text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:FORMULA 84 H2-017
Preparer's Name:DAVID SCHMETTERER
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS/66 (VAPOR PRESSURE 3.4 MM HG)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:ZINC MOLYBDATE
CAS:22914-58-5
Fraction by Wt: 5.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:10 MG/M3
Ingred Name:100 SOLVENT (VAPOR PRESSURE 9 MM HG)
CAS:64742-95-6
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:VOC: <340 GPL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE TOXICITY, ERSULT IN HEADACHE,
DIZZINESS, NAUSEA, & LOSS OF CONSCIOUSNESS. SEVERE EYE IRRITATION
POSSIBLY RESULTING IN PERMANENT DAMAGE. IRRITATED MUCOUS MEMBRANES.
VOMITING DUE TO INGESTION. DEF ATTING & DRYING OF SKIN, WHICH MAY
RESULT IN IRRITATION & DERMATITIS. SENSITIZATION AFTER REPEATED
CONTACT.
======================= First Aid Measures =======================
First Aid:NEVER GIVE UNCONSIOUS LIQUID. EYE:FLUSH W/WATER 15 MIN
HOLDING EYELIDS OPEN.GET MED AID. INHAL:REMOVE TO FRESH AIR.GIVE
OXYGEN IF BREATHING DIFFICULT.GIVE ARTIF RESP IF NOT BREATHING.GET
MED AID.KEEP WARM & COMFORTABLE. INGEST:CALL DR IMMED.ONLY INDUCE
VOMIT ON DR'S INSTRUCTIONS.IF VOMITING OCCURS SPONTANEOUSLY,KEEP
HEAD BELOW HIPS TO PREVENT ASPIRATION. SKIN:FLUSH W/H2O WHILE
REMOVING CONTAM **
===================== Fire Fighting Measures =====================
Flash Point:110F,43C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO COOL EXPOSED CONTAINER, &
TO KEEP FLAMMABLE STRUCTURES WET. DON'T ENTER FIRE AREA WITHOUT
PROTECTION BECAUSE DECOMP PRODUCT MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITIOIN
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DI SPOSAL.
Neutralizing Agent:N/K ** CLOTHES & SHOES. FOLLOW BY WASHING W/SOAP &
H2O. DON'T REUSE CLOTHES ***
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTBL.STORE IN COOL,DRY PLACE IN
BLDG FOR COMBUST STORAGE.WARNING:HOT ORGANIC CHEM VAPOR/MIST
SUSCEPTIBLE TO SPONTANEOUS COMBUSTN WHEN MIXED W/AIR
Other Precautions:IGNIT MAY OCCUR AT TEMP BELOW AUTOIGNIT/IGNIT
TEMPS.IGNIT TEMPS DECREASE W/INCREASING VAPOR VOLUME & VAPOR/AIR
CONTACT TIME & INFLUENCED BY PRESSR CHANGE.IGNIT MAY OCCUR AT
ELEVATED TEMP,ESPECIALLY IN VACUUM IF SUDDEN INGRESS AIR OR #
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATORS
WHERE VENTILATION IS INADEQUATE.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
# OTHER PRECAUTIONS CONT'D: OUTSIDE PROCESS EQUIPMENT OPERATING UNDER
ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPOR OR MIST TO THE
ATMOSPHERE OCCURS. ANY PROPOSED USE SHOULD BE THOROUGHLY EVALUATED
TO A SSURE THAT SAFE OPERATING CONDITIONS ARE ESTABLISHED AND
MAINTAINED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308 TO 396F
Vapor Density:> AIR
Spec Gravity:1.56
Viscosity:90 KU
Evaporation Rate & Reference:0.13 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW LIQUID / SOLVENT ODOR
Percent Volatiles by Volume:40.5
Corrosion Rate:NOT CORR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, &
INCOMPATIBILITIES. ALSO AIRCRAFT TRANSPORT MUST BE IN STRICK
ACCORDANCE W/REGULATIONS
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE, AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY. EPA HAZARDOUS WASTE CODE: D001, IGNITABLE.
*** OR SHOES UNTIL C LEANED. IF IRRITATION PERSISTS, GET MEDICAL
AID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AT143 ALPHA CRYL AT BASES & COLORS W/O LEAD
CAGE:0PK40
CAGE:0PK40
CAGE:BASSF
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 9%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-1*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 29%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 19%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL BENZYL PHTHALATE, BBP, BENZYL BUTYL PHTHALATE
1,2-BENZENEDICARBOXYLIC ACID, BUTYL PHENYLMETHYL ESTER
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: 8%
Other REC Limits:5 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *96-1*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 4.8-6.8 LBS/GAL; 572-811 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC, RESPIRATORY
TRACT IRRITANT/NERVOUS SYSTEM DEPRESSION. INGESTION: GI IRRITANT.
ASPIRATION OF MATERIAL INTO LUNGS MAY RESULT IN CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL. SKIN: IRR ITATION, ABSORPTION.
EYES: IRRITATION. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY
CAUSE PERMANENT CNS CHANGES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHES, NAUSEA, LOSS OF
CONSCIOUSNESS, VOMITING
======================= First Aid Measures =======================
First Aid:INHALATION: RESTORE BREATHING. REMOVE TO FRESH AIR. KEEP
WARM/QUIET. EYES: FLUSH IMMEDIATELY W/COPIOUS AMOUNTS OF RUNNING
WATER FOR 15 MINS. SKIN: CLEAN & WASH W/WATER. INGESTION: DON'T
INDUCE VOMITIN G. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:-5 TO 5F
Lower Limits:0.5
Upper Limits:19
Extinguishing Media:FOAM, CO2, CHEMICAL POWDER
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT W/SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTEME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES OF
IGNITION. CONFINE LEAK W/INERT ABSORBENT & CLEAN UP WITH
SPARK-PROOF TOOLS. AVOID PROLONGED BREATHING OF VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED AGAINST FLAMMABLE
LIQUIDS. USE STATIC LINES WHEN MIXING & TRANSFERRING.
Other Precautions:DON'T ALLOW MATERIAL TO FREE FALL MORE THAN FIVE
INCHES. FOR INDUSTRIAL USE ONLY. DON'T TAKE INTERNALLY. DON'T FLAME
CUT, WELD/BRAZE ON COATED METAL W/O NIOSH/MSHA TC23C RESPIRATOR.
AVOID PROLONGED BR EATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA TC23C CHEMICAL/MECHANICAL TYPE
FILTER SYSTEM TO REMOVE A COMBINATION OF PARTICLES, GAS & VAPORS.
USE AN AIR SUPPLIED RESPIRATOR IF NECESSARY.
Ventilation:LOCAL EXHAUST/GENERAL MECHANICAL.
Supplemental Safety and Health
MISUSE BY CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL/FATAL.
KEEP CONTAINERS TIGHTLY CLOSED. AVOID IGNITION SOURCES. PREVENT
PROLONGED SKIN CONTACT TO CONTAMINATED COTHING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133-410F
Vapor Pres:19-90.86
Vapor Density:>1
Evaporation Rate & Reference:(ETHER=1): <1
Appearance and Odor:LIQUID, VARIOUS COLORS W/AROMATIC ODOR
Percent Volatiles by Volume:69-95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID, ALKALIES, & OXIDIZERS
Stability Condition to Avoid:HEAT, OPEN FLAMES, STATIC ELECTRICITY,
SPARKS, ELECTRICAL EQUIPMENT & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, CO, CARBON SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL/INCINERATE IN APPROVED FACILITY BY
LICENSED CONTRACTOR. DON'T INCINERATE IN CLOSED CONTAINER. DISPOSE
OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. UN1263.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GERMI-KLEEN NON-ACID BOWL & BATHROOM DISINFECTANT #1715
Preparer's Name:F.C.
CAGE:93607
CAGE:93607
============= Composition/Information on Ingredients =============
Ingred Name:TETRASODIUM ETHYLENE DIAMINE TETRAACETATE
CAS:64-02-8
RTECS #:AH5075000
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL (SARA 313)
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:2(2-ETHOXYETHOXY) ETHANOLDIETHYLENE GLYCOL MONOETHYL ETHER
CAS:111-90-0
RTECS #:KK8750000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT EST.NK
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THOROUGHLY W/WATER >15 MINUTES. GET MEDICAL AID.
SKIN: FLUSH THOROUGHLY W/WATER. IF IRRITATION PERSISTS GET MEDICAL
AID. INGESTION: DO NOT INDUCE VOMITING. GIVE MILK, EGG WHITE,
GELATIN, OR IF NONE OF THESE AVAILABLE LARGE AMOUNTS WATER. GET
IMMEDIATE MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE TO BOILING
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RECONTAINERIZE BY MOPPIN, WET VACUUM OR USING
SUITABLE ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40 & 140F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR SALE TO, USE &
STORAGE BY SERVICE PERSONNEL ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:TO WATER
Vapor Density:TO WATER
Spec Gravity:0.96
Evaporation Rate & Reference:TO WATER
Solubility in Water:COMPLETE
Appearance and Odor:GREEN LIQUID, GIANE (TM) FRESH ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON OXIDES & AMINES
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE, FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:URESOLVE PLUS
Preparer's Name:JAY W. PARTON
CAGE:FO122
CAGE:FO122
CAGE:27908
============= Composition/Information on Ingredients =============
Ingred Name:2-METHOXYETHANOL (EGME) (SARA III)
CAS:109-86-4
RTECS #:KL5775000
Fraction by Wt: 60-80%
Other REC Limits:16 PPM
OSHA PEL:S, 25 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 2-4%
Other REC Limits:2 MG/CUM (CEILING)
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: IRRITATION. INHALATION:
HEADACHE, DIZZINESS, DROWSINESS, FATIGUE, NAUSEA, VOMITING, TREMOR,
CONFUSION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: OVEREXPOSURE MAY CAUSE INJURY TO
BONE MARROW & BLOOD CELLS, KIDNEY, LIVER, & TESTES.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN & CALL PHYSICIAN. EYES: FLUSH W/WATER FOR 15 MINS. CALL
PHYSICIAN. SKIN: REMOVE CONTAMINATED CLOTHING/FLUSH W/WATER.
INGESTION:INDUCE VOMITING. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:135F
Lower Limits:2.5%
Upper Limits:19.8%
Extinguishing Media:WATER SPRAY, CO2, ALCOHOL FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE EQUIPMENT. SMALL
SPILLS SHOULD BE FFLUSHED W/LARGE QUANTITIES OF WATER. LARGES
SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T BREATHE VAPOR, USE WITH ADEQUATE
VENTILATION. DON'T GET IN EYES, ON SKIN, OR CLOTHING. ACCIDENTAL
CONTACT SHOULD BE WASHED AWAY IMMEDIATELY.
Other Precautions:KEEP AWAY FROM HEAT/FLAME. KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR HIGH
CONCENTRATIONS.
Ventilation:LOCAL EXHAUST: WELL VENTILATION AREA. MECHANICAL: EXHAUST
HOOD
Other Protective Equipment:IMPERMEABLE APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:256F
Vapor Pres:6.2
Vapor Density:2.62
Spec Gravity:0.97
Evaporation Rate & Reference:(BU AC = 1) 0.62
Solubility in Water:COMPLETE
Appearance and Odor:BLUE TO GREEN LIQUID, SLIGHT PLEASANT ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAME, IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE FEDERAL, STATE, AND LOCAL REGULATIONS. COMBUSTIBLE
LIQUID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BARIUM SULFATE BARIMITE XF, BARIMITE UF
Preparer's Name:QUALITY ASSURANCE DEPT
CAGE:TO910
CAGE:TO910
============= Composition/Information on Ingredients =============
Ingred Name:BARITE
CAS:7727-43-7
RTECS #:CR0600000
Minumum % Wt:94.
Maxumum % Wt:100.
OSHA PEL:5 MG/M3 TWA (RESP DU
ACGIH TLV:10 MG/M3 TOTAL DUST
Ingred Name:QUARTZ. CRYSTALLINE SILICA.
CAS:14808-60-7
RTECS #:VV7330000
< Wt:.04
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BARITE, A NUISANCE DUST. ACUTE
EXPOSURE: INHALATION: INHALATION OF FINE BARITE DUST MAY CAUSE
IRRITATION OF THE NOSE AND THROAT BY MECHANICAL ACTION. SKIN
CONTACT: DIRECT CONTACT MAY CAUSE SLIGHT DRYN ESS, OR MAY CAUSE
MILD IRRITATION IF AN ALLERGIC PREDISPOSITION EXISTS. EYE CONTACT:
DIRECT CONTACT WITH DUST MAY CAUSE MECHANICAL IRRITATION OF EYES.
INGESTION: BARITE IS CONSIDERED TO BE RELATIVELY NON-TOXIC DUE TO
NON-ABSORPTION. CHRONIC EXPOSURE: INHALATION: PROLONGED OR REPEATED
INHALATION MAY CAUSE BARITOSIS, A BENIGN PNEUMOCONIOSIS. SKIN
CONTACT: NO DATA AVAILABLE. EYE CONTACT: NO DATA AVAI LABLE.
INGESTION: NO DATA AVAILABLE.
Explanation of Carcinogenicity:PRODUCT CONTAINS QUARTZ (CRYSTALLINE
SILICA) WHICH IS A KNOWN CARCINOGEN. IT IS HOWEVER PRESENT AT LESS
THAN 0.1%.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE TO FRESH AIR. IF BREATHING
HAS STOPPED, PERFORM ARTIFICIAL RESPIRATION, & GET MEDICAL
ATTENTION IMMEDIATELY. KEEP PERSON WARM & AT REST. TREAT
SYMPTOMATICALLY & SUPPOR TIVELY. SKIN: APPLY COMMON SKIN
MOSITURIZERS TO RELIEVE DRYNESS. IRRITATIONS ARE UNCOMMON; HOWEVER,
IF IRRIT/REDNESS DEVELOPS, SEEK MEDICAL ATTENTION. BROKEN SKIN MAY
BE CLEANED WITH MILD SOAP & WATER . EYES: WASH WITH LARGE AMOUNTS
OF WATER OR NORMAL SALINE SOLUTION. IF IRRITATION OR REDNESS
DEVELOPS, SEEK MEDICAL ATTENTION. INGEST: TREAT SYMPTOMATICALLY &
SUPPORTIVELY. IF VOMIT OCCURS, KEEP HEAD LOWER THAN HIPS TO
PREVENT ASPIRATION.
===================== Fire Fighting Measures =====================
Flash Point:NONE.
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS INDICATED.
Neutralizing Agent:N/P.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: PRESERVE IN SEALED CONTAINERS
TO PREVENT DISPERSION OF DUST IN AIR. OBSERVE ALL FEDERAL, STATE
AND LOCAL REGULATIONS WHEN STORING THIS SUBSTANCE. FOR ASSISTANCE
DETERMINING PROPER STORAGE OR DISPOSAL PROCEDURES, CONTACT THE
DISTRICT DIRECTOR OF THE ENVIRONMENTAL PROTECTION AGENCY.
Other Precautions:N/P.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE FOLLOWING RESPIRATORS ARE RECOMMENDED BASED
ON INFO FOUND IN PHYSICAL DATA, TOXICITY & HEALTH EFFECTS SECTIONS.
THEY ARE RANKED IN ORDER FROM MINIMUM TO MAXIMUM RESP PROTECTION.
SPECIFIC RESPIRATO R SELECTED MUST BE BASED ON CONTAM LEVELS IN
WORK PLACE, THE SPECIFIC OPERATION, MUST NOT EXCEED WORK LIMITS OF
RESPIRATOR AND BE NIOSH (ECOLOGICAL INFORMATION)
Ventilation:LOCAL EXHAUST OR PROCESS ENCLOSURE VENTILATION TO MEET
PUBLISHED EXPOSURE LIMITS.
REQUIREE BUT (SUPP DATA)
DUST (SUPP DATA)
Other Protective Equipment:WHERE THERE IS POSSIBILITY THAT EYE MAY BE
EXPOSED TO BULK QUANTITIES/ HIGH CONCENTRATION OF AIR-BORN DUST OF
SUBSTANCE, PROVIDE EYEWASH FOUNTAIN MEETING ANSI DESIGN CRITERIA
WITHIN IMMEDIATE WORK AREA.
Work Hygienic Practices:CLOTHING: PROTECTIVE CLOTHING IS NOT REQUIRED
(MFR).
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES (CONT'D): HARDNESS: 2.5 - 3.5 MOHS.
TO PREVENT EYE CONTACT WITH BULK QUANTITIES OR HIGH CONCENTRATIONS
OF AIR-BORN DUST OF THIS SUBSTANCE (MFR).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE.
Spec Gravity:4.3 - 4.5
Solubility in Water:INSOLUBLE.
Appearance and Odor:WHITE TO TAN COLORED POWDER. ODOR: NONE SPECIFIED
BY MANUFACTURER .
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBILITIES: WITH POWDERED ALUMINUM, VIOLENTLY EXPLOSIVE; WITH
PHOSPHORUS (PRIMED WITH POTASSIUM NITRATE-CALCIUM SILICIDE),
IGNITES.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. CONDITIONS TO AVOID: N/P.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC AND HAZARDOUS OXIDES OF SULFUR AND BARIUM.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION HAS NOT
BEEN REPORTED TO OCCUR UNDER NORMAL TEMPERATURES AND PRESSURES.
=================== Toxicological Information===================
Toxicological Information:TOXICITY DATA: TUMORIGENIC DATA (RTECS),
MUTAGENIC DATA (RTECS). EXPOSURE LIMIT: BARITE: OSHA TWA TOTAL
DUST: 10 MG/M3.
===================== Ecological Information =====================
Ecological:N/P. RESPIRATORY PROTECTION (CONT'D): APPROVED: ANY DUST &
MIST RESPIRATOR W/FULL FACEPIECE; ANY AIR PURYFYING FULL FACEPIECE
RESPIRATOR W/ HIGH EFFICIENCY PARTICULATE FILTER; ANY POWERED AIR
PURYFYIN G RESPIRATOR W/TIGHT FITTING FACEPIECE & HIGH EFFICIENCY
PARTICULATE FILTER.; ANY TYPE 'C' SUPPLIED-AIR RESPIRATOR W/FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE
MODE OR WITH A FULL FACEPIECE, HELMET OR HOOD OPERATED IN
CONTINUOUS-FLOW MODE; ANY SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DRY MATERIAL CAN BE LANDFILLED. WET MATERIAL CAN
BE SEWERED, IF QUANTITIES ARE SMALL AND DILUTED ENOUGH THAT
SLURRIES OR GELS WILL NOT CAUSE DRAIN SYSTEM BLOCKAGE. OBSERVE ALL
FEDERAL, STATE AND LOCA L REGULATIONS WHEN DISPOSING OF THIS
SUBSTANCE. BARITE IS NOT CONSIDERED A HAZARDOUS WASTE BY RCR A
CRITERIA (40CFR261).
=================== MSDS Transport Information ===================
Transport Information:D.O.T. CLASS: THIS SUBSTANCE IS NOT REGULATED AS
HAZARDOUS MATERIAL BY DOT.
===================== Regulatory Information =====================
SARA Title III Information:BARITE WAS ORIGINALLY SUBJECT TO SECTION 313
REPORTING REQUIREMENTS BECAUSE IT MET THE DEFINITION OF A BARIUM
COMPOUND. ON 6/24/94, THE EPA EXEMPTED BARITE FROM REPORTING
REQUIREMENTS AFTER REVIEWING AVAILABLE DATA ON THE HEALTH AND
ENVIRONMENTAL EFFECTS OF BARITE. REPORTING REQUIREMENTS (40 CFR
PART 372.22) ARE RESCINDED.
Federal Regulatory Information:ALL INGREDIENTS ARE ON THE TSCA CHEMICAL
SUBSTANCE INVENTORY.
State Regulatory Information:SUBSTANCES ON THE NEW JERSEY WORKPLACE
HAZARDOUS SUBSTANCES LIST PRESENT AT A CONCENTRATION OF 1% OR MORE
(0.1% FOR SUBSTANCES IDENTIFIED AS CARCINOGENS, MUTAGENS OR
TERATOGENS): QUARTZ, P. 113; BARIT E, P. 14.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-P-664C RUST INHIBITING PRIMER
CAGE:80592
CAGE:80592
============= Composition/Information on Ingredients =============
Ingred Name:ZINC CHROMATE
CAS:13530-65-9
RTECS #:GB3290000
Fraction by Wt: 4.0%
Other REC Limits:0.05MG/M3
OSHA PEL:0.1 MG/M3 (CRO3)
ACGIH TLV:0.01MG/M3(CR)A1;9192
Ingred Name:ALKYD
Fraction by Wt:
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD DRIER (OSHA PEL FROM 29CFR 1910.1025)
Fraction by Wt: 0.13%
Other REC Limits:0.05MG/M3
OSHA PEL:0.05 MG/M3 (PB)
ACGIH TLV:0.15 MG/M3 (PB);8990
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2.1%
Other REC Limits:100PPM
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.2%
Other REC Limits:100PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 24.6%
Other REC Limits:300 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 6.3%
Other REC Limits:50PPM
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 3.7%
Other REC Limits:50PPM
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
SECTION .
