMICAL, CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CAN BE MADE TO BURN (FLASH POINT GREATER
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL. ADVISE EPA; STATE AGENCY IF
REQUIRED. ABSORB ON INERT MATERIAL. SHOVEL, SWEEP OR VACUUM SPILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NFPA CLASS IIIB STORAGE. WASH
THOROUGHLY AFTER HANDLING.
Other Precautions:CONSULT WITH A HEALTH/SAFETY PROFESSIONAL FOR
SPECIFIC SELECTION OF PERSONAL PROTECTION/EXPOSURE CONTROL.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SUPDAT
Evaporation Rate & Reference:SUPDAT
Solubility in Water:NIL (% BY VOLUME)
Appearance and Odor:PURPLE LIQUID; HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CARBON MONOXIDE
AND OTHER ASPHYXIANTS.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FED, STATE & LOCAL REGS. NOT A RCRA
HAZARDOUS WASTE IF UNCONTAMD. IF "USED", RCRA CRITERIA
(IGNITABILITY, REACTIVITY, CORROSIVITY, TOXICITY CHARACTS) MUST BE
DETERMD. DO NOT FLUSH TO DRAIN/STRO M SEWER. CONTACT TO AUTHORIZED
DISPOSALSERVICE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN SPRAYING/APPLYING IN ANY CIRCUMSTANCES
LIKELY TO PRODUCE AIRBORNE LEVELS IN EXCESS OF TLV, USE AN ORGANIC
VAPOR CARTRIDGE/AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW TLV & PEL.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE
BATH, WASH FACILITIES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
FIRE HAZ CONT'D: VAPORS MAY TRAVEL LONG DISTANCES. FLASHBACK/FLAME TO
THE HANDLING SITE MAY OCCUR.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: <5%
Ingred Name:BIS (1,2,2,6,6-PENTAMETHYL-4-PIPERIDINYL) SEPACATE
Fraction by Wt: <5%
Ingred Name:BENZENEPROPANOIC ACID,
3-(2H-BENZOTRIAZOL-2-YL)-5-(1,1-DIMETHYLETHYL)-4-HYDROXY-,C7-9-BRAN
CHED AND LINEAR ALKYL ESTERS
Fraction by Wt: <5%
Ingred Name:METHYL PROPYL KETONE
Fraction by Wt: <5%
Fraction by Wt: <5%
Fraction by Wt: <5%
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
Ingred Name:1,3-BENZENEDICARBOXYLIC ACID POLYMER (POLYESTER RESIN)
Ingred Name:POLYESTER POLYOL
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:XYLENE: EYES: MAY CAUSE BURNING. SKIN:
POSSIBLE DERMATITIS W/PROLONGED EXPOSURE. MAY BE ABSORBED.
INHALATION. MAY CAUSE LIVER & KIDNEY DAMAGE. INGESTION: IRRITATION
OF THE DIGESTIVE TRACT. NERVOUS SYS TEM DEPRESSION. ASPIRATION OF
MATERIAL ENTERING THE LUNGS BY SWALLOWING/VOMITING CAN CAUSE LUNG
INFLAMMATION & DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:XYLENE: BURNING, TEARING, REDDENING,
DRYING/CRACKING OF SKIN, DIZZINESS, DROWSINESS, FATIGUE,
IRRITATION, LOSS OF COORDINATION, VOMITING, INFLAMMATION
* First Aid Measures *
DON'T USE SOLVENTS. INHALATION: REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION/CPR IF NECESSARY. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL FIRE
EXPOSED CONTAINERS W/WATER. FOG NOZZLES ARE PREFERRED. WEAR
NIOSH/MSHA APPROVED SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY ACCUMULATE IN INADEQUATELY
VENTILATED/CONFINED AREAS & FORM EXPLOSIVE MIXTURES W/AIR. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.(SUP
* Accidental Release Measures *
Spill Release Procedures:PROTECT FROM IGNITION. WEAR AIR-SUPPLIED
RESPIRATOR FOR UNVENTILATED LEAKS. COVER W/ABSORBENT & SCOOP INTO
CONTAINER. CLEAN RESIDUE W/A SUITABLE SOLVENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS.
Other Precautions:DON'T CUT, PUNCTURE/WELD ON/NEAR DRUM. VAPORS OF THIS
PRODUCT ARE >AIR & MAY COLLECT IN LOW/CONFINED AREAS.
* Physical/Chemical Properties *
Vapor Density:>1
Appearance and Odor:WHITE LIQUID W/SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME & OTHER IGNITION SOURCES
* Disposal Considerations *
Waste Disposal Methods:WHEN DISPOSING OF THIS MATERIAL, ENSURE THAT IT
IS PACKAGED, STORED, TRANSPORTED & OTHERWISE MANAGED IAW/LOCAL,
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
GUIDELINE"AIHA
Ventilation:GENERAL DILUTION/LOCAL EXHAUST. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:W A ELLISON
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIGLYCIDYL ETHER OF BISPHENOL -A RESIN (RESIN)
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TALC (PIGMENT)
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, AMORPHOUS-HYDRATED (PIGMENT)
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:ACUTE; INGEST: GASTROINTESTINAL IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHAL: NOSE OR THROAT IRRIT. ACUTE CENTRAL NERVOUS
SYSTEM DEPRESSION (HEADACHES , DIZZINESS, NAUSEA, CONFUSION). EYE:
SEVERE IRRIT. SKIN: SKIN SENSITIZATION (ALLERGIC REACTION).
DEFATTING & IRRITATION
Explanation of Carcinogenicity:IARC:CRYSTALLINE SILICA LIMITED EVIDENCE
CARCINOGENICITY IN HUMANS.NTP:CHROMIUM/CHROMIUM COMPOUNDS POTENTIAL
CARCINOGEN.
Effects of Overexposure:CHRONIC; SILICOSIS (DISABLING LUNG DISEASE).
LIVER, KIDNEY AND BLOOD INJURY. DERMATITIS. PROLONGED & REPEATED
OVEREXPOSURE: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
CONCENTRATING & INHALING PRODUCT MA Y BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
* First Aid Measures *
First Aid:INGEST:DONT INDUCE VOMITING.CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED.IF BREATHING STOPPED,GIVE
ARTIF RESP.KEEP WARM & QUIET.GET MED AID IMMED. EYE:FLUSH W/WATER
CONTAM CLOTHES.WASH AFFECTED AREA W/SOAP & WATER.GET MED AID IF
IRRIT PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
* Fire Fighting Measures *
Lower Limits:1.0
Upper Limits:8.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
* Accidental Release Measures *
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE ALL IGNITION
SOURCES. DIKE & CONTAIN WITH INERT MATERIAL (SAND, EARTH, ETC).
TRANSFER LIQUID OR USED ABSORBENT TO COVERED METAL CONTAINER. USE
NON-SPARKING TOOLS. PREVE NT SEWER, STREAM, OR GROUNDWATER
CONTAMINATION.
*Handling and Storage *
INTERNALLY. DO NOT BREATHE SANDING DUST. KEEP AWAY FROM CHILDREN.
AVOID SKIN CONTAACT.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
* Physical/Chemical Properties *
Vapor Density:> AIR
Spec Gravity:1.3
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALIS & AMINES. STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING
MATERIALS. ACCELERATORS.
OF IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING OR CUTTING,WILL PRODUCE SMOKE,CARBON MONOXIDE,CARBON
DIOXIDE,OXIDES OF CHROMIUM
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL LAWS/REGULATIONS. CONTAINS CHROMIUM. RESIDUE MAY BE HAZARDOUS
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR WHEN
WELDING, BRAZING OR SOLDERING IN CONFINED SPACE OR WHERE LOCAL
EXHAUST OR VENT DOES NOT KEEP EXPO SURE BELOW TLV.
Ventilation:USE ENOUGH VENT & LOCAL EXHST AT FLAME OR ARC TO KEEP FUMES
& GASES BELOW TLV'S IN WORKER'S BREATHING ZONE & GEN AREA.
Other Protective Equipment:ARM PROTECTORS, APRONS, HATS, SHOULDER PROT,
AS WELL AS DARK SUBSTANTIAL CLTHG. PROVIDE PROT SCREENS & FLASH
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:INCL FEVER, BODY ACHE, CHILLS. ARC RAYS FROM ELEC
OPERATIONS CAN INJURE EYES & BURN SKIN. ELEC SHOCK FROM ARC WELDING
EQUIP CAN KILL. HEAT RAYS (INFRARED RADIA FROM FLAME/HOT METAL) CA
N INJURE EYES. GASEOUS RXN PRODS SUCH AS CO & CO2, OZONE & NITROGEN
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICON
Ingred Name:IRON
ACGIH TLV:5 MG/M3
Ingred Name:COPPER (SARA III)
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME;1 DUST
Ingred Name:MANGANESE (SARA III)
Other REC Limits:3 MG/M3 FUME, STEL
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:MAGNESIUM
Fraction by Wt: 3.1-3.9%
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC OXIDE; (ZN)
Ingred Name:TITANIUM
Ingred Name:ALUMINUM (SARA III)
Fraction by Wt: REM
Ingred Name:SUPDAT:DURING ELECTRIC ARC WELDING.
Ingred Name:EYE PROT:SHADED LENS .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACTUAL EXPOS SHLD BE DETERM BY
MONITORING FUME IN OPERATOR'S BRTHG ZONE. SEE ANSI/AWS F1.1. SHORT
TERM EXPOS TO WELDING FUME MAY RESULT IN DISCOMFORT, DIZZ, NAUS OR
DRYNESS/IRRIT OF THROAT. LONG TERMEXPOS TO WELDING FUME,
GASES/DUST MAY CONTRIBUTE TO PULM IRRIT/PNEUMOCONIOSIS. LONG TERM
EXPOS TO IRON (EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT:IARC GROUP 2B
Effects of Overexposure:HLTH HAZ:FUME MAY PRDCE SIDEROSIS, WHICH IS GEN
REGARDED AS BENIGN. CHROMIUM SHLD BE CONSIDERED POSS CARCIN PER
REPORTED TO BE CARCIN. EXPOS LIMS SHLD BE MAINTAINED BELOW LEVEL
LISTED IN ING SECT. COPPER FUME MAY CAUSE METAL FUME FEVER WHICH
MAY (SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/IMPAIRED PULMONARY
FUNCTIONS OR ILLNESS MAY HAVE SYMPTOMS EXACERBATED BY FUME
IRRITANTS.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM DUST/FUME EXPOSURE. IF BREATHING HAS
STOPPED, PERFORM ARTF RESP. SUMMON MED AID IMMEDIATELY. INGEST:CALL
MD IMMEDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
SEEK ASSISTANCE FROM MD .
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC, OPEN FLAME & SPARKS CAN
IGNITE COMBUSTIBLES.
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PRECAUTIONARY LBL ON PRODUCT. TRAIN EMPLOYEE TO KEEP HIS HEAD OUT
OF FUMES.
DETAILS.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:SOLID WIRE OR ROD.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES & GASES OF INGREDIENTS. DEPENDS
ON WELDING PROCESS, COATINGS, FILLER METALS, CLEANING MATLS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE NIOSH/MSHA APPRVD
MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLIC. IN RESTRICTED VENT AREAS, USE NIOSH/MSHA
APPRVD CHEM-MECH FILTERS DES IGNED TO REMOVE A COMBINATION (ING 8)
Ventilation:USE VENT AS REQD TO CONTROL VAP CONC. AVOID PRLNGD/RPTD
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAMD CLTHG IMMED & DO NOT WEAR UNTIL PROPERLY
LAUNDERED.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:INTERIOR ALKYD SEMI-GLOSS WALL & TRIM ENAMEL. %
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLO HAZ:SUR F.
NEVER USE WELDING/CUTTING TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE
PROD (EVEN RESIDUE) MAY IGNITE EXPLOSIVELY.(ING 4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:HEAT PROT PROC:CNTNRS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PVNT VAP PRESS (ING 5)
Ingred Name:ING 4:BUILDUP WHICH COULD RESULT IN CONTAINER RUPTURE.
Ingred Name:FIRST AID PROC:VOMITING UNLESS ADVISED BY A PHYSICIAN.
CONTACT PHYSICIAN IMMEDIATELY.
Ingred Name:SPILL RELEASE:LOCAL HEALTH & POLLUTION CONTROL AGENCIES.
CALL SPILL RESPONSE TEAMS IF SPILL IS LARGE.
Ingred Name:RESP PROT:OF PARTICULATE & GAS AND VAP. IN CONFINED AREAS,
USE NIOSH/MSHA APPRVD AIR LINE TYPE RESPS/HOODS. (ING 9)
Ingred Name:ING 8:RESP PROT MAY ALSO BE NEC IN ANY LATER MFR OPERATIONS
Ingred Name:ING 9:OF VAPOR OR DUST.
Ingred Name:VENT:APPRVD RESP TO PVNT OVEREXP. PROVIDE GEN DILUTION/LOC
COATED WITH THESE PRODUCTS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS MAY B E HARMFUL/FATAL. DO NOT
BREATHE VAPORS OR SPRAY MIST. WEAR AN APPROP, PROPERLY FITTED RESP
(NIOSH/MSHA)(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DURING & AFTER APPLIC UNLESS AIR
MONITORING DEMONSTRATES VAP/MIST LEV ARE BELOW APPLIC LIM. FOLLOW
RESP MFR'S DIRECTIONS FOR RESP USE. BASED ON PRESENCE OF COMPONENT
(1), THESE PRODS MAY CAUS E NOSE, THROAT & EYE IRRIT. SYMPS OF
OVEREXP INCL DIZZ, HEADACHE, INTOXICATION W/EUPHORIA LEADING TO
UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
IMMED. SKIN:FLUSH W/COPIOUS AMTS OF LUKE WARM WATER. REMOVE CONTAMD
CLTHG PROMPTLY. IF IRRIT OCCURS, GET MED ATTN. INHAL:REMOVE EXPOSED
INDIV IDUAL TO FRESH AIR. RESTORE BRTHG IF REQD. CONT PHYS IMMED.
INGEST:RINSE MOUTH IMMED. GIVE EXPOSED INDIVIDUAL 6-8 OUNCES OF
LIQ. (NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON). DO NOT INDUCE
(ING 6)
* Fire Fighting Measures *
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:THE NATIONAL FIRE PROT ASSOCIATION CLASS B
EXTINGUISHER IS DESIGNED TO EXTING NFPA CLASS 1B FLAMMABLE LIQUID
FIRES.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFTIVE. WATER MAY BE USED TO COOL CLSD CNTNRS
TO PVNT PRESS BUILDUP & POSSIBLE (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:STOP AND/OR CNTN DISCHARGE IF IT MAY BE DONE
SAFELY. KEEP ALL SOURCES OF IGNIT AWAY. VENTILATE AREA OF SPILL.
USE NON-SPK TOOLS FOR CLEANUP. COVER W/INERT MATL TO REDUCE FUMES.
KEEP OUT OF DRAINS, SEW ERS/WATERWAYS. CONT FIRE AUTH. NOTIFY (ING
7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
INTERNALLY. GROUND CNTNRS WHEN POURING & LIM FREE FALL TO FEW
INCHES TO PVNT STATIC SPARKS. USE ONLY W/ADEQ VENT.
Other Precautions:AVOID SPONT COMBUST OF CONTAMD RAGS/OTHER EASILY
IGNITABLE ORG MATLS BY IMMED IMMERSION IN WATER. EMPTIED CNTNRS MAY
CNTN HAZ PROPERTIES. DO NOT CUT/PUNCTURE CNTNR. DO NOT WELD NEAR
CNTNR. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN USE.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NOT KNOWN.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:AVOID EXPOSURE TO SPARKS, OPEN FLAME, HOT
SURFACES & ALL SOURCES OF HEAT & IGNITION.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CNTN CO, CO*2 AND OXIDES OF
NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE WITH NORMAL VENTILATION MEANS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE ADEQUATE WASHING FACILITIES. WASH HANDS OR
OTHER CONTACT AREAS THOROUGHLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:PUREX
CAGE:PUREX
CAGE:0BYN5
* Composition/Information on Ingredients *
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHT IRRITATION. SKIN: SLIGHT
IRRITATION. INHAL: NO EFFECTS OF EXPOSURE EXPECTED. INGEST:
SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
WITH WATER. INHAL: NO EFFECTS OF EXPOSURE EXPECTED. REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O2/ARTF RESP) . INGEST: GIVE SEVERAL
GLASSES OF WATER OR MILK TO DILUTE THE INGESTED MATERIAL. CALL MD.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:MOP UP SPILLAGE, FLUSH OR RINSE WITH WATER AND
ALLOW TO DRY. DIKE AREA IF SPILLAGE IS LARGE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NORMAL HANDLING PROCESSES; INSIDE
Other Precautions:A PROGRAM OF REGULAR CLEANING, REPAIRING AND
REPLACING OF WORN-OUT PARTS AND CONTAMINATED EQUIPMENT IS HIGHLY
DESIRABLE. CHANGE CLOTHING IF WETTED WITH PRODUCT. DO NOT REUSE
CLOTHING WETTED WITH PROD BEFORE CLOTHING IS LAUNDERED.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.0
pH:7-7.5
Evaporation Rate & Reference:1 (WATER = 1)
Appearance and Odor:WHITE EMULSION, BLAND ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FLUSH WITH WATER INTO WASTE TREATMENT SYSTEMS
AND/ OR IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL ORDINANCES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST: REQUIRED.
Other Protective Equipment:RUBBER BOOTS, SAFETY SHOWER & EYE BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
CAGE:0MRZ6
* Composition/Information on Ingredients *
Ingred Name:SULFAMIC ACID
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & HARMFUL. EYE:
IRRITATION. INHALATION: HARMFUL, IRRITATION TO THE MUCOUS MEMBRANES
& UPPER RESPIRATORY TRACT. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: HARMFUL & IRRITATION. EYE: IRRITATION.
INHALATION: HARMFUL, IRRITATION TO THE MUCOUS MEMBRANES & UPPER
RESPIRATORY TRACT. INGESTION: HARMFUL.
* First Aid Measures *
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR OR OXYGEN IF NEEDED. INGESTION: OBTAIN MEDICAL ATTENTION
IN ALL CASE S.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP, PLACE IN A BAG & HOLD FOR WASTE
DISPOSAL. VENTILATE AREA & WASH SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING,
INHALATION, & RAISING DUSTS. KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & BASES.
Hazardous Decomposition Products:NITROGEN & SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER. IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DEPENDS ON CONCENTRATION ABOVE TIME WEIGHTED
TLV-CARTRIDGE RESPIRATOR OR MASK.
Ventilation:WHATEVER IS SUFFICIENT TO KEEP WORKING ROOM CONCENTRATIONS
BELOW TLV.
Other Protective Equipment:APRON, BARRIER CREAM
Supplemental Safety and Health
* Product Identification *
Product ID:GREEN EXT ALKYD
* Composition/Information on Ingredients *
Ingred Name:RESIN
Other REC Limits:NONE SPECIFIED
Ingred Name:LINSEED OIL
Other REC Limits:NONE SPECIFIED
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 6%
Ingred Name:CALCIUM CARBONATE
Ingred Name:ZINC OXIDE
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 5) (TOXICITY DATA: ORAL 5
G/KG)
Ingred Name:CHROMIUM OXIDE - AS CR3
Fraction by Wt: 3%
Other REC Limits:AS DUST 0.5 MG/M3
* Hazards Identification *
Health Hazards Acute and Chronic:DRYING OF SKIN. EYE IRRITAION.
EXCESSIVE INHALATION MAY CAUSE ANESTHESIA, HEADACHE, DIZZINESS,
NAUSEA, UPPER RESPIRTORY IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICAL RESPIRATION
IF NECESSARY, CALL A PHYSICIAN. SKIN CONTACT: WASH WITH MILD SOAP
AND WATER. APPLY A MILD CREAM, IN SEVERE CASES CONTACT A PHYSICIAN.
INGES TION: CALL A PHYSICIAN.
* Fire Fighting Measures *
Lower Limits:1
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WATER NOT A SUITABLE EXTINGUISHING
MEDIUM.
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER INTO RETAINING AREA OR
CONTAINER. AVOID SPARKS, FIRE OR HOT METAL SURFACES. SMALL
QUANTITIES MAY BE ABSORBED ONTO AN APPROPRIATE ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP COOL, AWAY FROM SOURCE OF
IGNITION, ADEQUATE VENTILATION. AVOID PROLONGED AND REPEATED
PERSONAL CONTACT.
Other Precautions:KEEP FROM OPEN FLAME.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, FIRE
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE AND CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
IN ACCORDANCE WITH APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESP APPRVD FOR ORGANIC SOLVENT
Ventilation:LOCAL EXHST
Supplemental Safety and Health
* Product Identification *
Product ID:NITRILE/RESIN
* Composition/Information on Ingredients *
Ingred Name:SOLVENTS
Ingred Name:POLYMERS
* Hazards Identification *
Effects of Overexposure:EYE/THROAT/SKIN/LUNG IRRIT
* First Aid Measures *
First Aid:WASH SKIN THOROUGHLY, FLUSH EYES W/WATER, REMOVE TO FRESH
AIR. REMOVE CONTAM CLOTHING. GIVE ARTIF RESP IF NEEDED, CALL MD
* Fire Fighting Measures *
Extinguishing Media:FOAM, DRY CHEM, FOG, CARBON DIOXIDE
Fire Fighting Procedures:AS VERY FLAMMABLE LIQ
Unusual Fire/Explosion Hazard:AVOID FIRE, HEAT, SPARKS, IGNITION
SOURCES, STG IN DIRECT SUNLIGHT
* Accidental Release Measures *
Spill Release Procedures:VENT AREA MECH, KEEP FROM FLAME, FIRE, SPARKS,
IGNITION SOURCES. DO NOT BREATHE VAPORS. CLEAN UP W/ABSORBENT MATL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNRS CLOSED, UPRIGHT, AWAY FROM
FIRE, FLAME, SPARKS, IGNITION SOURCES, DIRECT SUNLIGHT.
* Physical/Chemical Properties *
HCC:F3
Evaporation Rate & Reference:5.0 BUTYL ACETATE
Solubility in Water:NONE
Appearance and Odor:YELLOW COLORED LIQ
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE FULL-FACE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE OR CANISTER RESPIRATOR WITHIN USE LIMITATIONS OF THESE
DEVICES; IN ALL OTHER SITUATIONS, USE NIOSH/MSHA APPROVED SCBA.
Ventilation:LOCAL EXHAUST: RECD WHEN APPROPOPIATE TO CONTROL EMPLOYEE
EXPOS. MECHANICAL: NOT RECOMMENDED AS SOLE MEANS OF CONTROL.
Other Protective Equipment:WHERE SPILLS OR SPLASHING OCCURS, USE
IMPERVIOUSY COVERING & BOOTS. SAFETY SHOWER & EYE BATH SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING.
WASH CLOTHING BEFORE RE-USE. DISCARD CONTAMINATED LEATHER CLOTHING.
Supplemental Safety and Health
SPILL: STORM SEWERS & DITCHES WHICH LEAD TO NATL WATERWAYS.CALL
* Product Identification *
Product ID:DIOCTYL PHTHALATE
* Composition/Information on Ingredients *
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION-PRACTICALLY NON-TOXIC
TO ANIMALS. INHALATION-NO INFORMATION. SKIN-ESSENTIALLY
NON-IRRITATING. PRACTICALLY NON-TOXIC TO ANIMALS BY ABSORPTION.