Explanation of Carcinogenicity:ZINC CHROMATE:ACGIH:SUSPECT HMN
CARC.IARC:HMN CARC(GROUP 1);NTP:CHROM-N-CERT CHROM CMPDS:KNOWN
CARCINOGEN;OSHA:NO.
Effects of Overexposure:IRRITATION TO EYES; NOSE AND THROAT NEAR OR
ABOVE 50PPM FROM VAPORS. HIGHER CONCENTRATIONS COULD CAUSE DEATH
FROM EXPLOSION OR FROM BREATHING.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/PLENTY OF WTR FOR 15MIN AND CALL A
PHYSICIAN.INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING GIVE
ARTIFICIAL RESP;PREF MOUTH TO MOUTH.CALL A PHYSICIAN.INGESTION:CALL
A PHYSICIAN IMM EDIATELY. DO NOT INDUCE VOMITING. SKIN:WASH
THOROUGHLY WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:50F/10C
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:FOAM, DRY CHEMICAL, WATER
Fire Fighting Procedures:SELF-CONT BREATH APP,WATER FOG TO COOL EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT, SPARKS, FLAME
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF
IGNITION(FLAMES,ELECTRICAL,STATIC/FRICT SPK,HOT
SURFACES,ETC.).AVOID BRTH OF VAPORS.VENT AREA.CONT & SCOOP UP SPILL
W/NON-SPARK TOOLS,RAGS,ETC.USE INERT ABSORB MATL ON SMALL SPIL LS
OR ON RESIDUALS OF LARGE SPILLS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLO & UPRGHT TO PVNT
LEAK.AVOID FLM,WELD,SMK,SPK,OPEN LGHT,ETC.AVOID BRTH OF VAPOR/SPR
MST.AVOID EYE & SKIN CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK/PIT W/OUT ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR CANISTER WHERE OXYGEN CONTENT IS
ADEQUATE AND VAPOR CONCENTRATION IS LESS THAN 2% OR USE AIR
SUPPLIED FACE MASKS.
Ventilation:LOCAL/MECHANICAL EXHAUST
Other Protective Equipment:N/K
Work Hygienic Practices:SEE OTHER PRECAUTIONS
Supplemental Safety and Health
PH:N.RT OF ENTRY:FPN
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Spec Gravity:0.8
pH:N/K-FP
Evaporation Rate & Reference:MOD FAST (N-BU-AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED VISCOUS LIQUID WITH TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:63.4
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:N/K
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:302 ZINC WIRE
CAGE:12673
CAGE:12673
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 99.99%
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV: 5 MG/CUM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AVOID BREATHING DUST DURING SPRAYING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:FOR EXACT PHYSIOLOGICAL EFFECTS REFERENCE
SHOULD BE MADE TO AUTHORITATIVE SOURCES SUCH AS "DANGEROUS
PROPERTIES OF INDUSTRIAL MATERIALS" BY N. IRVING SAX.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:1662F
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUISH WHITE--NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:W/B ACRYLIC ENAMEL YELLOW, 728Y037
CAGE:04GC9
CAGE:04GC9
CAGE:0RGC9
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL). VP:0.8 @ 68F
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 8%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER). VP:0.0 @ 68F
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHTHALIC ACID, BENZYL BUTYL ESTER; (BUTYL BENZYL PHTHALATE)
(SARA 313) (CERCLA). VP:0.2 @ 302F
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: <5.0%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZOIC ACID, AMMONIUM SALT; (AMMONIUM BENZOATE) (CERCLA)
CAS:1863-63-4
RTECS #:DG3378000
Fraction by Wt: <5.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIUM HYDROXIDE (CERCLA). VP:420.0 @ 60F
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <5.0%
OSHA PEL:N/K
ACGIH TLV:25 PPM (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHANOL, 2-(2-METHOXYETHOXY)-; (DIETHYLENE GLYCOL
MONOMETHYL ETHER). VP:0.1 @ 20F
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: <0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC CONTENT. COATING:1.99 LB/GL (239 G/L).
MATERIAL:0.83 LB/GL (99 G/L)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO.
90-118) . ACUTE:INHAL:CONCENTRATED VAPORS MAY BE HARMFUL. MAY CAUSE
HDCH, DIZZ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:& NAUS. SKIN & EYE CONT:MAY CAUSE
IRRIT TO BOTH. SKIN ABSORP:MAY CAUSE IRRIT. INGEST:MAYBE HARMFUL IF
SWALLOWED. CHRONIC:NONE LISTED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN AND
RESPIRATORY DISORDER MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH IMMED W/LG AMTS OF
WATER FOR @ LEAST 15 MINS. SKIN:WASH AFFECTED AREAS W/SOAP & WATER.
REMOVE CONTAMD CLTHG. INGEST:DO NOT INDUCE VOMIT. GET MEDICAL
ATTENTION IMM EDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Lower Limits:0.3%
Upper Limits:10.6%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL WILL NOT SUSTAIN COMBUST UNLESS
WATER HAS EVAP. FIRE-EXPOS CNTNRS SHOULD BE COOLED W/WATER TO PVNT
PRESS BUILD-UP WHICH COULD RSLT IN CNTNR RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT & PROVIDE VENT. LG
SPILLS MAY BE SCOOPED UP W/NON-SPARKING TOOLS. SM SPILLS MAY BE
PICKED UP W/ABSORB MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HIGH TEMPERATURES AND
OPEN FLAMES. KEEP CONTAINERS TIGHTLY CLOSED. DO NOT TAKE
INTERNALLY. AVOID PRLONGED CONT WITH SKIN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF POOR VENTILATION, USE NIOSH/MSHA
APPROVED ORGANIC VAPOR MASK.
Ventilation:ADEQUATE VOLUME & PATTERN TO KEEP AIR CONTAMINANT
CONCENTRATION BELOW CURRENT APPLIC OSHA/ACGIH'S TLV LIMITS.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>195F,>91C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:YELLOW LIQUID WITH MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN TIGHTLY CLOSED CONTAINERS. INCINERATE
OR DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:9515101-9515108 SPECTRUM SHOULDER PORCELAIN
CAGE:16969
CAGE:8T797
CAGE:16969
============= Composition/Information on Ingredients =============
Ingred Name:CERAMIC FRIT
Fraction by Wt: MAJOR
ACGIH TLV:10 MG/CUM GLASS DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST MAY ALLOW METALS WITHIN FRIT TO
BE LEACHED WHILE IN THE DIGESTIVE TRACT/GLASSY POWDERED MATERIAL
CARRIES WITH IT THE DANGER OF POSSIBLE SILICEOUS (DISEASE OF
LUNGS)-LIKE EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DUST MAY ALLOW METALS WITHIN FRIT TO BE LEACHED
WHILE IN THE DIGESTIVE TRACT/GLASSY POWDERED MATERIAL CARRIES WITH
IT THE DANGER OF POSSIBLE SILICEOUS (DISEASE OF LUNGS)-LIKE
EFFECTS.
Medical Cond Aggravated by Exposure:LUNG DISEASE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM DUSTY AREA. SKIN: WASH W/SOAP &
WATER. EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NO FIRE HAZARD
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE AS NORMAL SOLID WASTE. SCOOP UP & PLACE
IN APPROPRIATELY MARKED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM FOOD & DRINK. WASH
HANDS BEFORE EATING. THIS MATERIAL SHOULD BE HANDLED & USED ONLY IN
A MANNER CONSISTENT W/THE PRODUCT INSTRUCTIONS.
Other Precautions:EFFORTS SHOULD BE MADE TO MINIMIZE EXPOSURE &
ENCOURAGE GOOD PERSONAL HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED FOR DUSTS & MISTS.
Ventilation:USE LOCAL EXHAUST OR OTHER MEANS TO MINIMIZE DUST EXPOSURE.
Work Hygienic Practices:ENCOURAGE GOOD PERSONAL HYGIENE. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:72828 - KARALLOY BRAZING ALLOY
CAGE:GO039
CAGE:5L381
CAGE:GO039
============= Composition/Information on Ingredients =============
Ingred Name:SUPDAT:TO FUME PLUME, AS WELL AS PRESENCE OF CONTAMS IN ATM
(SUCH AS CHLORINATED HYDROCARBON VAPS FROM CLEANING (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:& DEGREASING ACTIVITIES). WHEN ROD IS CONSUMED, FUME
& GAS DECOMP PRODS ARE DIFF IN PERCENT & FORM FROM (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:INGS LISTED. FUME & GAS DECOMP PRODS, NOT INGS IN
ROD, ARE IMPORTANT. DECOMP PRODS INCL THOSE ORIGINATING(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:FROM VOLATILIZATION, RXN/OXIDIATION OF MATLS SHOWN
IN INGS SECTION PLUS THOSE FROM BASE METAL, COATING, (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:ETC. THESE COMPONENTS ARE VIRTUALLY ALWAYS PRESENT
AS COMPLEX CMPDS & NOT AS METALS. REAS EXPECTED FUME (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:CONSTITUENTS WOULD INCL FLUORIDES & COMPLEX OXIDES
OF IRON, ALUMINUM, MANGANESE, SILICON, NICKEL, COPPER.(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:GASEOUS RXN PRODS MAY INCL CARBON MONOXIDE & CARBON
DIOXIDE. OZONE & NITROGEN OXIDES MAY BE FORMED BY (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:RADIATION OF THE ARC.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:REPORT ON CARCINS, 1991:ANTIC TO BE
CARCIN. HUMAN:LUNGS, NASAL CAVITIES.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:LENS. AS A RULE OF THUMB, START W/SHADE WHICH IS
TOO DARK TO SEE WELD ZONE. THEN GO TO NEXT LIGHTER (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:SHADE WHICH GIVES OFF SUFFICIENT VIEW OF WELD ZONE.
PROVIDE SCREENS & FLASH GOGGS, IF NEC, TO SHIELD OTHERS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:INCLUDE ARM PROTECTORS, APRONS, HATS,
SHOULDER PROTECTION, AS WELL AS DARK SUBSTANTIAL CLOTHING.
RTECS #:9999999ZZ
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
OSHA PEL:10 MG/M3 (ZNO)
ACGIH TLV:10 MG/M3 (ZNO)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:IRON (MFR CAS #7440-89-6)
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TIN (MFR CAS #7440-3-5)
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM (SARA III) (MFR CAS #7429-90-4)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/M3 DUST;5 FUME
ACGIH TLV:10 MG/M3 DUST
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT
IN DISCOMFORT SUCH AS:DIZZINESS, NAUSEA OR DRYNESS OR IRRITATION OF
NOSE, THROAT OR EYES. CHRON IC:LONG-TERM OVEREXPOSURE MAY LEAD TO
SIDEROSIS (IRON DEPOSITS IN LUNGS) & IS BELIEVED BY SOME (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON EVALUATION OF
CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP 2B. NTP 6TH
ANNUAL(ING 18)
Effects of Overexposure:HLTH HAZ:INVESTIGATORS TO AFFECT PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY AMERICAN RED CROSS. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:I
MMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK
ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD
.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:BRAZING SPARKS CAN IGNITE COMBUSTIBLES.
REFER TO ANSI 249.1 FOR FIRE PREVENTION DURING WELDING.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PRECAUTIONARY LBL ON THIS PROD. SEE ANSI Z-49.1, SAFETY IN WELDING
& CUTTING.
Other Precautions:TRAIN THE WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS & TO INSULATE
HIMSELF FROM WORK & GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE
BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT THE ARC, OR BOTH, TO KEEP
FUMES & GASES BELOW TLV'S IN WORKER'S BRTHG ZONE & GEN AREA.
Other Protective Equipment:WEAR HEAD, HAND & BODY PROT WHICH HELP TO
PVNT INJURY FROM RADIA, SPKS & ELEC SHOCK. SEE ANSI Z-49.1. THIS
MAY (ING 21)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:PROCESS, PROCS & RODS USED. OTHER CNDTNS WHICH ALSO
INFLUENCE COMPOSITION & QTY OF FUMES & GASES TO WHICH WORKERS MAY
BE EXPOS INCL:COATINGS ON METAL BEING WELDED(SUCH AS PAINT, PLATIN
G/GALVANIZATION), NUMBER OF WELDS & VOLOF WORK AREA, QUALITY & AMT
OF VENT, POSITION OF WELDER'S HEAD W/RESPECT(ING 10)
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BRAZING FUMES CANNOT BE SIMPLY
CLASSIFIED. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON METAL
BEING BRAZED, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:184 5650,INDUSTREX DEVLPR REPL,PART-C
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-75%
Ingred Name:GLUTARALDEHYDE-BIS-BISULFITE
CAS:7420-89-5
Fraction by Wt: 20-25%
Other REC Limits:NONE ESTABLISHED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:GLUTARALDEHYDE
CAS:111-30-8
RTECS #:MA2450000
Fraction by Wt: 10-15%
OSHA PEL:C 0.2 PPM
ACGIH TLV:C 0.2 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE "OVEREXPOSURE SYMPTOM"
Effects of Overexposure:INHALE:IRRITNT;EYES:BURNS;SKIN:EXTENDED CONTACT
CAUSES IRRITATION/REPEATED CONTACT:ALLERGIC REACTION
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF NEED;EYES:FLUSH W
LG AMTS H*2O FOR 15 MIN;SKIN:FLUSH W LG AMTS H*2O;INGEST:RINSE
MOUTH; GET IMMEDIATE ATTENTION FOR EYES OR INGEST.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP;H*2O SPRAY COOL
CONT.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS;LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA. PROTECT FROM PHYSICAL DAMAGE. AVOID ANY PHYSICAL
CONTACT. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT W CHEMICAL.
REMOVE & WASH CONTAMINATED CLOTHING. MAINTAIN STRICT HYGIENE. USE
OF NON-ALKALINE(ACID) TYPE HAND CLEANER REDUCES RISK OF ALLERGIC
SKIN REACTION
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED ORGANIC VAPOR RESPIRATOR IF POOR
VENTILATION.
Ventilation:MECHANICAL(GEN./LOCAL EXHAUST)
Other Protective Equipment:NORMAL FULL WORK CLOTHING COVERING
ARMS,LEGS:NO SKIN CONTACT
Supplemental Safety and Health
KEY1:N1. PART C OF A THREE PART PRODUCT UNDER SAME NSN.
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:B.P. Text:>212F,100C
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.15
pH:3
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR TO LIGHT BROWN LIQUID;ALDEHYDE ODOR.
Percent Volatiles by Volume:93
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE & LOCAL REGULATIONS. MFG SUGGESTS REACT
W SODIUM BISULFITE & FLUSH TO SEWER W EXCESS WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:857, PAINT REMOVER
CAGE:88304
CAGE:78304
CAGE:88304
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: <1.0%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 8990
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS
======================= First Aid Measures =======================
First Aid:MOVE TO FRESH AIR. SKIN: WASH W/WARM SOAPY WATER & SEEK MD.
EYE: FLUSH W/WATER, SEEK MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CO*2, FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW EVAPORATION OF SOLVENT, THEN FLUSH
RESIDUE INTO SANITARY SEWER, MOP AREA DRY.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE BEYOND 105F
Other Precautions:USE NORMAL SAFETY PRECAUTIONS FOR HANDLING ALKALINE
SOLVENT TYPE PAINT REMOVERS.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXH, ADEQUATE
Other Protective Equipment:RUBBER APRONS
Supplemental Safety and Health
% VOLATILE BYVOLUME: 70-75%; SPECIFIC GRAVITY: 1.05 - 1.06.
================== Physical/Chemical Properties ==================
NRC/State Lic Num:NA
Boiling Pt:B.P. Text:105F
Evaporation Rate & Reference:1.0
Appearance and Odor:VISCOUS YELLOW LIQ, AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PAINTED SURFACES, STRONG ACIDS, STRONG ALKALIES
Hazardous Decomposition Products:PHOSGENE, FROM EXTREME THERMAL
DECOMPOSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED, STATE, LOCAL REG
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CRAYOLA WASHABLE PAINT, 54-0105 033-PEACH
CAGE:85419
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (KAOLIN); (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NONE KNOWN. CHRONIC: NONE
KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CONTACT A PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP AND WATER.
INGESTION: DO NOT INDUCE VOMITING. CONTACT A PHYSICIAN OR POISON
CONTROL CENTE R. INHALATION: REMOVE PERSON TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE TO CONTAIN SPILL. KEEP OUT OF SEWERS AND
WATERCOURSES. ABSORB WITH INERT MATERIAL AND PLACE IN CONTAINER FOR
DISPOSAL. FLUSH RESIDUAL WITH COPIOUS AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:CLEAN, SAFE WORK PRACTICES.
Supplemental Safety and Health
SPEC GRAV: 1.19-1.31 (H*2O=1).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>215F,>102C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Density:<1
Spec Gravity:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:DISPERSES
Appearance and Odor:VARIOUS COLORS; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:555245 PRK. SHRUB,TREE & EVGRN. 12-6-6
CAGE:PARKR
CAGE:PARKR
============= Composition/Information on Ingredients =============
Ingred Name:UREA; CARBAMIDE
CAS:57-13-6
RTECS #:YR6250000
Fraction by Wt: 3-61%
Ingred Name:AMMONIATED PHOSPHATES
Fraction by Wt: 3-61%
Ingred Name:POTASSIUM CARBONATE, POTASH, PEARL ASH
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 3-61%
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: 3-61%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (LAB ANIMAL): 1500 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL. SKIN/EYES/MUCOUS
MEMBRANES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/MUCOUS MEMBRANES: IRRITATION. EYES:
IRRITATION & BURNS.
======================= First Aid Measures =======================
First Aid:INGESTION: IF CONSCIOUS, INDUCE VOMITING BY GIVING 1 OR 2
GLASSES OF WATER & TOUCH BACK OF THROAT W/FINGER. NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS/CONVULSIONS. EYES: FLUSH W/PLENTY
OF WATER. SKIN : REMOVE CONTAMINATED CLOTHING & WASH AFFECTED AREA
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>400F
Extinguishing Media:WATER, FOAM, OR CO2
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:HYDROGEN SULFIDE IS A REACTION PRODUCT &
IS TOXIC & EXPLOSIVE. SULFUR DUST WILL EXPLODE AT A MINIMUM
CONCENTRATION OF 35 G/CUM AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP PRODUCT & REPLACE IN LABELED
CONTAINER. USE PRODUCT ACCORDING TO DIRECTIONS FOR USE/DISPOSE OF A
DIRECTED ON LABEL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ITS ORIGINAL LABELED
CONTAINER IN COOL, DRY LOCKED PLACE OUT OF REACH OF CHILDREN. DON'T
ALLOW BAGS TO BECOME WET. AVOID TEMPS >212F.
Other Precautions:DON'T CONTAMINATE WATER, FOOD, OR FEED BY STORAGE OR
DISPOSAL. SHELF LIFE: 5 TO 7 YEARS OF GOOD PHYSICAL CONDITION IF
STORED PROPERLY. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF INADEQUATE VENTILATION WHERE DUST
CONCENTRATIONS EXCEED RECOMMENDED PEL'S, USE NIOSH APPROVED DUST
RESPIRATORS.
Ventilation:ADEQUATE
Supplemental Safety and Health
COMPLETELY EMPTY BAG INTO APPLICATION EQUIPMENT. DISPOSE OF EMPTY BAG
IN A SANITARY LANDFILL/INCINERATION/STATE & LOCAL AUTHORITIES BY
BURNING. SOLUBILITY: GENERALLY, SLOWLY SOLUBLE IN SOIL.
================== Physical/Chemical Properties ==================
Spec Gravity:0.5606-0.8329
pH:5-8
Solubility in Water:SEE SUPP.
Appearance and Odor:NATURAL MINERAL GRANULES W/FERTILIZER SALT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN SULFIDE
Stability Condition to Avoid:HEAT >212F
Hazardous Decomposition Products:UREA: CYANURIC ACID/AMMONIA/HYDROGEN
CYANIDE/NITROGEN OXIDES/BIURET/CO2. SULFUR COATED UREA: SULFUR &
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PRODUCT CANNOT BE USED ACCORDING TO
INSTRUCTIONS EXCESS PRODUCT MAY BE DISPOSED ON SITE/APPROVED WASTE
FACILITY. DISPOSE IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. SEE SUPP
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:70-2009 RUST KILL LIGHT YELLOW
CAGE:EO325
CAGE:91708
CAGE:EO325
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 14.12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALIPHATIC HYDROCARBON (MS)
CAS:8052-41-3
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ALCOHOL (SARA 313) (CERCLA)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 2.31%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 11.57%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC HYDROCARBON CONTAINS INGREDS #11,12.
CAS:64742-89-8
Fraction by Wt: 15-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA), CONTAINS
INGRED #14
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.18%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 18-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLITILE ORGANIC CONTENT AS LISTED ON MSDS, 603 GM/L.
RTECS #:9999999VC
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 14.97%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 7.24%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9596
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 7.24%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:C.I. PIGMENT YELLOW 73
CAS:13515-40-7
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:ANESTHETIC.IRRIT RESP
TRACT,ACUTE NERV SYS DEPRESS CHARACTERIZED BY FOLLOWING PROGRESSIVE
STEPS:HEAD,DIZZ,STAGGERING
GAIT,CONFUSION,UNCONSC,COMA,ASPHIXIATION.SKIN/EYE CONTACT:PRIMARY
IRRIT .CHRONIC:OVEREXPO TO THIS MATL(OR COMPO)HS BEEN SUGGESTED AS
CAUSE OF REPRODUCTIVE DISORDERS,CARDIAC/LIV ABNORM,EYE DMG.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.
Effects of Overexposure:ANESTHETIC,IRRIT RESP TRACT,NERVOUS SYS
DEPRESSION-HEADACHE,DIZZ,STAGGERING
GAIT,CONFUSION,UNCONSC,COMA,ASPHIXIATION. EYE/SKIN IRRIT.
REPRODUCTIVE DISORDERS,CARDIAC & LIVER ABNORMALITIES, EYE DAMAGE.
Medical Cond Aggravated by Exposure:ASHTMA. RESPIRATORY &/OR SKIN
ALLERGIES IN SUSCEPTABLE PERSONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.RESTORE BREATHING.TREAT
SYMPTOM.CONSULT DR.SPLASH(EYE):FLUSH IMMED W/LG ATMS OF
WATER,INCLUDE UNDER EYELIDS,FOR @LEAST 15MINS.IRRIT PERSISTS
CONSULT PHYSICIAN.SPLASH(SKIN):WA SH W/SOAP/WATER.REMOVE CONTAMIN
CLOTH.CONSULT DR IF IRRIT PERSISTS.INGEST:CONSULT DR/POISON CNTRL
CNTR IMMED.TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:-138F,-94C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:0.9
Upper Limits:NP
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
OSHA:CLASS IA, DOT FLAMMABLE LIQUID.
Fire Fighting Procedures:H2O MAY BE INEFFECTIVE;IF USE,FOG NOZZ
PREFER.H2O MAY BE USED TO COOL CLSD CNTNR-PREVENT PRESSURE
BUILDUP/AUTO-IGN WHEN EXPO TO EXTREME HEAT.FULL PROTECT(SUPPL)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT/ELECTR EQPMT/SPARKS/OPN
FLAME.APPLICATION TO HOT SURFACES REQUIRE SPEC PRECAUT.CLSD CNTNR
MAY EXPLO WHEN EXPO TO EXTREME HEAT.DURING (SUPPLE)
================== Accidental Release Measures ==================
Spill Release Procedures:LIMIT SPREAD OF SPILL/LEAK.REMOVE ALL SOURCES
OF IGNITION.SOAK UP W/INERT ABSORBANT MATL.USE NON-SPARKING TOOLS
WHEN REMOVING WET ABSORBENT.SEE OTHER MSDS SECTION FOR REQUIRED
PROTECTIVE MEASURES.KEEP MATL OUT OF SEWERS &/OR DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM EXTREME HEAT/FIRE/OPEN
FLAME.STORE IAW OSHA 1910.106.DONT STORE >100F(38C).STORE LG QUANT
ONLY IN BLDG DESIGNED TO COMPLY W/1910.106.
Other Precautions:DONT HNDLG TIL MFG SAF PRECAUT READ/UNDERSTOOD.STORE
IN WELL VENTI AREA.KEEP DR OUT OF DIRECT SUN/TIGHT
CLSD/UPRIGHT.DONT STORE/USE NEAR HEAT/SPARK/OPN FLAME.GROUND/BOND
WHEN POUR.DONT USE PRESS TO EM PTY-NOT PRESS VESS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOORS:USE MECHANICAL FILT RESP WHILE
SPRAYING.RESTRICTED VENTI AREA:USE APPROV CHEM/MECH FILT DESIGNED
TO REMOVE COMBINATION OF PARTICULATES & VAPORS.CONFINED AREAS:USE
APPROVED AIR LINE TYP RESP O R HOODS.
Ventilation:PROVIDE VENTI OF SUFFIC VOL/PTRN TO KEEP AIR CONTAM CONCEN
BEL VALS.EXHAUS FILT SYS TO AVOID ENVIRO CONTAM.IAW EMISS REG
Other Protective Equipment:WEAR CHEM RESIST SHOES.REMOVE/WASH CONTAM
CLOTH BEF REUSE.WEAR RUBB/PLAST APRON.CLEAN H2O SOURCE AVAI FOR
EYE/SKIN FLUSH
Work Hygienic Practices:WASH HANDS BEF EAT/WASHRM USE.SMOKE IN
DESIGNATED SMOKING AREAS ONLY.AVOID REP/PROL SKIN CONTACT.LIQ
PENETR LEATHER-BURN
Supplemental Safety and Health
FIREFIGHT:EQPTM +SCBA SHOULD BE USED TO PROT FIGHTER FRM HAZ COMBUST
PROD.AVOID BURN LIQ SPREAD W/H2O. FIRE/EXPLO:EMERG
CONDITIONS/OVEREXPO MAY CAUSE HEALTH HAZ.SYMPT MAY NOT BE IMMED
APPARENT.GET MED ATTN.VAP MAY IGNITE BY STAT ELECT/FRICSPARKS.VAP
HEAVIER THAN AIR-TRAVEL DISTANCES TO IGN PT/FLASHBACK.KEEP CNTNR
CLSD
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:43.0F,6.1C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:>AIR
Spec Gravity:NP
pH:NP
Viscosity:NP
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NP
Appearance and Odor:LIGHT YELLOW
Percent Volatiles by Volume:89.98
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PEROXIDES OR STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEAT TO
DECOMPO,AS IN WELD OR FIRE.FUMES MAY CONTAIN:CO,CO2,&VARIOUS OTHER
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPO OF IAW ALL LOC,STATE,FED REGS.APPROVED
LANDFILL,APPROVED HAZ WASTE SITE,INCINERATION.CHEM SUBJ TO REPORT
REQMTS SEC 313 SARA TITLE III:ETHYL
BENZENE,XYLENE,TOLUENE,N-BUTANOL,ACETONE.CNTNR DISPO IAW APPL
LAWS/REGS.DONT GIVE EMPTY DR TO PEOPLE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:140 8731 INDICATOR STOP BATH, CONCENTRATE
CAGE:19139
CAGE:0E4P0
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BROMOCRESOL PURPLE
CAS:115-40-2
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 3.3 G/KG (ACETIC ACID)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXPOSURE TO EXTREMELY HIGH
AIRBORNE CONCENTRATIONS OF RESPIRATORY IRRITANTS HAS BEEN
ASSOCIATED WITH DEVELOPMENT OF ASTHMA-LIKE REACTIVE AIRWAYS
SYNDROME. INHALTION OF VAPOR EXTREMELY IRRITA TING. EYE CONTACT
CAUSES SEVERE BURNS. SKIN CONTACT CAUSES SEVERE BURNS. INGESTION
MAY CAUSE BURNS OF GI TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, RESPIRATORY TRACT IRRITATION,
EYE BURNS, SKIN BURNS, GI TRACT BURNS, DEATH.
Medical Cond Aggravated by Exposure:ACUTE OVEREXPOSURE TO EXTREMELY
HIGH AIRBORNE CONCENTRATIONS OF RESPIRATORY IRRITANTS HAS BEEN
ASSOCIATED WITH DEVELOPMENT OF AN ASTHMA-LIKE REACTIVE AIRWAYS
SYNDROME IN SUSCEPTIBLE INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF WATER.
CALL A PHYSICIAN OR POISON CONTROL CENTER ASAP. NEVER GIVE ANYTHING
BY MOUTH IF UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:128F,53C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:CLASSIFIED AS COMBUSTIBLE. MATERIAL
CONTAINS A COMBUSTIBLE SOLVENT THAT MAY ACCUMULATE IN CONTAINER
HEADSPACE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. MAY REQUIRE
NEUTRALIZATION. FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE TO
REMOVERESIDUAL.
Neutralizing Agent:NEUTRALIZATION AND SEWERING MAY NOT BE ALLOWED IN
SOME STATES AND MUNICIPALITIES
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR AT CONCENTRATIONS
GREATER THAN THE EXPOSURE LIMITS. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. USE ONLY WITH ADEQUATE VENTILATION.
Other Precautions:KEEP FROM CONTACT WITH OXIDIZING MATERIALS. KEEP AWAY
FROM HEAT AND FLAME. KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: FULL-FACE ORGANIC VAPOR
CARTRIDGE. IF RESPIRATO RS ARE USED, A PROGRAM SHOULD BE STARTED
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
EXTREMELY HIGH AIRBORNE CONCENTRATIONS ARE NOT GENERATED DURING NORMAL
CONDITIONS OF USE BUT MAY OCCUR FOLLOWING A SPILL. THE POTENTIAL TO
GENERATE EXTREMELY HIGH AIRBORNE CONCENTRATIONS IN A SPILL SI
TUATIONS DEPENDS UPON PHYSICAL FACTORS SUCH AS THE CONCENTRATION OF
THE SOLUTION, VOLUME OF SPILL, VENTILATION RATE.
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:14.6
Vapor Density:1.9
Spec Gravity:1.07
pH:< 2
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, SHARP VINEGAR ODOR
Percent Volatiles by Volume:100 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LIDOCAINE HYDROCHLORIDE INJECTION
Preparer's Name:GREGORY KOLAR
CAGE:24832
CAGE:24832
CAGE:39832
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:LIDOCAINE HYDROCHLORIDE
CAS:73-78-9
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYLPARABEN
CAS:99-76-3
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER FOR INJECTION (NOTE: PH ADJUSTED WITH HYDRCHLORIC
ACID AND/OR SODIUM HYDROXIDE.)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL MOUSE LD50: 220 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE,SKIN,RESPIRATORY
IRRITATION,UNUSUALLY SLOW HEARTBEAT,DIFFICULTY BREATHING,SWELLING
MAY OCCUR.PRODUCT INTENDED FOR THERAPUTIC USE ONLY WHEN PRESCRIBED
BY A PHYSICIAN.POTENTIAL ADVERSE REACTIONS FRO M PRESCRIBED DOSES
AND OVERDOSES ARE DESCRIBED IN PACKAGE INSERT.OCCUPATIONAL EXPOSURE
HAS NOT BEEN FULLY INVESTIGATED.
Effects of Overexposure:EYE,SKIN,RESPIRATORY IRRITATION,UNUSUALLY SLOW
HEARTBEAT,DIFFICULTY BREATHING,SWELLING MAY OCCUR.PRODUCT INTENDED
FOR THERAPUTIC USE ONLY WHEN PRESCRIBED BY A PHYSICIAN.POTENTIAL
ADVERSE REACTIONS FRO M PRESCRIBED DOSES AND OVERDOSES ARE
DESCRIBED IN PACKAGE INSERT.OCCUPATIONAL EXPOSURE HAS NOT BEEN
FULLY INVESTIGATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION. INHALATION: MOVE TO
FRESH AIR. IF NOT BREATHING GIVE CPR. GET MEDICAL ATTENTION.
INGESTION: FLUSH MOUTH OUT WITH WATER IMMEDIATELY. GET MEDICAL
ATTENTION. GENERAL: FOR ADDITIONAL INFORMATION SEE THE PRODUCT
INSERT.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE OR FOAM
AS APPROPRIATE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION IT EMITS
TOXIC FUMES OF NITROGEN OXIDES (NOX).
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN-UP; WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. USE ABSORBENT TOWELS OR BOOMS TO CLEAN-UP SPILL. WIPE
SURFACES CLEAN AND WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AS A GENERAL RULE, WHEN HANDLING
PHARMACEUTICAL PRODUCTS AVOID ALL CONTACT AND INHALATION OF DUST,
FUME, MISTS, OR VAPORS ASSOCIATED WITH THE PRODUCT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH SATIFACTORY VENTILATION, RESPIRATORY
PROTECTION NOT USUALLY REQUIRED.
Ventilation:GENERAL ROOM VENTILATION IS USUALLY SATISFACTORY, USE LOCAL
EXHAUST VENTILATION WHEN NECESSARY.
Other Protective Equipment:WEAR DISPOSABLE GARMENTS IF DIRECT SKIN
CONTACT IS ANTICIPATED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
pH:5 - 7
Solubility in Water:SOLUBLE(WITH HCL)
Appearance and Odor:CLEAR, COLORLESS SOLUTION. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:PROTECT FROM FREEZING.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION IT EMITS
TOXIC FUMES OF NITROGEN OXIDES (NOX).
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:439070 WEST KIT LEV 1
CAGE:1W937
CAGE:1W937
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <40%
Other REC Limits:10 MG/CUM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HUMAN PROTEIN
Fraction by Wt: <10%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT: 8.54 G/KG ETHYLENE GLYCOL
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ETHYLENE GLYCOL MAY CAUSE
IRRITATION OF MUCOUS MEMBRANES & RESPIRATORY PASSAGES. INGESTION:
ETHYLENE GLYCOL MAY CAUSE INTOXICATION & COMA. SKIN: ETHYLENE
GLYCOL MAY CAUSE IRRITATION. HUMANPROTEIN SOURCES ARE CAPABLE OF
TRANSMITTING INFECTIOUS DISEASE.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREAS THOROUGHLY. INGESTION, EYES OR
CONTACT W/OPEN WOUND. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE AS IF CAPABLE OF TRANSMITTING
INFECTIOUS DISEASE. ABSORB ON INERT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:HEAT WILL DEGRADE EFFICACY. HANDLE AS
IF CAPABLE OF TRANSMITTING INFECTIOUS DISEASE.
Other Precautions:STORE AS INDICATED ON DIRECTION INSERT. FOR IN VITRO
DIAGNOSTIC USE ONLY. NOT FOR HUMAN OR ANIMAL USE. HANDLE BROKEN OR
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:GENERAL IS ACCEPTABLE
Other Protective Equipment:EYE BATH
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:>1
Evaporation Rate & Reference:(WATER = 1): <1
Solubility in Water:COMPLETE
Appearance and Odor:AMBER VISCOUS LIQUID, W/SLIGHT ODOR
Percent Volatiles by Volume:>75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS NECESSARY FOR BIOHAZARDOUS MATERIALS.
DISPOSE OF IN ACCORDANCE W/APPLICABLE FEDERAL, STATE, & LOCAL LAWS
& REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SA 71 SOLVENT BLEND
CAGE:7L600
CAGE:7L600
CAGE:0FCC1
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA 313) (CERCLA)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 14%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 14%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYTLENE GLYCOL MONOBUTYL ETHER (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9495
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL) (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9495
Ingred Name:APLIPHATIC PETROLEUM DISTILLATES (VM & P NAPHTHA)
CAS:64742-89-8
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NORMAL BUTANOL (N-BUTYL ALCOHOL) (SARA 313) (CERCLA)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 13-17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 18%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313) (AS A COMPONENT OF TECHNICAL GRADE
XYLENES)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION MAY CAUSE NASAL &
RESPIRATORY IRRITATION & CNS EFFECTS.EXPOSURE CAN CAUSE SKIN & EYE
IRRITATION.INGESTION MAY CAUSE GI TRACT IRRITATION.ASPIRATION MAY
CAUSE CHEMICAL PNEUMONITIS,WHICH CAN BE
FATAL.CHRONIC:PROLONGED/REPEATED EXPOSURE MAY CAUSE CARDIAC
ABNORMALITY AND/OR EYE DAMAGE.
Explanation of Carcinogenicity:ISOPROPYL ALCOHOL IS LISTED AS A GROUP 3
(INSUFFICIENT HUMAN EVEIDENCE) POTENTIAL CARCINOGEN.
Effects of Overexposure:INHALED-COUGHING, SHORTNESS OF BRETAH,
DIZZINESS, WEAKNESS, FATUGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS,
POSSIBLE DEATH. EYES-BURNING, TEARING, REDNESS, SWELLING, EYE
DAMAGE. SKIN-REDNESS, BURNING, DRY ING, CRACKING, SKIN BURNS, SKIN
DAMAGE.INGESTED-NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR. RESTORE BREATHING AS
REQUIRED. GET MEDICAL ATTENTION IMMEDIATELY. EYE-FLUSH WITH WATER
FOR 15 MINUTES, HOLD LIDS OPEN. GET MEDICAL ATTENTION. SKIN-REMOVE
CONTAMINATED C LOTHES. WASH WITH SOAP & WATER. SEEK MEDICAL
ATTENTION.INGESTION-DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:10F,-12C
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
OPERATED IN POSITIVE PRESSURE DEMAND AND FULL PROTECTIVE GEAR WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE-GIVES OFF VAPOR WHICH
TRAVELS ALONG GROUND TO SOURCE OF IGNITION AND IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:ABSORB SPILL WITH INERT MATERIAL & PLACE
IN A CONTAINER FOR LATER DISPOSAL.LARGE:ELIMINATE ALL SOURCES OF
IGNITION.CONTAIN SPILL.KEEP OUT OF SEWERS & WATERCOURSES.PUMP OR
VACUUM TRANSFER.ABSORB RESIDUE W/INERT MATERIAL & PLACE IN
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
DLA-HMIS: STORE IN A COOL, DRY PLACE AWAY FROM SOURCES OF IGNITION
AND STRONG OXIDIZING AGENTS.
Other Precautions:CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS WHEN
EMPTIED; SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES. ALL
HAZARD PRECAUTIONS MUST BE OBSERVED. DLA-HMIS:USE PROPER BONDING
AND GROUNDING PROCEDURE S WHEN TRANSFERRING PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE
WITH 29 CFR 1910.13 4 AND MANUFACTURER'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE EXPLOSION-PROOF MECHANICAL VENTILATION OR
LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING & BOOTS. DLA-HMIS:
EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:DLA-HMIS: WASH HANDS AFTER HANDLING AND BEFORE
EATING, DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE
REUSE.
Supplemental Safety and Health
SUDDEN RELEASE OF HOT ORGANIC CHEMICAL VAPORS OR MISTS FROM PROCESS
EQUIPMENT OPERATING AT ELEVATED TEMPERATURE OR SUDDEN INGRESS OF
AIR INTO VACUUM EQUIPMENT MAY RESULT IN IGNITIONS W/O PRESENCE OF O
BVIOUS IGNITION SOURCES (AUTOIGNITION).
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:70
Vapor Density:>1.0
Spec Gravity:0.836
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: FLAMMABLE
LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
AVOID EXPOSURE/CONTACT TO SOURCES OF IGNITION AND INCOMPATIBLE
MATERIALS.
Hazardous Decomposition Products:VARIOUS HYDROCARBONS, CARBON MONOXIDE
AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. DLA-HMIS: EPA/RCRA WASTE NUMBER
D001 (IGNITEABLE) MAY APPLY TO UNUSED/UNCONTAMINATED PRODUCT.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-424-2799
Product ID: NP-6000/7000/8000 SERIES TONER BLACK
Cage: EO160
Country: JA
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 01QM9
Box: UNKNOW
Cage: EO160
Country: JA
Cage: EO274
Country: JA
Cage: 1BA63
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: TONER,INDIRECT ELECTROSTATIC PROCESSING
Specification Number: UNKNOWN
Unit of Issue: EA
UI Container Qty: 0
Type of Container: CARTRIDGE
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CHRONIC:BASED UPON AVAI DATA HUMAN EXPO TO TONER HAS BEEN
SHOWN TO CAUSE MIN RESP TRACT IRRIT AS MAY OCCUR W/LG ATMS OF ANY NONTOXIC
DUSTS.RESULTS OF 1 ANIMAL STUDY WHERE RATS INHAL TONER THAT WAS 10X MORE
RESPIRABLE THAN COMMERC AVAI TONER WERE OBSERVED TO HAVE NO LUNG CHANGES @LOW
EXPO.@HI EXPO LEVELS SLIGHT (SUPPL)
Explanation Of Carcinogenicity: PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/
OSHA:NONE.