EYE-ESSENTIALLY NON- IRRITATING. CHRONIC: MUTAGENICITY-IN VITRO,
LIMITED EVIDENCE OF MUTAGENICITY.
Explanation of Carcinogenicity:CARCINOGENIC IN LABORATORY ANIMALS.
INLAB ANIMALS, AFFECTS MALE REPRODUCTION; ADVERSELY AFFECTS EMBRYO.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST-INDUCE VOMITING OF CONSCIOUS PATIENT IMMED BY GIVING 2
GLASSES OF WATER & PRESSING FINGER DOWN THROAT. INHALE-REMOVE FROM
CONTAMINATED AREA. IF BREATHING HAS STOPPED, PERFORM CPR, THEN
OXYGEN I F NEEDED. SKIN-REMOVE CONTAMINATED CLOTHING & WASH SKIN
MIN. CONTACT A PHYSICIAN IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:0.3%
Extinguishing Media:USE CO2 OR DRY CHEMICAL FOR SMALL FIRES,
ALCOHOL-TYPE AQUEOUS FILM-FORMING FOAM OR WATER SPRAY FOR LARGE
FIRES.
Fire Fighting Procedures:WEAR SCBA AND COMPLETE PERSONAL PROTECTIVE
EQUIPMENT WHEN POTENTIAL FOR EXPOSURE TO VAPORS EXIST. USE WATER
SPRAY TO COOL FIRE-EXPSOED STRUCTURES/VESSELS.
Unusual Fire/Explosion Hazard:FOAM OR WATER CAN CAUSE FROTHING.
MATERIAL CREATES A SPECIAL HAZARD BECAUSE IT FLOATS ON WATER.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. AVOID EYE/SKIN
CONTACT. IF FIRE POTENTIAL EXISTS, BLANKET SPILL W/FOAM. CONTAIN
SPILL. TO CLEAN UP SPILL, FLUSH AREA SPARINGLY W/WATER OR USE AN
ABSORBANT. AVOID RUNOFF INT O STORM SEWERS & DITCHES.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM SPARKS AND FLAME. KEEP
CONTAINERS CLOSED. USE ONLY DOT-APPROVED CONTAINERS. WHEN
TRANSFERRING FOLLOW PROPER GROUNDING PROCEDURES.
Other Precautions:AVOID BREATHING MIST. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:CLEAR, COLORLESS, MOBILE LIQUID WITH MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS SUCH AS HYDROGEN PEROXIDE, NITRIC ACID, PERCHLORIC
ACID OR CHROMIUM TRIOXIDE.
Stability Condition to Avoid:FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:PRODUCT WHEN SPILLED OR DISPOSED IS HAZARDOUS
SOLID WASTE AS DEFINED IN RESOURCE CONSERVATION RECOVERY ACT REGS
TREATMENT IN FEDERAL/STATE AP PROVED FACILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:INHALATION SHOULD BE AVOIDED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:BRXTH
CAGE:BRXTH
* Composition/Information on Ingredients *
Ingred Name:CARBON BLACK
Fraction by Wt: 3-4%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:POLYESTER RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DYESTUFF; (DYES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WAX
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL IRRITATION TO
RESPIRATORY TRACT MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF
ANY NON-TOXIC POWDER.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS, ON THE
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ACCUMULATION OF DUST IN THE
RESPIRATORY SYSTEM.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR IF EFFECTS OCCUR. CONSULT
LOCAL MEDICAL PERSONNEL. EYES: IMMEDIATELY FLUSH WITH PLENTY OF
WATER. SEEMD . INGESTION: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY POWDER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . THESE MATERIALS WILL BURN IN THE CASE OF FIRE. AVOID
INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:THESE MATERIALS HAVE NO UNUSUAL FIRE OR
EXPLOSION HAZARDS. THE DECOMPOSITION PRODUCTS ARE CARBON MONOXIDE,
CARBON DIOXIDE AND NO*X.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE.
* Physical/Chemical Properties *
Spec Gravity:1.2 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE ODORLESS POWDER (BLACK COLORED)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PHENOL DERIVATIVES. CARBON MONOXIDE
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEEDED/FOR
SYMPTOMS OF OVEREXPOSURE, WEAR A NIOSH-APPROVED RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:NEOPRENE/OTHER CHEMICAL RESISTANT
APRON/COVERALLS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:T O VYFHUIS
* Composition/Information on Ingredients *
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
Fraction by Wt: <5%
Ingred Name:L.P.G. (LIQUID PETROLEUM GAS) PROPELLANT(FLAMMABLE)
Fraction by Wt: <5%
Ingred Name:NON HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY IRRITATION.
SKIN: PROLONGED/REPEATED CONTACT MAY LEAD TO IRRITATION, DERMATITIS
& ABSORPTION. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
DRYING, BURNING
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR & RESTORE BREATHING IF
NECESSARY. SKIN: WASH W/PLENTY OF WATER. EYES: IMMEDIATELY FLUSH
CASES.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:USE WATER SPRAY/FOG TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. DROPPING CANS MAY BURST.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. AVOID BREATHING
VAPORS & SKIN CONTACT. SOAK UP W/ABSORBENT MATERIAL.
*Handling and Storage *
CONTAINERS.
Other Precautions:PLEASE READ & FOLLOW THE DIRECTIONS ON THE PRODUCT
LABEL FOR PROPER USE OF PRODUCT & THE NECESSARY PRECAUTIONS FOR
PROTECTION.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:COMPLETE
Appearance and Odor:WIDE HOLLOW CONE SPRAY; SEMI-STABLE FOAM;
SOLVENT/FLORAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CO, CO2
BURST. OPEN FLAMES & HOT SURFACES.
* Disposal Considerations *
Waste Disposal Methods:AEROSOL CONTAINER. DON'T PUNCTURE/INCINERATE.
WHEN CONTENTS ARE DEPLETED, CONTINUE TO DEPRESS SPRAY BUTTON UNTIL
ALL GAS IS EXPELLED. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN
TO PREVENT INHALATION OF MISTS, FUMES OR DUSTS.
Ventilation:WORK SHALL BE CONDUCTED IN WELL VENTILATED AREAS.
Other Protective Equipment:FOR END-USERS, PLEASE REFER TO THE PRODUCT
LABEL FOR PERSONAL PROTECTIVE CLOTHING/EQUIPMENT.
Work Hygienic Practices:WASH THORO W/SOAP & WATER AFTER HNDLG. REMOVE
CONTAMD CLTHG & WASH BEFORE REUSE. DO NOT EAT, SMOKE/DRINK AT
WORKPLACE.
Supplemental Safety and Health
PH: 4.2-4.5. FIRE FIGHT PROC: IF WATER ENTERS DRAINAGE SYS, ADVISE AUTH
DOWNSTREAM. FIRST AID PROC: INFECTION ESP IN IMMUNE-IMPAIRED. SPILL
PROC: CNTN & ABSORB RINSATE W/INERT ABSORB & PLACE INTO SAME DISP
CNTNR AS SPILLED MATL. SM SPILLS TO SOIL CAN BE SHOVELED DIRECTLY
INTO DISP CNTNRS. IN THE EVENT OF A (ING 3)
* Product Identification *
Product ID:ACROBE BIOLARVICIDE
* Composition/Information on Ingredients *
Ingred Name:POLYPEPTIDE, BACILLUS THURIGIENSIS SUBSPECIES ISRAELENSIS,
CRYSTAL PREPARATION; (BACILLUS)
Fraction by Wt: 1.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:INERT MATERIALS; (INERTS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: LG SPILL, CNTCT MFR FOR GUIDANCE ON AVAIL CLEAN-UP
OPTIONS. DEPENDING ON QTY RELEASED TO THE ENVIRON, (ING 4)
Ingred Name:ING 3: NOTIFICATIONS TO REGULATORY AUTH MAY BE REQD. IF
SPILL IS TO A WATER BODY, IMMED NOTIFY APPLIC AUTH (ING 5)
Ingred Name:ING 4: DOWNSTREAM SO THAT CONTINGENCIES CAN BE TAKEN IF
NECESSARY.
Ingred Name:WASTE DISP: RENDER CNTNR UNUSABLE BY CRUSHING &/OR
PUNCTURING & DISPOSE IN SAFE MANNER. IT IS THE ULTIMATE (ING 7)
Ingred Name:ING 6: RESPONSIBILITY OF THE WASTE GENERATOR TO DETERM AT
THE TIME OF DISP WHETHER THE PROD (&/OR "EMPTY" CNTNR (ING 8)
Ingred Name:ING 7: RESIDUE) MEETS ANY HAZ WASTE CRITERIA. FOLLOW ALL
APPLIC FED, STATE, PROVINCIAL & LOC REGS REGARDING (ING 9)
Ingred Name:ING 8: WASTE MANAGEMENT METHODS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED OR ABSORBED THROUGH
THE SKIN. LIKE ALL FORMS OF RESPIRABLE FOREIGN PROTEIN, THIS
MATERIAL WOULD HAVE POTENTIAL FOR CAUSING PULMONARY SENSITIZATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ALLERGIC BRONCHIAL ASTHMA, CHRONIC
OBSTRUCTIVE PULMONARY DISEASE AND ANY IMMUNE DEFICIENCY DISEASE OR
STATE.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. GET MED ATTN IF BRTHG IS DFCLT.
EYES: FLUSH W/PHYSIOLOGICAL SALINE SOLN FOR 5 MIN WHILE HOLDING
EYELIDS OPEN. GET MED ATTN IF IRRIT OCCURS. SKIN: WASH W/PLENTY OF
SOAP & WA TER. GET MED ATTN IF IRRIT OCCURS. NOTES TO MD: MATL
CONTAINS VIABLE SPORES. ALTHOUGH B THURINGIENSIS IS NOT NORM
PATHOGENIC TO MAN, INHAL OF MIST CONTAINING HUGE CONC OF SPORES MAY
CAUSE (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:THIS MATERIAL WILL NOT BURN. MEDIA SUITABLE FOR
SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
KEEP UNNEC PEOPLE AWAY. AVOID BRTHG DUST, VAPS & FUMES FROM BURNING
MATLS. CONTROL RUN-OFF WATER. (SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROP PROT CLTHG & EQUIP. DIKE SPILL
AREA TO PVNT SPILL FROM SPREADING. ABSORB W/INERT ABSORB MATL (E.G.
GRANULAR CLAY/SAWDUST) & SHOVEL/SWEEP INTO COVERED CNTNRS FOR
PROPER DISP. RINSE SPILL AR EA & TOOLS SEVERAL TIMES W/SOAPY
WATER.(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:TIGHTLY RECLOSE CONTAINERS OF UNUSED
STORAGE IN OR AROUND THE HOME.
Other Precautions:DO NOT CONTAMINATE WATER, FOOD OR FEED BY
STORAGE/DISPOSAL. STORE IN A SECURE, COOL, DRY, WELL-VENTILATED
AREA AWAY FROM CHILDREN, LIVESTOCK & FOOD PRODUCTS. AVOID CONTACT
WITH SKIN, EYES OR CLOTHING. AVOID BREATHING SPRAY MIST.
* Physical/Chemical Properties *
HCC:T6
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT TAN LIQUID; SLIGHTLY ACIDIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN. (STORE AT AMBIENT TEMPERATURES
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:TO AVOID DISP, ALL ATTEMPTS SHOULD BE MADE TO
UTILIZE PROD COMPLETELY I/A/W ITS INTENDED &/OR REGISTERED USE. IF
THIS IS NOT POSS, HANDLE W/CARE & DISP IN SAFE MANNER. EMPTY CNTNRS
MAY RETAIN SOME PRO D RESIDUES. DO NOT REUSE. RINSE THORO. (ING 6)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE RESPIRATOR APPROVED BY NIOSH/MSHA FOR
POLYMER/WHEN PARTICULATE DUST OF THE CURED POLYMER IS PRESENT.
Ventilation:LOCAL: REQUIRED. MECHANICAL EXHAUST: RECOMMENDED
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:CASTOR OIL, 4,4-DIPHENYLMETHANE DIISOCYANATE POLYMER
Ingred Name:DIPHENYLMETHANEDIISOCYANATE (MDI), METHYLENE BIS
(PHENYLISOCYANATE), 4,4 DIPHENYLMETHANE DIISOCYANATE (MDI)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY CAUSE CHEMICAL DERMATITIS,
EXPOSURE MAY RESULT IN SENSITIZATION. INHALATION: EXPOSURE CAN
CAUSE IRRITATION OF MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:RASH, IRRITATION, CHEST PAIN, SHORTNESS OF
BREATH.
* First Aid Measures *
TO FRESH AIR AT ONCE. GIVE OXYGEN IF NEEDED. INGESTION: DON'T
INDUCE VOMITING. IF CONSCIOUS, GIVE 1-2 GLASSES OF MILK/WATER.
OBTAIN MEDICA L ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:COC
Upper Limits:9.5
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER SPRAY FOR LARGE
FIRES.
Fire Fighting Procedures:USE SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MOISTURE CONTAMINATION MAY FORM CO2 GAS
PRESSURE IN CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:ABSORB EXCESS MATERIAL IN SAWDUST/ABSORBENT
POWDER. WASH RESIDUE W/DETERGENT & WATER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/SKIN & CLOTHING.
Other Precautions:VAPORS CAN FORM DURING HEATING, FOAMING/SPRAYING.
* Physical/Chemical Properties *
Vapor Pres:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK LIQUID W/LOW/NO DETECTABLE ODOR (WEAKLY
AROMATIC)
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, BASES, OXIDIZERS/WATER, INCOMPATIBLE MATERIALS.
Stability Condition to Avoid:HEAT, MOISTURE
Hazardous Decomposition Products:HIGH HEAT & FIRE: OXIDES OF NITROGEN &
CARBON, TRACES OF HYDROGEN CYANIDE, DIPHENYLMETHANE-DIISOCYANATE
VAPORS/AEROSOLS.
BASES, OXIDIZERS/WATER.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED/INCINERATED IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:TYPICAL USE OF THIS PRODUCT DOES NOT REQUIRE THE
USE OF A RESPIRATOR. IF PRODUCT IS MISTED, USE NIOSH/MSHA APPROVED
MASK FOR SPRAY MIST.
Ventilation:THE WORK AREA SHOULD BE PROVIDED W/ADEQUATE LOCAL EXHAUST
VENTILATION IN CONFINED AREAS.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING WHEN HANDLING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:SWALLOWED, VOMIT SHOULD BE INDUCED UNDER MED
SUPERVISION. DRINK 1-2 GLASSES OF WATER & INDUCE VOMIT BY TOUCHING
BACK OF THROAT W/FINGER. DO NOT INDUCE VOMIT/GIVE ANYTHING BY MOUTH
TO UN CON PERS. WASTE DISP METH:AWAY FROM WATER SUPPLY. OTHER PREC:
TREATED AREAS. READ LABEL BEFORE USE.
* Product Identification *
Preparer's Name:S. SPRINKLE
* Composition/Information on Ingredients *
Ingred Name:DIPYRIDO(1,2-A;2',1'-C) PYRAZINEDIIUM, 6,7-DIHYDRO-,
DIBROMIDE; (DIQUAT) (DIQUAT DIBROMIDE; 6,7-D1-HYDRODIPYRIDO (ING 2)
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:ING 1:(1,2:A:2',1'-C) PYRAZINEDIUM DIBROMIDE) (SARA III)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:(SHORT TERM EXPOSURE) IRRITATING
TO SKIN, EYES & MUCOUS MEMBRANES. SKIN:LOCAL IRRITATION POSSIBLE.
EYE:LOCAL IRRITATION. INGEST:HARMFUL IF SWALLOWED. MAY CAUSE
NAUSEA. CHRONIC: (LONG TERM EXPOSU RE) IRRITATING TO SKIN, EYES &
MUCOUS MEMBRANES. SKIN:REPEATED CONTACT MAY INCREASE ABSORPTION
LEADING(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TO IRRITATION. EYE:IRRITANT. WILL
CAUSE REDDENING & TEARING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:GET PERS OUT OF CONTAM AREA TO FRESH AIR. IF BRTHG HAS
STOPPED, ARTF RESP SHOULD BE STARTED. OXYGEN MAY BE ADMIN, IF
READILY AVAIL. SEEK MED ATTN IMMED. EYE:IMMED FLUSH W/LG AMTS OF
OF SURF. SEEK MED ATTN IMMED. SKIN:IMMED WASH CONTAM SKIN W/PLENTY
OF SOAP & WATER. IF IRRIT PERSISTS, SEEK MED ATTN IMMED. INGEST:IF
(SUPDAT)
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:STOP LEAK. CONTAIN SPILL. REMOVE AS MUCH MATL
AS POSS W/ABSORB MATL, THEN DISP OF CONTAM ABSORB IN CLSD LABELED
CNTNR & CONT YOUR STATE PESTICIDE/ENVIRON CONTROL AGENCY/HAZ WASTE
REPRESENTATIVE AT NEA REST EPA REGIONAL OFFICE FOR GUIDANCE.
Neutralizing Agent:MUD, SILT OR OTHER ANIONIC SOLUTIONS WILL NEUTRALIZE
DIQUAT DIBROMIDE.
*Handling and Storage *
KEEP CNTNR CLSD. STORE IN COOL, DRY PLACE. STORE IN ORIG CNTNR.
KEEP OUT OF REACH OF CHILDREN & ANIMALS.
Other Precautions:IF STORED OUTDOORS, PLACE CNTNR ON ITS SIDE TO PVNT
WATER COLLECTING ON TOP OF DRUM. DO NOT EAT, DRINK/SMOKE IN WORK
AREA. DO NOT STORE NEAR SEEDS, FEEDS, FOOD STUFFS. AVOID CONTAM
WATER SOURCES. DO N OT ALLOW GRAZE ANIMALS ON (SUPP DATA)
* Physical/Chemical Properties *
HCC:T4
Vapor Density:0.6
pH:6
Evaporation Rate & Reference:0.1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:DARK BROWN, TRANSPARENT, NON-VISCOUS; NOT
OBJECTIONABLE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ANIONIC WETTING AGENTS, E.G. ALKYL SULPHONATES, ALKYLARYL SULFONATES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
NOX & ER.
* Disposal Considerations *
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . WASTE
RESULTING FROM USE OF THIS PROD MAY BE DISP OF ON SITE/AT APPRVD
WASTE DISP FACILITY. OPEN DUMPING IS PROHIBITED. DISP OF ANY UNUSED
PROD IN DESI GNATED LANDFILL AREA/BURY IN SAFE PLACE(SUPDAT)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:TYPICAL USE DOES NOT REQUIRE RESPIRATORS:
HOWEVER, IN EMERGENCY SITUATIONS WHERE EXPOSURE EXCEEDS OSHA
STANDARDS; NISOH/MSHA APPRVD CHEM CARTRIDGE RESP W/ORG VAP
CARTRIDGE & FULL FACEPIECE.
Ventilation:GENERAL EXHAUST IS ADEQUATE UNDER NORMAL CIRCUMSTANCES.
Other Protective Equipment:SHOES/BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ASPIR OF LIQ INTO LUNGS. GET MED ATTN. SPILL PROC: NOT
FLUSH TO SEWER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NONHAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY IRRITATE EYES. INGESTION
MAY RESULT IN VOMITING. ASPIRATION MUST BE AVOIDED TO AVOID
PNEUMONITIS. CHRONIC: MARKED IRRITATION OF EYES UPON CHRONIC
OVER-EXPOSURE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS
DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. EYE: FLUSH
SKIN: WASH W/SOAP & WATER. REMOVE CONTAMD CLTHG & SHOES; DO NOT
REUSE UNTIL CLEANED. IF PERSISTENT IRRIT OCCURS, GET MED ATTN.
INGEST: DO NOT INDUCE VOMIT. IF VOMIT OCCURS SPONT, KEEP HEAD BELOW
HIPS TO PVNT (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER
SPRAY.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. EVAC
HAZ AREA OF UNPROTECTED PERS. COOL FIRE-EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUMULATE IN LOW
AREAS/AREAS INADEQUATELY VENTD. VAPS MAY ALSO TRAVEL ALONG GROUND
TO BE IGNITED @ LOCATIONS DISTANT FROM HNDLG SITE.
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT. SM SPILLS: TAKE UP
W/ABSORB & PLACE IN LBLD CONTRS FOR DISP. LG SPLLS: EVAC AREA OF
UNPROTECTED PERS. STOP LEAK & CNTN SPILL. REMOVE VIA VACUUM TRUKS.
TAKE UP REMAINDER W/AB SORB & PLACE IN LBLD CONTRS FOR DISP. DO
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN MODERATE TEMPERATURES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING PRODUCT.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE, BLUE-GRAY, PETROLEUM ODOR
Percent Volatiles by Volume:1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN A DISPOSAL FACILITY APPROVED UNDER RCRA
REGULATIONS FOR HAZARDOUS WASTE. USE NON-LEAKING CONTAINERS. SEAL
TIGHTLY AND LABEL PROPERLY. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS (FP N).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS OF USE WITH
ADEQUATE VENTILATION.
Ventilation:LOCAL: PREFERRED. MECHANICAL: ACCEPTABLE.
Other Protective Equipment:LAB COAT, EYE WASH STATION, SAFETY SHOWER.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
= Wt:2.
Ingred Name:DEXTROSE
= Wt:1.5
Ingred Name:DEIONIZED WATER
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVERVIEW: DO NOT INGEST. THIS PRODUCT
IS NOT EXPECTED TO BE HAZARDOUS UNDER NORMAL CONDITIONS OF USE.
EYES: MAY CAUSE IRRITATION. SKIN: NOT EXPECTED TO BE HAZARDOUS BY
CONTACT. INGESTION: MAY CAUSE MI LD GASTROINTESTINAL DISTURBANCES.
INHALATION: NOT EXPECTED TO BE A HAZARD BY INHALATION.
Explanation of Carcinogenicity:NEITHER STARCH OR DEXTROSE LISTED AS
CAUSING CANCER BY IARC, NTP, OSHA.
Effects of Overexposure:EYES: IRRITATION. SKIN: NONE EXPECTED.
INHALATION: NONE EXPECTED. INGESTION: MILD GASTROINTESTIONAL
DISTURBANCES.
Medical Cond Aggravated by Exposure:NO INFORMATION AVAILABLE.
* First Aid Measures *
MINUTES, REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. IF
IRRITATION D EVELOPS OR PERSISTS, GET MEDICAL ATTENTION. INGESTION:
GET MEDICAL ATTENTION IF ANY ADVERSE EFFECTS SHOULD DEVELOP. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: MOVE
TO FRESH AIR . GIVE OXYGEN IF BREATHING DIFFICULT, GIVE ARTIFICIAL
RESPIRATION IF STOPPED. KEEP PERSON WARM, QUIET, AND GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS
WITH FULL FACE PIECE OPERATED IN THE PRESSURE DEMAND OR OTHER
POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE EXPECTED.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEANUP PERSONNEL
SHOULD WEAR PROPER PROTECTIVE CLOTHING AND EQUIPMENT. ABSORB
MATERIAL ON VERMICULITE OR OTHER SUITABLE ABSORBENT MATERIAL. WHEN
SATURATED SHOVEL OR SCOOP UP MATERIAL AND CONTAINERIZE FOR
DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE CONTAINER TIGHTLY CLOSED IN A
COOL, DRY AREA SUITABLE FOR GENERAL CHEMICAL STORAGE.