Signs And Symptions Of Overexposure: EYE TRANSIENT IRRIT.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:SYMPTOMATIC MOVE TO FRESH AIR.GET MED ATTN IF SYMPTOMS
PERSIST.EYE:ANY MATL THAT CONTACTS EYE SHOULD BE WASHED OUT IMMED W/WATER.GET
MED ATTN IF SYMPTOMS OCCUR.SKIN:WASH W/SOAP/WATER.GET MED ATT N IF SYMPTOMS
OCCUR.INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP MATL ONTO PAPER AND PLACE IN FIBER CARTON.DONT
USE VACCUUM CLEANER TO CLEANUP SPILLS OF POWDERED TONER.THE FINE PARTICLES
CAN CAUSE FIRE OR EXPLOSION.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MATL HASNT BEEN TESTED FOR ENVIRO EFFECTS.IN SPILL
SITUATION MATL MAY BE VISUALLY UNPLEASANT;HOWEVER ITS NOT EXPECTED TOCAUSE
ANY ADVERSE ENVIRO EFFECTS.INCINERATE/LANDFILL.CAN BE INCINERATED WHEN IN
COMPLIANCE W/LOC REGS.DISCAHR/TREAT/DISPO MAY(SUP)
Handling And Storage Precautions: AVOID BREATH DUST.USE W/ADEQUATE VENTI.KEEP
FROM CONTACT W/OXIDIZING MATLS.MIN DUST GENERATION/ACCUMULATION.
Other Precautions: REF:PAMPHLET #654:PREVENTION OF FIRE/DUST EXPLOSIONS IN
CHEMICAL,DYE,PARMACEUTICAL & PLASTICS INDUSTRIES.USE ADEQUATE
VENTILATION.KEEP CNTNR CLSD.4 TO 6 ROOM VOLUMES OF AIR EXCHANGED/HR IS
SUFFICIENT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: TONER MATERIAL, LIKE MOST ORGANIC MATL IN POWDER
FORM,IS CAPABLE OF CREATING A DUST EXPLOSION.NON-FLAMM SOLID(ACCORDING TO
TEST METHOD OF 16CFR1500.44).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE SHOULD BE NEEDED
Ventilation: GOOD VENTILATION(TYPICALLY 4-6 ROOM VOLUMES PER HR)SHOULD BE
USED.VENTILATION RATES SHOULD BE MATCHED TO CONDITONS.
Other Protective Equipment: WASHING FACILITIES.
Work Hygienic Practices: WASH WELL AFT HNDLG.GOOD INDUSTRIAL HYG PRAC SHOULD BE
FOLLOWED-INVOLVES PREVENTING EYE CONTACT,MIN SKIN CONTACT/INHAL.
Supplemental Safety and Health: HEALTH:DEGREE OF LUNG FIBROSIS OBSERVED DUE TO
EXCESSDUST AMTS RETAINED IN LUNGS FOR PROL INTERVAL.INHAL/SKIN:EXPECTED TO BE
LOW HAZ FOR RECOMMENDED HNDLG.EYE:NO SPEC HAZ KNOWN.MAY CAUSE TRANSIENT IRR
IT.INGEST:EXPECTED TO BE LOW INGEST HAZ. DISPO:BE SUBJ TO FED/STATE/LOC
LAWS.SARA/40CFR372:CR III/CMPDS=2%,AS METAL=0.5%
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
M.P/F.P Text: 212F,100C
Vapor Pres: NEGLIGIBLE
Vapor Density: NA
Spec Gravity: 1.4-1.6
PH: NA
Evaporation Rate & Reference: NEGLIGIBLE,BUTYLACETATE=1
Solubility in Water: NEGLIGIBLE
Appearance and Odor: FINE SOLID POWDER, BLACK COLOR, SLIGHT PLASTIC ODOR
Percent Volatiles by Volume: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.COMBUSTION
WILL PRODUCE CARBON DIOXIDE,POSSIBLY TOXIC CHEMS SUCH AS CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 136066
Product ID: NP-6000/7000/8000 SERIES TONER BLACK
Review Date: 10/27/1997
Net Unit Weight: 1500G
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 0
Type Of Container: CARTRIDGE
Additional Data: PER MSDS:WT=1500G; DOT SHIPPING NAME:NOT REGUALTED;HAZ
CLASS/UN#:NA.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: NP-6000/7000/8000 SERIES TONER BLACK
Cage: EO160
Assigned IND: Y
Company Name: CANON INC
Street: 30-2 SHIRMOMARUKO 3 CHOME OMTA-KU
Zipcode: 00000
Country: JA
Label Required IND: Y
Date Of Label Review: 10/27/1997
Status Code: C
Label Date: 10/27/1997
Year Procured: 1997
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: INHAL/SKIN:EXPECTED TO BE LOW HAZ FOR RECOMMENDED
HNDLG.EYE:NO SPECIFIC HAZ KNOWN.MAY CAUSE TRANSIENT IRRIT.INGEST:EXPECTED TOB
E LOW INGEST HAZ.TARGET ORGANS:EYES.AVOID BREATH DUST.USE W/ADEQUATE VEN
TI.KEEP FROM CONTACT W/OXIDIZING MATLS.MIN DUST GENERATION/ACCUMULATION.
FIRST AID: INHAL:SYMPTOMATIC MOVE TO FRESH AIR.GET MED ATTN IF SYMPTOMS
PERSIST.EYE:ANY MATL THAT CONTACTS EYE SHOULD BE WASHED OUT IMMED
W/WATER.GET MED ATTN IF SYMPTOMS OCCUR.SKIN:WASH W/SOAP/WATER.GET MED ATTN IF
SYMPTOMS OCCUR.INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED ATTN.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOLYSULFIDE (TECHNICAL, TECHNICAL FINE, SUPERFINE)
METAL
CAGE:019Y6
SYST
Contract Num:SP0450-00-M-D480
CAGE:1LFJ4
CAGE:019Y6
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
> Wt:98.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: EXPOSURE TO FINE
DUST & SMALL PARTICLES IN EXCESS OF THE TLV MAY CAUSE IRRITATION TO
EYES, SKIN AND RESPIRATORY SYSTEM
Explanation of Carcinogenicity:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE AREA TO FRESH AIR
IMMEDIATELY. IF BREATHING STOPPED, PERFORM ARTIFICIAL RESPIRATION.
GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING & SHOES
IMMEDIATE. WASH AFFECTED AREA W/ SOAP OR MILD DETERGENT, LARGE
AMOUNTS OF WATER UNTIL NO EVIDENCE OF CHEMICAL REMAINS. (15-20
MINUTES). GET MED ATTENTION. EYE: WASH EYES IMMEDIATELY WITH LARGE
AMOUNTS OF WATER OR NO RMAL SALINE, OCCASIONAL LIFTING UPPER &
LOWER LIDS, UNTIL NO EVIDENCE OF CHEMICAL REMAINS (15-20 MINUTES)
GET MEDICAL ATTN. INGESTION: IF VOMITING OCCURS, KEEP HEAD LOWER
THAN HIPS TO PREVENT ASPIRATI ON. GET MEDICAL ATTN IF NEEDED.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, WATER SPRAY OR REGULAR FOAM. FOR
LARGER FIRES, USE WATER SPRAY, FOG OR REGULAR FOAM.
Fire Fighting Procedures:NO ACUTE HAZARD. MOVE CONTAINER FROM FIRE AREA
IF POSSIBLE. AVOID BREATHING VAPORS OR DUSTS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:SLIGHT FIRE HAZARD WHEN EXPOSED TO HEAT
OR FLAME. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE TOXIC OXIDES
OF SULFUR.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR LARGE SPILLS, SWEEP UP WITH A MINIMUM OF
DUSTING & PLACE INTO SUITABLE CLEAN, DRY CONTAINERS FOR RECLAMATION
OR LATER DISPOSAL. RESIDUE SHOULD BE CLEANED UP USING A
HIGH-EFFICIENCY PARTICULATE FIL TER VACUUM.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE NATIONAL AND REGIONAL
PROVISIONS IN FORCE. STORE AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:EMERGENCY EYE WASH: WHERE THERE IS ANY POSSIBILITY
THAT AN EMPLOYEE'S EYES MAY BE EXPOSED TO THIS SUBSTANCE, THE
EMPLOYER SHOULD PROVIDE AN EYE WASH FOUNTAIN WITHIN THE IMMEDIATE
WORK ARE FOR EMERGENC Y USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATOR SUITABLE FOR LEVELS OF DUST/FUME
IN THE WORK ENVIRONMENT.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION AND/OR GENERAL DILUTION
VENTILATION TO MEET PUBLISHED EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING NOT REQUIRED. AVOID
REPEATED OR PROLONGED CONTACT WITH THIS SUBSTANCE. EMERGENCY EYE
WASH FOUNTAIN WITHIN THE IMMEDIATE WORK AREA FOR EMERGENCY USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:>315.C, 599.F
M.P/F.P Text:(OXIDIZES)
Vapor Pres:APPROX 0 @20C
Spec Gravity:4.80@14C
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS, DARK GRAY TO BLACK POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN PEROXIDE: VIGOROUS OR VIOLENT REACTION. OXIDIZERS (STRONG):
FIRE AND EXPLOSION HAZARD. POTASSIUM NITRATE: FORMS EXPLOSIVE
MIXTURE.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES &
PRESSURES. PREVENT DISPERSION OF DUST IN AIR.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC &/OR HAZARDOUS GASES.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION HAS NOT
BEEN REPORTED TO OCCUR UNDER NORMAL TEMPERATURES & PRESSURES.
=================== Toxicological Information===================
Toxicological Information:INHALATION: CHRONIC EXPOSURE: 25 ONE-HOUR
EXPOSURES TO 490 MG/M3 CAUSED NO EFFECTS IN ALL THE ANIMALS TESTED
EXCEPT ONE WHICH DIED AFTER THE THIRD EXPOSURE. SKIN CONTACT: ACUTE
EXPOSURE: DERMATITIS HA S NOT BEEN REPORTED IN EXPOSED WORKERS.
INGESTION: CHRONIC EXPOSURE: RATS FED UP TO 500 MG DAILY FOR 44
DAYS SHOWED NO TOXIC SIGNS AND ALL GAINED WEIGHT.
===================== Ecological Information =====================
Ecological:ACUTE AQUATIC TOXICITY: TESTS CONDUCTED IN 1990 AT LEVELS UP
TO 750 MG/L POWDERED MBS2 RESULTED IN 0 MORTALITY TO RAINBOW TROUT
(SALMO GAIRDNERI).
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE NATIONAL AND REGIONAL PROVISIONS IN
FORCE.
=================== MSDS Transport Information ===================
Transport Information:NO CLASSIFICATION CURRENTLY ASSIGNED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILICON ALKYD ENAMEL, B56WZ100 ULTRA WHITE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS). VP:2.
CAS:64742-88-7
Fraction by Wt: 18%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS 140-FLASH). VP:0.5.
CAS:64742-88-7
Fraction by Wt: 2%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA; (MEDIUM AROMATIC HYDROCARBONS). VP:0.1.
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-HEPTANONE; (METHYL N-AMYL KETONE). VP:70.
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 2.67 LBS/GAL.
RTECS #:9999999VO
Ingred Name:SUPP DATA:MAY NOT BE IMMEDIATELY APPARENT. OBTAIN MEDICAL
ATTENTION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:LEVELS ARE NOT ATTAINABLE IN WORKPLACE.
REPORTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS CAN BE HARMFUL/FATAL. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:WARNING: PRODUCT CONTAINS CHEMICAL(S) KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER (CAL PROP 65).
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE
PARTICULATES WHICH MAY BE PRESENT AT HAZ LEVELS ONLY(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:DURING SANDING/ABRADING OF DRIED FILM. IF NOT
SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE DUSTS (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:ARE ACGIH TLV 10 MG/M3 (TOTAL DUST); OSHA PEL 15
MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY IRRIT &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSSIBLY DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INDICATIONS OF EXCESSIVE EXPOS TO
VAPS/SPRAY MIST. REDNESS & ITCH/BURNING SENSATION MAY INDICATE
EYE/EXCESSIVE SKIN EXPOS. CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY
CAUSE ADVERSE EFTS TO LIVER, URINARY & REPRO SYS. RATS EXPOS TO
TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOS (ING 9)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:104F,40C
Lower Limits:0.2%
Upper Limits:15.3%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:COMBUST. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY
EXPLODE WHEN EXPOS TO EXTREME HEAT. APPLICATION TO (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY - 2. CONTENTS ARE
COMBUST. KEEP AWAY FROM HEAT & OPEN FLAME. CONSULT NFPA CODE. USE
APPRVD BONDING & GROUNDING PROCS.
Other Precautions:KEEP CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY TO
APPRVD CNTNRS W/COMPLETE & APPROP LABELING. DO NOT TAKE INTERNALLY.
KEEP OUT OF REACH OF CHILDREN. USE ONLY W/ADEQ VENT. AVOID BRTHG
VAP & SPRAY MIST. AVOID CONT W/SKIN & EYES. (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR NIOSH APPRVD DUST/MIST RESP FOR DUST WHICH
(SUPDAT)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOS TO INGS IS MAINTAINED BELOW APPLIC EXPOS LIMS. (SUPP DATA)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. RESP PROT:MAY BE GENERATED FROM PROD, UNDERLYING
PAINTS/ABRASIVE. VENT:REFER TO OSHA STD 1910.94, 1910.107, 1910.
108. EXPLO HAZ:HOT SURFS REQS SPECIAL PRECS. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS(ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>174F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.26
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:59.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
(40 CFR 261). WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLIC EPA HAZ WASTE NUMBER. INCIN IN APPRVD FACILITY. DO NOT INCIN
CLSD CNTNR. DISP O F I/A/W FED, STATE & LOC REGS
REGARDINGPOLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:694 CLEAR MARINE SEALANT
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:SILANE, METHYLTRIACETOXY-; (METHYLTRIACETOXYSILANE)
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 2%
OSHA PEL:10 PPM (MFR)
ACGIH TLV:10PPM; 15 STEL (MFR)
Ingred Name:ETHYLTRIACETOXYSILANE
CAS:17689-77-9
Fraction by Wt: 2%
OSHA PEL:10 PPM (MFR)
ACGIH TLV:10PPM; 15 STEL (MFR)
Ingred Name:SILICA, AMORPHOUS
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 8%
OSHA PEL:6 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 TDUST (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DIRECT CONTACT IRRITATES
SLIGHTLY TO MODERATELY WITH REDNESS & SWELLING. SKIN: SINGLE SHORT
EXPOSURE (< 24 HRS) MAY IRRITATE. REPEATED PROLONGED CONTACT (24-48
HRS) MAY IRRITATE MODERATELY. INHA L: VAPOR OVEREXPOSURE MAY
IRRITATE EYES, NOSE & THROAT. INGEST: SMALL AMOUNTS TRANSFERRED TO
MOUTH (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: BY FINGERS DURING USE, ETC., SHOULD
NOT INJURE. SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE
DISCOMFORT. NO INJURY FROM DUSTS SHOULD OCCUR DURING REASONABLE
USE. IF USE CREATES RESPIRABLE PA RTICLES SOME RESPIRATORY SYSTEM
INJURY MAY OCCUR. CURED SEALANT IS NONHAZARDOUS.
Medical Cond Aggravated by Exposure:THIS PRODUCT, AS WITH ANY CHMICAL,
MAY ENHANCE ALLERGIC CONDITIONS ON CERTAIN PEOPLE. MANUFACTURER
DOES NOT KNOW OF ANY MEDICAL CONDITIONS THAT MIGHT BE AGGRAVATED BY
EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: FLUSH WITH WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION. SKIN: GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS. INHAL: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:250F,121C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT KNOWN TO MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PRODUCT AND USE ABSORBENT MATERIAL TO
TAKE CARE OF ANY OIL-LIKE RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 90F/32C. USE REASONABLE
CARE AND CAUTION.
Other Precautions:PROD FORMS ACETIC ACID (HOAC) WHEN EXPOSED TO
WATER/HUMID AIR. PROVIDE VENT DURING USE TO CONTROL HOAC EXPOS W/IN
10PPM (CURRENT TLV) OR USE NIOSH/MSHA APPRVD RESP PROT. PREC ARE
FOR ROOM TEMP HNDLG. USE @ ELEVATED TEMPS/AEROSOL/ (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
UNLESS LOCAL EXHAUST VENTILATION IS INADEQUATE OR AIR SAMPLING DATA
SHOW EXPOSURES ARE WTIHIN TLV & PEL GUIDELINES. SUITABLE
RESPIRATOR: NIOSH/MSHA APPRO VED ACID GAS/ORGANIC VAPOR TYPE.
Ventilation:MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASHING @ MEALTIME & END OF SHIFT IS ADEQ.
REMOVE CONTAMD CLTHG & SHOES AS SOON AS POSS & CLEAN THORO BEFORE
REUSE.
Supplemental Safety and Health
OTHER PREC: SPRAY APPLICATIONS, MAY REQUIRE ADDED PRECAUTIONS. GOOD
PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY CHEMICAL BE REMOVED FROM
SKIN AS SOON AS PRACTICAL, ESPECIALLY BEFORE EATING OR SMOKING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<5 @ 77F
Vapor Density:>1 @ 77F
Spec Gravity:1.04 @ 77F/25C
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:< 0.1%
Appearance and Odor:CLEAR PASTE; ACETIC ACID-LIKE ODOR.
Percent Volatiles by Volume:<5(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:AIR OR MOISTURE CAUSES POLYMERIZATION AND
ACETIC ACID.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MANUFACTURER SUGGESTS THAT ALL LOCAL, STATE AND
FEDERAL REGULATIONS CONCERNING HEALTH & POLLUTION BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT MANUFACTURER IF
THERE ARE ANY DISPOSAL QUESTIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBOWAX PEG 8000, P15510 009
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:POLY(OXY-1,2-ETHANEDIYL), .ALPHA.-HYDRO-.OMEGA.-HYDROXY-
EINECS/ELINCS: UNLISTED.
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT)28 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE MILD EYE
IRRITATION. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
INGESTION: MAY CAUSE GASTROINTESTINAL IRRITATION WITH NAUSEA,
VOMITING AND DIARRHEA. INHALATION: NO HAZARD EX PECTED IN NORMAL
INDUSTRIAL USE. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS. TARGET ORGANS: NONE.
Explanation of Carcinogenicity:CAS# 25322-68-3: NOT LISTED BY ACGIH,
IARC, NIOSH, NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LST 15
MINS, OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN:
FLUSH WITH PLENTY OF SOAP AND WATER FOR AT LST 15 MINS WHILE
REMOVING CONTA MD CLOTHING & SHOES. GET MED AID IF IRRIT DEVELOPS
OR PERSISTS. INGEST: IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS PERSON. GET MED A ID. INHAL: REMOVE FROM EXPOSURE TO
FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT,
GIVE OXYGEN. GET MED AID. NOTES TO PHYS: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=268.C, 514.4F
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR A SELF-CONTAINED
BREATHING APPARATUS IN PRESSURE-DEMAND, NIOSH (APPROVED OR
EQUIVALENT), AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DUSTS A SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES WITH AIR. DURING A FIRE, IRRITATING AND
HIGHLY TOXIC GASES MAY BE GENERATED BY THERMAL DECOMPOSITION OF
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN EXPOSURE CONTROLS, PERSONAL
PROTECTION (SECTION 8). SPILLS/LEAKS: SWEEP UP OR ABSORB MATERIAL,
THEN PLACE INTO A SUITABLECLEAN, DRY, CLOSED CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION! THIS IS EXPECTED TO BE A LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING. MAY CAUSE IRRITATION. USE
WITH ADEQUATE VENTILATION.