Other Precautions:AVOID EYE CONTACT.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.7(WATER)
Spec Gravity:NO INFO
Evaporation Rate & Reference:APPROX 1 WATER=1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, ODORLESS, SOLUTION.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER REACTIVE MATERIALS AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NO INFORMATION AVAILABLE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE AND/OR CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
Toxicological Information:TOXICITY DATA: TO THE BEST OF MANUFACTURERS
KNOWLEDGE, THE TOXICOLOGICAL PROPERTIES OF THIS MIXTURE HAVE NOT
BEEN THOROUGHLY EVALUATED. DATA IS LISTED BELOW FOR INDIVIDUAL
EFFECTS OF OVEREXPOSURE: CHRONIC*: STARCH: NO CHRONIC EFFECTS DATA
FOUND. NOT LISTED AS CAUSING CANCE R BY IARC, NTP, OR OSHA.
DEXTROSE: MUTATION DATA CITED. REPRODUCTIVE EFFECTS DATA CITED. NOT
LISTED AS CAUSING CANCER BY IARC, NTP, OR OSHA. * SEE "OTHER
INFORMATION FIELD".
* Ecological Information *
Ecological:EPA WASTE NUMBER: NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. EPA WASTE NUMBERS: NONE
* MSDS Transport Information *
Transport Information:NON-REGULATED MATERIAL.
* Regulatory Information *
CHEMICALS NAME LIST: STARCH = NO; CHEMICAL CATEGORY: STARCH = NO.
STARCH = NO; DEXTROSE= NO.
Federal Regulatory Information:EPA TSCA STATUS: THE INGREDIENTS OF THIS
PRODUCT ARE ALL ON THE TSCA INVENTORY LIST.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR NIOSH/MSHA
APPRVD POS PRESS SUPPLIED AIR RESP WHILE MIXING ACTIVATOR W/ANY
PAINT/CLEAR ENAMEL, DURING APPLICATION/UNTIL ALL VAPS/SPRAY MISTS
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
EFTS OF OVEREXP:MAY RESULT IN LIVER/KIDNEY INJURY. TESTS FOR
EMBRYOTOXIC ACTIVITY IN ANIMALS HAS BEEN INCONCLUSIVE. ETHYL
ACETATE:PRLNGD/RPTD HIGH EXPOS OF LAB ANIMALS RESULTED IN SECONDARY
ANEMIA W/I NCR IN WHITE BLOOD CELLS; FATTY DEGENERATION, CLOUDY
SWELLING & EXCESS OF BLOOD IN VARIOUS ORGANS. AROMATIC (SEE ING 6)
* Product Identification *
Product ID:ISOCYANATE ACTIVATORS HARDENERS & ADDITIVES
* Composition/Information on Ingredients *
Ingred Name:SUPP DATA:HYDROCARBON:RECURRENT OVEREXPOS MAY RESULT IN
LIVER/KIDNEY INJURY. HAS BEEN TOX TO FETUS IN LAB (SEE ING 7)
Ingred Name:ING 6:ANIMALS AT DOSES THAT ARE TOX TO MOTHER. ALIPHATIC
POLYISOCYANATE:RPTD EXPOS MAY CAUSE ALLERGIC SKIN (SEE ING 8)
Ingred Name:ING 7:RASH, ITCHING, SWELLING. OVEREXPOS MAY CAUSE
ASTHMA-LIKE RXN W/SHORT OF BREATH, WHEEZING, COUGH/PERM (SEE ING 9)
Ingred Name:ING 8:LUNG SENSIT. EFT MAY BE DELAYED FOR SEVERAL HRS AFTER
Ingred Name:ING 9:TEMPORARY UPPER RESP &/OR LUNG IRRIT W/COUGH, DFCLTY
CHEMICAL BURNS. LIQUID SPLASHES IN EYE MAY RESULT IN CHEM BURNS.
Ingred Name:N-BUTYL ACETATE (SARA III)
Ingred Name:ETHYL ACETATE (SARA III)
Ingred Name:ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS (ALIPHATIC
POLYISOCYANATE)
Other REC Limits:1.0 MG/M3 (MFR)
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS. INHAL:MAY CAUSE
NOSE/THROAT IRRIT. RPTD/PRLNGD OVEREXPOS TO SOLVS MAY LEAD TO PERM
BRAIN & NERVOUS SYS DMG. EYE WATERING, HDCH, NAUSEA, DIZZ, LOSS OF
COORDINATION ARE SIGNS THAT SO LV LEVELS ARE TOO HIGH. EXPOS TO
ISOCYANATES MAY CAUSE ASTHMA-LIKE RXN W/SHORT OF BREATH,
WHEEZING,(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:HLTH HAZ:COUGH/LUNG SENSIT. EFT MAY BE DELAYED
FOR SEVERAL HRS AFTER EXPOS. PERSONS W/LUNG/BRTHG PROBLEMS OR PRIOR
RXN TO ISOCYANATES MUST NOT BE EXPOSED TO VAPS/SPRAY MIST OF PROD.
EYE:MAY CAUSE IRRI T/BURNING. SKIN:RPTD/PRLNGD LIQ CNTCT MAY CAUSE
IRRIT W/DISCOMFORT/DERM. BUTYL ACETATE: RECURRENT OVEREXPOS (SUPP
DATA)
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING LUNG
DISEASE, ASTHMA, BREATHING DIFFICULTIES MAY HAVE INCREASED
SUSCEPTIBILITY TO TOXICITY OF EXCESSIVE EXPOSURE.
* First Aid Measures *
First Aid:INGST:IN UNLIKELY EVENT OF INGESTION, CALL MD IMMED & HAVE
NAMES OF INGREDS AVAILABLE. INHAL:REMOVE TO FRESH AIR. IF BRTHG
DFCLTY PERSISTS/OCCURS LATER, CALL MD. EYE:IMMED FLUSH W/PLENTY OF
IRRIT OCCURS, CALL MD.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.9%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CNTNRS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW FLASH POINT.
* Accidental Release Measures *
Spill Release Procedures:DO NOT BREATHE VAPS. DO NOT GET IN EYES/ON
SKIN. WEAR NIOSH/MSHA APPRVD POS PRESS SUPPLIED AIR VAP/PARTICULATE
ABSORB W/INERT MATL. VENT A REA. POUR LIQ DECONTAM SOLN OVER (SEE
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING W/O
NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:MISCIBLE.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE
AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATORY REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:2 PPM
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! STRONG OXIDIZER. CNTCT W/OTHER
MATL MAY CAUSE A FIRE. CORROSIVE. CAUSES EYE & SKIN BURNS. CAUSES
DIGESTIVE & RESP TRACT BURNS. ACUTE: EYE:CAUSES SEV EYE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJUR Y. SKIN: MAY CAUSE SEV SKIN IRRIT.
CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF THE SKIN.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INGEST: CAUSES GI TRACT BURNS. MAY
CAUSE PERFORATION OF THE DIGESTIVE TRACT. INHAL: MAY BE FATAL IF
INHALED. EFTS MAY BE DELAYED. MAY CAUSE IRRIT OF THE RESP TRACT
W/BURNING PAIN IN THE NOSE& THROAT, COUGHING, WHEEZING,
SHORTNESSOF BRTH & PULM EDEMA. CHRONIC: RPTD INHAL MAY CAUSE
CHRONIC BRONCHITIS. REPEATED EXPOS MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING THE UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW
VICTIM TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP & H*2O
AID IF IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST:DO
NOT INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL:REMOVE FROM EXPOS
TO FRESH AI R IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. GET MEDICAL AID. NOTES TO MD:TREAT
SYMPTOMATICALLY & SUPPORTIVELY. NO SPECIFIC ANTIDOTE EXISTS.
* Fire Fighting Measures *
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:GENERAL INFO: USE PROPER PERSONAL PROT
EQUIPMENT AS INDICATED IN PERS PROT EQUIP SECTION.
SPILLS/LEAKS:ABSORB SPILL W/INERT MATERIAL, (E.G., DRY SAND OR
EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAI NER. USE H*2O SPRAY
TO DISPERSE THE GAS/VAPOR.
Neutralizing Agent:SPILL WITH SODIUM BICABONATE.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. STORE
IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:DO NOT GET ON SKIN OR IN EYES. DO NOT INGEST OR
INHALE.
* Physical/Chemical Properties *
Vapor Pres:6.8
pH:1.0
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR OR YELLOWISH TRANSPARENT LIQUID. STRONG ACRID
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
PROTECTION GUIDE FOR SPECIFICS. REACTS EXPLOSIVELY W/ORG MATLS &
COMBUSTIBLE MATLS.
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS.
Hazardous Decomposition Products:NITROGEN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:4-DIMETHYLAMINOCINNAMALDEHYDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION,
INGESTION OR ABSORPTION THROUGH SKIN. CAUSES SEVERE IRRITATION.
HIGH CONCENTRATIONS ARE EXTREMELY DESTRUCTIVE TO TISSUES OF THE
MUCOUS MEMBRANES AND UPPER RESPIRATO RY TRACT, EYES, AND SKIN.
SYMPTOMS OF EXPOSURE MAY INCLUDE BURNING SENSATION, COUGHING,
WHEEZING, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:LARYNGITIS, SHORTNESS OF BREATH,
HEADACHE, NAUSEA AND VOMITING. THE CHEMICAL, PHYSICAL AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYE:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
OF WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:MOVE TO
FRESH AI R. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING DIFFICULT GIVE OXYGEN. INGEST:WASH OUT MOUTH WITH WATER
IF PERSON IS CONSCIOUS. CALL MD.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUPIS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN OR
ON CLOTHING. SEVERE IRRITANT.
* Physical/Chemical Properties *
Appearance and Odor:RUST-ORANGE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR WITH ORGANIC MERCURY CARTRIDGE IF EXPOSURE LEVEL IS
EXCEEDED.
Ventilation:MECHANICAL (GENERAL) VENTILATION OR LOCAL EXHAUST
VENTILATION TO KEEP EXPOSURE LEVELS BELOW PEL.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. PLACE CONTAMINATED CLOTHING IN CLOSED CONTAINER. WASH OR
DISCARD.
Supplemental Safety and Health
THIS MSDS IS FOR MERCURIC IODIDE WHICH IS PART OF THE BATTERY. MERCURIC
IODIDE WILL GO IN SOLUTION WHEN POTASSIUM HYDROXIDE SOLUTION IS
ADDED. THIS IS PART B OF 4 PARTS. FOR OTHER PARTS, SEE PNI A, C
AND D, SAME NSN. EMPTY BATTERY BY ITSELF IS NOT HAZARDOUS.
* Product Identification *
Product ID:MERCURIC IODIDE,RED,N.F.,PART B
Kit Part:Y
CAGE:TROYC
CAGE:TROYC
* Composition/Information on Ingredients *
Ingred Name:MERCURIC IODIDE
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS- ACUTE: EYE AND SKIN
BURNS. TRANSIENT STIMULATION OF CENTRAL NERVOUS SYSTEM FOLLOWED BY
DEPRESSION. FATAL KIDNEY INJURY. THIS PRODUCT CAUSES DELAYED BURNS.
CHRONIC: NONE SPECIFIED BY MA NUFACTURER.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES/SKIN: BURNS. INGESTION: TRANSIENT
STIMULATION OF CENTRAL NERVOUS SYSTEM FOLLOWED BY DEPRESSION,
VOMITING, DROWSINESS, COMA, RESPIRATORY FAILURE, CONVULSIONS, FATAL
KIDNEY INJURY. THIS PRODUCT CAU SES DELAYED BURNS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AND KIDNEY
CONDITIONS.
* First Aid Measures *
IRRITATION PERSISTS,SEE DOCTOR. SKIN:WASH WITH MILD SOAP AND WATER
WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. INHALATION:REMOVE
VICTIM T O FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.SEE DOCTOR.
INGESTION:DO NOT INDUCE VOMIT.SEE DOCTOR IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. (MERCURY VAPORS).
* Accidental Release Measures *
Spill Release Procedures:REMOVE PERSONNEL.ELIMINATE IGNITION
SOURCES.VENTILATE AREA.WEAR PROTECTIVE CLOTHING AND EQUIPMENT.SWEEP
UP AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND COVER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES AND
INCOMPATIBLE MATERIALS. KEEP CONTAINERS CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
* Physical/Chemical Properties *
HCC:T3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AND REDUCING AGENTS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:BURNING MAY CAUSE THE RELEASE OF
CARBON MONOXIDE, CARBON DIOXIDE AND MERCURY VAPORS.
* Disposal Considerations *
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:7 +/- 0.3.
* Product Identification *
Product ID:READY TO USE LENS CLEANER
CAGE:SHELD
CAGE:SHELD
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION. SKIN:IRRITATION,
DERMATITIS. INGEST:STOMACH UPSET.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
MINS WHILE HOLDING EYELIDS APART. REMOVE CONTACT LENSES IF APPLIC.
ASSISTANCE. DO NOT INDUCE VOMIT. RINSE MOUTH W/WATER, THEN DRINK
1-2 GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERS.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN LARGE SPILLS. ABSORB W/COMMERCIALLY
AVAILABLE ABSORBENT. SMALL SPILLS - FLUSH TO SEWER W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
* Physical/Chemical Properties *
pH:SUPDAT
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID; LEMON SCENT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:CONSULT STATE, LOCAL & FEDERAL REGULATIONS
GOVERNING THE DISPOSAL OF DETERGENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
CAGE:0K0U5
* Composition/Information on Ingredients *
Ingred Name:WATER
Ingred Name:HYDROXYETHYL METHACRYLATE, ETHYLENE GLYCOL METHACRYLATE
Ingred Name:POLYCARBOXYLIC ACID COPOLYMER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
ALLERGIC REACTION & MILD IRRITATION. INHALATION: UPPER RESPIRATORY
IRRITATION. INGESTION: GI IRRITATION TISSUES & IRRITATION OF THE
ORAL MUCOSA. VEHICLES CAN ALTER SKIN ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, PAIN, TEARING,
CLOUDYNESS, IMPAIRED VISION, BLISTERING, ITCHING, SORENESS,
COUGHING, SNEEZING, VOMITING, ABDOMINAL TENDERNESS, NAUSEA, BLOOD
IN VOMITUS & BLOOD IN FECES, BLEEDING.
* First Aid Measures *
W/LARGE AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DRINK 2 GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
* Fire Fighting Measures *
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. COVER W/ABSORBENT MATERIAL.
PLACE IN METAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL PLACE. USE W/ADEQUATE VENTILATION. WEAR APPROPRIATE
Other Precautions:AVOID EYE/SKIN CONTACT. AVOID PROLONGED BREATHING OF
* Physical/Chemical Properties *
pH:2.9-4
Appearance and Odor:CLEAR SLIGHT YELLOW W/SLIGHT ACRYLATE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF COMPLETELY CURED/POLYMERIZED MATERIAL
IN A SANITARY LANDFILL, IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN BRAZING IN CONFINED SPACE.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:ARM PROTECTORS, APRONS, HATS, SHOULDER
Work Hygienic Practices:DETERMINE THE COMPOSITION/QTY OF FUMES/GASES IS
TO TAKE AN AIR SAMPLE IN THE WORKER'S BREATHING ZONE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILVER (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
Other REC Limits:0.2 MG/CUM FUMES
OSHA PEL:0.1MG/M3 FUME/1 DUST
Ingred Name:ZINC OXIDE
Ingred Name:CADMIUM OXIDE (FUME)
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: METAL FUME FEVER, METALLIC
TASTE IN THE MOUTH, DRYNESS OR IRRITATION OF THE THROAT, NOSE &
CHEST PAIN, COUGHING, SHORTNESS OF BREATH, NAUSEA, BODY ACHE &
CHILLS.
Explanation of Carcinogenicity:NICKEL CONSIDERED A POSSIBLE CARCINOGEN.
CADMIUM SUSPECTED CARCINOGENS BASED ON ANIMAL TESTS.
Effects of Overexposure:INHALATION: LONG TERM EXPOSURE MAY CAUSE
PULMONARY IRRITATION, PNEUMOCONIOSIS, PULMONARY EDEMA, LUNG &
KIDNEY DAMAGE, WHICH MAY BE FATAL.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH IMPAIRED PULMONARY
FUNCTIONS OR ILLNESS MAY HAVE SYMPTOMS EXACERBATED BY FUME
IRRITANTS.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM DUST/FUME EXPOSURE. IF BREATHING HAS
STOPPED, PERFORM ARTIFICIAL RESPIRATION. SUMMON MEDICAL AID
IMMEDIATELY.
* Fire Fighting Measures *
Unusual Fire/Explosion Hazard:NON FLAMMABLE. OPEN FLAME & SPARKS CAN
IGNITE COMBUSTIBLES.
*Handling and Storage *
Handling and Storage Precautions:BRAZING ROD OR WIRE IS A NONHAZARDOUS
SOLID AT AMBIENT TEMPERATURE. HAZARDS MAY RESULT FROM FUME
GENERATED DURING BRAZING.
Other Precautions:BRAZING ALLOYS ARE FREQUENTLY USED WITH A FLUORIDE
TYPE FLUX. IF APPLICABLE, FLUX FUME SHOULD BE CONSIDERED IN
EVALUATION OF HAZARDS.
* Physical/Chemical Properties *
Appearance and Odor:SOLID WIRE OR ROD. RODS MAY BE COATED W/CHEMICAL
FLUX. FLUX COATING MAY BE RED.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:BRAZING FUMES & GASES, SILVER, COPPER,
ZINC (OXIDE), CADMIUM (OXIDE), TIN (OXIDE), (BORON OXIDE),
FLUORIDES (F).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE AIRLINE RESPIRATOR UNLESS AIR SAMPLING SHOWS
EXPOSURE TO BE BELOW PEL. THEN, EITHER CHEMICAL CARTRIDGE
RESPIRATORS OR AIRLINE RESPIRATORS REQUIRED. USE SAME PRECAUTIONS
DURING MIXING OR ANY OPERAT IONS WHERE PAINT FUMES WOULD BE
PRESENT.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP BELOW PEL/TLV DURING
MIXING, APPLICATION, CURING & REMOVE DECOMP PROD (WELD,CUT).
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO KEEP SKIN
CONTACT AT A MINIMUM.
Work Hygienic Practices:WASH HANDS AND ANY EXPOSED SKIN THOROUGHLY
BEFORE EATING OR SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JANE FREEMAN
* Composition/Information on Ingredients *
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:PREPOLYMER OF HEXAMETHYLENE DIISOCYANATE
Other REC Limits:.5 MG/M3;STEL 1MG/M3
Ingred Name:SILICA (PIGMENT)
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
Ingred Name:MAGNESIUM FERRITE (PIGMENT)
Fraction by Wt: 1.0-5.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ISOAMYL KETONE (SOLVENT)
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENE (SOLVENT) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:ZINC METAL (SARA III) (NUISANCE DUST)
Other REC Limits:NONE SPECIFIED
Ingred Name:TRIVALENT CHROME (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BUTYL ACETATE (SOLVENT) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE-DIISOCYANATE MONOMER
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:SKIN, EYE, RESP TRACT IRRIT. CHRONIC:
RESPIRATORY SENSITIZATION & SKIN SENSITIZATION. DERMATITIS.
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE, LIVER AND KIDNEY DAMAGE.
LUNG INJURY.
Explanation of Carcinogenicity:IARC HAS LISTED SILICA AS A PROBABLE
HUMAN CARCINOGEN.
Effects of Overexposure:WATERING EYES, THROAT DRYNESS, COUGHING,
HEADACHE, CHEST TIGHTNESS/BURNING SENSATION. HEADACHE, DIZZINESS,
NAUSEA, RASH, ITCHING HIVES & SWELLING OF EXTREMITIES.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. NOTIFY PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH
PHYSICIAN. SKIN: WASH AFFECTED AREAS WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. WASH BEFORE REUSE. CONSULT PHYSICIAN IF
IRRITATION DEVELOPS/PERSISTS. INGESTION: CALL A PHYSICAN OR POISON
CONTROL CENTER IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:8.2
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT WITH SELF-CONTAINED
BREATHING APPARATUS. DURING FIRE, IRRITATING/HIGHLY TOXIC GASES &
SMOKE PRESENT FROM DECOMP/COMBUSTION PRODUCTS.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD.KEEP FROM HEAT/IGNIT
SOURCE.CLSD CNTNR MAY EXPLODE W/HEAT,BURST WHEN CONTAM W/WATER.
DONT APPLY TO HOT SRFCS.NEVER CUT,WELD NEAR DRUM-EXPLOSIVE.
* Accidental Release Measures *
Spill Release Procedures:EVAC NON-ESSENTL PEOPLE.REMOVE IGNIT
SOURCE.VENT.AVOID BREATHING.COVER SPILL W/INERT ABSORB.POUR LIQ
OPEN CNTNR ADD DECONTAM SOLUTION.CO VER LOOSELY.WASH DOWN AREA
*Handling and Storage *
FROM IGNIT SOURCE. KEEP CONTAINER CLOSED.
Other Precautions:. IF MOISTURE ENTERS, DONT RESEAL. DONT INGEST.
GROUND CNTNRS WHEN POURING. AVOID LIQ FREE FALL >FEW INCHES. USE
W/VENT & RESP EQUIP. EMPTIED CNTNRS MAY RETAIN HZD RESIDUE. FOLLOW
PRECAUTIONS. AVOID E YE, SKIN, OR CLOTHING CONTACT.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:> AIR
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:REACTS WITH WATER
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, GLYCOL ETHERS, AMINES
Stability Condition to Avoid:CONTAMINATION WITH WATER
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN, TRACES OF
HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATION IS PREFERRED METHOD OF DISPOSAL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COUMARIN, KUMARIN, CUMARIN
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD FOR USUAL
HANDLING. SKIN/EYES: IRRITATION. INGESTION: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
MILK/WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:THIS MATERIAL IN SUFFICIENT QUANTITY &
REDUCED PARTICLE SIZE IS CAPABLE OF CREATING A DUST EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP MATERIAL & PACKAGE FOR SAFE FEED TO
AN INCINERATOR.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS.
* Physical/Chemical Properties *
Vapor Pres:<0.1
Evaporation Rate & Reference:(N-BU AC=1): <0.1
Solubility in Water:SLIGHT
Appearance and Odor:WHITE CRYSTALLINE SOLID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:COMBUSTION: CO, CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE BY INCINERATION/CONTRACT W/LICENSED
CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT/DISPOSAL
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:FUME HOOD.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS AND CLOTHES THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
FIRST AID PROCEDURES: UNCONSCIOUS PERSON. CALL PHYSICIAN.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM HYDROXIDE(SARA III)
Ingred Name:AMMONIUM CHLORIDE (SARA III)
Fraction by Wt: 7%
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO) TETRA-, TETRASODIUM SALT;
(ETHYLENEDIAMINETETRAACETIC ACID, TETRASODIUM SALT,DIHYDRATE)
Fraction by Wt: <1%
Ingred Name:WATER; (DEMINERALIZED WATER)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE CORROSIVE TO EYES,
SKIN AND RESPIRATORY TRACT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF NEC. CALL PHYS.
OPEN TO ENSURE COMPLETE RINSING OF EYE. CALL PHYS. SKIN: IMMED
NOT INDUCE VOMIT. GIVE LRG QTYS OF WATER. GIVE AT LST 1 OZ OF
VINEGAR IN AN EQUAL AMT OF WATER. NEVER GIVE ANYTHING BY MOUTH TO
AN (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE, OR ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:PUT IN A BEAKER, DILUTE WITH WATER AND
NEUTRALIZE WITH 6M HCL. WASH DOWN DRAIN WITH A LARGE EXCESS OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL AREA,
AWAY FROM ACIDS AND OXIDIZERS.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. DO NOT BREATHE
CHEMICALS. WASH HANDS AND CLOTHES THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:B3
Appearance and Odor:CLEAR, COLORLESS LIQUID, SUFFOCATING ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS OR OXIDIZERS.