Other Precautions:STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
FED REGULATORY INFO: UNDER CWA. OSHA: NONE OF CHEMS IN THIS PROD ARE
CONSIDERED HIGHLY HAZ BY OSHA. SECTION 302(RQ): NONE OF CHEMS IN
MATL HAVE RQ. SECTION 302(TPQ): NONE OF CHEMS IN PROD HAVE TPQ. OS
HA: NONE OF CHEMS IN PROD ARE CONSIDERED HIGH HAZ BY OSHA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=60.C, 140.F
Vapor Pres:NOT AVAILABLE
Vapor Density:NOT AVAIL
Spec Gravity:1.20
pH:NOT AVAIL
Viscosity:NOT AVAIL
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:LD50/LC50: CAS# 25322-68-3: ORAL,MOUSE = 34
GM/KG; ORAL, RABBIT: LD50 = 14 GM/KG; ORAL, RAT: DL50 = 28 GM/KG;
SKIN, RABBIT: LD50 = >20 GM/KG. EPIDEMIOLOGY, TERATOGENICITY,
REPRODUCTIVE EFFECTS, NEUROT OXICITY, MUTAGENICITY, AND OTHER
STUDIES: NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY, ENVIRONMENTAL FATE, PHYSICAL/CHEMICAL AND
OTHER: NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAX CONC OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LISTED. RCRA F, P, & U SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:NO CHEMICAL ARE REPORTABLE UNDER SECTION
313.
Federal Regulatory Information:TSCA CAS #25322-68-3 IS LISTED ON TSCA
INVENTORY. HLTH & SFTY RPTG LIST: NONE OF CHEMS IN PROD ARE UNDER
CHEM TEST RULE. SECTON 12B: NONE OF CHEMS ARE LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT N EW USE FULE: NONE OF CHEMS IN MATL
HAVESNUR UNDER TSCA. CLEAN AIR ACT: THIS MATL DOES NOT CNTN ANY HAZ
AIR POLLUTANTS. THIS MATL DOES NOT CNTN ANY CLASS 1 OZONE
DEPLETORS. THIS MATL DOES NOT CNTN ANY CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD ARE LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS IN PROD ARE LISTED AS TOXIC POLLUTANTS
(SUPDAT)
State Regulatory Information:CAS# 25322-68-3 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: MINNESOTA. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS PROD ARE LISTED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CAT, MIL-C-85285B, TYPE 1, 36375, 03GY292CA
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:DO188
CAGE:33461
CAGE:DO188
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE 0 MM HG) HEXAMETHYLENE
DIISOCYANATE (HDI) (CAS NO. 822-06-02) FREE MONOMER CONTENT*
CAS:28182-81-2
Fraction by Wt: 35%
Other REC Limits:TVL 1 MG/M3 MOBAY
Ingred Name:*LESS THAN 0.7% BASED ON RESIN SOLIDS AT THE TIME OF
MANUFACTURE. AFTER 3-6 MO. STORAGE, THE FREE MONOMER CONTENT MAY **
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:**RISE, MAX-1.6%. THE ACGIH HAS PROPOSED A TLV OF 0.005 PPM
TWA IN THE NOTICE OF INTENDED CHANGES FOR 1987-88. MOBAY ***
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:***RECOMMENDS A CEILING LEVEL OF 0.02 PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE 0 MM HG) HEXAMETHYLENE
DIISOCYANATE (HDI) (CAS NO. 822-06-0), FREE MONOMER ****
CAS:28182-81-2
Fraction by Wt: 40%
Other REC Limits:NONE SPECIFIED
Ingred Name:****CONTENT LESS THAN 0.7% BASED ON RESIN SOLIDS AT TIME OF
MANUFACTURE. AFTER 3-6 MO. STORAGE, THE FREE MONOMER*****
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:*****CONTENT MAY RISE, MAX-1.6%. THE ACGIH HAS PROPOSED A
TLV OF 0.005 PPM IN THE NOTICE OF INTENDED CHANGES FOR******
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:******1987-88. MOBAY RECOMMENDS A CEILING LEVEL OF 0.02
PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:C8&10 AROMATIC HYDROCARBON (VAPOR PRESSURE 3 MM HG)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 8.4 MM HG)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM;200 PPM STEL
ACGIH TLV:150 PPM;200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE(VAPOR PRESSURE .7 MM HG)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 283 G/L
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING;
EYES/NOSE/THROAT. INHALATION MAY CAUSE HEADACHES/DIFFICULT
BREATHING/UNCONSCIOUSNESS. CHRONIC: PREVIOUS REPEATED OVER
EXPOSURE/SINGLE LARGE DOSE, POSSIBLE DEVELOPMENT OF ISOC YANATE
SENSITIZATION CAN CAUSE REACTIONTO LATER EXPOSURE OF ISOCYANATE
LEVELS WELL BELOW THE TLV VALUE OF ISOCYANATES.
Effects of Overexposure:INHALE: IRRITATE-RSPRTRY TRACT/ACUTE NERVOUS
SYSTEM DEPRESSION PROGRESS: HEADACHE/DIZZINESS
STAGGERING/CONFUSION/UNCONSCIOUSNESS/COMA. SKIN:
IRRITATE-SWELL/REDNESS/DRY/DEFAT/CRACK. EYE: IRRITATE/TEAR/
REDNESS/SWELL/STING. INGEST: IRRITATE/CORROSIVE TO MOUTH/STMCH
TISSUE/DIGEST TRACT. CHEM PNEUMONITIS.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISCOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO RISK-FREE AREA. RESTORE BREATHING.
ASTHMA-LIKE SYMPTOMS (IMMED/DELAYED BY HRS). MED ATTN. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH AREAS W/SOAP/WATER. WASH CONTAMINATED
CLOTHING BE FORE REUSE. EYES: FLUSH W/CLEAN LUKEWARM WATER (LOW
PRESSURE)-15 MIN, LIFT LIDS. MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. NOTHING BY MOUTH TO AN UNCONSCIOUS PERSON. MEDICAL
ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:76.0F,24.4C
Lower Limits:1
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:FULL GEAR W/SELF-CONTAINED BREATHING APPARATUS
ON FIREFIGHTERS. WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP/AUTO IGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:CNTNRS CLSD. NO HEAT/SPARKS/ELECTRICAL
EQUIPMENT/OPEN FLAME. CLSD CNTNRS MAY EXPLODE W/EXTREME HEAT.
APPLIC TO HOT SURFACES--SPECIAL PRECAUTIONS. DECOMP HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAR AREA. REMOVE ALL SOURCES OF IGNITION
(FLAME/SPARK SOURCES/HOT SURFACES). VENTILATE AREA. CONTAIN AND
REMOVE WITH INERT ABSORBANT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:BUILDINGS DESIGNED TO COMPLY WITH OSHA
1910.106. NO STORING NEAR HIGH TEMPERATURES, FIRE, OPEN FLAME,
SPARK SOURCES. WELL VENTILATED AREAS.
Other Precautions:CONTAINERS TIGHT/UPRIGHT-NO LEAKAGE. NO PROLONGED
BREATHING VAPORS/SPRAY MISTS--MAY CAUSE ALLERGIC REACTION. NO
CONTACT SKIN/EYES. NO INGESTION. UNDERSTAND MFR'S SAFETY
PRECAUTIONS. SUBJECT TO REPORTI NG REQUIREMENTS OF SECTION 313 OF
THE*
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED RESPIRATOR RECOMMENDED FOR ORGANIC
VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBSERVE
OSHA REGULATIONS FOR RESPIRATOR USE. VENTILATION TO KEEP EXPOSURE
LEVELS BELOW OSHA LIMITS.
Ventilation:VENTILATION SUFFICIENT TO KEEP AIRBORNE CONCENTRATIONS OF
SOLVENT VAPORS OR MISTS BELOW TLV'S. NO IGNITE SOURCES.
Other Protective Equipment:FACE SHEILDS. LONG SLEEVES/LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
*SUPERFUND AMENDMENTS REAUTHORIZATION ACT OF 1986 & 40 CFR 372.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:260 TO 338F
Vapor Density:>AIR
Spec Gravity:1.08
Viscosity:*
Evaporation Rate & Reference:0.15 (X N-BUTYL ACETATE)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:30.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURES: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DUE TO PRODUCT RESIDUE AND FLAMMABLE VAPOR DO NOT
INCINERATE CLOSED CONTAINERS/HANDLE WITH CARE. EPA HAZARDOUS WASTE
NUMBER/CODE: D001, F003, F 005.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:75974201 POLYESTER RESIN DION ISO 6631T
CAGE:GO898
CAGE:GO898
CAGE:80592
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE, MONOMER (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 50%
Other REC Limits:50 PPM
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYESTER RESIN
OSHA PEL:100 MG/CUM
ACGIH TLV:100 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, TEARING, BLURRED
VISION, CORNEAL DAMAGE. SKIN: IRRITATION, DAMAGE TO INTERNAL
ORGANS. INHALATION: IRRITATION OF RESPIRATORY TRACT, NOSE/THROAT,
HEADACHES, DIZZINESS, NAUSEA, WEAKNESS , COLLAPSE, COMA, DEATH,
LIVER/KIDNEY DAMAGE/HARMFUL. INGESTION: DIZZINESS, NAUSEA, STOMACH
UPSET, & HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, TEARING, BLURRED VISION,
CORNEAL DAMAGE. SKIN: IRRITATION, DAMAGE TO INTERNAL ORGANS.
INHALATION: IRRITATION OF RESPIRATORY TRACT, NOSE/THROAT,
HEADACHES, DIZZINESS, NAUSEA, WEAKNESS , COLLAPSE, COMA, DEATH,
LIVER/KIDNEY DAMAGE/HARMFUL. INGESTION: DIZZINESS,NAUSEA, STOMACH
UPSET, & HARMFUL.
Medical Cond Aggravated by Exposure:AILMENTS OF KIDNEY, LIVER, SKIN &
RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS.
SKIN: WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE FROM
EXPOSURE. IF BREATHING HAS STOPPED OR IS DIFFICULT, ADMINISTER
ARTIFICIAL RESPI RATION OR OXYGEN AS INDICATED. INGESTION: DON'T
INDUCE VOMITING. NOTE TO PHYSICIAN: THERE IS NO SPECIFIC ANTIDOTE
FOR EFFECTS FROM OVEREXPOSURE. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:85F
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:USE CO2, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WEAR PROTECTIVE
EQUIPMENT INCLUDING FULL-FACE SELF-CONTAINED BREATHING APPARATUS.
FIRE FIGHTING AT A MAXIMUM DISTANCE/PROTECTED AREAS.
Unusual Fire/Explosion Hazard:VAPORS FORM FLAMMABLE/EXPLOSIVE MIXTURES
IN AIR, MAY TRAVEL/GROUND TO IGNITION SOURCE & FLASH. POLYMERS MAY
FORM IN STORAGE TANK VENT/FLAME/EXPLOSIVE RUPTURING.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. STAY UPWIND.
SMALL SPILLS: TAKE UP W/SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
MATERIAL. FLUSH AREA W/WATER. DIKE LARGE SPILLS FOR LATER DISPOSAL.
CONTAIN RUNOFF FROM FIRE CONTROL/DILUTION WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING OF VAPORS, MISTS OR
FUMES, CONTACT W/SKIN & EYES. KEEP IN A CLOSED, LABELED CONTAINER
W/IN A COOL (WELL SHADED), DRY VENTILATED AREA.
Other Precautions:PROTECT FROM PHYSICAL DAMAGE. NOT FOR USE OR STORE IN
OR AROUND THE HOME. GROUND/BOND DRUMS. DON'T USE PRESSURE TO EMPTY
DRUMS. DON'T USE W/O FULLY UNDERSTANDING "REACTIVITY DATA".
FLAMMABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOESN'T KEEP <TLV/PEL. IF WITHIN
OSHA PROTECTION FACTOR, AIR PURIFYING CV/FILTER UNITS OK.
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST/MECHANICAL VENTILATION IN
PATTERN/VOLUME <TLV
Other Protective Equipment:RESISTANT PROTECTIVE GARMENTS, APRONS,
COVERALLS, BOOTS, ETC.
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING BEFORE REUSE.
OBSERVE GOOD HYGIENE/SAFETY PRACTICES WHEN HANDLING THIS PRODUCT.
Supplemental Safety and Health
DON'T USE THIS PRODUCT UNTIL MSDS HAS BEEN READ/UNDERSTOOD. DON'T WEAR
CONTAMINATED CLOTHING. DISCARD CONTAMINATED FOOTWEAR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:295F
Vapor Pres:4.5
Spec Gravity:0.9-1.2
pH:<7
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:VISCOUS LIQUID W/A STYRENE ODOR.
Percent Volatiles by Volume:20-70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, CAUSTIC, METALLIC HALIDES (SALTS), FREE
RADICAL CATALYSTS & PEROXIDE.
Stability Condition to Avoid:OPEN FLAME & HEAT.
Hazardous Decomposition Products:SMOKE, CO, CO2
Conditions to Avoid Polymerization:HEAT, OXIDIZING AGENTS, FREE RADICAL
CATALYSTS & PEROXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DOT REPORTABLE QUANTITIES IS 1000 LBS. DISPOSE
OF IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS. LIQUID
POLYESTER RESIN WASTE HAVING A FLASH POINT <140F IS A HAZARDOUS
WASTE UNDER RCRA HAVING TH E CHARACTERISTIC OF IGNITABILITY-D001.
FLAMMABLE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRO-SEAL 872 B-2 #0872B10
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 20.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TOLUENE (SARA 313) (CERCLA) (VP = 23)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYSULFIDE POLYMER (NON-HAZARDOUS)
CAS:68611-50-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALUMINUM POWDER (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:FENOLIC RESIN POWDER NON-HAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:SILICA DERIVITIVES
CAS:67762-90-7
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: BURNING, TEARING, REDDENING.
SKIN: DRYING, CRACKING, DERMATITIS. INHAL: DIZZINESS, DROWSINESS,
FATIGUE, LIVER/KIDNEY DAMAGE. INGEST: DROWSINESS, DIZZINESS,
NAUSEA. CHRONIC: DISTURBANCE IN MEMORY, THINKING ABILITY,
EMOTIONS, & COORDINATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKEWARM WATER FOR 15 MINUTES, CALL DR. SKIN:
WASH W/SOAP & WATER, CALL DR. INHAL: REMOVE TO FRESH AIR, CALL DR.
INGEST: CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:74.0F,23.3C
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEANUP RESIDUE
W/SUITABLE SOLVENT. CERCLA RQ FOR TOLUENE, 1000 LBS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DONT
STORE >120F. GROUND/BOND WHEN TRANSPORTING.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DONT
CUT/PUNCTURE/WELD ON/NEAR DRUM. VAPORS ARE >AIR, MAY COLLECT IN
LOW/CONFINED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN APPLYING IN ANY CIRCUMSTANCES LIKELY TO
PRODUCE AIRBORNE LEVELS OF HAZARDOUS INGREDIENTS IN EXCESS OF TLV,
USE ORGANIC VAPOR CARTRIDGE OR AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENT TO MAINTAIN VAPORS BELOW TLV.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, BEFORE SMOKING
OR EATING. AVOID INGESTION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Vapor Density:>AIR
Spec Gravity:1.46
VOC Pounds/Gallon:66
Evaporation Rate & Reference:NA
Appearance and Odor:WHITE PASTE.
Percent Volatiles by Volume:15.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR DIOXIDE,
TRACES OF HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDER/STATE/LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-22750 E PART A M1-048, M22750-1X-26595
Kit Part:Y
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE. VP: 38
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-20%
OSHA PEL:100PPM;150PPM STEL
ACGIH TLV:50 PPM,S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A
CAS:25085-99-8
Fraction by Wt: 20-50%
Ingred Name:DILUENT 8
CAS:68609-97-2
Fraction by Wt: 1-5%
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK). VP: 71.2
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-20%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER) CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE HYDRATE) (CONTAINS ING 6 AT 1%-0.1%)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-20%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CRYSTALLINE SILICA
Ingred Name:VOLATILE ORGANICS COMPOUNDS: 203 GPL
RTECS #:9999999VO
Ingred Name:SUPP DATA: ELEVATED TEMP PROCESS CNDTNS, ESP IN PROCESS
OPERATING UNDER VACUUM IF SUBJECTED TO SUDDEN INGRESS OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: AIR/OUTSIDE PROCESS EQUIP OPERATING UNDER ELEVATED
PRESS IF SUDDEN ESCAPE OF VAPS/MISTS TO ATM OCCURS. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:ANY PROPOSED USE OF PROD IN ELEVATED TEMP PROCESSES
SHOULD BE THORO EVALUATED TO ASSURE THAT SAFE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: OPERATING CNDTNS ARE ESTABLISHED AND MAINTAINED.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: 1991. ANTICIPATED TO BE A CARCINOGEN.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: AIR SAMPLING TEST.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP MAY PRDCE VARIOUS EFTS,
INCL: ACUTE TOX, RSLTG IN HDCH, DIZZ, NAUS, & LOSS OF
CONSCIOUSNESS. SEV EYE IRRIT POSS RSLTG IN PERM DAM. IRRITATED MUC
MEMB. VOMIT DUE TO INGEST. DEFAT & DRY O F SKIN. SENSIT AFTER RPTD
CONT. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNGD OCCUP OVEREXP TO SOLV
W/PERM (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: IARC 2A, IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 341, 1987. NTP 6TH ANNUAL REPORT
ON CARCIN, (ING 12
Effects of Overexposure:HLTH HAZ: BRAIN & NERV SYS DAM. INTENTIONAL
MISUSE BY DELIB CONC & INHALING CONTENTS MAY BE HARMFUL/FATAL.
NOTE: TOLUENE (CAS # 108-88-3) APPEARS ON NAVY LISTING OF OCCUP
CHEM REPROD HAZARDS. SEEK CON SULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HNDLG &
EXPOS INFO .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF CLEAN LUKEWARM LOW PRESS WATER FOR @
LST 15 MIN, OCCAS LIFTING LIDS OPEN. GET MED ATTN. INHAL: REMOVE TO
FRESH AIR & PROVIDE OXYGEN IF BRTHG DFCLT. GIVE ARTF RESP IF NOT
BRTHG. G ET MED ATTN. KEEP WARM & COMFORTABLE. NEVER GIVE AN UNCON
PERSON LIQ. INGEST: CALL PHYS IMMED. ONLY INDUCE VOMIT ON
INSTRUCTIONS OF PHYS. IF VOMIT OCCURS SPONT, KEEP HEAD BELOW HIPS
TO PVNT(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:1.2%
Extinguishing Media:FOAM, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE USED TO KEEP EXPOSED CONTAINERS COOL, AND TO KEEP
FLAMMABLE STRUCTURE WET.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING-FLAMM. ELIM ALL IGNIT SOURCES.
HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING. SOAK UP
WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL TIGHTLY
FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS A HAZARDDOUS-FLAMMABLE
MATERIAL. KNOW APPLICABLE D.O.T. REGULATIONS BEFORE ATTEMPTING TO
TRANSPORT THIS MATERIAL.
Other Precautions:WARNING:HOT ORG CHEM VAPS/MISTS ARE SUSCEPTIBLE TO
SUDDEN SPONT COMBUST WHEN MIXED W/AIR. IGNIT MAY OCCUR @ TEMPS
BELOW THOSE PUBLISHED AS "AUTOIGNIT" TEMPS. IGNIT TEMP DECR
W/INCREASING VAP VOL & VAP /AIR CONTACT TIME & ARE (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQ VENT TO MAINTAIN VAP
CONC BELOW ESTABLISHED TLV LIM AS GIVEN BY OSHA. IN MORE CONFINED
AREAS A NIOSH/MSHA APPRVD RESP EQUIPPED W/ORG VAP CARTRIDGE SHOULD
BE WORN. WHEN IN D OUBT WEAR APPRVD RESP & ORDER (ING 13)
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ASPIR OF LIQ INTO LUNGS. NEVER GIVE ANYTHING BY MOUTH
TO UNCON PERSON. SKIN: FLUSH W/WATER WHILE REMOVING CONTAMD CLTHG &
SHOES. FOLLOW BY WASHING W/SOAP & WATER. DO NOT REUSE CONTAMD
CLTHG/SHOES. IF IRRIT PERSISTS, GET MEDATTN. OTHER PREC:INFLUENCED
BY PRESS CHANGES. IGNITE MAY OCCUR @ TYPICAL (ING 8)
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>174F,>79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.168
Evaporation Rate & Reference:3.41(N-BUTYL ACETATE=1)
Appearance and Odor:WHITE LIQUID
Percent Volatiles by Volume:24.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITIES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE AND FEDERAL REGULATION. CONTACT AN APPROVED DISPOSAL
FACILITY.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-387-5930
Product ID: CITRUS-KLEEN #1095
Cage: 93607
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 93607
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: CLEANING COMPOUND, SOLVENT-DETERGENT
Unit of Issue: CN
UI Container Qty: 5 GL CN
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CAUSES SKIN/EYE IRRIT. DO NOT INGEST. HARMFUL IF
SWALLOWED. MAY CAUSE SEVERE MUCOSAL DAMAGE & GASTRIC DISTRESS. MAY CAUSE
SYSTEMIC INTOXICATION.
Medical Cond Aggravated By Exposure: MAY AGGRAVATE EXISTING DERMATITIS &
IRRITATE SENSITIVE SKIN.
First Aid: EYES: FLUSH W/WATER 15 MIN. GET MED AID. SKIN: THOROUGHLY WASH
W/WATER & APPLY CREAM. IF IRRIT PERSISTS, GET MED AID. INGESTION: DON'T
INDUCE VOMITING. GIVE MILK, EGG WHITE, GELATIN, WATER. GET IMMEDI ATE MED
AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RECONTAINERIZE BY MOPPING, WET VACUUM OR USE SUITABLE
ABSORBENT. RINSE REMAINING MATERIAL TO DRAINS. BE CAUTIOUS OF SLIPPERY
FLOORS.
Waste Disposal Methods: FOLLOW LOCAL, STATE, FEDERAL REGS.
Handling And Storage Precautions: STORE BETWEEN 40-120F.
Other Precautions: KEEP AWAY FROM CHILDREN. FOR SALE, USE, STORAGE BY SERVICE
PERSONNEL ONLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TOC
Flash Point Text: NONE TO BOILING
Lower Limits: NOT EST.
Upper Limits: NOT EST.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: GENERALLY NOT REQUIRED.
Ventilation: LOCAL.
Other Protective Equipment: RUBBER BOOTS SHOULD BE WORN IF WORKING IN STANDING
SOLUTIONS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Vapor Pres: =WATER
Vapor Density: =WATER
Spec Gravity: 1.062
PH: 13.5
Evaporation Rate & Reference: =WATER
Solubility in Water: COMPLETE
Appearance and Odor: ORANGE LIQUID, ORANGE ODOR
Percent Volatiles by Volume: 87.0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: ACIDS, OXIDIZERS.
Hazardous Decomposition Products: CARBON OXIDES, AMINES.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 132746
Product ID: CITRUS-KLEEN #1095
Review Date: 04/24/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CN
Container QTY: 5 GL CN
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: CITRUS-KLEEN #1095
Cage: 93607
Company Name: NATIONAL CHEMICAL LABORATORIES OF PENNSYLVANIA INC
Street: 401 N 10TH ST
Zipcode: 19123-3803
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CAUSES SKIN/EYE IRRIT. DO NOT INGEST. HARMFUL IF
SWALLOWED. MAY CAUSE SEVERE MUCOSAL DAMAGE & GASTRIC DISTRESS. MAY CAUSE
SYSTEMIC INTOXICATION.
NK
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SUPERIOR NO.11
CAGE:6F776
CAGE:6F776
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM NITRATE
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 30.0%
Ingred Name:SODA ASH
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 30.0%
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
CAS:1303-96-4
RTECS #:VZ2275000
Fraction by Wt: 30.0%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3; 9192
===================== Hazards Identification =====================
Effects of Overexposure:LARGE AMOUNTS TAKEN BY MOUTH MAY HAVE SERIOUS
OR EVEN FATAL EFFECTS
======================= First Aid Measures =======================
First Aid:EXTERNALLY:WASH WITH WATER WHEN EXPOSED TO EYES OR SKIN.
INTERNALLY:DRINK SEVERAL GLASSES OF WATER OR MILK & CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE
Fire Fighting Procedures:USE PLENTY OF WATER
Unusual Fire/Explosion Hazard:MODERATE, WHEN MIXED WITH ORGANIC MATTER,
WILL IGNITE ON FRICTION.EXPLODES WHEN MIXED WITH CYANIDES
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER MATERIAL IS RELATIVELY
HARMLESS EXCEPT ON INGESTION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM EXTREME HEAT
Other Precautions:STORE IN DRY, COOL AREA. WATER OR MOISTURE WILL
REDUCE SHELF LIFE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON-TOXIC, MASK WHEN WORKING OR BRAZING
Ventilation:MECHANICAL IS PREFERRED
Other Protective Equipment:USUAL & CUSTOMARY
Supplemental Safety and Health
ITEM IS TYPE "C" OF MIL-F-16136
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSED
Spec Gravity:2.15
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE HYGROSCOPIC POWDER, SLIGHT BITTER TASTE
Percent Volatiles by Volume:1.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING MATERIALS AT HIGH TEMPERATURES
Stability Condition to Avoid:HEATING IN PRESENCE OF CYANIDES OR OTHER
REDUCING AGENTS
Hazardous Decomposition Products:FMES CONTAIN NITROGEN OXIDES & B2O*3
==================== Disposal Considerations ====================
Waste Disposal Methods:WASH WITH ABUNDANT WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AWLGRIP LINEAR POLYURETHANE TOPCOAT-GLOSS COLOR BASE
CAGE:HO579
CAGE:HO579
CAGE:90608
============= Composition/Information on Ingredients =============
Ingred Name:ING 18: BREATHE VAPS, SPRAY MIST/SANDING DUSTS. DO NOT GET
IN EYES, ON SKIN/ON CLTHG. FOR INDUSTRIAL USE ONLY, (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: BY PROFESSIONAL, TRAINED PERSONNEL USING PROPER
EQUIPMENT. NOT INTENDED FOR SALE TO/USE BY THE GENERAL PUBLIC.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:VENT: (GENERAL AND/OR LOCAL EXHAUST) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: AND FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:VOLATILE ORGANIC CONTENT (MATERIAL): 475-591 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: RSLT IN CNS DEPRESS, HEMORRHAGES INTO
VARIOUS VITAL ORGANS HAVE BEEN NOTED, NARCOTIC EFTS HAVE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: BEEN NOTED, MAY CAUSE INJURY TO KIDNEYS, LIVER &
LUNGS, CORNEAL EFTS MAY OCCUR, COMA MAY RSLT FROM (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OVEREXP. REPORTS HAVE ASSOC RPTD & PRLNG OCCUP
OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG. INTENTIONAL (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: MISUSE BY DELIBERATELY CONCENTRATING & INHALING
CONTENTS MAY BE HARMFUL/FATAL. WARNING! HARMFUL/FATAL IF (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: SWALLOWED. HARMFUL IF INHALED/ABSORBED THRU SKIN.
OVEREXP MAY CAUSE BLOOD DISORDERS. BASED ON TESTS W/ (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: LAB ANIMALS, OVEREXP MAY CAUSE REPRO DISORDERS &
BIRTH DEFECTS. WARNING! THIS PROD CONTAINS A CHEMICAL (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER,
BIRTH DEFECTS OR REPRODUCTIVE HARM.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IF BRTHG CEASES, RESTORE USING APPROVED CPR
TECHNIQUES, AND SUMMON MEDICAL HELP IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL
AT SOURCE, CONTAIN AREA OF SPILL TO PVNT SPREADING, (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: PUMP LIQ TO SALVAGE TANK. REMAINING LIQ MAY BE
ABSORBED W/INERT MATL SUCH AS SAND, CLAY, EARTH/FLOOR (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: ABSORB & SHOVELED INTO CONTRS W/NON-SPARKING TOOLS.
PVNT RUN-OFF TO SEWERS, STREAMS/OTHER BODIES OF (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: WATER. IF RUN-OFF OCCURS, NOTIFY THE PROPER
AUTHORITIES AS REQUIRED THAT A SPILL HAS OCCURRED.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: & PREC ON LABELS OF ALL PROD BEING BLENDED AS
COMBINATION MAY CONTAIN HAZ OF EACH COMPONENT. DO NOT (ING 19)
RTECS #:9999999ZZ
Ingred Name:2-BUTANONE VP: 70 @ 20C
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2-5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-ETHOXY-, ACETATE; (CELLULOSE ACETATE
2-ETHOXYETHYLETHANOATE) VP: 2 @ 20C
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 16-23%
OSHA PEL:100 PPM, S
ACGIH TLV:5 PPM, S
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL MONOMETHYL ETHER ACETATE) VP: 4 @ 20C
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 9-24%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:XYLENE; (DIMETHYL BENZENE) (SARA 313) (CERCLA) VP: 10 @ 20C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-6%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAN CAUSE SEV IRRIT,
REDNESS, TEARING & BLURRED VISION. SKIN: PRLNG/RPTD CONT CAN CAUSE
MOD IRRIT, DEFAT & DERM. SOLV CAN PENETRATE SKIN CAUSING EFTS
SIMILAR TO THOSE IDENTIFIED UNDER ACUT E BRTHG SYMP. INHAL: EXCESS
INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS,
HDCH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: POSS UNCON & EVEN ASPHY. MAY ALSO
CAUSE TIGHTNESS IN CHEST. INGEST: HARMFUL, CAN CAUSE BURNING
SENSATION, SORE THROAT, ABDOM PAIN, NAUS, VOMIT & DIARR. CHRONIC:
PRLNG & RPTD BRTHG OF SPRAY M IST &/SANDING DUST OVER PERIOD OF YRS
MAY CAUSE DISEASES OF LUNGS. CAN CAUSE IRRIT TO MUC MEMB. HIGH VAPS
MAY (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AREA THORO W/SOAP & WATER. REMOVE SOILED CLTHG.
GET MED ASSIST IF IRRIT PERSISTS. WASH CLTHG BEFORE REUSE. EYE:
FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15 MIN. GET MED ASSIST.
INGEST: GET ME D ATTN IMMED. DO NOT INDUCE VOMIT. ASPIR OF MATL
INTO LUNGS CAN CAUSE CHEM PNEUMIT WHICH CAN BE FATAL. INHAL: IF
DFCLT BRTHG OBTAIN FRESH AIR. IF CONTINUED DFCLT, SUMMON MED ASSIST
IMMED. (ING 13)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Lower Limits:1.10%
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, OR OTHER
APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. SUMMON PROFESSIONAL FIREFIGHTERS. DURING FIRE, TOX GASES & SMOKE
ARE IRRIT PRESENT FROM DECOMP/ (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT, SPARKS & FLAME. DO
NOT SMOKE. EXTING ALL PILOT LIGHTS & TURN OFF ALL SOURCES OF IGNIT,
INCL HEATERS, FANS & OTHER NON-EXPLO-PROOF (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SML SPILL: ABSORB ON INERT MATL SUCH AS PAPER,
VERMICULITE, FLOOR ABSORB & TRANSFER TO HOOD. LGE SPILL: ELIM ALL
IGNIT SOURCES (FLARES, FLAMES INCL PILOT LIGHTS, ELEC SPARKS). PERS
NOT WEARING PROT EQ UIP SHOULD BE EXCLUDED FROM AREA OF SPILL (ING
14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT TO PVNT
LEAKAGE. KEEP CONTR CLSD WHEN NOT IN USE. DO NOT STORE > 120F. DO
NOT TRANSFER CONTENTS TO BOTTLES/OTHER(SUP DAT)
Other Precautions:CONTRS OF THIS MATL MAY BE HAZ WHEN EMPTIED BECAUSE
THEY RETAIN PROD RESIDUES (VAP, LIQ, &/SOLID). ALL HAZ PREC GIVEN
IN THIS MSDS MUST BE OBSERVED. IMPORTANT!! THIS PROD MAY BE BLENDED
W/OTHER PROD P RIOR TO USE. READ ALL WARNINGS (ING 18)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROP, PROPERLY FITTED RESP (NIOSH/MSHA
APPRVD) DURING & AFTER APPLICATION UNLESS AIR MONITORING
DEMONSTRATES VAP, MIST & PARTICULATE LEVELS ARE BELOW APPLIC LIM.
FOLLOW RESP MFR'S DIRECTIONS FO R RESP USE. ENGINEERING/ADMIN (ING
21)
Ventilation:USE ONLY WITH ADEQUATE VENTILATION. MAINTAIN CONTINUOUS
FLOW OF FRESH AIR. PROVIDE SUFFICIENT MECHANICAL (ING 22)
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING AND BOOTS.
EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: COMBUST. CLSD CONTR MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. EXPLO HAZ: ELEC EQUIP, DURING USE & UNTIL ALL VAPS
ARE GONE. VAPS MAY IGNITE EXPLO. VAPS MAY SPREAD LONG DIST & BEYOND
CL SD DOORS. PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINUOUS FLOW
OF FRESH AIR. HNDLG/STOR PREC: UNLABELED CONTAINERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>172F,>78C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:50-63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POTASSIUM-TERT-BUTOXIDE, PERMANGENATE, CHLOROFORM, CHLOROSULFONIC ACID,
HYDROGEN PEROXIDE, NITRIC ACID.
Stability Condition to Avoid:EXCESS HEAT AND/OR OXIDIZING MATERIALS.
Hazardous Decomposition Products:MAY DECOMPOSE INTO FUMES CONTAINING
CARBON MONOXIDE AND CARBON DIOXIDE. WHEN HEATED TO DECOMPOSITION
EMITS TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD
BEING SURE TO ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR
HOOD DUCT WORK. DISP OF CONTAMINATED ABSORBENT CONTR & UNUSED
CONTENTS I/A/W LOCAL, STATE & FEDERAL REGS. DO NOT INCINERATE
CLOSED CONTRS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:140S VINYL ENAMELS,CHASSIS BLACK,DUCO BLACK,VINYL CLEARS
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT (IARC CARCINOGEN
GROUP 3) *96-2*
CAS:8052-42-4
RTECS #:CI9900000
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:GILSONITE
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, DERMATITIS &
BURNING. EYES: IRRITATION & BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURN.
======================= First Aid Measures =======================
First Aid:INGESTION: CALL PHYSICIAN IMMEDIATELY & HAVE THE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL A TTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<73F
Lower Limits:1
Upper Limits:13.1
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/EXPLOSED. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP 120F.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. OBSERVE
LABEL PRECAUTIONS. DON'T BREATHE VAPORS/MISTS. DON'T PERMIT ANYONE
W/O PROTECTION IN T HE PAINTING AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED.
CONFINED SPACES, WEAR A POSITIVE-PRESSURE , SUPPLIED AIR RESPIRATOR
(TC-19C).
Ventilation:SUFFICIENT VENTILATION
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:129-437F
Vapor Density:>1
VOC Grams/Liter:3.7
Evaporation Rate & Reference:(ETHER =1): <1
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:61-92
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW TO CONTAMINATE GROUND WATER SYSTEMS.
INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE
LIQUID, UN1263.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:X306
CAGE:98502
CAGE:98502
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CHROMATE (SARA III)
CAS:13765-19-0
RTECS #:GB2750000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG CR/M3
ACGIH TLV:0.001 MG/M3;A2, 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD SULFOCHROME
CAS:1344-37-2
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPN
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 15-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 20-35%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION;IRRITATION OF MUCOUS
MEMBRANES AND PULMONARY FIBROSIS. EYES;BURNS,REDNESS,CINJUCTIVNESS.
SKIN;REDNESS,SWELLING,BURNS POSSIBLE
ULCERATIONS.INGESTION;IRRITATION,CHEMICAL BURNS OF THE MOUTH, T
HROAT AND ESOPHAGUS AND STOMACH
Effects of Overexposure:INHALATION;ASPHYXIATION. EYES; SENSATION OF
SEEING HALOS AROUND LIGHTS. SKIN; CRACKING,IRRITATION
ANDDERMITITIS.
Medical Cond Aggravated by Exposure:NONE GIVEN
======================= First Aid Measures =======================
First Aid:INHALATION;REMOVE TO FRESH AIR,GIVE CPR IF REQUIRED.
SKIN;WASH WITH SOAP AND WATER. EYES;FLUSH WITH WATER FOR 15MINUTES
GET MEDICAL ATTENTION. INGESTION; DRINK ONE OR TWO GLASSES OF WATER
TO DILUTE, D O NOT INDUCE VOMITING,CONSULT PHYSCIAN OR POUSON
CONTROL OFFICE IMMEDIATELYTREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.0
Upper Limits:UNK
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE WATER TO COOL
CONTAINERS EXPOSED TO FIRE. WEAR SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION,AVOID BREATHING
VAPORS, VENTILATE AREAS, REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:STORE OUT OF SUN AND AWAY FROM
HEAT,SPARKS AND OPEN FLAMES, CLOSE CONTAINERS AFTER EACH USE.
Other Precautions:DO NOT TAKE INTERNALLY, USE APPROVE GROUNDING
PROCEDURES, NEVER USE PRESSURE TO EMPTY.DO NOT WELD OR CUT DRUM.
READ SAFETY PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH RESPIRATOR WHERE TLVS ARE EXCEEDED
Ventilation:LOCAL TO MAINTAIN TLVS BELOW.
Other Protective Equipment:NA
Work Hygienic Practices:EWASH HANDS BEFORE EATING,SMOKING OR USING
WASHROOM
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:UNK
Vapor Density:> AIR
Spec Gravity:UNK
Evaporation Rate & Reference:< ETHER
Solubility in Water:UNK
Appearance and Odor:GREEN PRIMER
Percent Volatiles by Volume:73.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:NA
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY, DO NOT
INCINERATE CLOSED CONTAINERS, DISPOSE IN ACCORDANCE WITH LOCAL,
STAE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BATTERY, STORAGE (NICKEL-CADMIUM)
CAGE:74025
CAGE:74025
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA III)
CAS:7440-43-9
RTECS #:EU9800000
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CADMIUM HYDROXIDE
CAS:21041-95-2
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3 (CD FUME)
ACGIH TLV:0.05 MG/M3 (CD FUME)
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:NICKEL HYDROXIDE (SARA III)
CAS:12054-48-7
RTECS #:QR7040000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG NI/M3
ACGIH TLV:0.1 MG NI/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 225 MG/KG CD(OH)2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:POTASSIUM HYDROXIDE: INHALATION OF
AIRBORNE DUST OR MIST MAY CAUSE DAMAGE TO THE UPPER RESPIRATORY
TRACT AND EVEN TO THE LUNG TISSUE. CADMIUM/CADMIUM HYDROXIDE: MAY
CAUSE IRRITATION OF MUCOUS MEMBRANE S. CHRONIC EXPOSURE MAY CAUSE
IRREVERSIBLE LUNG INJURY, KIDNEY DISEASE & OTHER ADVERSE EFFECTS.
Explanation of Carcinogenicity:NICKEL/NICKEL COMPOUND ARE LISTED AS
CARCINOGENIC TO HUMANS BY IARC.
Effects of Overexposure:POTASSIUM HYDROXIDE: INHALATION CAN PRODUCE
CHEMICAL PNEUMONIA. THIS MATERIAL IS DESTRUCTIVE TO SKIN TISSUE,
EYE TISSUE, & MOUTH, THROAT, STOMACH TISSUES. CADMIUM/CADMIUM
HYDROXIDE: CAN PRODUCE DRYNES S OF THE MOUTH & THROAT, HEADACHE,
NAUSEA & DIZZINESS. INGESTION CAN CAUSE NAUSEA, VOMITING, DIARRHEA
& ABDOMINAL CRAMPS
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:POTASSIUM HYDROXIDE: FLUSH EYES FOR 15 MINUTES WITH WATER AND
WASH SKIN TISSUE WITH WATER. IF PATIENT IS CONSCIOUS GIVE LARGE
QUANTITIES OF WATER. DO NOT INDUCE VOMITING. GET EMERGENCY MEDICAL
ATTENTI ON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR PROPER PROTECTIVE
EQUIPMENT AND SELF CONTAINED BREATHING APPARATUS WITH FULL
FACE-PIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDOZERS MAY CAUSE
FIRE OR EXPLOSION. CADMIUM FUMES OR VAPORS ARE TOXIC AND CAN CAUSE
DEATH.
================== Accidental Release Measures ==================
Spill Release Procedures:BATTERY AND CELL CASES WILL NORMALLY CONTAIN
MATERIALS OF CONCERN. USE INDUSTRIAL ABSORBENT TO COLLECT LIQUID
POTASSIUM HYDROXIDE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT INVERT. AVOID BREAKING,
CRUSHING OR OTHERWISE DESTROYING THE PHYSICAL INTEGRITY OF THE CELL
OR BATTERY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A DUST OR MIST MASK WHEN HANDLING THE
POTASSIUM HYDROXIDE SOLUTION.