Stability Condition to Avoid:HEAT, FLAMES.
Hazardous Decomposition Products:MAY EMIT TOXIC FUMES OF AMMONIA.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
FOR ENCLOSED AREAS, USE NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR OR SCBA.
Ventilation:LOC EXHAUST IS USUALLY ADEQ. HOWEVER, MECH VENT SHOULD BE
USED WHEN SPRAYING IN ENCLOSED AREA. VAP CONC SHOULD (SUPDAT)
Other Protective Equipment:AS NECESSARY TO PREVENT PROLONGED OR
REPEATED SKIN CONTACT.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER USE/OR BEFORE
BREAKS, LUNCH & AT END OF WORK PERIODS. REMOVE CONTAM CLTHG & (SUPP
DATA)
Supplemental Safety and Health
VENT:BE MINIMIZED AS MUCH AS POSSIBLE. WORK HYGENIC PRAC:LAUNDER BEFORE
REUSE. SPILL PROC:MOP UP OR SOAK UP WITH ABSORBNENT MATERIAL, SUCH
AS SAND OR CLAY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (ALIPHATIC
HYDROCARBON)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DISTILLATES,PETROLEUM,VACUUM; (PETROLEUM OIL (SEVERELY
HYDROTREATED))
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
METHYL ETHER)
Fraction by Wt: 2-3%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HEADACHE, DIZZINESS,
NAUSEA AND ANESTHETIC EFFECTS. EYES:IRRITATION. SKIN:REPEATED OR
PROLONGED CONTACT MAY CAUSE DRYING AND DEFATTING OF SKIN.
INGEST:LOW ORDER OF ORAL TOXICITY; HOWEVER M INUTE AMOUNT ASPIRATED
INTO LUNGS DURING INGESTION MAY CAUSE SEVERE PULMONARY INJURY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR AND CONTACT MD. ADMIN OXYGEN IF BRTHG
AND CONTACT MD. SKIN:WASH WITH SOAP AND WATER; APPLY MEDICATED SKIN
CR EAM. INGEST:CONTAINS ALIPHATIC HYDROCARBONS AND PETROLEUM OIL.
DO NOT INDUCE VOMITING. IF VOM OCCURS SPONTANEOUSLY, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS. CONTACT MD
IMMED.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL, OR CARBON DIOXIDE. DO NOT USE A
DIRECT STREAM OF WATER.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER FOG MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA BY OPENING DOORS & WINDOWS. REMOVE
IGNIT SOURCES. REMOVE LEAKING CONTAINER & TRANSFER REMAINING
PRODUCT TO ANOTHER VESSEL. PREVENT PROD FOR GOING INTO SEWERS &
WATER SOURCES BY DIKING OR IMP OUNDING. USING APPROP SAFETY EQUIP,
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
STORE AWAY FROM IGNITION SOURCES AND AVOID BREATHING VAPORS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Pres:<5
Vapor Density:4.8-5.3
Solubility in Water:NIL
Appearance and Odor:DARK BROWN LIQUID WITH SWEET, MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING
Stability Condition to Avoid:AVOID SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS FOR PETROLEUM DISTILLATES. RCRA HAZ WASTE NO:
THIS MATL HAS THE RCRA CHARACTERISTIC OF IGNITABILITY AND IF
DISCARDED IN ITS PURCHASEDFORM WOULD HAVE THE HAZ WASTE NUMBER
DOO1.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PERSONAL RESPIRATORS (NIOSH APPROVED): IF THE
EXPOSURE LIMIT IS EXCEEDED, WEAR A SUPPLIED AIR, FULL-FACEPIECE
RESPIRATOR, AIRLINED HOOD OR FULL-FACEPIECE SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:SYS OF LOC &/OR GEN EXHST IS RECOM TO KEEP EMPLOYEE
EXPOSURES BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GENERALLY
PREF BECAUSE IT CAN CTL EMISSIONS (SUPDAT)
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . ADDITIONAL PROTECTION INCLUDING IMPERVIOUS BOOTS,
APRON OR COVERALLS AS NEEDED IN AREAS OF UNUSUAL EXPOSURE.
Supplemental Safety and Health
SPILL PROC: MATLS, SUCH AS SAW DUST. DO NOT FLUSH TO SEWER! JT BAKER
SOLUSORB(TM) SOLVENT ABSORBENT IS RECOM FOR SPILLS OF THIS PROD.
VENT: OF CONTAMINANT AT ITS SOURCE, PREVENTING DISPERSION OF IT IN
TO GEN WORK AREA. PLEASE REFER TO ACGIH DOCUMENT, INDUS VENT,
MANUAL OF RECOM PRACTS, MOST RECENT ED, FOR DETAILS.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: A SLIGHT IRRITANT TO
MUCOUS MEMBRANES. TOXIC EFFECTS EXERTED UPON NERVOUS SYSTEM,
PARTICULARLY OPTIC NERVE. ONCE ABSORBED INTO BODY, IT IS VERY
SLOWLY ELIMINATED. SYMPTOMS OF OVEREXPOSURE MAY INCLUDE HEADACHE,
DROWSINESS, NAUSEA, VOMITING, BLURRED VISION, BLINDNESS, COMA &
LATER. INGESTION: TOXIC. SYMPTOMS PARALLEL INHA LATION. CAN
MILLILITERS. SKIN CONTACT: METHYL ALCOHOL IS A DEFATTING AGENT AND
MAY CAUSE SKIN TO BECOME DRY AND CRACKED. SKIN ABSORPTION CAN O
CCUR; SYMPTOMS (EFFECTS OF OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS: MAY PARALLEL INHALATION
EXPOSURE. EYE CONTACT: IRRITANT. CONTINUED EXPOSURE MAY CAUSE EYE
LESIONS. CHRONIC EXPOSURE: MARKED IMPAIRMENT OF VISION AND
ENLARGEMENT OF THE LIVER HAS BEEN R EPORTED. REPEATED OR PROLONGED
EXPOSURE MAY CAUSE SKIN IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED LIVER OR KIDNEY FUNCTION MAY
BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL A
PHYSICIAN. INGEST: INDUCE VOMITING IMMEDIATELY AS DIRECTED BY
MEDICAL PERSONNE L. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. SKIN CONTACT: REMOVE ANY CONTAMINATED CLOTHING.WASH SKIN
MEDICAL ATTENTION IF IRRITATION DEVELOPS OR PERSISTS. EYE CONTACT:
MINUTES, LIFTING LOWER AND UPPER EYELIDS OCCASIONALLY. GET MEDICAL
ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:7.3%
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO BLANKET FIRE, COOL FIRE EXPOSED
CONTAINERS AND TO FLUSH NON-IGNITED SPILLS OR VAPORS AWAY FROM
FIRE. VAPORS CAN FLOW AL ONG SURFACES TO DISTANT IGNITION SOURCE
AND FLASH BACK.
Unusual Fire/Explosion Hazard:FLAMMABLE. ABOVE FLASH POINT, VAPOR-AIR
MIXTURES ARE EXPLOSIVE WITHIN FLAMMABLE LIMITS NOTED ABOVE.
MODERATE EXPLOSION HAZARD AND DANGEROUS FIRE HAZARD WHEN EXPOSED TO
HEAT, SPARKS OR FLAMES. SENSITIV E TO STATIC DISCHARGE.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA OF LEAK/SPILL. REMOVE ALL SOURCES OF
IGNIT. WEAR APPROP PERSONAL PROT EQUIP AS SPECIFIED IN SECTION 8,
EXPOS CTLS/PERSONAL PROT. ISOLATE HAZ AREA. KEEP UNNEC & UNPROT
PERS FROM ENTERING. CNT N & RECOVER LIQ WHEN POSS. USE NON-SPKG
TOOLS & EQUIP. COLLECT LIQ IN APPROP CNTNR OR ABSORB W/INERT MATL
(EG, VERMICULITE, DRY SAND, EARTH) & PLACE IN CHEM WASTE CNTNR. DO
NOT USE COMBUST (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY, WELL-VENTILATED LOCATION, AWAY FROM ANY AREA WHERE
THE FIRE HAZARD MAY BE ACUTE. OUTSIDE OR DETACHED STORAGE IS
PREFERRED. SEPARATE FROM INCOMPAT IBLES.
Other Precautions:CNTNRS SHOULD BE BONDED & GROUNDED FOR TRANSFERS TO
AVOID STATIC SPARKS. STORAGE & USE AREAS SHOULD BE NO SMOKING
AREAS. USE NON-SPARKING TYPE TOOLS & EQUIP INCLUDING EXPLOSION
PROOF VENT. CNTNRS OF T HIS MATL MAY BE HAZ WHEN EMPTY SINCE THEY
RETAIN PROD RESIDUES (VAP, LIQ); OBSERVE ALL WARNINGS & PR ECS
LISTED FOR PROD.
* Physical/Chemical Properties *
Vapor Density:1.1(AIR=1)
Spec Gravity:0.8
pH:NO INFO FOUND
Evaporation Rate & Reference:5.9 (BUAC=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRATES, PERCHLORATES OR SULFURIC
ACID. WILL ATTACK SOME FORMS OF PLASTICS, RUBBER AND COATINGS. MAY
REACT WITH METALLIC ALUMINUM AND GENERATE HYDROGEN GAS.
Stability Condition to Avoid:HEAT, FLAMES, IGNITION SOURCES AND
INCOMPATIBLES. STABLE UNDER ORDINARY CONDITIONS OF USE AND STORAGE.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE, CARBON
MONOXIDE AND FORMALDEHYDE WHEN HEATED TO DECOMPOSITION.
* Toxicological Information*
CARCINOGEN: KNOWN-NO; ANTICIPATED-NO; IARC CATEGORY-NONE. AIRBORNE
EXPOS LIMITS: FOR METH YL ALCOHOL: OSHA PERMISSIBLE EXPOSURE LIMIT
* Ecological Information *
Ecological:WHEN RELEASED INTO SOIL, THIS MATL IS EXPECTED TO READILY
BIODEGRADE. WHEN RELEASED INTO SOIL, MATL IS EXPECTED TO LEACH INTO
GROUNDWATER. WHEN RELEASED INTO SOIL, MATL IS EXPECTED TO QUICKLY
EVAP. WH EN RELEASED INTO WATER, MATL IS EXPECTED TO HAVE HALF-LIFE
READILY BIODEGRADE. WHEN RELEASED INTO AIR, MATL IS EXPECTED TO
EXIST IN A EROSOL PHASE W/SHORT HALF-LIFE. WHEN RELEASED INTO AIR,
MATL IS EXPECTED TO BE READILY DEGRADED BY RXN W/PHOTOCHEMICALLY
PRDCED HYDROXYL RADICALS. WHEN RELEASED INTO AIR, (TRANSPORT INFO)
* Disposal Considerations *
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPRVD
INCINERATOR OR DISPOSED IN RCRA APPRVD WASTE FACILITY. PROCESSING,
USE OR CONTAM OF PROD MAY CHA NGE WASTE MANAGEMENT OPTIONS. STATE &
LOC DISP REGS MAY DIFFER FROM FED DISP REGS. DISPOSE OF CNTNR &
UNUSED CONTENTS I/A/W FED, STATE & LOC REQS.
* MSDS Transport Information *
Transport Information:DOMESTIC (LAND, DOT) - PROPER SHIPPING NAME:
PROPER SHIPPING NAME: MET HANOL. HAZARD CLASS: 3.2, 6.1. UN/NA:
ECOLOGICAL INFO: THIS MATL IS EXPECTED TO HAVE A HALF-LIFE BWTWEEN
READILY REMOVED FORM ATM BY WET DEPOSITION. ENVIRONMENTAL
TOXICITY:THIS MATL IS EXPECTED TO BE SLIGHTLY TOXIC TO AQUATIC
LIFE.
* Regulatory Information *
CHRONIC:YES; FIRE:YES; PRESSURE: NO; REACTIVITY:NO (PURE / LIQUID).
REMOVING CONTAM CLTHG & SHOES. WASH CLTHG BEFORE REUSE. IF INHALED,
REMOVE TO FRESH AIR. IF NOT B RTHG GIVE ARTF RESP. IF BRTHG IS
DFCLT, GIVE OXYGEN. IN ALL CASES GET MED ATTN IMMED. PROD USE:
SECTIONS HAVE BEEN REVISED. (STATE RE G INFO)
INVENTORY STATUS - PART 1: TSCA-YES; EC-YES; JAPAN-YES;
AUSTRALIA-YES. CHEMICAL INVENTORY STATUS - PART 2: KOREA-YES;
CANADA DSL-YES; CANADA NDSL-NO; PHIL-YES. FEDE RAL, STATE &
NO. CDTA: NO. ASUTRALIAN HAZCHEM CODE: 2PE. POISON SCHEDUL E: S6.
WHMIS: THIS MSDS HAS BEEN PREPARED ACCORDING TO THE HAZARD CRITERIA
OF THE CONTROLLED PRODUCT S REGULATIONS (CPR) AND THE MSDS CONTAINS
ALL OF THE INFORMATION REQUIRED BY THE CPR.
State Regulatory Information:N/P. SARA REG INFO: PROD MOLECULAR WEIGHT:
HEALTH: 3-SEVERE; FLAMMABILITY: 4-EXTREME (FLAMMABLE); REACTIVITY:
1-SLIGHT; CONTACT: 1-SLIGHT. LAB PROTECTIVE EQUIP: GOGGS & SHIELD;
STORAGE COLOR CODE: RED (FLAMMABLE).
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP: AMTS OF DUST RETAINED IN THE LUNGS FOR A PRLNGD
INTERVAL.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STYRENE ACRYLATE COPOLYMER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:ORGANIC PIGMENT
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, AMORPHOUS FUMED; (AMORPHOUS SILICA)
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOS TO LG AMTS OF ANY NONTOX DUST. MAY CAUSE COUGH &
RAISE PHLEGM. CHRONIC: NONE. TONER PRESENT A LOW HAZ FOR USUAL
OCCUP SETTINGS. BASED ON AVAIL DATA , HUMAN EXPOS TO TONER HAS BEEN
SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LG AMTS OF
ANY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
Effects of Overexposure:HLTH HAZ: NON-TOX DUSTS. RSLTS OF ONE ANIMAL
THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES
AT LOW EXPOS (MOST REL EVANT LEVEL TO POTNTL HUMAN EXPOS). AT HIGH
LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESS
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE LISTED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: WASH NOSTRILS, RINSE MOUTH. INGESTION: DILUTE
STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER. EYES: FLUSH WITH
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.
* Accidental Release Measures *
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.
* Disposal Considerations *
Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESTRICTED AREA: NIOSH APPROVED ORGANIC VAPOR
RESPIRATOR. SPRAYING: MECHANICAL PREFILTER MAY BE REQUIRED.
CONFINED AREAS: NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR.
EXCEEDED TLV AREA: NIOSH/MSHA APP ROVED RESPIRATOR WITH RIGHT
FACTOR.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN SUFFICIENT
VOLUME & PATTERN TO KEEP CONCENTRATIONS BELOW EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:W. A. ELLISON
* Composition/Information on Ingredients *
Ingred Name:ISOBUTYL ACETATE (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:NITROCELLULOSE (RESIN)
Other REC Limits:NONE SPECIFIED
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL BENZENE (SARA III)
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-HEPTANE
Other REC Limits:NONE SPECIFIED
UFL: 8.0)
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE SPECIFIED
CALCULATED *NEGLIGIBLY PHOTOCHEMICALLY REACTIVE MATERIALS
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATION (GASTROINTESTINAL, NOSE,
THROAT, EYE, PRIMARY SKIN). LUNG ASPIRATION:CHEMICAL
PNEUMONITIS-CAN BE FATAL. CENTRAL NERVOUS SYSTEM DEPRESSION.
CORNEAL DAMAGE. SKIN ABSORPTION. OVEREXPOSURE: L IVER, KIDNEY,
BLOOD DAMAGE. PERIPHERAL NERVOUS SYS DAMAGE, PERIPHERAL NEUROPATHY,
PERMANENT BRAIN & NERVOUS SYS DAMAGE.
Explanation of Carcinogenicity:DI(2-ETHYLHEXYL)PHTHALATE IS LISTED AS A
POTENTIAL CARCINOGEN.
Effects of Overexposure:INGEST: NAUSEA/VOMITING. INHALE: HEADACHES,
DIZZINESS, NAUSEA, CONFUSION.
Medical Cond Aggravated by Exposure:TOLUENE HAS BEEN FOUND TO CAUSE
KIDNEY, LUNG & SPLEEN DAMAGE IN LAB ANIMALS. METHYL ETHYL KETONE
MAY BE EMBRYOTOXIC, FETOTOXIC & TERATOGENIC.
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMITING. CALL POISON CONTROL,
EMERGENCY ROOM OR PHYSICIAN IMMEDIATELY. INHALE: REMOVE TO FRESH
AIR IMMEDIATELY. GIVE ARTIFICIAL RESPIRATION IF NEEDED. KEEP WARM &
QUIET. GET IMM EDIATE MEDICAL AID. EYE: FLUSH THOROUGHLY WITH LARGE
FLUSH WITH WATER WHILE REMOVING CONTAMINATED CLOTHES. CONSULT A
PHYSICIAN.
* Fire Fighting Measures *
Lower Limits:1.0
Extinguishing Media:USE NFPA CLASS B(CO2, ALL PURPOSE DRY CHEMICAL OR
ALCOHOL FOAM) FOR LIQUID FIRES. POLYMER FOAM PREFERRED FOR LARGE
FIRES
Fire Fighting Procedures:USE SCBA. WATER MAY BE INEFFECTIVE, USE TO
COOL CNTNRS(FOG NOZZLE PREFERABLE) TO PREVENT PRESSURE
BUILD-UP&AUTO-IGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY
NOT BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE GEAR. SPECTATORS AWAY.
ELIMINATE IGNITE SOURCES. DIKE, CONTAIN&REMOVE W/INERT MATERIAL
(EARTH, ETC). USE COVERED METAL CONTAINERS FOR RECOVERY AND
DISPOSAL. USE NON-SPARKING TOOLS. PRE VENT CONTAMINATION OF SEWERS,
STREAMS,GROUNDWATER.
*Handling and Storage *
INTERNALLY. CNTNRS CLOSED AFTER USE. KEEP FROM CHILDREN.
Other Precautions:DO NOT REUSE CONTAINERS FOR ANY PURPOSE. CONTAINERS
SHOULD BE GROUNDED AND BONDED TO THE RECEIVING CONTAINER. DO NOT
WELD, BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO EMPTY.
DRUM IS NOT A P RESSURE VESSEL.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> THAN AIR
Spec Gravity:0.9
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
SOURCES.
Hazardous Decomposition Products:BURNING, INCLUDING HEATED BY
WELDING/CUTTING PRODUCES SMOKE, CARBON MONOXIDE & CARBON DIOXIDE,
POSSIBLE NITROGEN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS &
LAWS. INCINERATE IN EPA PERMITTED FACILITY. DO NOT INCINERATE
CLOSED CONTAINERS. FLAMMABLE-USE PRECAUTIONS FOR DISPOSAL OF
ABSORBENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST, SANDING DUST & ORGANIC VAPORS
IN RESTRICTED OR CONFINED AREAS.
Ventilation:ADEQ TO MAINTAIN WORKING ATM BELOW TLV & LEL. MECH EXHST
MAY BE REQD IN CONFINED AREAS. DISCHARGE EXHST ONLY IN (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE & WASH CLOTHING BEFORE REUSE. WASH HANDS
BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
IGNITION SOURCES.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 1.2%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA, CRYSTALLINE
Fraction by Wt: 0.3%
OSHA PEL:0.1 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:IRON (III) OXIDE; (IRON OXIDE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:CARBON BLACK
Fraction by Wt: 1.8%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:CALCIUM CARBONATE
Fraction by Wt: 6%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HARMFUL IF INHALED. MAY
AFFECT BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS. SKIN/EYE
CONT:CAUSES IRRIT. INGEST:IRRIT OF DIGEST TRACT & NERV SYS DEPRESS
(DROW, DIZZ, LOSS OF COORD & FATG). ASPI R HAZ-THIS MATL CAN ENTER
LUNGS DURING SWALLOWING/VOMIT & CAUSE LUNG INFLAMM & DMG.
CHRONIC:SKIN CONT: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
Effects of Overexposure:HLTH HAZ:PRLNG/RPTD EXPOS MAY CAUSE DERM.
INHAL:SANDING DUST INHAL MAY CAUSE LUNG DMG. NOTICE:RPTS HAVE ASSOC
PERM BRAIN & NERV SYS DMG W/RPTD, PRLNG OVEREXP TO SOLVS AMONG PERS
ENGAGED IN PAINTING TR ADE. INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED I/A/W SAFE
HANDLING & USE INFORMATION.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM HAZARD AREA, MAINTAIN BREATHING, CALL MD.
SKIN:REMOVE W/SOAP & WATER. EYES:FLUSH IMMEDIATELY W/LARGE AMOUNTS
OF WA TER TO DILUTE. DO NOT INDUCE VOMITING. CALL MD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT USE WATER STREAM ON BURNING LIQUID. COOL EXPOSED
CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. CLOSED CONTAINERS MAY BURST
IF EXPOSED TO EXTREME HEAT OR FIRE. TOXIC GASES MAY FORM WHEN
PRODUCT BURNS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. USE NON-SPARKING TOOLS TO RETURN MATERIALS TO
CONTAINER. ABSORB RESIDUE W/FULLER'S EARTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:COMBUST - KEEP AWAY FROM HEAT & FLAME.
USE ONLY W/ADEQUATE VENTILATION. AVOID PROLONGED CONTACT W/SKIN &
BREATHING OF VAPOR SPRAY MIST/SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES & BUILD UP OF
VAPORS.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE &
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLIANCE W/LOCAL,
STATE & FEDERAL REGULATIONS. DO NOT INCINERATE SEALED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:N/A(MFR).NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN
Ventilation:USE ONLY IN EXHAUST HOOD.
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHRYSENE (LIMIT FROM COAL TAR PITCH VOLITILES) (SARA III)
Fraction by Wt: </=0.1%
Other REC Limits:
OSHA PEL:0.2 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OVEREXPOSURE.
Explanation of Carcinogenicity:CHRYSENE:ACGIH;SUSPECTED HUMAN
CARCINOGENREPORTED ANIMAL CARCINOGEN (MFR).
Effects of Overexposure:REPORTED ANIMAL CARCINOGEN(MFR).
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MINUTES,THEN OBTAIN PROMPT MEDICAL ATTENTIONSKIN:PROMPTLY WASH SKIN
WITH MILD SOAP AND LARGE VOLUMES OF WATER .REMOVE CONTAMINATED
CLOTHIN G.INHALATION:IMMEDIATELY MOVE TO FRESH SAIR(MFR).SUPPORT
BREATHING (GIVE O*2/ARTIFICAL RESPIRATION)INGESTION:N/A(MFR).
* Fire Fighting Measures *
Flash Point:
Lower Limits:
Upper Limits:
Extinguishing Media:WATER,CO*2,DRY CHEMICAL,ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WHEN
FIGHTING A CHEMICAL FIRE(MFR).USE NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:N/A(MFR).
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP MATERIAL.FLUSH AREA WITH WATER.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:STORE SEALED CONTAINER IN COOL,DRY
LOCATION.