Ventilation:USE ADEQUATE LOCAL EXHAUST VENTILATION WHEN HANDLING THE
LIQUID IN THE BATTERY.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO MINIMIZE SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:Z5
Melt/Freeze Pt:M.P/F.P Text:DECOM 300C
Solubility in Water:INSOLUBLE
Appearance and Odor:NO ODOR. WHITE SALT. (CADMIUM HYDROXIDE)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT, NITRATES, NITRIC CAID.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CELLS AND BATTERIES MAY BE RTETURNED AT SENDERS
EXPENSE TO MARATHON POWER TECHNOLOGIES. DISPOSAL SHALL BE BY
APPROVED METHODS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FC2207-FO, COLOR FC2207 OR COLOR PRINTER (SUPDAT)
CAGE:CLRCS
CAGE:CLRCS
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYL POLYSILOXANE (NON HAZARDOUS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:5,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: TRANSIENT WEAK IRRITATION. SKIN:
NON-IRRITANT. INHAL: ESSENTIALLY NON-TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE LIQUID FROM SKIN W/A DRY TOWEL AND WASH EXPOSED
AREA W/DETERGENT. EYE: IMMED FLUSH WITH WATER FOR AT LEAST 15
MINUTES. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) (FP N ). INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point:>204F,>96C
Extinguishing Media:CO*2, DRY CHEMICALS, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL
FIRE/EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FLUID FOR SALVAGE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS ARE
NEEDED FOR SAFETY REASONS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART #: CP4007 FUSER OIL.
================== Physical/Chemical Properties ==================
Spec Gravity:0.97-0.98
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, TRANSPARENT, ODORLESS FLUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SIO, CO*2 AND TRACES OF INCOMPLETELY
BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN COMPLIANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:P104J
CAGE:00656
CAGE:00656
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PYROPEL P 84 POLYIMIDE FIBER
CAGE:24173
CAGE:24173
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP)
. INGEST: CALL MD IMMED . SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD . EYE: IMMED FLUSH WITH POTABLE WATER FOR AMINIMUM
OF 15 MIN,SEEK ASSISTANCE FROMMD .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE, NON-FLAMMABLE MATERIAL, LOI-38.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:NONE
Spec Gravity:1.41(H2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW FIBROUS SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LONG TERM EXPOSURE TO CAUSTIC.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL BY LOCAL ACCEPTABLE METHOD FOR NON-
HAZARDOUS SOLID MATERIALS. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TONER-KYOCERA 1010, 103361-01
CAGE:DUMEC
CAGE:DUMEC
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE-ACRYLATE COPOLYMER
CAS:25213-39-2
Fraction by Wt: 55-60%
Ingred Name:IRON(III) OXIDE; (MAGNITE)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 35-40%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 5-10%
Ingred Name:METAL COMPLEX AZO DYE. MFR CAS # 84179-66-8
CAS:85179-66-8
Fraction by Wt: <5%
Ingred Name:SILICA, AMORPHOUS; (AMORPHOUS SILICA)
CAS:7631-86-9
Fraction by Wt: <1%
OSHA PEL:6 MG/M3 RDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CERIUM OXIDE; (METAL OXIDE)
CAS:1306-38-3
Fraction by Wt: <1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO SYMPTOMS FROM OVEREXPOSURE.
Medical Cond Aggravated by Exposure:CHRONIC UNPROTECTED EXPOSURE TO
TONER DUST MAY AGGRAVATE BREATHING DIFFICULTIES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP & WATER. INHAL: REMOVE TO FRESH AIR. INGEST: RINSE MOUTH
OUT WITH WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER/FOAM/DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER IS COMBUSTIBLE. EXPLOSIVE LIMITS OF
TONER PARTICLES SUSPENDED IN AIR ARE EQUAL TO THOSE OF COAL DUST.
================== Accidental Release Measures ==================
Spill Release Procedures:LOOSE TONER CAN BE REMOVED BY USING VACUUM.
RESIDUE CAN BE REMOVED WITH SOAP AND COLD WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE UNDER NORMAL USE. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH HANDS WITH SOAP AND WATER BEFORE EATING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:194F,90C
Spec Gravity:1.1(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER/FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE-NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. DISPOSAL METH MUST MEET LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1-CHLORO-2,4-DINITROBENZENE GRADE 1, C6396
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, 1-CHLORO-2,4-DINITRO-; (1-CHLORO-2,4-DINTROBENZENE
GRADE I)
CAS:97-00-7
RTECS #:CZ0525000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 1070 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE FATAL IF INHALED,
SWALLOWED OR ABSORBED THROUGH SKIN. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. SYMPTOMS OF EXPOSURE MAY INC LUDE BURNING SENSATION,
COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE,
NAUSEA AND (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VOMITING. ABSORPTION INTO THE BODY
LEADS TO THE FORMATION OF METHEMOGLOBIN WHICH IN SUFFICIENT
CONCENTRATION CAUSES CYANOSIS. ONSET MAY BE DELAYED 2 TO 4 HOURS OR
LONGER. MAY CAUSE ALLERGICRESPIRATORY AND SKIN REACTIONS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES/SKIN: IMMEDIATELY FLUSH
EYES OR SKIN WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES
WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. INHAL: REMOVE TO
FRE SH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:367F,186C
Lower Limits:2%
Upper Limits:22%
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS, RUBBER BOOTS AND HEAVY RUBBER
VENTILATE AREA AND WASH SPILL SI TE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL,
DRY PLACE.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. READILY ABSORBED
THROUGH SKIN. HIGHLY TOXIC. SEVERE IRRITANT. STRONG SENSITIZER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>120F,>49C
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE AND
CARBON DIOXIDE, NITROGEN OXIDES, HYDROGEN CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1,2-ETHANEDOIL;GLYCOL
CAGE:62910
CAGE:0BEF1
CAGE:0Z8D6
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL, RAT LD50:4700MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER!HARMFUL/FATAL IF INGEST.MAY BE
HARMFUL IF INHALED.AFFECTS CENTRAL NERVOUS SYTEM.MAY CAUSE
IRRIT.INHAL:RM TEMP SUBSTANCE HAS LOW VAP PRESSURE & VAP INHAL
UNLIKELY.HIGH CONCEN SYMPTOMS SIMILAR TO ETHYL ALCOHOL
INTOXICATION.INGEST:MASSIVE DOSAGE PARALLETL ALCHOL
INTOXICATION,VOMIT,HEAD,RAPID RESP/HEART RATE(SUPPLE)
Effects of Overexposure:INHAL:DIZZINESS,HEADACHE,SHORTNESS OF
BREATH.PULMONARY EDEMA,CENTRAL NERVOUS SYSTEM DEPRESSION.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN
DISORDERS,EYE PROBLEMS,OR IMPAIRED LIVER,KIDNEY,OR RESP FUNCTION
MAY BE MORE SUSCEPTIBLE TO EFFECTS OF THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INGEST:INDUCE VOMIT IMMED BY GIVING 2 GLASSES OF WATER OR
MILK & STICKING FINGER DOWN THROAT.NEVER GIVE ANYTHING BY MOUTH IF
UNCONSC.CALL DR IMMED.INHAL:REMOVE TO FRESH AIR.NOT BREATH GIVE ART
RESP.BR EATH DIFFI GIVE OXY.CALL PHYSICIAN.SKIN:REMOVE ANY CONTAMIN
CLOTH.WASH W/PLENTY OF WATER FOR @LEAST 15MINS.IRRIT DEVELOPS GET
MED ATTN.EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS.CALL
DR.
===================== Fire Fighting Measures =====================
Flash Point:=110.C, 230.F
Autoignition Temp:=400.C, 752.F
Lower Limits:3.2
Upper Limits:15.3
Extinguishing Media:DRY CHEM,FOAM,CO2.WATERSPRAY MAY BE USED TO
EXTINGUISH SURROUNDING FIRE/COOL EXPO CNTNR.WATERSPRAY REDUCE
FUME/IRRIT GAS
Fire Fighting Procedures:IN EVENT OF FIRE WEAR FULL PROTECTIVE CLOTH &
NIOSH-APPROVE SELF-CONTAINED BREATH APPARATUS W/FULL FACEPIECE
OPERATED IN PRESSURE DEMAND OR OTHER +PRESS MODE.
Unusual Fire/Explosion Hazard:SLIGHT TO MODERATE FIRE HAZ WHEN EXPO TO
HEAT/FLAMES.ABOVE FLASH PT VAP-AIR MIXTURES ARE EXPLO W/IN FLAMM
LIMITS NOTED ABOVE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGN SOURCES.VENTI AREA OF
LEAK/SPILL.CLEANUP PERSONNEL MAY REQUIRE PROTECTIVE
CLOTH.DIKE.AVOID RUNOFF INTO STORM SEWERS/DITCHES WHICH LEAD TO
NATURAL WATERWAYS.ABSORB LIQ SPILLS W/DRY ABSORB ENT.CONTAINERIZE
UNUSABLE MATL FOR DISPOSAL.RQ=1LB
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE MIST/FUMES.USE
W/ADEQUATE VENTILATION.KEEP IN TIGHTLY CLSD CNTNR,STORED IN COOL
DRY VENTILATED AREA.PROTECT AGAINST PHYSICAL DMG.
Other Precautions:SEPARATE FROM ACIDS & OXIDIZING MATLS.REFER TO ACGIH
DOC "INDUSTRIAL VENTIALTION,A MANUAL OF RECOMMENDED PRACT"MOST
RECENT EDITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV EXCEEDED A FULL FACEPIECE CHEM CARTRIDGE
RESP MAY BE WORN IN GENERAL UP TO 100X TLV OR MAX USE CONCEN SPEC
BY RESP SUPPLIER WHICHEVER IS LESS.ATERNATIVELY SUPPLIED AIR FULL
FACEPIECE RESP OR AI RLINED HOOD MAY BE WORN.
Ventilation:SYSTEM OF LOC &/OR GEN EXHAU IS RECOMMENDED TO KEEP
EMPLOYEE EXPO BEL AIRBORNE EXPO LIMITS.LOC EXHAU VENTI PREFERRED.
Other Protective Equipment:MAINTAIN EYE WASH FOUNTAIN & QUICK-DRENCH
FACILITIES IN WORKAREA.
Work Hygienic Practices:WASH THOROUGHLY AFT HNDLG.LAUNDER CONTAMIN
CLOTH BEF REUSE.
Supplemental Safety and Health
HEALTH HAZ:LOW BLOOD PRESSURE,STUPOR,COLLAPSE,UNCONSC W/CONVUL.DEATH
FROM RESP ARREST/CARDIOVASCULAR COLLAPSE.SKIN:MINOR
IRRIT,PENETRATION MAY OCCUR.PROLONG CONTACT CAUSE SOFTENING
SKIN.EYE:IRRIT,PAIN ,EYE DMG.
================== Physical/Chemical Properties ==================
HCC:V5
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=192.8C, 379.F
Melt/Freeze Pt:=-12.6C, 9.F
Vapor Pres:0.05 @20C
Vapor Density:2.14
Spec Gravity:1.1
Evaporation Rate & Reference:<0.002, REF UNK
Solubility in Water:MISCIBLE W/WATER.
Appearance and Odor:COLORLESS OILY LIQUID, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.REACTS VIOLENTLY W/CHLOROSULFONIC
ACID,OLEUM,SULFURIC ACID,PERCHLORIC ACID.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE MAY
FORM WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAINER & UNUSED CONTENTS IN
ACCORDANCE W/FED/STATE/LOCAL REQUIREMENTS.SARA SEC 313
CHEMICALS:ETHYLENE GLYCOL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL SULFOXIDE, 99+%, M8180-2
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:ING 3:SULFOXIDE DEGRADES GIVING OFF FORMALDEHYDE, METHYL
MERCAPTAN, & SULFUR DIOXIDE.
RTECS #:9999999ZZ
Ingred Name:METHYL SULFOXIDE; (DMSO)
CAS:67-68-5
RTECS #:PV6210000
Fraction by Wt: >99%
Ingred Name:SUPP DATA: CHLORIDE, MAGNESIUM PERCHLORATE, SILVER
FLUORIDE, METHYL BROMIDE, IODINE PENTAFLUORIDE, NITROGEN (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:PERIODATE, DIBORANE, SODIUM HYDRIDE, PERCHLORIC &
PERIODIC ACIDS. WHEN HEATED ABOVE ITS BP METHYL (ING 4)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)14500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THRU SKIN. VAPOR/MIST IS IRRITATING TO THE EYES, MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN IRRITATION. MAY
CAUSE ALLERGIC RESPIRATORYAND SKIN REACTIONS. CHRONIC: TARGET
ORGAN(S): EYES; SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/COPIOUS AMTS OF WATER FOR @ LST 15 MIN &
SEEK MED ADVICE. SKIN: IMMED FLUSH W/COPIOUS AMTS OF WATER FOR @
LST 15 MIN WHILE REMOVING CONTAMD CLTHG & SHOES. WASH CONTAMD CLTHG
BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
INGEST: WASH OUT MOUTH PROVIDED PERSON IS CONSCIOUS. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:203F,95C
Lower Limits:3.5%
Upper Limits:63%
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FORMS EXPLOSIVE MIXTURES IN AIR. EMITS
TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA AND WASH SPILL SITE
AFTER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAP. AVOID CONT
W/EYES/SKIN/CLTHG. READILY ABSORBED THRU SKIN. IRRITANT. KEEP
TIGHTLY CLSD. HYGROSCOPIC. STORE IN A COOL DRY PLACE.
Other Precautions:SENSITIZER. HARMFUL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:USE PROTECTIVE CLOTHING & MASK. SAFETY
SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID: SULFOXIDE (DMSO) UNDERGOES A VIOLENT EXOTHERMIC RXN ON
MIXING W/COPPER WOOL & TRICHLOROACETIC ACID. ON MIXING W/POTASSIUM
PERMANGANATE IT WLL FLASH INSTANTANEOUSLY. IT REACTS VIOLENTLY
WITH: ACID HALIDES, CYANURIC CHLORIDE,SILICON TETRACHLORIDE,
PHOSPHORUS TRICHLORIDE & TRIOXIDE, THIONYL (ING 2)
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:372F,189C
Melt/Freeze Pt:M.P/F.P Text:65.1F,18.4C
Vapor Pres:0.42@20C
Vapor Density:2.7
Spec Gravity:1.101
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID CHLORIDES; PHOSPHORUS HALIDES; STRONG ACIDS; STRONG OXIDIZING
AGENTS; STRONG REDUCING AGENTS. METHYL (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALK-600
CAGE:55208
CAGE:55208
============= Composition/Information on Ingredients =============
Ingred Name:MFR STATES NO HAZ.COMPONENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYE:IRR;SKIN:IRR,BURNS,DEFATTING TO SKIN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WTR FOR 15MIN;SKIN:WASH W/SOAP&WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE W/WEAK ACETIC ACID
SOLUTION.ABSORB,AND PLACE IN DISPOSAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONT.TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Other Protective Equipment:AS REQD TO PREVENT PROLONGED CONTACT W/SKIN.
Supplemental Safety and Health
MSDS DATED 04-02-86/PH AS 1S=12;PH @ 10:1 DILUTION=11/
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:215F,102C
Vapor Pres:20.
Vapor Density:1.
Spec Gravity:1.0
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:THICK,CLEAR LIQUID,MILD ODOR.
Percent Volatiles by Volume:80.
================= Stability and Reactivity Data =================
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW LOCAL,STATE,FED REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GLUTAMIC OXALOACETIC TRANSAMINASE
CAGE:GO448
CAGE:GO448
============= Composition/Information on Ingredients =============
Ingred Name:GLUTAMIC-OXALACETIC TRANSAMINASE
CAS:9000-97-9
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN, EYE/RESPIRATORY TRACT
IRRITATION UPON CONTACT. ALLERGIC REACTIONS IN CERTAIN SENSITIVE
INDIVIDUALS MAY DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:ALLERGIES, ASTHMA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES/SKIN: WASH THOROUGHLY
W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PHYSICAL CONTACT & DUST DURING REMOVAL.
USE NORMAL CLEAN-UP PROCEDURES & WASH THOROUGHLY W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR DUST MASK.
Ventilation:LOCAL EXHAUST: AS REQUIRED. MECHANICAL (GENERAL): VENT FAN.
Supplemental Safety and Health
SOLUBILITY IN WATER: POWDERS-APPRECIABLE. LIQUIDS-MISCIBLE.
================== Physical/Chemical Properties ==================
Solubility in Water:(SEE SUPP)
Appearance and Odor:POWDERS- WHITE TO TAN. LIQUIDS-WHITE TO BROWN. BOTH
HAVE TYPICAL ENZYME ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH IN SEWERAGE SYSTEM W/WATER IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:48KH33178DP23 DARK GREEN COIL
CAGE:0G0J3
CAGE:0G0J3
============= Composition/Information on Ingredients =============
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 10%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *97-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: >5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SEC-BUTANOL ALCOHOL *97-4*
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: >5%
Other REC Limits:100 PPM
OSHA PEL:150 PPM
ACGIH TLV:303 MG/CUM
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS *97-4*
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: >5%
Other REC Limits:STEL 400 PPM
ACGIH TLV:300 PPM
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE *97-4*
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE (DIMETHYLMETHANE)*97-4*
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *97-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: >5%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB *97-4*
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: >5%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER *97-4*
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: >5%
Other REC Limits:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL/FATAL. EYES/SKIN:
IRRITATION. INHALATION: ANESTHETIC, WILL IRRITATE THE RESPIRATORY
TRACT & MAY CAUSE NERVOUS SYSTEM DEPRESSION. REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUS E PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, LIGHTHEADEDNESS,
HEADACHE, DIZZINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS, COMA.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/LAARGE
AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:2.3
Extinguishing Media:CO2, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE BUT MAY BE USED
TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WEAR SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DON'T APPLY ON HOT SURFACES. AEROSOL
CONTAINERS HOLD EXTREMELY FLAMMABLE GAS & LIQUID UNDER PRESSURE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION & PROVIDE MAXIMUM
VENTILATION. EQUIP PERSONAL W/PROPER RESPIRATORY, SKIN & EYE
PROTECTION. TAKE UP MATERIAL W/SAWDUST, VERMICULITE/OTHER ABSORBENT
MATERIAL & PLACE IN CONTAI NERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAMES.
Other Precautions:TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME/HOT SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED (TC-23-C) PAINT
SPRAY/(TC-19-C) AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP
THE CONCENTRATION OF INGREDIENTS BELOW EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING, APRON.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F
Vapor Pres:<78
Vapor Density:>1
Spec Gravity:0.7-0.8
Evaporation Rate & Reference:(BU O AC = 100): <57
Solubility in Water:21-4%
Percent Volatiles by Volume:85-96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS & STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. UN1954.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBON DIOXIDE
CAGE:87286
CAGE:0ZGE6
CAGE:0XMLI
CAGE:87286
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 100%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SIMPLE ASPHYXIANT.HIGH CONCENTRATIONS
OF CARBON DIOXIDE IN THE AMBIENT AIR CAN REDUCE THE OXYGEN CONTENT
NECESSARY TO SUPPORT LIFE.IN THE SOLID PHASE(DRY ICE) CONTACT
W/BODY TISSUE WILL PRODUCE COLD B URNS OR FROSTBITE W/IN SEVERAL
SECONDS.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT LISTED AS A
CARCINOGEN BY NTP, IARC, OSHA.
Effects of Overexposure:SHORTNESS OF BREATH,HEADACHE,DIZZINESS,
WEAKNESS,DROWSINESS & RINGING IN EARS.DRY ICE IN CONTACT W/BODY
TISSUE PRODUCES BURNING SENSATION;& FROSTBITE OCCURS W/IN SEVERAL
SECONDS.
Medical Cond Aggravated by Exposure:CONDITIONS WHICH CAUSE BREATHING
DIFFICULTY.
======================= First Aid Measures =======================
First Aid:DO NOT ATTEMPT TO REMOVE AN INDIVIDUAL FROM THE SCENE W/OUT
UTILIZING PROPER RESCUE EQUIPMENT OR YOU MAY BECOME A CASUALTY.
MOVE VICTIM TO FRESH AIR WHILE KEEPING THEM WARM, DRY & QUIET. IF
BREATHING HAS STOPPED PERFORM ARTIFICIAL RESPIRATION. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:MATERIAL IS AN EXTINGUISHING AGENT ITSELF.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:CONFINEMENT OF CARBON DIOXIDE IN VESSELS
CONTAINERS OF IMPROPER DESIGN CAN RESULT IN EXPLOSION OR RUPTURE
FROM OVER- PRESSURIZATION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE THE AREA OF THE SPILL OR RELEASE,
EMPLOY EMERGENCY FIRST AID PROCEDURES,PROVIDE PLENTY OF FRESH
AIR.REMOV DRY ICE RESIDUAL & ALLOW TO SUBLIME IN A SECURED,
WELL-VENTILATED AREA & CONTACT THEMANUFACTURER'S SAFETY
DEPARTMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:LIQUID & VAPOR STORAGE CONTAINERS ARE
UNDER HIGH PRESSURE.DO NOT MIS-HANDLE OR ABUSE,CNTS.USE ONLY
EQUIPMENT DESIGNED FOR CARBON DIOXIDE.