Other Precautions:REPORTED CANCER HAZARD.AVOID EYE OR SKIN
CONTACT.AVOID BREATHING VAPORS.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K F=N
Vapor Pres:N/A MFR
Vapor Density:N/A MFR
pH:
Evaporation Rate & Reference:N/A MFR
Solubility in Water:N/A MFR
Appearance and Odor:WHITE SOLID
Percent Volatiles by Volume:N/AMFR
Corrosion Rate:N/K
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:N/A.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH APPLICABLE FEDERAL,STATE,OR LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE IN WELL VENTILATED AREA.
Supplemental Safety and Health
* Product Identification *
Product ID:JOINT COMPOUND
CAGE:CENTU
CAGE:CENTU
* Composition/Information on Ingredients *
Ingred Name:STYRENE
Ingred Name:BUTADIENE
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROXEL
* Hazards Identification *
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES: MAY CAUSE IRRITATION, FLUSH WITH WATER. SKIN: MAY CAUSE
IRRITATION, FLUSH WITH
WATER.
* Fire Fighting Measures *
Extinguishing Media:WATER, CO2 FOAM
Fire Fighting Procedures:WATER
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER AND REMOVE IN SUITABLE
CONTAINERS. SMALL AMOUNTS MAY BE ABSORBED
INTO APPROPIATE ABSORBANT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY AREA. KEEP FROM
FREEZING.
Other Precautions:ALWAYS READ LABEL AND FOLLOW DIRECTIONS CARFULLY.
KEEP AWAY FROM CHILDREN.
* Physical/Chemical Properties *
Vapor Density:- AIR
Spec Gravity:H2O=1 HEAVIER
Evaporation Rate & Reference:WATER=1 SLOWER
Solubility in Water:CAN BE DILUTED
Appearance and Odor:MILKY WHITE FAINT ODOR
* Disposal Considerations *
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE AND LOCAL REGULATIONS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD
RESPS (NEG PRESS TYPE) UNDER SPECIFIED CNDTNS (SUPDAT)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR W/EQUIVALENT VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . IMPERVIOUS PROT CLTHG SHOULD BE WORN TO PVNT SKIN CONT.
(ING 6)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
TREATMENT KIT. WASTE DISP METH:& FED REGS. RESP PROT:(SEE YOUR SFTY
EQUIP SUPPLIER). ENGINEERING &/OR ADMIN CONTROLS SHOULD BE IMPLE
FULL LENGTH FACESHIELD .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (CERCLA)
Ingred Name:SPILL PROC:RISK. TAKE UP & CONTAINERIZE FOR PROPER DISP AS
DESCRIBED UNDER DISP. COMPLY W/FED, STATE & LOC REGS (ING 3)
Ingred Name:ING 2:ON REPORTING RELS. REFER TO REGULATORY INFO FOR
REPORTABLE QTY & OTHER REGULATORY DATA. EM SCIENCE RECS (ING 4)
Ingred Name:ING 3:SPILL-X NEUTRALIZERS & ABSORB AGENTS FOR VARIOUS
TYPES OF SPILLS. ADDNL INFO ON SPILL-X PRODS CAN BE (ING 5)
Ingred Name:ING 4:PROVIDE THRU EM SCIENCE TECHNICAL SERVICE DEPT
Ingred Name:OTHER PROT EQUIP:ACID-RESISTANT PROTECTIVE SUIT W/RUBBER
BOOTS. SAFETY EQUIPMENT SHOULD BE READILY AVAILABLE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT CAUSES SEVERE BURNS, EYE
DAMAGE. VAPOR INHALATION CAUSES LACHRYMATION, SEVERE IRRITATION OF
RESPIRATORY PASSAGES; BRONCHITIS, PULMONARY EDEMA AND CHEMICAL
PNEUMONITIS MAY OCCUR. MAY BE FATAL I F SWALLOWED. TEST ON LAB
ANIMALS INDICATE MATERIAL MAY PRODUCE ADVERSE MUTAGENIC AND
REPRODUCTIVE EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:IMMEDIATELY FLUSH THOROUGHLY W/LARGE AMOUNTS OF WATER. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE. EYES:IMMEDIATELY FLUSH
AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGEST:DO NOT INDUCE VOMITING; GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:5.4%
Extinguishing Media:CO*2, DRY CHEMICAL, "ALCOHOL" FOAM, WATER MIST.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE FIRE & EXPLOSION HAZARD. VAPOR
CAN TRAVEL DISTANCES TO IGNITION SOURCE & FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROT SECTION. ELIM ANY IGNIT
SOURCES UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLO/FIRE HAZS.
CONTAIN RELS & ELIM ITS SOURCE, IF THIS CAN BE DONE W/OUT (ING 2)
Neutralizing Agent:FOLLOWING EM SCIENCE SPILL-X NEUTRALIZER & ABSORB IS
REC FOR THIS PROD: (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
DO NOT BREATHE VAPOR.
Other Precautions:DO NOT GET IN EYES ON SKIN OR ON CLOTHING. RETAINED
RESIDUE MAY MAKE EMPTY CONTAINERS HAZARDOUS; USE CAUTION! DO NOT
TAKE INTERNALLY. HARMFUL IF INHALED. FLAMMABLE LIQUID & VAPOR.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, STRONG ALKALIES, METALS, AMINES, CYANIDES, SULFIDES, CHROMIC
ACID, NITRIC ACID, HYDROGEN PEROXIDE, (SUPDAT)
Stability Condition to Avoid:HEAT; CONTACT W/IGNITION SOURCES. DILUTED
ACID REACTS W/METALS TO PRODUCE FLAMMABLE HYDROGEN GAS.
Hazardous Decomposition Products:CO*X.
* Disposal Considerations *
TECHNOLOGY - NEUTRALIZE TO PH 6-9. CONT YOUR LOC PERMITTED WASTE
DISP SITE (TSD) FOR PERMISSIBLE TREATMENT SITES. ALWAYS CONT
PERMITTED WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE W/ALL CURRENT
LOC, STATE(SUPDAT)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL/LOCAL EXHAUST: REQUIRED.
Other Protective Equipment:SAFETY SHOWER & EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT
W/EYES, SKIN & CLOTHING.
Supplemental Safety and Health
* Product Identification *
Product ID:TRIZMA BASE REAGENT GRADE
* Composition/Information on Ingredients *
Ingred Name:1,3-PROPANEDIOL , 2-AMINO-2-(HYDROXYMETHYL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: IRRITATION,
HARMFUL, MUCOUS MEMBRANES, UPPER RESPIRATORY TRACT. EYES/SKIN:
IRRITATION & SKIN ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION/INGESTION: HARMFUL. IRRITATION OF
MUCOUS MEMBRANE, UPPER RESPIRATORY TRACT. EYES/SKIN: IRRITATION.
* First Aid Measures *
MINUTES. SKIN: WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION.
IF BREATHIN G IS DIFFICULT, GIVE OXYGEN. CALL PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER,
ALCOHOL/POLYMER FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP, PLACE IN BAG & HOLD FOR WASTE
DISPOSAL. AVOID RAISING DUST. VENTILATE AREA & WASH SPILL SITE
AFTER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:SODIUM CARBONATE/SLAKED LIME.
*Handling and Storage *
Handling and Storage Precautions:DON'T BREATHE DUST. AVOID CONTACT
AVOID PROLONGED/REPEATED EXPOSURE. WASH
THOROUGHLY AFTER HANDLING.
Other Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL DRY PLACE.
* Physical/Chemical Properties *
Appearance and Odor:WHITE CRYSTALS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES & OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES
* Disposal Considerations *
Waste Disposal Methods:THIS MATERIAL SHOULD BE IGNITED IN PRESENCE OF
SODIUM CARBONATE/SLAKED LIME. SUBSTANCE SHOULD BE MIXED
W/VERMICULITE/THE W/DRY CAUSTICS, WRAPPED IN PAPER/BURNED IN
CHEMICAL INCINERATOR EQUIPPED W/AFTE RBURNER/SCRUBBER. OBSERVE
FEDERAL/STATE/LOCAL LAW.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATORY
OR AIR SUPPLIED RESPIRATOR WHEN IN CONFINED SPACE OR LOCAL EXHAUST
DOES NOT KEEP EXPOSURE BELOW RECOMMENDED EXPOSURE LIMIT.
Ventilation:USE ENOUGH LOCAL VENTILATION AND LOCAL EXHAUST AT ARC TO
KEEP FUMES AND GASES FROM WORKER'S BREATHING ZONE AND GENERAL AREA.
LENS, (SUPP DATA)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
HAND, HEAD, BODY PROTECTION TO PREVENT INJURY FROM RADIATION,
SPARKS AND ELECTRICAL SHOCK.
Supplemental Safety and Health
EYE PROT:PROT SCREENS. FLASH GOGGS TO SHIELD OTHERS. START W/SHADE TOO
DARK THEN GO TO LIGHTER SHADE WHICH GIVES SUFFICIENT VIEW OF WELD
ZONE. -- HAZ DECOMP PROD: WHICH WORKERS MAY BE EXPOS INCL: COAT
INGS ON METAL BEING WELDED (SUCH AS PAINT, PLATING/GALVANIZING),
NUMBER OF WELDERS & VOL OF WORK AREA, (TOX INFO)
* Product Identification *
Resp. Party Other MSDS Num.:A=NIC & CHR, MSDS VERSION NUMBER: 3
CO
* Composition/Information on Ingredients *
Ingred Name:IRON
Fraction by Wt: BALANCE
Ingred Name:CHROMIUM
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MANGANESE
Minumum % Wt:.6
Other REC Limits:ACGIH TLV:1 MG/M3(M)
OSHA PEL:C5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SILICON
Minumum % Wt:.3
Maxumum % Wt:5.
Other REC Limits:TLV:3 MG/M3(SIO2)(M)
Ingred Name:MOLYBDENUM
Maxumum % Wt:6.
Ingred Name:CARBON
Minumum % Wt:0.
Maxumum % Wt:1.
ACGIH TLV:2 MG/M3
Ingred Name:PHOSPHORUS
Minumum % Wt:0.
Maxumum % Wt:.5
OSHA PEL:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULPHUR
Minumum % Wt:0.
Maxumum % Wt:.5
Ingred Name:NITROGEN
Minumum % Wt:0.
Maxumum % Wt:.5
Ingred Name:COPPER
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:NIOBIUM
Minumum % Wt:0.
Maxumum % Wt:1.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELECTRIC ARC-WELDING MAY CREATE: FUMES
AND GASES CAN BE DANGEROUS. ARC RAYS CAN INJURE EYES AND BURN SKIN.
ELECTRIC SHOCK CAN KILL. CHROMIUM COMPOUNDS ARE REQUIRED BY OSHA TO
BE CONSIDERED CARCINOGENI C (MFR).
Explanation of Carcinogenicity:NICKEL: IARC MONOGRAPHS ON THE
REASONABLY ANTICIPATED TO BE HUMAN CARCIN OGEN. ANIMAL: LUNGS,
NASAL CAVITIES.
Effects of Overexposure:SHORT TERM TO WELDING FUMES - DIZZINESS,
NAUSEA, DRYNESS AND IRRITATION OF NOSE, EYES, THROAT, CHEST
TIGHTNESS, FEVER, ALLERGIC REACTION. LONG TERM - SIDEROSIS,
BELIEVED TO AFFECT PULMONARY FUNCTION.
* First Aid Measures *
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY AMERICAN RED
CROSS. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION.
INGESTION: CALL MD IMMEDIATELY . SKIN: FLUSH WITH COPIOUS AMOUNTS
OF WAT ER. CALL MD . EYE: IMMEDIATELY FLUSH WITH POTABLE WATER FOR
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
PREVENTION DURING THE USE OF WELDING AND ALLIED PROCEDURES. HMIS
HAZARD RATING: HEALTH - 3; FLAMMABILITY - 0 ; REACTIVITY - 0.
* Accidental Release Measures *
Spill Release Procedures:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:TRAIN WORKER TO KEEP HEAD OUT OF
FUMES. DO NOT TOUCH LIVE ELEC PARTS & INSULATE FROM WORK & GROUND.
FOR MAX SAFETY: BE CERTIFIED FOR, & WEAR NIOSH APPRVD RESP AT ALL
TIMES WHEN WELDING OR BRAZING. USEEXHST SYS. MAKE SURE INHALED
AIR DOES NOT CONTAIN FUME CONSTITUENTS ABOVE PEL'S.
Other Precautions:OTHER PRECAUTIONS FOR ADDITIONAL SAFETY INFORMATION
CUTTING, AND THE WELDING HANDBOOK, VOL 1, CHAPTER 9, SAFE PRACTICES
* Physical/Chemical Properties *
Vapor Density:N/A(AIR=1)
Appearance and Odor:BARE FILLER METALS ARE SOLID WIRE, SHINY SILVER
APPEARANCE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE UNLESS OTHERWISE STATED.
Hazardous Decomposition Products:COMPOSITION & QUALITY OF WELDING FUMES
& GASES ARE DEPENDENT UPON METAL BEING WELDED, PROCESS, PROC &
ELECTRODES USED. OTHER CNDTNS WHICH ALSO INFLUENCE COMPOSITION &
QTY OF FUMES & GASES TO (SUPP DATA)
* Toxicological Information*
Toxicological Information:N/P --SUPP DATA: QUALITY & AMT OF VENT,
POSITION OF WELDER'S HEAD W/RESPECT TO FUME PLUME & PRESENCE OF
CONTAMS IN ATM (CHLORINATED HYDROCAROBN VAPS FROM CLEANING &
DEGREASING ACTIVITIES). WHEN ELECTR ODE IS CONSUMED, FUME & GAS
DECOMP PRODS GENERATED ARE DIFF IN PERCENT & FORM FROM INGS LISTED.
FUME & GAS DECOMP PRODS, & NOT INGS IN ELECTRODE, ARE IMPORTANT.
CONC OF GIVEN FUME/GAS COMPONENT MAY DE CR/INCR BY MANY TIMES
ORIGINAL CONC. NEW CMPDS IN ELECTRODE MAY FORM. DECOMP PRODS OF
NORMAL OPERATION INCL THOSE ORIGINATING FROM VOLATILIZATION,
RXN/OXIDATION OF MATLS IN INGS SECTION, PLUS THOSE FR OM BASE METAL
& COATING, (ECOL INFO)
* Ecological Information *
Ecological:N/P --TOX INFO: ETC., AS NOTED. REASONABLY EXPECTED FUME
CONSTITUENTS OF PROD COULD INCL PRIMARILY OXIDES OF IRON;
SECONDARILY OXIDES OF CHROMIUM, NICKEL, MANGANESE, SILICON &
MOLYBDENUM. PRESENT OSHA EXPOS LIMS FOR HEXAVALENT-CHROMIUM IS
REDUCTION FROM 5 MG/M3 GEN FUME LEVEL. GASEOUS RXN IN PRODS MAY
INCL CARBON MONOXIDE & CARBON DIOXIDE. OZONE & NITROGEN OXIDES MAY
BE FORMED BY RADIA FROM ARC, IN ADDN TO SHIELDING GASES LIKE ARGON
& HELIUM WHEN EMPLOYED. ONE REC WAY TO DETERM COMPOSITION & QTY OF
FUMES & GASES ARE TO TAKE AIR SAMPLE FROM INSIDE WELDER'S
(TRANSPORT INFO)
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT RESIDUE, DISPOSAL CONTAINER OR
LINER IN ENVIRONMENTAL ACCEPTABLE MANNER, IN FULL COMPLIANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:N/P --ECOLOGICAL INFO: HELMET IF WORN OR IN
WELDING SOCIETY (AWS). SEE AWS PUBLICATION: "FUMES AND GASES IN THE
WELDING ENVIRONMENT" AN D AWS "EFFECTS OF WELDING ON HEALTH 1X".
* Regulatory Information *
SARA Title III Information:CHROMIUM, NICKEL AND MANGANESE ARE LISTED IN
Federal Regulatory Information:NICKEL AND CHROMIUM COMPOUNDS ARE
REQUIRED BY OSHA TO BE CONSIDERED CARCINOGENIC.
State Regulatory Information:THE STATE OF CALIFORNIA REQUIRES THE
FOLLOWING INFORMATION: WARNING: THIS PRODUCT CONTAINS CHEMICALS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
* Other Information *
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OPEN AREA:BUR MINES MECH RESPIRATOR;CLOSED:BUR
MINES CHEM/MECH FILTE
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST TO KEEP TLV BELOW LIMIT
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC NAPTHA
Ingred Name:VM&P NAPHTHA
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
Fraction by Wt: 7.5%
Ingred Name:ACETONE (SARA III)
Fraction by Wt: <0.5%
Ingred Name:MINERAL SPIRITS
Fraction by Wt: <0.5%
* Hazards Identification *
Effects of Overexposure:INHALATION-ANESTHETIC,IRRITATION OF RESPIRATORY
OR ACUTE NERVOUS SYSTEM DEPRESSION.
* First Aid Measures *
First Aid:CONTACT-FLUSH SKIN AND EYES WTH WATER WHILE REMOVING
. INHALATION-REMOVE TO FRESH AIR. CALL
PHYSICIAN IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Extinguishing Media:NFPA CLASS B EXTINGUISHER; POLYMER FOAM FOR LARGE
FIRES
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS SHOULD BE
AVAILABLE
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Other Precautions:GROUND CONTAINERS WHEN POURING.AVOID FREE FALL OF
LIQUID IN XS OF FEW INCHES DO NOT FLAME CUT, BRAZE OR WELD COATED
MATERIAL WITHOUT BUR OF MINES APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION
* Physical/Chemical Properties *
HCC:F2
Vapor Density:>AIR
Evaporation Rate & Reference:<ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS-INCINERATE IN APPROVED FACILITY-DO NOT
INCINERATE CLOSED CONTAINERS
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OVERHEATED, USE A NIOSH-APPROVED RESPIRATOR
TO PREVENT OVEREXPOSURE.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
PERCENTAGE CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
* Product Identification *
Product ID:OILDAG
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5.0 MG/M3 OIL MIST
ACGIH TLV:5.0 MG/M3 OIL MIST
Ingred Name:GRAPHITE, NATURAL
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE-
INHALATION:NO ACUTE EFFECTS EXPECTED WITHIN EXPOSURE LIMITS.
EYES:MAY CAUSE TEMPORARY IRRITATION. SKIN:REPEATED OR PROLONGED
CONTACT CAN CAUSE IRRITATION AND DERMATITI S. INGESTION:CAN CAUSE
GASTROINTESTINALIRRITATION, NAUSEA, VOMITING AND DIARRHEA. CHRONIC-
MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, GASTROINTESTINAL TRACT IRRITATION,
NAUSEA, VOMITING, DIARRHEA
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
CONTAMINATED CLOTHING. WASH SKIN WITH SOAP & WATER. INHALED:REMOVE
TO FRESH AIR. P ROVIDE CPR/OXYGEN IF NEEDED. ORAL:KEEP INDIVIDUAL
CALM. CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:USE CARBON DIOXIDE, FOAM/DRY CHEMICAL. DO NOT POUR
WATER OVER BURNING OIL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL WITH NON-FLAMMABLE ABSORBENT AND
PLACE INTO PROPER CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
HEAT, FLAME & STRONG OXIDANTS. KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP OUT OF REACH OF CHILDREN. AVOID PROLONGED INHALATION
OF MISTS OR VAPORS. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING.
* Physical/Chemical Properties *
HCC:T6
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:NIL
Appearance and Odor:BLACK LIQUID - BLAND ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS. RCRA
STREAMS, PONDS OR UNDERGROUND WATER SUPPLY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE APPROVED RESPIRATORY PROTECTION IF
VENTILATION IS INADEQUATE TO KEEP AIRBORNE CONCENTRATION BELOW
RECOMMENDED EXPOSURE STANDARDS.
Ventilation:USE ADEQUATE VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED NON-WATERPROOF SHOES & BOOTS.
Supplemental Safety and Health
FIRE & EXPLOSION HAZARDS CONT'D; FIRE HAZARD IS INCREASED AS LIQUID
* Product Identification *
Preparer's Name:REBECCA STEVENS
* Composition/Information on Ingredients *
Ingred Name:FUNCTIONING SPRAY ADJUVANT
Ingred Name:ALKYLARYLPOLYOXYETHYLENE GLYCOLS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Ingred Name:NON-FUNCTIONING SPRAY ADJUVANT
Ingred Name:FATTY ACID
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION/PERMANENT
DAMAGE/BLINDNESS. SKIN: MODERATE IRRITANT. INHALATION: RESPIRATORY
TRACT IRRITATION & PULMONARY EDEMA.
ABSORPTION/INHALATION/INGESTION: PRACTICALLY NON-TOXIC TO INTER NAL
ORGANS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PAIN, A FEELING OF HEAT, DISCOLORATION,
SWELLING, BLISTERING, NASAL DISCHARGE, SORE THROAT, COUGHING,
BRONCHITIS, DIFFICULTY IN BREATHING, TEARS, REDNESS, BLURRED
VISION.
* First Aid Measures *
WORN. SKIN: WASH W/SOAP & WATER. INGESTION: GIVE WATER/MILK.
CONSULT MEDICAL PERSONNEL BEFORE INDUCING VOMITING. DON'T
ADMINISTER FLUIDS BY MO UTH IF UNCONSCIOUS. INHALATION: REMOVE TO
FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:USE SCBA & PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES/FORMS VAPORS/CAN CATCH
FIRE & BURN W/EXPLOSIVE VIOLENCE. INVISIBLE VAPORS SPREAD EASILY &
IGNITE BY AN IGNITION SOURCE. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. STOP LEAK
SOURCE. SMALL: CLEAN UP W/ABSORBENT MATERIALS/PUMPING. REMOVE
CONTAMINATED SOIL WHERE FEASIBLE. DON'T CONTAMINATE WATER BY
CLEANING OF EQUIPMENT.
*Handling and Storage *
Handling and Storage Precautions:DON'T USE/STORE NEAR FLAME, SPARKS/HOT
SURFACES. USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER CLOSED.
Other Precautions:DON'T WELD, HEAT/DRILL CONTAINER. REPLACE CAP/BUNG.
KEEP PESTICIDE IN ORIGNIAL CONTAINER. EMPTIED CONTAINER STILL
CONTAINS HAZARDOOUS/EXPLOSIVE VAPOR/LIQUID.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, WATER VAPOR, CO.
* Disposal Considerations *
Waste Disposal Methods:DON'T APPLY DIRECTLY TO WATER/WETLANDS EXCEPT
IAW/EPA APPROVED PESTICIDE LABEL. DISPOSE OF IAW/LOCAL, STATE &
FEDERAL REGULATIONS. PRODUCT IS TOXIC TO AQUATIC ORGANISMS AT HIGH
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CALCIUM NITRATE TETRAHYDRATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INGESTION: CAUSES GASTROINTESTINAL IRRITATION. INHALATION:
RESPIRATORY TRACT IRRITATION. MAY CAUSE METHEMOGLOBINEMIA,
CYANOSIS, TACHYCARDIA, DYSPNEA & DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
CONVULSIONS
* First Aid Measures *
IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. INHALATION:
REMOVE TO FRE SH AIR IMMEDIATELY. OBTAIN MEDICAL ATTENTION IN ALL
CASES. NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:USE AGENT MOST APPROPRIATE TO EXTINGUISH
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH (APPROVED) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:THIS MATERIAL, IS AN EXPLOSION HAZARD
WHEN EXPOSED TO MECHANICAL SHOCK/FRICTION. CONTACT W/COMBUSTIBLE
MATERIAL MAY CAUSE A FIRE.
* Accidental Release Measures *
Spill Release Procedures:VACUUM/SWEEP UP MATERIAL & PLACE INTO A
SUITABLE DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
REMOVE ALL SOURCES OF IGNITION.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A TIGHTLY CLOSED CONTAINER.
STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE/COMBUSTIBLE MATERIALS & OTHER IGNITION SOURCES.
Other Precautions:USE W/ADEQUATE VENTILATION. MINIMIZE DUST
GENERATION/ACCUMULATION. AVOID CONTACT W/EYES/SKIN/CLOTHING. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPOS E CONTAINERS TO
HEAT/SPARKS/OPEN FLAMES.
* Physical/Chemical Properties *
Vapor Pres:<0.1
Appearance and Odor:SOLID WHITE DELIQUESCENT MASS W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLE MATERIALS, REDUCING AGENTS, ORGANIC MATTER
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED WHEN USED AS INTENDED, BUT MAY BE
REQUIRED FOR OTHER THAN NORMAL CUSTOMER USE IN BULK PROCESSING
FACILITIES.
Ventilation:NOT REQUIRED
Supplemental Safety and Health
* Product Identification *
CAGE:XEROX
CAGE:XEROX
* Composition/Information on Ingredients *
Ingred Name:BISPHENOL-A PROPYLENE OXIDE FUMARATE (POLYMER),POLYESTER
RESIN
Ingred Name:IRON OXIDE
Ingred Name:CARBON BLACK
Fraction by Wt: <5%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/M3
Ingred Name:SILICA AMORPHOUS HYDRATED, SILICEOUS EARTH, FUMED SILICA,
COLLOIDAL SILICON DIOXIDE, (SUSPECTED HUMAN CARCINOGEN)
Fraction by Wt: <1%
ACGIH TLV:0.2 MG/CUM RESP/DUST
Ingred Name:ZINC STEARATE
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/INGESTION/SKIN: IRRITATION.
INHALATION: MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
W/EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:CARBON BLACK IS A SUSPECTED HUMAN
CARCINOGEN BY ACGIH.
Effects of Overexposure:EYES/INGESTION/SKIN: IRRITATION. INHALATION:
MINIMAL IRRITATION MAY OCCUR W/EXPOSURE TO LARGE AMOUNTS OF ANY
NON-TOXIC DUST.
* First Aid Measures *
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL
GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM & DRY CHEMICAL
Fire Fighting Procedures:AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR VACUUM.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONGED INHALATION OF
EXCESSIVE DUST.
* Physical/Chemical Properties *
Spec Gravity:1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER W/FAINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:TOXIC COMBUSTION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE. DISPOSE OF IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
EXPOSURE LIMITS LISTED IN INGREDIENTS SECTION BY USING ENGINEERING
CONTROLS. IF NOT FEASABLE, USE APPROVED AIR PURIFYING RESPIRATOR
W/APPROVED FILTERS AND /OR SORBENTS.
Ventilation:GENERAL AND/OR LOCAL EXHAUST TO REGULATE EXPOSURE LEVELS.
Other Protective Equipment:IF REPEATED/PROLONGED SKIN CONTACT OR
CONTAMINATION LIKELY, WEAR FULL PROTECTIVE CLOTHING.
Work Hygienic Practices:ESTABLISH GOOD PERSONAL HYGENE & WORK
PRACTICES. ALWAYS WASH HANDS & FACE BEFORE EATING, DRINKING, OR
SMOKING.
Supplemental Safety and Health
* Product Identification *
CAGE:DEGUS
CAGE:DEGUS
* Composition/Information on Ingredients *
Ingred Name:IRON (III) HEXACYANOFERRATE
* Hazards Identification *
Health Hazards Acute and Chronic:EYES: MAY CAUSE EYE IRRITATION. IN
CASE OF CONTACT, FLUSH EYES W/ WATER. CALL DOCTOR IF IRRITATION
PERSISTS. SKIN: POSSIBLE IRRITATION. IN CASE OF CONTACT, WASH SKIN
W/ SOAP & WATER. CALL DOCTOR IF IR RITATION PERSISTS. SKIN
ABSORBTION: NOT EXPECTED. INHAL: MAY CAUSE IRRITATION TO RESP
TRACT. IF INHALED, AND IRRITATION OCCURS, REMOVE TO FRESH AIR. IF
IRRIT PERSISTS, CALL DOCTOR. INGEST: NOT EXPECTE D TO BE TOXIC IF
INGESTED. CHRONIC: NONE KNOWN.
Effects of Overexposure:CAUTION: MAY CAUSE IRRITATION TO EYES, SKIN, &
RESP TRACT. IN CASE OF CONTACT, FLUSH EYES W/ WATER & WASH SKIN W/
SOAP & WATER. IF INHALED, & BREATHING BECOMES DIFFICULT, REMOVE TO
FRESH AIR. IF IRRIT ATION PERSISTS CALL DR. RISKS INCLUDE: REDUCED
VISIBILITY & PHYSICAL IRRITATION.
Medical Cond Aggravated by Exposure:CONJUNCTIVITIS OF THE EYE,
DERMATITIS OF SKIN, ASTHMA, AND RESP DISEASES.
* First Aid Measures *
First Aid:EYES: FLUSH EYES W/ WATER. CALL PHYSICIAN IF IRRIT PERSISTS.
SKIN: WASH SKIN W/ SOAP & WATER. CALL PHYSICIAN IF IRRIT PERSISTS.
SKIN ABSORBTION: FLUSH SKIN W/ SOAP & WATER. INHAL: REMOVE TO FRESH
AIR. IF IRRIT PERSISTS, CALL PHYSICIAN. INGEST: NOT EXPECTED TO BE
TOXIC BY INGESTION.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE WATER MIST W/ SURFACE ACTIVE MATERIALS.
Fire Fighting Procedures:THIS PRODUCT IS NONFLAMMABLE. EVACUATE
ENCLOSED AND SURROUNDING AREAS. IF SMOKE AND FUMES CANNOT BE
AVOIDED, USE PROXIMITY SUIT AND SCBA.
Unusual Fire/Explosion Hazard:DUST LAYERS MAY SELF IGNITE AT TEMPS
* Accidental Release Measures *
Spill Release Procedures:SEE HEALTH HAZ SECTION & CONTROL MEASURES
SECTION FOR HAZARDS & EXPOSURE CONTROLS. FOR SMALL SPILLS, SWEEP OR
SHOVEL SOLIDS INTO PROPER CONTAINER FOR DISPOSAL. IN CASE OF
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINERS TIGHTLY CLOSED
WHEN NOT IN USE.
Other Precautions:CERCLA/SARA REQUIRES NOTIFICATION TO THE APPROPRIATE
FED/STATE/LOCAL AUTHORITIES OF RELEASES OF HAZARDOUS OR EXTREMELY
HAZARDOUS QUANTITIES EQUAL TO OR GREATER THAN THE REPORTABLE
CONTAINS NO REPORTABLE QUANTITIES.
* Physical/Chemical Properties *
Spec Gravity:1.8-1.9 WATER=1
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULAR SOLID; WEAK AMINE ODOR OR ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO INCOMPATABILITIES KNOWN.
Hazardous Decomposition Products:CAN INCLUDE HYDROGEN CYANIDE, AMONIA,
CARBON MONOXIDE, CARBON DIOXIDE.
* Ecological Information *
Ecological:SEE OTHER PRECAUTIONS
* Disposal Considerations *
Waste Disposal Methods:DUE TO BEING A RCRA LISTED HAZARDOUS WASTE,
DISPOSALS SHOULD BE CONDUCTED BY AN EPA PERMITTED DISPOSAL
ASSISTANCE. PRODUCT IS RCRA CHARA CTERISTIC HAZARDOUS WASTE.
* Regulatory Information *
Federal Regulatory Information:THIS PRODUCT IS IN COMPLIANCE WITH THE
SUBSTANCES RIGHT TO KNOW ACT.
State Regulatory Information:
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:N.A.
Ventilation:N.A.
Other Protective Equipment:N.A.
Supplemental Safety and Health
* Product Identification *
Product ID:BIOCIDE
* Composition/Information on Ingredients *
Ingred Name:CHLOROPHENATES(TRI,PENTA & OTHER),IN ISOPROPYL ALCOHOL
ACGIH TLV:N.A.
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
Ingred Name:BENZATRIAZOLE
ACGIH TLV:N.A.
Ingred Name:WATER
ACGIH TLV:NONE
* Hazards Identification *
Effects of Overexposure:CONTACT EXPOSURE:NAUSEA AND DERMATITIS AFTER
PROLONGED & EXTENSIVE SKIN CONTACT,NAUSEA,VOMITING
* First Aid Measures *
First Aid:FLOOD EXPOSED AREA WITH SOAP & WATER
* Fire Fighting Measures *
Flash Point:N.A.
Extinguishing Media:N.A.
Fire Fighting Procedures:N.A.
Unusual Fire/Explosion Hazard:N.A.
* Accidental Release Measures *
Spill Release Procedures:AVOID CONTACT WITH SKIN AND DISPOSE BY
FLUSHING WITH WATER
*Handling and Storage *
Handling and Storage Precautions:STORE IN CONTAINERS COMPATIBLE WITH
ALKALINE SOLUTIONS.DO NOT STORE WHERE ACCIDENTAL LEAKING COULD
CONTACT EXPLOSIVE MATERIAL
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:T6
Boiling Pt:B.P. Text:2.2F
Vapor Density:0.6
Spec Gravity:1.0
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS WITH AROMATIC ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALINE SOLUTION(PH8-9).
Hazardous Decomposition Products:N.A.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN AN APROVED SANITATION FILL
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0F0U5
*
Contractor Summary
*
Cage: 0F0U5
Country: UK
*
Ingredients
*
------------------------------
OSHA PEL: SEE TABLE Z3
------------------------------
HYDROTREATED
------------------------------
% Wt: 1-5
------------------------------
% Wt: 1-5
OSHA PEL: 5 MG/M3 (OIL MIST)
ACGIH TLV: 5 MG/M3 (OIL MIST)
------------------------------
% Wt: 1-5
------------------------------
% Wt: <0.5
------------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYE:IRRITATING ON CONTACT. SKIN:PROLONGED CONTACT MAY
DEFAT SKIN LEADING TO IRRITATION OR DERMATITIS. INHAL:VAPORS MAY BE
IRRITATING TO THE RESPIRATORY SYSTEM. PROLONGED OVEREXPOSURE TO VAPORS MAY
CAU SE KIDNEY EFFECTS AND MAY CAUSE TEMPORARY NERV SYS IMPAIRMENT
(LIGHTHEADEDNESS). INGEST:MAY CAUSE(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CRYSTALLINE SILICA QUARTZ GROUP 2A (IARC).
ANTICIPATED TO BE A CARCIN (NTP).
Signs And Symptions Of Overexposure: HLTH HAZ:DIGESTIVE SYSTEM IRRITATION.
ASPIRATION INTO LUNGS MAY CAUSE LUNG DAMAGE. CRYSTALLINE SILICA IS A
POTENTIAL CANCER HAZARD, CAUSING LUNG AND INJECTION SITE CANCER BY THE
INHALATION, INTRAPLEUR AL AND INTRAPERITONEAL ROUTES OF EXPSOURE IN
LABORATORY ANIMALS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
IF IRRITATION PERSISTS CALL MD. SKIN:WASH WITH SOAP & WATER. INHAL:MOVE
TO FRESH AIR. CALL MD. INGEST:DO NOT INDUCE VOMITING. CALL M D.
*
Handling and Disposal
*
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COVER WITH
INORGANIC ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL AND PLACE IN US DOT
APPROVED METAL CONTAINER AND SEAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE COMPLETELY ABSORBED WASTE PRODUCT AND
WASTE/BULK PRODUCT IN AN INDUSTRIAL WASTE FACILITY. CONSULT APPLICABLE
REGULATIONS OR AUTHORITIES BEFORE DISPOSAL. DISPOSAL MUST BE IN ACCORDANCE
WITHLOCAL, STATE AND FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: KEEP AWAY FROM HEAT, SPARKS & FLAME.USE
ONLY IN AREAS WIATH SUFFICIENT VENTILATION TO MAINTAIN VAPOR CONCENTRATIONS
BELOW RECOMMENDED EXPOSURE LIMITS.
Other Precautions: AVOID EYE AND SKIN CONTACT AND PROLONGED BREATHING OF
VAPORS. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: CC
Lower Limits: 0.7%
Upper Limits: 7%
Extinguishing Media: FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CARBON DIOXIDE
& VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). TREAT AS OIL FIRE. USE WATER ONLY TO COOL SURROUNDING
CONTAINERS OF FLAMMBLE OR COMBUST MATLS.
Unusual Fire/Explosion Hazard: DENSE SMOKE MAY BE GENERATED WHEN BURNING.
*
*
Respiratory Protection: THE USE OF A PROPER NIOSH/MSHA APPROVED RESPIRATOR IS
REQUIRED IF CONTAMINANT CONCENTRATIONS EXCEED EITHER THE PEL OR TLV.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH:7.8-8.4.
*
Physical/Chemical Properties
*
Vapor Pres: <1
PH: SUPDAT
Solubility in Water: DISPERSABLE
Appearance and Odor: PASTE, BUFF, SLIGHT KEROSENE ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, SMOKE
PARTICLES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Cage: 0F0U5
Company Name: PACEBROOK LTD
Country: UK
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. KEEP AWAY FROM HEAT AND OPEN FLAME.
ACUTE:EYE CONTACT CAN CAUSE IRRITATION. MAY CAUSE SKIN IRRITATION. SWALLOWING
MAY CAUSE DIGESTIVE SYSTEM IRRITATION. INHALATION MAY CAUSE IRRITATION TO
RESPIRATORY SYSTEM. CHRONIC:CONTAINS PETROLEUM DISTILLATES WHICH MAY CAUSE
CANCER. MAY CAUSE KIDNEY EFFECTS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALL-PURPOSE CANISTER MASK.
Ventilation:LOCAL TYPE PREFERABLE
Other Protective Equipment:APPROVED WORKING CLOTHES; SAFETY SHOWER;
EYEBATH
Supplemental Safety and Health
SCINTILLATION GRADE
* Product Identification *
Product ID:P-DIOXANE
* Composition/Information on Ingredients *
Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
* Hazards Identification *
Effects of Overexposure:DROW,HEAD,NAU,VOMIT;IRRIT
EYES,NOSE,THROAT;LIVER DAMAGE,KIDNEY FAILURE;SKIN IRRIT;
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR, ADMINISTER OXYGEN OR ARTIFICIAL
RESPIRATION IF NECESSARY;(CALL A DOCTOR;SWALLOWED:IF
CONSCIOUS,IMMEDIATELY INDUCE VOMITING;CALL A
MIN.
* Fire Fighting Measures *
Lower Limits:2.0
Extinguishing Media:ALCOHOL FOAM,CARBONDIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:TENDS TO FORM EXPLOSIVE PEROXIDES ESPECIALLY
WHEN ANHYDROUS.
Unusual Fire/Explosion Hazard:DANGEROUS WHEN EXPOSED TO HEAT OR FLAME;
CAN REACT VIGOROUSLY WITH OXIDIZING MATERIAL.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION;ABSORB SPILL
ON SAND EARTH OR VERMICULITE; CAREFULLY SWEEP UP & REMOVE. FLUSH
SPILL AREA WITH WATER.
*Handling and Storage *
KEEPAWAY FROM HEAT,SPARKS,FLAME. KEEP IN TIGHTLY CLOSED CONTAINER.
DO NOT ALLOWTO EVAPORATE TO NEAR DRYNESS.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:F2
Evaporation Rate & Reference:(BU AC =1) 2.7
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR,COLORLESS LIQUID,MILD ETHER-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CAN REACT VIGOROUSLY W/ OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, FLAME
Hazardous Decomposition Products:THERMAL DECOMP/BURNING -PRODUCES
CARBON MONOXIDE
* Disposal Considerations *
Waste Disposal Methods:ATOMIZE INTO AN INCINERATOR PROVIDING
ENVIRONMENTAL REGULATIONS PERMIT. COMBUSTION MAY BE IMPROVED BY
MIXING WITH A MORE FLAMMABLE SOLVENT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR OIL MIST IF TLV IS
EXCEEDED.USE THE PRODUCT IN A WELL VENTILATED AREA ONLY!
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:OIL IMPERVIOUS APRON
Work Hygienic Practices:WASH HANDS AFTER USING. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:TERRY HELLER
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATES,STRAIGHT RUN MIDDLE
OSHA PEL:5MG/CUM(MIST)
ACGIH TLV:5MG/CUM(MIST)
Ingred Name:PETROLEUM DISTILLATES,HYDROTREATED LIGHT NAPHTHENIC
OSHA PEL:5MG/CUM(MIST)
ACGIH TLV:5MG/CUM(MIST)
Ingred Name:PETROLEUM DISTILLATES,HYDROTREATED HEAVY NAPHTHENIC
OSHA PEL:5MG/CUM(MIST)
ACGIH TLV:5MG/CUM(MIST)
Ingred Name:SULFURIZED FATTY OIL
Ingred Name:ANIMAL FATTY OIL
Ingred Name:TOLYLTRIAZOLE (METHYL-1H-BENZOTRIAZOLE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:MAY CAUSE SKIN IRRITATION OR
ACNE(MECHANICAL BLOCKAGE OF PORES).MAY INFECT OPEN
SORES/CUTS(PRODUCT NOT STERILE).EYES:MAY CAUSE
IRRITATION.INGEST:LOOSE BOWELS.INHAL:NOT ESTABLISHED.
Explanation of Carcinogenicity:MANUFACTURER STATES THAT MINERAL OIL
USED IN METAL MACHINING IS KNOWN TO CAUSE CANCER(PER CALIFORNIA
FINDINGS).
Effects of Overexposure:SKIN:IRRITATION, ACNE.PROLONGED EXPOSURE MAY
AGGRAVATE DERMATITIS. INGESTION:LOOSE BOWEL MOVEMENTS. INHALATION:
OVEREXPOSURE CAUSES COUGHING, SORE THROAT, HEADACHE, CHEST PAIN,
DIFFICULT BREATHING.
Medical Cond Aggravated by Exposure:SKIN:INFECTION OF OPEN SORES/CUTS.
ACNE BY MECHANICAL BLOCKAGE.AGGRAVATES EXISTING DERMATITIS.
INHAL:INDIVIDUALS WITH RESPIRATORY IMPAIRMENTS(EG. EMPHYSEMA) SHOW
INCREASED SENSITIVITY TO VAPORS/MISTS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. UNCONSCIOUSNESS:
BREATHING-RESUSCITATE BY MOUTH; NOT BREATHING-CALL DOCTOR. EYES:
CHECK FOR IRRITATI ON. SKIN: WASH AREA WITH NON-ABRASIVE SOAP AND
WATER. INGESTION: DO NOT INDUCE VOMITING. CALL DOCTOR OR POISON
CONTROL CENTER AT ONCE!
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CO2,FOAM,DRY CHEMICAL,WATER FOG
Fire Fighting Procedures:FOR FIRES IN ENCLOSED AREAS, FIREFIGHTERS
SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION WILL PRODUCE OXIDES OF SULFUR
AND CARBON. SEALED CONTAINERS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. USED WRAGS MAY SPONTANEOUSLY COMBUST.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE IF LARGE AMOUNT SPILLED IN A
CONFINED SPACE.ABSORB SPILL WITH FIRE-RETARDING SAW
DUST,DIATOMACEOUS EARTH.DISPOSE IN FIRE PROOF CONTAINER.REPORT
MARITIME SPILLS TO COAST GUARD. WASH AREA WITH DETERGENT AND WATER
TO REMOVE SLIPPERYSURFACES.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT OR FLAME.IF
STORED OUTDOORS,STORE SO AS TO SHED WATER.TREAT EMPTY CONTAINERS
THE SAME AS FULL ONES.
Other Precautions:AVOID INHALATION OF MISTS OR VAPORS.DO NOT CUT,BRAZE,
WELD,SOLDER OR PRESSURIZE CONTAINER AS DOING SO MAY CAUSE CONTAINER
TO EXPLODE.RETURN EMPTY DRUMS TO A DRUM CONDITIONER FOR
CLEANING.FOR INDUSTRIA L USE ONLY!
* Physical/Chemical Properties *
HCC:V6
Vapor Density:>1
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK BROWN MOBILE LIQUID WITH CHARACTERISTIC ODOR
OF SULFURIZED FAT.
Percent Volatiles by Volume:<1%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS FUMING NITRIC ACID MAY PRODUCE HAZARDOUS
REACTIONS. AVOID POLLUTING WITH ANY OXIDIZING AGENT.
Stability Condition to Avoid:SPARKS,FLAMES,IGNITION SOURCES. DO NOT
SMOKE IN PRESENCE OF OIL MIST.
Hazardous Decomposition Products:OXIDES OF SULFUR AND CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A FIRE PROOF CONTAINER,IN
ACCORDANCE WITH FEDERAL,STATE & LOCAL REGULATIONS. DO NOT REUSE
REFUSE CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
* Product Identification *
Preparer's Name:S HEALY
* Composition/Information on Ingredients *
Other REC Limits:0.1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
* Accidental Release Measures *
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
* Physical/Chemical Properties *
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:FOR USE OTHER THAN NORMAL CUSTOMER OPERATING
PROCS (SUCH AS BULK TONER PROCESSING FACILITIES), ANSI APPRVD (ING
6)
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: YELLOW DEVELOPER. EFTS OF OVEREXP: STUDY WAS
CONDUCTED USING SPECIAL TEST TONER TO COMPLY W/EPA TESTING
PROTOCOL. TEST TONER WAS TEN TIMES MORE RESPIRABLE THAN
COMMERCIALLY A VAIL XEROX TONER & WOULD NOT BE FUNCTIONALLY
SUITABLE FOR XEROX EQUIP.
* Product Identification *
CAGE:0E6G9
CAGE:0E6G9
* Composition/Information on Ingredients *
Ingred Name:KAOLIN; (CU-ZN FERRITE POWDER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTER
Fraction by Wt: >4.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 0.2-0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SPILL PROC: USED TO REDUCE STATIC BUILDUP (SEE SECTION ON
FIRE & EXPLO). RESIDUE CAN BE REMOVED W/SOAP & COLD (ING 5)
Ingred Name:ING 4: WATER. GARMENTS MAY BE WASHED OR DRY CLEANED AFTER
REMOVAL OF LOOSE TONER.
REQUIRED. FOR MORE INFO, CONTACT XEROX.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESP TRACT IRRIT MAY OCCUR AS
W/EXPOS TO LARGE AMTS OF ANY NON-TOXIC DUST. THE RSLTS OBTAINED
FROM XEROX SPONSORED CHRONIC TONER INHAL STUDY, DEMONSTRATED NO
LUNG CHANGE IN RATS FOR THE LOWEST(1MG/M3) EXPOS LEVEL (IE, LEVEL
MOST RELEVANT TO POTNTL HUMAN EXPOS). VERY SLIGHT DEGREE OF
FIBROSIS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
(4MG/M3) EXPOS LEVEL, WHILE SLIGHT DEGREE OF FIBROSIS WAS NOTED IN
ATTRIBUTED TO "LU NG OVERLOADING," A GENERIC RESPONSE TO EXCESSIVE
AMTS OF ANY DUST RETAINED IN LUNGS FOR PRLNGD PERIOD. THIS (SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
* First Aid Measures *
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, IT CAN FORM EXPLOSIVE MIXTURES
WHEN DISPERSED IN AIR.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO SEALABLE WAST CNTNR. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. IF VACUUM IS USED, MOTOR MUST
BE RATED AS DUST TIGHT. CONDU CTIVE HOSE BONDED TO MACHINE SHOULD
BE (ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE. AVOID PROLONGED INHALATION OF
EXCESSIVE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:YELLOW POWDER; FAINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
* Disposal Considerations *
Waste Disposal Methods:THIS MATL IS NOT A HAZ WASTE ACCORDING TO
REQS HOWEVER, MAY BE MORE RESTRICTIVE. PLEASE CONSULT W/APPROP
FEDERAL, STATE & LOCAL WASTE DISP AUTHS. INCINERATE ONLY IN CLOSED
CNTNR.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN EXPOSURE LEVELS
IAW PEL(TLV) LIMITS, USE A NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTIRDGE.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:NONE SPECIFIED BY THE MANUFACTURER.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE. DO NOT WEAR
CLOTHING OR FOOTWEAR WHICH HAS BEEN CONTAMINATED BY THIS PRODUCT.
Supplemental Safety and Health
NONE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM SULFITE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METABISULFITE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
Ingred Name:ETHYLENE DIAMINE TETRAACETIC ACID TETRASODIUM SALT
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CITRATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/INGESTION/INHAL:MANUFACTURER
STATES THAT LOW HAZARD IS EXPECTED FOR RECOMMENDED HANDLING.
EYES:NO SPECIFIC HAZARD KNOWN. MAY CAUSE TEMPORARY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT
ARE LISTED BY IARC, OSHA OR NTP AS A CARCINOGEN.
Effects of Overexposure:MAY CAUSE TEMPORARY IRRITATION OF THE EYES.
Medical Cond Aggravated by Exposure:NONE ARE SPECIFIED BY THE
MANUFACTURER.
* First Aid Measures *
1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION. INHAL:REMOVE TO FRESH
AIR.
* Fire Fighting Measures *
Flash Point:NON COMBUSTIBLE
Extinguishing Media:THIS PRODUCT IS NON-FLAMMABLE. USE APPROPRIATE
AGENT TO FIGHT THE SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING WHEN FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY RESULT IN
TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO AN ACID FREE SEWER WITH PLENTY OF
WATER. NOTE THAT THE DISCHARGE MAY BE SUBJECT FEDERAL, STATE OR
LOCAL LAWS.
Neutralizing Agent:NONE SPECIFIED BY THE MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND AWAY FROM
STRONG ACIDS AND BASES.
Other Precautions:WASH HANDS AFTER USING.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:NEGLIGIBLE
Spec Gravity:>1
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:APPRECIABLE
Appearance and Odor:POWDER; ODORLESS.
Percent Volatiles by Volume:NEGLIG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:STRONG ACIDS OR BASES.
Hazardous Decomposition Products:SULFUR DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:MANUFACTURER STATES THAT HIS PRODUCT HAS A
MODERATE BOD(BIOLOGICAL OXYGEN DEMAND). DISCHARGE,TREATMENT OR
DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR RESPIRATOR (MSHA/NIOSH) SUITABLE FOR
CONCENTRATIONS AND TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:MECHANICAL LOCAL EXHAUST VENTILATION AT POINT OF
CONTAMINANT ENCOUNTERED.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER AND EYE
WASH FACILITY.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
CORROSIVE.
* Product Identification *
Kit Part:Y
POLYMERS
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENETRIAMINE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 PPM
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRADE SECRET- ADDUCT OF ETHYLAMINE, SUBSTITUTEDAMINE AND
BISPHENOL A
Fraction by Wt: SECRET
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOLAMINE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-VAPOR OR MISTS CAN CAUSE
SEVERE IRRITATION TO THE NOSE & THROAT. DELAYED EFFECTS: PROLONGED
OR REPEATED EXPOSURE CAN CAUSE LIVER AND KIDNEY DAMAGE. SUBSTANCE
CAN CAUSE ALLERGIC SKIN REACTIO N.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:EYE-CORROSIVE TO EYES; CAUSES PERMANENT,
IRREVERSIBLE EYE INJURY. SKIN-CORROSIVE TO SKIN; CAUSES BURNS.
INGESTION-SUBSTANCE WILL CAUSE BURNING AND SWELLING OF MOUTH,
THROAT AND ABDOMEN.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA, EYE OR RESPIRATORY
CONDITIONS.
* First Aid Measures *
First Aid:INHALATION-MOVE SUBJECT TO FRESH AIR. GIVE OXYGEN IF
BREATHING IS DIFFICULT. EYE AND SKIN-FLUSH EYES WITH LARGE AMOUNTS
SKIN THOROUGHLY WITH SOAP AND WATER. REMOVE AND WASH CLOTHING
BEFORE RESUE. INGESTION-DILUTE BY GIVING 2 GLASSES OF WATER TO
DRINK. SEE A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.4
Upper Limits:7.2
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER.
Fire Fighting Procedures:WEAR BREATHING APPARATUS AND FULL PROTECTIVE
GEAR. DO NOT USE A SOLID STREAM OF WATER. A SOLID STREAM OF WATER
CAN SPREAD FIRE.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAT
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE THE SPILL AREA. WEAR FULL PROTECTIVE
EQUIPMENT. DIKE AND CONTAIN SPILL WITH INERT MATERIAL. TRANSFER TO
CONTAINERS SUITABLE FOR DISPOSAL. KEEP SPILL AND CLEANING RUNOFFS
OUT OF MUNICIPAL SEWE RS AND OPEN BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
HEAT, FROM SOURCES OF IGNITION AND FROM REACTIVE MATERIALS. DO NOT
STORE NEAR FOOD OR FEED.
Other Precautions:CORROSIVE TO COPPER AND BRASS ON LONG TERM STORAGE.
CORROSIVE MATERIAL! AVOID ALL EYE AND SKIN CONTACT. PLEASE READ
TECHNICAL DATA SHEET BEFORE HANDLING THE PRODUCT.
* Physical/Chemical Properties *
HCC:B2
Vapor Pres:<1
Vapor Density:>1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR TO STRAW COLOR LIQUID, AMMONICAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING AGENTS, ALDEHYDES, KETONES, EPOXIDES, ACRYLATES, AND
ORGANIC HALIDES.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE LIQUID; LANDFILL OR INCINERATE
CONTAMINATED DIKING MATERIAL IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
BREATHING APPARATUS.
MECHANICAL (GENERAL): EXPLOSION PROOF. SUFFICIENT IN
VOLUME/PATTERN.
Other Protective Equipment:EYEWASH, NEOPRENE BOOTS & COVERALLS
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:THOMAS R DERAM
* Composition/Information on Ingredients *
Ingred Name:ISOBUTYL METHACRYLATE
Ingred Name:TRIMETHYLOLPROPANE TRIMETHACRYLATE
Fraction by Wt: <1%
Other REC Limits:1 MG/CUM
Ingred Name:N,N-DIMETHYL-P-TOLUIDINE, DIMETHYL-P-TOLUIDINE
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION: NOSE &
RESPIRATORY TRACT IRRITATION, CENTRAL NERVOUS SYSTEM EFFECTS SUCH
AS DIZZINESS, HEADACHE, NAUSEA, & LOSS OF CONSCIOUSNESS. INGESTION:
LOW ORAL TOXICITY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: ALLERGIC RASH, ITCHING, & SWELLING.
* First Aid Measures *
First Aid:INGESTION: INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
IF BREATHING DIFFICULTY, ADMINISTER OXYGEN. IF NOT BREATHING,
ADMINISTER ARTIFICIAL RESPIRATION. SKIN: WASH W/SOAP & WATER. EYES:
ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG (BY TRAINED
PERSONNEL)
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT, INCLUDING
SELF-CONTAINED BREATHING APPARATUS, IS RECOMMENDED. COOL HEATED
CONTAINERS W/COLD WATER SPRAY. FIGHT FROM SAFE DISTANCE.
Unusual Fire/Explosion Hazard:SEALED CONTAINERS EXPOSED TO ELEVATED
TEMPS MAY RUPTURE EXPLOSIVELY DUE TO POLYMERIZATION. VAPORS ARE
HEAVIER THAN AIR/TRAVEL TO IGNITION SOURCE. COMBUSTIBLE.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. REMOVE SOURCES OF IGNITION.
CONFINE & REMOVE W/INERT ABSORBENT. VENTILATE AREA.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, DIRECT SUNLIGHT, SPARKS, & FLAME. CLOSE CONTAINER AFTER
EACH USE.
Other Precautions:AVOID CONTACT W/SKIN & BREATHING OF VAPOR. MATERIAL
HAS STRONG SOLVENT PROPERTIES & CAN SOFTEN PAINT & RUBBER.
* Physical/Chemical Properties *
Vapor Pres:3
Evaporation Rate & Reference:(BU AC = 1): 0.5
Appearance and Odor:COLORLESS LIQUID, ACRYLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REDUCING & OXIDIZING AGENTS
Stability Condition to Avoid:STORAGE UNDER INERT ATMOSPHERE,
CONTAMINATION, HEAT, DIRECT SUNLIGHT, SPARKS, FLAME & OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:CO, CO2, SMOKE
Conditions to Avoid Polymerization:EXCESSIVE HEAT, STORAGE IN ABSENCE
OF INHIBITOR; INADVERTENT ADDITION OF CATALYST
* Disposal Considerations *
Waste Disposal Methods:EPA CHARACTERISTIC HAZARD WASTE. DON'T ALLOW
MATERIAL TO CONTAMINATE GROUND WATER SYSTEM. INCINERATE IN AN
APPROVED FACILITY. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SPECIFIC RESP SELECTED MUST BE BASED ON CONTAM
LEVELS FOUND IN WORKPLACE, MUST BE BASED ON SPECIFIC OPERATION,
MUST NOT EXCEED WORKING LIMS OF RESP & MUST BE NIOSH APPRVD. FOR
MORE SPECIFIC INFORMATIO N CONTACT NEHC .
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION SYSTEM.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . WEAR IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP: LGE DOSES MAY CAUSE CNS DEPRESS. CHRONIC: INGEST:
RPTD/PRLNG EXPOS MAY CAUSE SKIN ERUPTIONS & CNS DISTURB DUE TO
BROMIDE POIS. ABSORPTION MAY ALSO CAUSE DISTURBED BLOOD ELECTROLYTE
BA LANCE. LITHIUM CMPDS ARE LIKELY TO ADVERSELY AFFECT GI, NERV &
RENAL SYS. THEY MAY CAUSE ANOREXIA, WT LOSS, (ING 3)
* Product Identification *
CAGE:ADRES
CAGE:ADRES
* Composition/Information on Ingredients *
Ingred Name:LITHIUM BROMIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: GEN WEAK, FATG, DEHYDRATION, THIRST, SALIVATION,
NAUS, VOMIT, DIARR, TREMORS, GIDD, TINNITUS, DROW, (ING 4)
Ingred Name:ING 3: SLURRED SPEECH, BLURRED VISION, HYPERACTIVE DEEP
REFLEXES, MUSC HYPERIRRITABILITY, COMA, NYSTAGMUS, (ING 5)
Ingred Name:ING 4: LETHARGY, STUPOR, POLYURIA, & ALIGURIA. LITHIUM
SALTS: FOR COMPLETE INFORMATION CONTACT NEHC .
MIN). GET MED ATTN IMMED. INGEST: IF VOMIT OCCURS, (ING 7)
Ingred Name:ING 6: KEEP HEAD LOWER THAN HIPS TO HELP PVNT ASPIR. TREAT
SYMPTOMATICALLY & SUPPORTIVELY. GET MED ATTN IF (ING 8)
Ingred Name:ING 7: NEEDED. NOTE TO MD: ANTIDOTE: THE FOLLOWING ANTIDOTE
HAS BEEN REC. HOWEVER, DECISION AS TO WHETHER SEV OF (ING 9)
Ingred Name:ING 8: POISONING REQUIRES ADMIN OF ANY ANTIDOTE & ACTUAL
Ingred Name:ING 9: BROMIDE POISONING: GIVE SODIUM CHLORIDE, 1 GRAM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HLTH EFTS: ACUTE: INHAL MAY
CAUSE IRRIT. ADDNL EFTS MAY INCL RINGING IN EARS, NAUS, VOMIT,
DIARR, DROW, TWITCHING & BLURRED VISION. SKIN/EYES: MAY CAUSE
IRRIT. INGEST: MAY CAUSE DRUNKENNESS. CHRONIC: MAY CAUSE RASH,
RINGING IN EARS, NAUS, VOMIT, DIARR, DFCLTY SPEAKING, DROW,
TWITCHING, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: VISUAL DISTURB & COMA. LITHIUM
BROMIDE: TARGET EFTS: MAY CAUSE CNS DEPRESS & AFFECT BLOOD
ELECTROLYTE BALANCE. ACUTE: INHAL: MAY CAUSE IRRIT OF RESP SYS,
MALAISE, DROW, ANOREXIA, NAUS, VOMIT , DIARR, BLURRED VISION,
TINNITUS, WEAK, MUSC TREMORS & INCRD TENDON REFLEXES. SKIN: MAY
CAUSE IRRIT. INGEST: (SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR IMMED. PERFORM ARTF RESP IF NEC.
KEEP WARM & AT REST. TREAT SYMPTOMATICALLY & SUPPORTIVELY. GET MED
ATTN IMMED. SKIN: REMOVE CONTAM CLTHG & SHOES IMMED. WASH
W/SOAP/MILD DET ERGENT & LGE AMTS OF WATER UNTIL NO EVIDENCE OF
IMMED W/LGE AMTS OF WATER/NORM SALINE, OCCAS LIFTING UPPER & LOWER
LIDS, UNTIL (ING 6)
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISH USING AGENT SUITABLE FOR TYPE OF
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO ACUTE HAZARD. MOVE CONTR FROM FIRE AREA IF POSSIBLE.
AVOID BREATHING VAPORS/DUST; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:STOP LEAK IF YOU CAN DO IT WITHOUT RISK. FOR
SMALL SPILLS, DIKE UP WITH SAND OR OTHER ABSORBENT MATERIAL AND
PLACE INTO CLEAN, DRY CONTAINER FOR LATER DISPOSAL. KEEP
UNNECESSARY PEOPLE AWAY. ISOLATE H AZARD AREA AND DENY ENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE ALL FEDERAL, STATE AND LOCAL
REGULATIONS WHEN STORING THIS SUBSTANCE. KEEP CONTAINER TIGHTLY
CLOSED. HANDLE WITH CAUTION.
Other Precautions:AVOID BREATHING VAPOR OR MIST. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. USE ONLY WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
Spec Gravity:1.6
Solubility in Water:WATER SOLUTION
Appearance and Odor:LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO DATA AVAILABLE.
Stability Condition to Avoid:PROTECT FROM FREEZING. STORE AWAY FROM
INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC AND/OR HAZARDOUS GASES.
* Disposal Considerations *
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS
WHEN DISPOSING OF THIS SUBSTANCE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT/VALUE IS EXCEEDED FOR
ANY COMPONENT, USE AN APPROVED NIOSH/OSHA RESPIRATOR.
Ventilation:SUFFICIENT MECHANICAL (LOCAL EXHAUST/GENERAL EXHAUST) TO
MAINTAIN EXPOSURE BELOW PEL & TLV.
Other Protective Equipment:EYEWASH & SOLVENT IMPERVIOUS APRON, BARRIER
CREAMS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HEALTH HAZ CONT'D: OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
* Product Identification *
Product ID:WELDWOOD NF CONTACT CEMENT
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE ETHER (DIOXANE), (DIETHYLENE DIOXIDE),
Fraction by Wt: 1-5%
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY IRRITATE
EYES/SKIN/NOSE/RESPIRATORY TRACT. HARMFUL IF INHALED. HARMFUL/FATAL
IF SWALLOWED. INGESTION: ASPIRATION OF MATERIAL INTO THE LUNGS DUE
TO VOMITING CAN CAUSE CHEMICAL PNEUMONITIS WHICH MAY BE FATAL.
INHALATION: MAY AFFECT THE BRAIN/NERVOUS SYSTEM. PROLONGED/REPEATED
CONTACT W/SKIN MAY CAUSE DERMITITIS. SUPP
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, VOMITING, DIARRHEA, DEPRESSED
RESPIRATION, DIZZINESS, HEADACHE, NAUSEA, DEFATTING
Medical Cond Aggravated by Exposure:1,1,1-TRICHLOROETHANE-MAY AGGRAVATE
LIVER DISEASE & RHYTHM DISORDERS OF THE HEART.
* First Aid Measures *
IMMEDIATELY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, DRY CHEMICALS, WATER FOG
Fire Fighting Procedures:USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & WILL COLLECT IN LOW
AREAS. CHECK ALL LOW AREAS (BASEMENTS, SUMPS) FOR VAPOR BEFORE
ENTERING.
* Accidental Release Measures *
Spill Release Procedures:DIKE AREA. USE ABSORBENT MATERIAL/SCRAPE UP
DRIED MATERIAL & PLACE INTO CONTAINERS.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM CAUSTICS & OXIDIZERS.
KEEP CONTAINERS AWAY FROM EXCESSIVE HEAT & FREEZING. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T STORE AT TEMPS
VAPORS MAY BE HARMFUL/FATAL.
* Physical/Chemical Properties *
Vapor Density:4.5
Spec Gravity:1.3
Evaporation Rate & Reference:(ETHYL ETHER=1): 2.6
Appearance and Odor:OPAQUE LIQUID W/PUNGENT SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT W/REACTIVE METALS; ALUMINUM & MAGNESIUM, STRONG OXIDIZERS,
CAUSTICS
Stability Condition to Avoid:EXCESSIVE HEAT & FREEZING
Hazardous Decomposition Products:CARBON OXIDES, NITROGEN OXIDES,
HYDROGEN CHLORIDE, PHOSGENE & CHLORINE
* Disposal Considerations *
Waste Disposal Methods:LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL VENTILATION FOR PROLONGED USE IN A CONFINED
AREA.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:SILICONE FORM-A-GASKET ADHESIVE SEALANT BLU
Preparer's Name:STEPHEN REPETTO
* Composition/Information on Ingredients *
Ingred Name:POLYDIMETHYL SILOXANE; (POLY(DIMETHYLSILOXANE))
Ingred Name:POLYACETOXY SILANE
Fraction by Wt: <5%
Ingred Name:SILICA, CRYSTALLINE - FUSED; (SILICON DIOXIDE)
OSHA PEL:SEE TABLE Z3
Ingred Name:PIGMENT
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SILICON DIOXIDE DUST HAS BEEN SHOWN TO
CAUSE ADVERSE PULMONARY EFFECTS ON INHALATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:ACETIC ACID PRODUCED DURING CURE IRRITATES
EYES, NOSE, AND THROAT.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. SKIN: WIPE OFF GEL WITH PAPER TOWEL OR CLOTH. WASH
MINUTES WITH WATER. OBTAIN MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WIPE OR SCRAPE UP SPILLED MATERIAL. MAINTAIN
GOOD VENTILATION FOR LARGE SPILLS. PLACE SCRAP MATERIAL IN A WELL-
VENTILATED PLACE AND ALLOW TO CURE TO RUBBER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A DRY AREA. KEEP CONTAINERS
CLOSED WHEN NOT IN USE. AVOID SKIN AND EYE CONTACT. AVOID BREATHING
VAPORS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:POLYMERIZED
Appearance and Odor:BLUE GEL WITH ACETIC ACID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POLYMERIZED BY CONTACT WITH MOISTURE. ACETIC ACID LIBERATED.
Stability Condition to Avoid:
Hazardous Decomposition Products:ACETIC ACID, FORMALDEHYDE, SILICA
MIST.
* Disposal Considerations *
Waste Disposal Methods:CURED RUBBER SCRAP CAN BE LANDFILLED OR
INCINERATED FOLLOWING EPA, FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL RECOMMENDED
Supplemental Safety and Health
* Product Identification *
Product ID:LEAK DETECTION FLUID(AIR,NAT GAS,PROPANE)
* Composition/Information on Ingredients *
Ingred Name:LEAK DETECTION COMPOUNDS(TYPE NOT SPECIFIED)
* Hazards Identification *
Effects of Overexposure:CAN IRRITATE EYES & SKIN
* First Aid Measures *
First Aid:FLUSH WELL WITH WATER,IF EYE IRRITATION PERSISTS,SEEK MEDICAL
ASSISTANCE
* Fire Fighting Measures *
Flash Point:NONE TO BOILING
* Accidental Release Measures *
Spill Release Procedures:MOP UP & FLUSH RESIDUE WITH LARGE QUANTITIES
OF WATER
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,THIN LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:PLACE ANY ABSORBED MATERIAL IN CONTAINERS
SUITABLE FOR SHIPMENT TO DISPOSAL AREA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NECESSARY IN MOST CASES. IN CONFINED AREAS
USE A NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST: REQUIRED. MECHANICAL (GENERAL): AS NEEDED IN
CONFINED AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
RUBBER BOOTS.
Work Hygienic Practices:WASH HANDS & FACE THOROUGHLY BEFORE SMOKING,
EARING DRINKING OR USING THE TOILET. REMOVE CONTAMINATED CLOTHING
(SUPDAT)
Supplemental Safety and Health
HYGIENE PRACT: AND WASH THOROUGHLY BEFORE RE-USE.
* Product Identification *
Kit Part:Y
CAGE:MAPCA
CAGE:MAPCA
CAGE:MAPXX
* Composition/Information on Ingredients *
Ingred Name:ISOPHORONEDIAMINE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMIDO AMINE ADDUCT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZYL ALCOHOL
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: THIS PRODUCT IS CORROSIVE TO
EYES, SKIN, AND MUCOUS MEMBRANES. IT IS ALSO CAPABLE OF PRODUCING
ALLERGIC RESPONSE AND SENSITIZATION. SIGNS & SYMPTOMS OF EXPOSURE:
IRRITATION, REDNESS, DIFFICULTY IN BREATHING. CHRONIC: NONE KNOWN.
FORCALIFORNIA: THIS PROD CNTNS CHEMS KNOWN TO STATE OF CALIFORNIA
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TO CAUSE CANCER, BIRTH DEFECTS OR
OTHER PREPRODUCTIVE TOXICITY.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
PERSISTS, CONSULT PHYS. SKIN: WASH W/SOAP & WATER. IF IRRIT
PERSISTS, SEE PHYS. INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT
INDUCE VOMITING. GIVE LG QTY OF MILK OR WATER. DO NOT GIVE
ANYTHING BY MOUTH TO UNCON PERSON. SEEK IMMED MED ATTN.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CARBON DIOXIDE (CO*2), DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. CONTAIN BY DIKING
WITH SOIL OR OTHER INERT ABSORBENT MATERIAL AND PUT INTO A DOT
APPROVED WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. WEAR
SUITABLE PROTECTIVE CLOTHING TO MINIMIZE PERSONAL EXPOSURE.
Other Precautions:NONE KNOWN.
* Physical/Chemical Properties *
Solubility in Water:DISPERSIBLE
Appearance and Odor:AMBER LIQUID, AMMOINACAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OR BY PRODUCTS: CARBON MONOXIDE (CO),
CARBON DIOXIDE (CO*2), OXIDES OF NITROGEN, OTHER UNIDENTIFIED
ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL STATE, LOCAL
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JOSEPH PALMERI
* Composition/Information on Ingredients *
Ingred Name:WATER
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN
Ingred Name:WATER SOLUBLE ORGANIC SOLVENT
Ingred Name:WATER SOLUBLE ORGANIC COMPOUND
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHT IRRITATION. INGESTION:
HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DISCOLORATION
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. EYES: FLUSH COPIOUSLY W/WATER
ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:COVER W/ABSORBENT MATERIAL, COLLECT THE
MIXTURE & PLACE IN A CLOSED CONTAINER FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T TAKE INTERNALLY. INK IS NOT ACCESSIBLE UNLESS
THE CARTRIDGE IS FORCED/BROKEN.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:RED LIQUID W/MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:EXHAUSTED PLASTIC CARTRIDGE MAY BE DISPOSED OF
AS PLASTIC WASTE. ENSURE DISPOSAL IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE PROPERLY FITTED RESPIRATOR APPROVED BY
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST
Supplemental Safety and Health
NK
* Product Identification *
Kit Part:Y
Preparer's Name:JULIE TILLOTSO
* Composition/Information on Ingredients *
Ingred Name:AROMATIC POLYISOCYANATE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = 3.7LB/GL LESS WATER
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRITATION TO RESPIRATORY
TRACT, HEADACHE, DIZZINESS, DROWSINESS. EYE: IRRITATION. SKIN:
SENSITIVITY, IRRITATION. CHRONIC: AFFECT ALLERGIC RESPIRATORY/SKIN
REACTION. RESPIRATORY TRACT, CNS, KID NEYS, LIVER, REPRODUCTIVE
SYSTEM, CARDIAC SENSITIZATION.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS.
* First Aid Measures *
REMOVE CLOTHES. WASH W/SOAP & WATER. INGEST: DRI WATER. IN ALL
CASES, GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE AREA &
REMOVE WITH INERT ABSORBENT & NONSPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:CONTAINERS SHOULD BE GROUNDED WHEN
POURING. AVOID FREE-FALL OF LIQUID IN EXCESS OF A FEW INCHES.
Other Precautions:MAKE SURE DRUM IS COMPLETELY EMPTY BEFORE ATTEMPTING
TO WELD OR BRAZE. DRUMS SHOULD BE INDUSTRIALLY CLEANED PRIOR TO
REUSE. DONT FLAME CUT, BRAZE, WELD WITHOUT NIOSH RESPIRATOR OR
APPROPIATE VENTILATI ON.
* Physical/Chemical Properties *
Vapor Density:>AIR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
WATER OR WATER CONTAINING PRODUCTS.
Stability Condition to Avoid:REACT W/WATER OR WATER CONTAINING PRODUCTS
TO GIVE OFF HEAT & FUMES. DONT ALLOW WATER INTO SEALED DRUMS (MAY
EXPLODE).
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON
MONOXIDE/OXIDES NITROGEN. MAY PRODUCE HAZARD FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE,
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PRODUCT/ANY
COMPONENT IS EXCEEDED (SEE TLV/PEL), A NIOSH APPRVD AIR SUPPLIED
RESP IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA
REGS ALSO PERMIT OTHER N IOSH RESP (NEGATIVE PRESSURE TYPE) UNDER
SPECIFIED CNDTNS (SEE MFR SAFETY EQUIP SUPPLIER). ENGINEERING
&/ADMIN CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOS.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN NIOSH
APPROVED FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
SPILL PROC: REFER TO REGULATIONS INFO FOR REPORTABLE QTY & OTHER
REGULATORY DATA.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED. IRRITATING ON
CONTACT WITH SKIN, EYES OR MUCOUS MEMBRANES. VAPOR IRRITATING TO
EYES AND RESPIRATORY PASSAGES.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER. EYES:
INHALATION: REMOVE TO FRESH AIR; GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. INGESTION: IF CONSCIOUS, DRINK WATER AND
INDUCE VOMITING IMMEDIATELY AS DIRECTED BY MEDICAL PERSONNEL. NEVER
GIVE ANYTHING B Y MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:OC
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICALS, OR CO*2.
Fire Fighting Procedures:N/PWEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS TOXIC
FUMES.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNECESSARY PERSONNEL.
WEAR SUITABLE PROT EQUIP LISTED UNDER EXPOSURE/PERSONAL PROTECTION.
ELIM ANY IGNIT SOURCES UNTIL AREA IS DETERM TO BE FREE FROM
EXPOSION/FIRE HAZ. CNTN RELE ASE & ELIM ITS SOURCE, IF THIS CAN BE
DONE W/OUT RISK. TAKE UP & CONTAINERIZE FOR PROPER DISP AS
DESCRIBED UNDER DISP. COMPLY W/FED, STATE, & LOCAL REGULATIONS ON
REPORTING RELS. (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE. DO NOT BREATH VAPOR OR MIST. DO NOT
GET IN EYES, ON SKIN, OR ON CLOTHING.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:VISCOUS, COLORLESS LIQUID.
Percent Volatiles by Volume:NOT AVAIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT; CONTACT WITH COMBUSTIBLES.
Hazardous Decomposition Products:NO*X.
Conditions to Avoid Polymerization:DOES NOT OCCUR.
* Toxicological Information*
Toxicological Information:TOXICOLOGICAL FINDINGS: TESTS ON LABORATORY
ANIMALS INDICATE MATERIAL MAY PRODUCE ADVERSE MUTAGENIC AND
REPRODUCTIVE EFFECTS. CITED IN REGISTRY OF TOXIC EFFECTS OF
CHEMICAL SUBSTANCES (RTECS).
* Disposal Considerations *
Waste Disposal Methods:MATERIAL DOES NOT HAVE AN EPA WASTE NUMBER AND
IS NOT A LISTED WASTE, HOWEVER CONSULTATION WITH A PERMITTED WASTE
DISPOSAL SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONTACT A
PERMITTED WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE WITH ALL
CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: NON-REGULATED. DOT ID
NUMBER: NONE.
* Regulatory Information *
Federal Regulatory Information:TSCA STATEMENT: THE CAS NUMBER OF THIS
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:HOOD.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:IS HAVING DFCLTY BRTHG. IF PATIENT HAS STOPPED BRTHG
ADMIN ARTF RESP. REMOVE & WASH CONTAMD CLTHG. IF PATIENT IS IN
CARDIAC ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL
MED ASSISTANCE HAS ARRIVED. GET MED ATTN IF NECESSARY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:UNDECANOIC ACID, METHYL ESTER; (METHYL UNDECENOATE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:COMBUSTIBLE. CONTACT LENSES SHOULD NOT
BE WORN IN THE LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS-AVOID DIRECT PHYSICAL CONTACT! ACUTE:CAN BE HARMFUL IF
SWALLOWED. CAN BE HARMFUL IF INHAL ED. CAN BE HARMFUL IF ABSORBED
THROUGH THE SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POISON.
IT SHOULD BE ADMIN ONLY BY PHYS/TRAINED EMER PERS. MED ADVICE CAN
BE OBTAINED FROM POIS CTL CTR. INGEST:CALL MD IMMED . EYES:FLUSH
SKIN. INHAL:REMOVE PATIENT TO FRESH AIR. ADMIN OXYG IF PATIENT
(SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA-REGULATED EQUIP.
VENTILATE AREA. ABSORB ON VERMICULITE/SIMILAR MATL. SWEEP UP &
PLACE IN APPROP CNTNR. HOLD FOR DISPOSAL. WASH CONTAMD SURFACES TO
REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE APPROP OSHA/MSHA APPRVD SFTY
EQUIP. AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD & STORE
IN COOL DRY PLACE. STORE ONLY W/COMPAT CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! OUR PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN.
Solubility in Water:NOT KNOWN.
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSAL MUST BE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS.
Ventilation:LOCAL EXHAUST TO MINIMIZE VAPOR CONCENTRATION
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CALCIUM DICHROMATE
Fraction by Wt: 2.0%
OSHA PEL:C, 0.1 MG/M3 (CRO3)
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 5.0%
Ingred Name:MAGNESIUM CHROMATE
Fraction by Wt: 3.0%
OSHA PEL:C, O.1 MG/M3 (CRO3)
* Hazards Identification *
Effects of Overexposure:SKIN IRRITANT.
* First Aid Measures *
First Aid:SKIN:WASH THOROUGHLY W SOAP & WATER;EYES:WASH OUT IMMEDIATELY
W PLENTY OF WATER.GET MEDICAL ATTENTION;INHALATION:REMOVE AFFECTED
INDIVIDUAL TO FRESH AIR;INGESTION:IMMEDIATELY GET MEDICAL HELP.
* Fire Fighting Measures *
Lower Limits:UNK
Extinguishing Media:CO*2,FOAM,DRY CHEM
Fire Fighting Procedures:NONE KNOWN
Unusual Fire/Explosion Hazard:CAN EMIT TOXIC VAPORS.
* Accidental Release Measures *
Spill Release Procedures:SMALL:MOP/WIPE UP W RAGS/PAPER TOWELS.CLEAN
AREA/SURFACE W METHYL ETHYL KETONE USING PROTECTIVE
EQUIPMENTS.LARGE:STOP LEAK W/O RISK.ELIMINATE IGN SOURCES & DIKE
SPILL AREA.PUMP INTO SALVAGE TANK.ABSOR B REMAING LIQ W ABSORBENT &
SHOVEL INTOCONTAINERS
*Handling and Storage *
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
COOL DRY AREA.PROTECT CONTAINER AGAINST PHYSICAL DAMAGE.KEEP AWAY
FROM HEAT,FLAME,ETC.
Other Precautions:AVOID PROLONGED OR REPEATED SKIN CONTACT.
* Physical/Chemical Properties *
HCC:F3
Boiling Pt:B.P. Text:UNK
Vapor Pres:UNK
Vapor Density:UNK
Evaporation Rate & Reference:UNK
Solubility in Water:INSOLUBLE
Appearance and Odor:OLIVE GREEN SYRUP,SLIGHT TOLUENE ODOR
Percent Volatiles by Volume:8.1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CAN REACT W REDUCING MATERIALS
Stability Condition to Avoid:SURCE OF IGNITION
Hazardous Decomposition Products:OXIDES OF SULFUR,HYDROGEN
SULFIDE,FORMIC ACID
* Disposal Considerations *
Waste Disposal Methods:DO NOT INCINERATE LIQUID WASTE &
CONTAINERS(EMTPY/FULL)OF THE PRODUCT.WASTE PRODUCT IN TIGHTYLY
CLOSED CONTAINERS SUITABLE FOR SHIPMENT BE SHIPPED TO DISPOSAL
AREA.DISPOSE OF IAW LOCAL,STATE & FED REG ULATONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT. USE SCBA OR
AIR SUPPLIED RESPIRATOR IN HIGH AIRBORNE CONCENTRATIONS.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:EYEWASH FACILITY & PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, BEFORE
Supplemental Safety and Health
MORE INFORMATION ON FILE.
* Product Identification *
Kit Part:Y
Preparer's Name:DAVID WIENCKOWSKI
* Composition/Information on Ingredients *
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 1-5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Fraction by Wt: 1-5.0%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.1 MG/M3
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.3 PPM/STEL 2.0
Ingred Name:(NON-HAZARDOUS & OTHER INGREDIENTS) PROPRIETARY INGREDIENT
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: IRRITATION.
INHAL: IRRITATION. INGEST: NAUSEA, VOMIT, PAIN, STOMACH UPSET,
DIARRHEA. MAY EFFECT LUNGS & RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:QUARTZ CRYSTALLINE SILICA IS LISTED BY
IARC & NTP & FORMALDEHYDE IS LISTED BY IARC, NTP & OSHA.
Medical Cond Aggravated by Exposure:LUNGS & RESPIRATORY SYSTEM.
* First Aid Measures *
IMMED FLUSH W/WATER, REMOVE CONTAM CLOTHES/SHOES. PROFESSIONALLY
WASH BEFORE REUSE. GET MED AID. INHAL: GET FRESH AIR. GET IMMED MED
AID. I F NOT BREATHING, GIVE ARTIF RESP. INGEST: GET MED AID.
INDUCE VOMIT AS DIRECTED BY DOCTOR. NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:SMALL FIRE: DRY CHEMICAL, CARBON DIOXIDE, HALON,
WATER SPRAY, FOAM. LARGE FIRE: WATER SPRAY, FOG, ALCOHOL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED POSITIVE PRESSURE SCBA
W/FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DURING A FIRE IRRITATING/HIGHLY TOXIC
GASES MAY BE GENERATED.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. STOP SPILL IF SAFE. DIKE. USE
APPROPRIATE SAFETY MEASURES & PROTECTIVE EQUIPMENT. USE SUPPLIED
AIR RESPIRATOR OR SCBA. ABSORB, CONTAINERIZE. REPORT IF REQUIRED.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTED AREA.
Other Precautions:CONTAINER RETAINS RESIDUE. DONT REUSE EMPTY CONTAINER
W/OUT PROFESSIONAL CLEANING.
* Physical/Chemical Properties *
Vapor Pres:NA
Vapor Density:NA
pH:NA
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE.
Appearance and Odor:RED PASTE, W/SULFIDE ODOR.
Percent Volatiles by Volume:2.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, REDUCERS & ACIDS.
Stability Condition to Avoid:NA
Hazardous Decomposition Products:SMOKE, SOOT, CO2, CO, FORMALDEHYDE,
OTHER ALDEHYDES, OXIES OF SULPHUR & HYDROGEN SULFIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL/STATE/LOCAL REGULATIONS.
RECYCLE/REWORK IF FEASIBLE. INCINERATE OR TREAT IF NOT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR CONDITIONS OF USE WHEERE EXPOSURE TO THE
DUST OR MIST IS APPARENT, A HALF-FACE DUST/MIST RESPIRATOR MAY BE
WORN. FOR EMERGENCIES OR INSTANCES WHERE THE EXPOSURE LEVELS ARE
NOT KNOWN USE A FULL-FAC E POSITIVE PRESSURE AIR SUPPLIED
RESPIRATOR. WARNING: AIR-PURIFYING RESPIRATORS DO NOT PROTECT
WORKERS IN OXYGEN-DEFICIENT ATMOSPHERES.
Ventilation:A SYSTEM OF LOCAL &/OR GENERAL EXHAUST IS RECOMMENDED TO
KEEP EMPLOYEE EXPOSURES AS LOW AS POSSIBLE. LOCAL EXHAUST GENERALLY
PREFERRED.
DUSTING POSSIBLE.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING,
WASH FOUNTAIN AND QUICK-DRENCH FACILITIES IN WORK AREA.
Supplemental Safety and Health
CLPJT. NFPA RATINGS: HEALTH: 0 FLAMMABILITY: 1 REACTIVITY: 1 OTHER:
WATER REACTIVE.
* Product Identification *
Product ID:MAGNESIUM METAL, TURNINGS AND RIBBON (SEE SUPPL)
Kit Part:Y
CAGE:0ZGA2
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM METAL
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DUSTS/FUMES MAY IRRITATE
RESPIRATORY TRACT AND MAY CAUSE METAL FUME FEVER. INGESTION:
MAGNESIUM METAL DOES NOT HAVE WELL-CHARACTERIZED TOXICITY. SKIN:
PARTICLES EMBEDDED IN THE SKIN MAY C AUSE ERUPTIONS. EYE: HIGH
CONCENTRATIONS OF DUST MAY CAUSE MECHANICAL IRRITATION. WATCHING A
MAGNESIUM FIRE CAN CAUSE EYE INJURY. CHRONIC: NOR INFORMATION
FOUND.
Explanation of Carcinogenicity:NO
Effects of Overexposure:INHALATION: SYMPTOMS MAY INCLUDE COUGHING,
CHEST PAIN, FEVER, AND LEUKOCYTOSIS. INGESTION: MAY CAUSE
ABDOMINAL PAIN AND DIARRHEA. SKIN: MOLTEN MAGNESIUM MAY CAUSE
SERIOUS SKIN BURNS.
Medical Cond Aggravated by Exposure:EXISTING WOUNDS CONTAMINATED WITH
MAGNESIUM ARE VERY SLOW TO HEAL.
* First Aid Measures *
First Aid:INHALTION:REMOVE TO FRESH AIR. GET MEDICAL ATTENTION FOR ANY
BREATHING DIFFICULTY. INGESTION: DO NOT INDUCE VOMITING. GIVE LARGE
QUANTITIES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PER SON. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: REMOVE ANY
CONTAMINATED CLOTHING. WASH SKIN WITH SOAP OR MILD DETERGENT AND
DEVELOPS OR PERSISTS. EYE: IMMEDIATELY FLUSH EYE WITH PLENTY OF
OCCASIONALLY. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
* Fire Fighting Measures *
Extinguishing Media:USE METAL EXTINGUISHING POWDERS SUCH AS G-1(R)
GRAPHITE POWDER, MET-L-X(R) POWDER, POWDERED TALC, DRY GRAPHITE,
POWDERED SODIUM CHLORIDE, SODA ASH, OR DRY SAND. "SEE OTHER"
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE. FIRE FIGHTERS SHOULD PROTECT TH EIR EYES AND SKIN
FROM FLYING PARTICLES. IN ORDER TO PREVENT EYE INJURY, DO NOT LOOK
DIRECTLY AT MAGNESIUM FIRES.
Unusual Fire/Explosion Hazard:FINE DUST DISPERSED IN AIR IN SUFFICIENT
CONCENTRATIONS, AND IN PRESENCE OF AN IGNITION SOURCE IS A
POTENTIAL DUST EXPLOSION HAZARD. MINIMUM EXPLOSIBLE CONCENTRATION
HYDROGEN GAS AND MAY CAUSE AND EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE THE
AREA OF THE SPILL/LEAK. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT AS SPECIFIED IN EXPOSURE CONTROLS. COLLECT SPILLED
MATERIAL & TRANSFER TO CLEAN, DR Y METAL COVERED CONTAINER FOR
RECOVERY OR DISPOSAL. DO NOT USE WATER IN THE COLLECTION PROCESS.
IF SPILL HAS COME INTO CONTACT WITH WATER, PROCEED WITH CAUTION.
"SEE OTHER INFORMATION".
*Handling and Storage *
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTAINER.
STORE IN COOL, DRY, VENTILATED AREA. PROTECT AGAINST PHYSICAL
DAMAGE. STORE FINELY DIVIDED POWDER, CHIPS OR SHAVINGS IN DETACHED
FIRE RESISTANT BUILDING, PROTECTED FR OM MOISTURE & AWAY FROM
OXIDIZERS, CHLORINE, BROMINE, IODINE, ACIDS, & POSSIBLE SOURCES OF
IGNITION.
Other Precautions:STORE: HEAVIER SECTIONS MAY BE STORED IN THE OPEN.
STORE & USE NEAR IN NO SMOKING AREAS. USE NON-SPARKING TYPE TOOLS &
EQUIPMENT, & EXPLOSION PROOF VENTILATION. CONTAINERS OF THIS
MATERIAL MAY BE HAZ ARDOUS WHEN EMPTY SINCE THEY RETAIN PRODUCT
RESIDUES (DUST, SOLIDS); OBSERVE ALL WARNINGS & PRECAUTI ONS
LISTED.
* Physical/Chemical Properties *
HCC:R2
Vapor Density:NO DATA
pH:NO INFORMATION
Evaporation Rate & Reference:NO DATA (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER SOLID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CARBONATES, CYANIDES, CHLORINATED HYDROCARBONS, SULFATES,
ACIDS AND OTHER MAETALS. REACTS WITH ACIDS TO FORM HYDROGEN GAS.
Stability Condition to Avoid:MOISTURE, HEAT, FLAMES, IGNITION SOURCES
AND INCOMPATIBLES.
Hazardous Decomposition Products:TOXIC GASES AND VAPORS MAY BE RELEASED
IF INVOLVED IN FIRE.
* Toxicological Information*
NORMAL ROUTES OF OCCUPATIONAL EXPOSURE. CANCER LIST: INGREDIENT:
CATEGORY -NONE.
* Ecological Information *
Ecological:ENVIRONMENTAL FATE: NO INFORMATION FOUND. ENVIRONMENTAL
TOXICITY: NO INFORMATION FOUND.
* Disposal Considerations *
Waste Disposal Methods:WHATEVERE CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE HANDLED AS HAZARDOUS WASTE & SENT TO RCRA
APPROVED WASTE FACILITY. PROCESSING, USE OR CONTAMINATION OF
PRODUCT MAY CHANGE WASTE MANAGEMEN T OPTION. STATE & LOCAL DISPOSAL
REGS MAY DIFFER FROM FEDERAL DISPOSAL REGS. DISPOSE OF CONTAINER &
UNUSED CONTENTS I/A/W/ FEDERAL, STATE REGULATIONS.
* MSDS Transport Information *
Transport Information:DOMESTIC (LAND, D.O.T.): PROPER SHIPPING NAME:
I.M.O.): PROPER SHIPPI NG NAME: MAGNESIUM. HAZARD CLASS: 4.1.
* Regulatory Information *
YES. CHRONIC: NO. FIRE: YES PRESSURE: NO. REACTIVITY: YES (PURE /
SOLID) .
CODE: 4[Y]. POISON SCHEDULE: NO INFORMATION FOUND. WHMIS: THIS
MSDS HAS BEEN PREPARED ACCORDING TO THE HAZARD CRITERIA OF THE
CONTROLLED PRODUCTS REGULATIONS (CPR) & THE MSDS CONTAINS ALL OF
THE INFORMATION REQUIRED BY THE CPR.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE
BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT THE ARC, OR BOTH, TO KEEP
FUMES & GASES BELOW TLV'S IN WORKER'S BRTHG ZONE & GEN AREA.
Other Protective Equipment:EMER EYE WASH & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR HEAD, HAND & BODY PROT WHICH HELP TO
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:USED, COATINGS, NUMBER OF WORKERS, QUALITY & AMT OF
VENT, CONTAM IN ATM. FUMES & GASES MAY VARY IN FORM & PERCENT FROM
INGS LISTED. REAS EXPECTED FUME CONSTITUENTS FROM THESE PRODS WOU
LD INCL FLUORIDES & COMPLEX OXIDES OF INGS. GASEOUS RXN PROD MAY
INCL CARBON MONOXIDE & CARBON DIOXIDE. OZONE & (ING 7)
* Product Identification *
Product ID:CUTTING ELECTRODE
* Composition/Information on Ingredients *
Ingred Name:IRON (III) OXIDE; (IRON OXIDE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:MANGANESE (SARA III)
OSHA PEL:5 MG/M3, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATE)
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM SILICATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATE
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SUPP DATA:NITROGEN OXIDES MAY BE FORMED BY THE RADIATION
FROM THE ARC.
Ingred Name:EYE PROT:LENS. AS A RULE OF THUMB, START W/SHADE WHICH IS
Ingred Name:ING 9:SHADE WHICH GIVES SUFFICIENT VIEW OF WELD ZONE.
Ingred Name:OTHER PROT EQUIP:PVNT INJURY FROM RADIA, SPKS & ELEC SHOCK.
SUBSTANTIAL CLOTHING.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT
IN DISCOMFORT SUCH AS: DIZZINESS, NAUSEA OR DRYNESS/IRRITATION OF
NOSE, THROAT OR EYES. CHRONIC :LONG-TERM OVEREXPOSURE MAY LEAD TO
SIDEROSIS (IRON DEPOSITS IN LUNG) & IS BELIEVED BY SOME (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INVESTIGATORS TO AFFECT PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
* First Aid Measures *
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY THE AMERICAN RED CROSS. INGEST:CALL MD IMMEDIATELY .
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE: WELDING ARC & SPARKS CAN
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF
FUMES. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS & TO
INSULATE HIMSELF FROM WORK & GROUND.
Other Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LBL ON
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMPOSITION & QTY OF FUMES & GASES ARE
DEPENDENT UPON METAL BEING WELDED, PROCESS, PROCS, ELECTRODES USED,
GASES(SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | gloves_mandatory |