Other Precautions:AVOID DIRECT SKIN CONTACT WITH DRY ICE OR VENTING
CARBON DIOXIDE LIQ OR VAPOR.USE PROTECTIVE EQUIP & CLOTHING AND GET
PROPER TRAINING BEFORE HANDLING CARBON DIOXIDE IN CYLINDERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS - USE IN
STRICT ACCORDANCE W/THE MANUFACTURER'S RECOMMENDATIONS.
Ventilation:FRESH AIR LOCAL EXHAUST/MECHANICAL
Other Protective Equipment:SAFETY SHOES, HARD HATS & EAR PROTECTION
SHOULD BE WORN WHEN WORKING W/PRESSURIZED CARBON DIOXIDE.
Work Hygienic Practices:PERSONS HANDLING CARBON DIOXIDE SHOULD BE FULLY
TRAINED IN ADVANCE.
Supplemental Safety and Health
USE A PROPER PRESSURE REDUCING REGULATOR WHEN CONNECTING CYLINDER TO
LOWER PRESSURE < 1500 PSIG. NEVER HEAT CYLINDER TO INCREASE
DISCHARGE RATE. KEEP CYLINDERS UPRIGHT AND PROPERLY SECURED IN
SECURED AREAS AWAY FROM HIGH TRAFFIC. HAVE ONLYQUALIFIED PERSONNEL
REFILL CYLINDERS.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-109F,-79C
Vapor Pres:1 ATM
Vapor Density:1.5 AIR=1
Solubility in Water:90ML/100ML H2O
Appearance and Odor:IN SOLID TRANSLUCENT WHITE & ODORLESS.IN GAS & LIQ
COLORLESS & ODORLESS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE ALKALI METALS(SUCH AS SODIUM, POTASSIUM, MAGNESIUM, ALUMINUM,
TITANIUM, ZIRCONIUM), ORGANOMETALLICS, HYDRIDES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HEATING ABOVE 1700C CAUSES
DECOMPOSITION OF CARBON MONOXIDE & OXYGEN.
Conditions to Avoid Polymerization:IT CAUSES VIOLENT POLYMERIZATION OF
ACRYLALDEHYDE OR ETHLENEIMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW CARBON DIOXIDE TO RELEASE, SUBLIME OR
DISSIPATE IN THE OPEN AIR.AVOID RELEASING IN COURTYARDS OR INDOORS
OR ANY AREAS WHERE HEAVY CARBON DIOXIDE VAPORS CAN ACCUMULATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WHITE TRAFFIC MARKER BRADY CAT 91521
CAGE:59581
CAGE:1AA96
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
< Wt:20.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
< Wt:15.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUOL
CAS:108-88-3
RTECS #:XS5250000
< Wt:15.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
< Wt:15.
OSHA PEL:1800 MG/M3;1000 PPM
Ingred Name:N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
< Wt:10.
ACGIH TLV:1900 MG/M3;800 PPM
Ingred Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
< Wt:5.
OSHA PEL:435 MG/M3;100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
< Wt:5.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
< Wt:5.
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
> Wt:3.
Ingred Name:SOYA ALKYD RESIN
> Wt:3.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: IRRITATING. SKIN:
IRRITATION/ALLERGIC REACTIONS ARE POSSIBLE. PROLONGED/REPEATED
CONTACT MAY CAUSE DERMATITIS. INHALATION: CYANOSIS MAY RESULT FROM
OVEREXPOSURE. MAY BE HARMFUL. INGESTION: MATER IAL MAY BE
HARMFUL/FATAL. IRRITATING TO MOUTH, THROAT & STOMACH. OVEREXPOSURE
MAY CAUSE POSSIBLE REPRODUCTIVE HAZARD.
Effects of Overexposure:IRRITATION, PAIN, TEARING, REDDENING OF EYES,
SWELLING, STINGING SENSATION, DEFATTING & DRYING OF SKIN, RASH,
HEADACHE, DIZZINESS, NAUSEA, DECREASED BLOOD PRESSURE, CHANGES IN
HEART RATE
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. KEEP VICTIM WARM. INGESTION: DON'T INDUCE VOMITING. GIVE
A GLASS OFWATER/MILK. NEVER GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:=-20.C, -4.F
Lower Limits:1
Upper Limits:36
Extinguishing Media:WATER FOG, DRY CHEMICAL, CO2, ALCOHOL FOAM, FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
PRESSURE-DEMAND MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE IF
EXPOSED TO HEAT/FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL; DRY SAND/EARTH, THEN
PLACE IN A CHEMICAL WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED AIR PURIFYING
RESPIRATOR W/AN ORGANIC VAPOR CARTRIDGE/CANISTER WHERE AIRBORNE
CONCENTRATIONS EXCEED EXPOSURE LIMITS. USE A POSITIVE PRESSURE AIR
SUPPLIED RESPIRATOR FOR UNCON TROLLED RELEASES/WHERE EXPOSURE
LEVELS ARE NOT KNOWN/WHERE AIR PURIFYING RESPIRATORS MAY NOT
PROVIDE ADEQUATE PROTECTION.
Ventilation:LOCAL EXHAUST VENTILATION MAY BE NECESSARY TO CONTROL ANY
AIR CONTAMINANTS TO W/IN THEIR TLVS DURING THE USE OF THIS PRODUCT.
Other Protective Equipment:CHEMICAL SUIT, RUBBER BOOTS, PROTECTIVE
CLOTHING/ACID SUIT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-44 TO 284F
Vapor Pres:40
Vapor Density:>1
Spec Gravity:0.9013
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID W/AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FIRE/FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313: THIS PRODUCT CONTAINS THE
FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS &
REAUTHORIZATION ACT OF 1986 & 40 CFR PART 37 2: TOLUOL, ACETONE,
XYLENE, METHANOL, ETHYL BENZENE.
Federal Regulatory Information:CERCLA-SARA HAZARD CATEGORY: THIS
PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA HAZARD CATEGORIES
PROMULGATED UNDER SECTIONS 311 & 312 OF THE SUPERFUND AMENDMENT &
REAUTHORIZATIN ACT OF 1986 (SARA TI TLE III) & IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES: IMMEDIATE
HEALTH HAZARD, CHRONIC HEALTH HAZARD, FIRE HAZARD, PRESSURIZED GAS
HAZARD.
State Regulatory Information:NEW JERSEY RIGHT TO KNOW THE FOLLOWING
MATERIALS ARE NON-HAZARDOUS, BUT ARE AMONG THE TOP FIVE COMPONENTS
IN THIS PRODUCT: WATER, CALCIUM CARBONATE. PENNSYLVANIA RIGHT TO
KNOW: THE FOLLOWING NON-HAZAR DOUS INGREDIENTS ARE PRESENT IN THE
PRODUCT AT GREATER THAN 3%: WATER, CALCIUM CARBONATE, ACRYLIC
RESIN. CALIFORNIA PROPOSITION 65: WARNING: THE CHEMICALS NOTED
BELOW & CONTAINED IN THIS PRODUCT, ARE KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER/BIRTH DEFECTS & OTHER REPRODUCTIVE HARM:
TOLUOL.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BENZOIC ANHYDRIDE CRYSTALLINE, B7756
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:BENZOIC ANHYDRIDE CRYSTALLINE
CAS:93-97-0
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. TO THE BEST OF KNOWLEDGE, THE CHEMI CAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MIN. SKIN: WASH WITH SOAP AND COPIOUS AMOUNTS OF WATER. INHAL:
REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTF RESP. IF BREATHING
IS DIF FICULT, GIVE O*2. CALL PHYS. WASH CONTAMINATED CLOTHING
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:>230F,>110C
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER MATERIA L PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE DUST. AVOID CONT
W/EYES/SKIN/CLTHG. IRRITANT. KEEP TIGHTLY CLOSED. MOISTURE
SENSITIVE. STORE IN COOL DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:680F,360C
Melt/Freeze Pt:M.P/F.P Text:102F,39C
Spec Gravity:1.199
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. MAY DECOMPOSE ON EXPOSURE TO MOIST AIR/H*2O.
STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE AND
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL WITH COMBUSTIBLE
SOLVENT AND BURN IN CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE, AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TOOLING STONE - T10
CAGE:57593
CAGE:57593
============= Composition/Information on Ingredients =============
Ingred Name:GYPSUM OSHA PEL: 15 MG/M3 TDUST, 5 RDUST
CAS:13397-24-5
RTECS #:MG2360000
OSHA PEL:SEE ING
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE; (LIMESTONE) OSHA PEL: 15 MG/M3 TDUST, 5
RDUST
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:SEE ING
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL IS NOT KNOWN TO BE
TOXIC. LARGE AMOUNTS OF DUST MAY CAUSE A NUISANCE CONDITION OF
COUGHING, SNEEZING AND NASAL IRRITATION. MATERIAL WILL HARDEN IF
WET AND RESULT IN BLOCKAGE IF INGESTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHALATION: REMOVE TO FRESH
AIR. EYES: RINSE WITH PLENTY OF RUNNING WATER FOR AT LEAST 15
MINUTES. SKIN: WASH THOROUGHLY.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NON-
COMBUSTIBLE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM MATERIAL INTO A WASTE
CONTAINER FOR DISPOSAL. AVOID CREATING DUST. WEAR NIOSH/MSHA
APPROVED RESPIRATOR IF REQUIRED. DO NOT FLUSH DOWN DRAINS TO AVOID
BLOCKAGE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:EXCESSIVE PARTICULATES IN WORKPLACE
AIR MUST BE AVOIDED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
FOR NUISANCE DUST.
Ventilation:VENTILATE AT MIXER AS REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:GOOD FACTORY HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
SPEC GRAV: 0.04-2.7 (H2O=1)
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:SUPDAT
Solubility in Water:0-0.2% @ 40C
Appearance and Odor:LIGHT PINK POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CAO, SO3.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF AS INERT SOLID IN A SANITARY
LANDFILL OR BY OTHER PROCEDURES IN COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RUST SCAT METAL PRIMER 35-153
Preparer's Name:THOMAS E. MAREK
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS). VP:2
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 26.9%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:C I PIGMENT YELLOW 36; (ZINC CHROMATE)
CAS:37300-23-5
RTECS #:GE4600000
Fraction by Wt: 22.8%
OSHA PEL:0.1 MG(CRO3)/M3
ACGIH TLV:0.01 MG(CR)/M3, A1
Ingred Name:VOLATILE ORGANIC CONTENT:3.14 LBS PER GALLON
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR
REPEATED CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING,
DERMATITIS. INHALATION:EXCESSIVE INHAL OF VAPORS CAN CAUSE NASAL &
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, POSSIBLE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC CHROMATE: IARC GROUP 1, SUP 7, P
165, 1987; KNOWN CARCINOGEN, NTP 7TH ANNUAL REPORT, 1994.
Effects of Overexposure:HLTH HAZ:UNCONSCIOUSNESS, AND EVEN
ASPHYXIATION. INGESTION:CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING, AND DIARRHEA. CHRONIC:ASPIRATION INTO LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAMD
CLTHG. LAUNDER CONTAMD CLTHG BEFORE REUSE. EYES:FLUSH W/LG AMTS OF
WATER, LIFTING UPPER & LOWER LIDS OCCASNLY, GET MED ATTN. INGEST:DO
NOT I NDUCE VOMIT. KEEP PERSON WARM & GET MEDATTN. INHAL:REMOVE TO
FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG HAS STOPPED,
APPLY ARTF RESP. KEEP PERSON WARM, QUIET & GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:COMBUSTIBLE LIQUID. USE FOAM, DRY CHEMICAL, CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA WITH FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE
MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNIT BY HEAT PILOT LIGHTS, OTHER FLAMES
& IGNIT SOURCES @ LOCATIONS DIST FROM MATL HNDLG POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBANT OR OTHER ABSORBANT MATERIAL AND PICK UP WITH SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES.
Other Precautions:USE WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL
Other Protective Equipment:BARRIER CREAM. ANSI APPRVD EMERGENCY EYE
WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.42 (H*2O=1)
Evaporation Rate & Reference:70 (ETHER =1)
Solubility in Water:NONE
Appearance and Odor:YELLOW OPAQUE LIQUID, MINERAL SPRIRITS ODOR.
Percent Volatiles by Volume:50.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM BICARBONATE, SX0325
CAGE:63612
CAGE:63612
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 4220 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS (ACUTE AND
CHRONIC). SYMPTOMS OF EXPOSURE: MAY CAUSE EYE IRRITATION.
Explanation of Carcinogenicity:THE MATERIAL IS NOT LISTED
(IARC,NTP,OSHA) AS CANCER CAUSING AGENT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE INDICATED.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE IF ANY ADVERSE EFFECTS SHOULD DEVELOP.
SKIN: WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INHALATION: REMOVE
TO FR ESH AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED. INGESTION: GET IMMEDIATE MEDICAL ATTENTION; OF CONSCIOUS,
GIVE WATER FREELY.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE INDICATED.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF ALL UNNECESSARY PERSONNEL.
WEAR SUITABLE PROTECTIVE EQUIPMENT LISTED UNDER EXPOSURE/PERSONAL
PROTECTION. ELIMINATE ANY IGNITION SOURCES UNTIL AREA IS DETERMINED
TO BE FREE FROM EXPLOS ION OR FIRE HAZARDS. CONTAIN THE RELEASE AND
ELIMINATE ITS SOURCE, IF THIS CAN BE DONE WITHOUT RISK. TAKE UP &
CONTAINERIZE FOR PROPER DISPOSAL AS DESCRIBED UNDER DISPOSAL.
(SUPDAT)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE.
Other Precautions:DO NOT GET IN EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATL SHOULD BE HNDLD OR TRANSFERRED IN AN APPRVD FUME HOOD
OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY. HNDLG CARE GENRLLY IN KEEPING W/SAFE LAB PRACTICES IS
RECOMMENDED.
Supplemental Safety and Health
SPILL RELEASE: COMPLY WITH FEDERAL, STATE, AND LOCAL REGULATIONS ON
REPORTING RELEASES. REFER TO REGULATORY INFO FOR REPORTABLE QTY &
OTHER REGULATORY DATA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=122.C, 251.6F
M.P/F.P Text:DECOMPOSES
Spec Gravity:2.16 (H*2O =1)
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, ODORLESS, CRYSTALLINE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS. OTHER: REACTS VIOLENTLY WITH AMMONIUM PHOSPHATE, MONOBASIC.
Stability Condition to Avoid:NONE INDICATED.
Hazardous Decomposition Products:CO*X.
=================== Toxicological Information===================
Toxicological Information:ORL-RAT LD50: 4220 MG/KG. TOXICOLOGICAL
FINDINGS: TESTS ON LABORATORY ANIMALS INDICATE MATERIAL MAY PRODUCE
ADVERSE MUTAGENIC AND REPRODUCTIVE EFFECTS. CITED IN REGISTY OF
TOXIC EFFECTS OF CHEMICAL SU BSTANCES (RTECS).
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL DOES NOT HAVE EPA NUMBER AND IS NOT
LISTED WASTE, HOWEVER CONSULTATION WITH A PERMITTED WASTE DISPOSAL
SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONTACT PERMITTED WASTE
DISPOSER (TSD) TO ASSU RE COMPLIANCE WITH ALL CURRENT LOCAL, STATE
AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: NON-REGULATED. DOT ID
NUMBER: NONE.
===================== Regulatory Information =====================
SARA Title III Information:TSCA STATEMENT: THE CAS NUMBER OF THIS PROD
IS LISTED ON THE TSCA INVENTORY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THINNER, 3812-S;(FORMERLY KNOWN AS T-3812)
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETRLOLEUM DISTILLATE
Fraction by Wt: 52.0%
ACGIH TLV:100 PPM(PER MFR
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 48.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES HEADACHE,NAUSEA,IMPAIRMENT OF REACTION
TIME AND COORDINATION.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR TO IMPROVE BREATHING;SKIN:WASH
WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING;EYES:FLUSH WITH
WATER FOR AT LEAST 15 MIN.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:20-73F (CC)
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:COOL CLOSED CONTNRS W/H*2O USING FOG NOZZLES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS & OPEN
FLAMES.CLOSE CONTAINERS AFTER EACH USE.DO NOT STORE ABOVE 120F
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
SMOKING;OBSERVE LABEL PRECAUTIONS;CONTAINERS SHOULD BE GROUNDED
WHEN POURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESP TC-23C IF AIR CONTMNANTS
CONTROL IS NOT FEASIBLE
Ventilation:LOCAL & MECH PROVIDE SUFFICIENT VENT TO KEEP BELOW TLV
LEVEL
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE
PRACTICES.
Supplemental Safety and Health
MSDS FM MFR DATED:11/24/82;VAPOR PRESSURE 10.00 & VAPOR DENSITY 3.00
NOTED BY MFR ARE OF PRINCIPAL SOLVENT;PREVIOUSLY ITEM IDENTIFIED AS
T-3812;EFF 8/10/82,ITEM(FORMULA UNCHGD) CODE IS 3812-S.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:212-302F
Vapor Pres:UNK
Vapor Density:UNK
Spec Gravity:0.795
Evaporation Rate & Reference:<1(SLOWR THAN ETHR
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID THINNER W/CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2,SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5IP
CAGE:GO230
CAGE:GO230
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:POTASSIUM SILICATE, POTASSIUM METASILICATE *93-1*
CAS:1312-76-1
Ingred Name:SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM
SALT SILIC ACID
CAS:6834-92-0
RTECS #:VV9275000
Ingred Name:CALCIUM FLUORIDE, FLUORSPAR, CALCIUM DIFLUORIDE, IRTRAN 3,
LIPARITE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:2.5 MG/CUM (AS F)
OSHA PEL:2.5 MG/CUM (AS F)
ACGIH TLV:2.5 MG/CUM (AS F)
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
ACGIH TLV:5-10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF NOSE, THROAT, EYES. MAY
LEAD TO SIDEROSIS WHICH MAY AFFECT PULMONARY FUNCTION. ARC RAYS CAN
INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL. SEE SUPP.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, IRRITATION OF
NOSE & THROAT. EYES: IRRITATION. SKIN: DRYNESS & BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY OR ALLERGIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP HEAD OUT OF FUMES, DON'T TOUCH
LIVE ELECTRICAL PARTS, INSULATE FROM WORK & GROUND.
Other Precautions:TO DETERMINE COMPOSTION & QUANTITY OF FUMES & GASES
TO WHICH WORKERS ARE EXPOSED IS TO TAKE AN AIR SAMPLE INSIDE THE
WELDERS HELMET OR IN THE BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATORY WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:LOCAL EXHAUST AT THE ARC TO KEEP THE FUMES & GASES BELOW
THE TLV.
Other Protective Equipment:HELMET, ARM PROTECTORS, APRONS, HATS,
SHOULDER PROTECTION, DARK SUBSTANTIAL CLOTHING, SCREENS, FLASH
Supplemental Safety and Health
THE PRODUCT AS SUPPLIED IS NON-HAZARDOUS. HEALTH HAZARDS OCCUR DURING
OPERATIONS. THE COMPOSITION & QUANTITY OF WELDING FUMES ARE
DEPENDENT ON THE PROCESS, PROCEDURES, MEDIA, CONTAMINENTS IN THE
ATMOS PHERE, & ELECTRODES USED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE SUPP
Stability Condition to Avoid:SEE SUPP
Hazardous Decomposition Products:CO, CO2, OZONE & NITROGEN OXIDES
FORMED BY THE RADIATION FROM ARC. WELDING FUMES - COMPLEX OXIDES
FROM THE INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1,4-HYDROXYBENZALDEHYDE, O-246
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:BENZALDEHYDE, P-HYDROXY-; (1.4-HYDROXYBENZALDEHYDE)
CAS:123-08-0
RTECS #:CU6475000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS-AVOID
DIRECT PHYSICAL CONTACT! CAN BE HARMFUL IF INHALED, SWALLOWED AND
ABSORBED THROUGH THE SKIN. CAN CAU SE EYE AND SKIN IRRITATION. DUST
AND/ORVAPS CAN CAUSE IRRIT TO RESP TRACT. CAN BE IRRIT TO MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POIS.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. SKIN:IF NO BURNS HAVE OCCURRED, USE
SOAP & W ATER TO CLEANSE SKIN. DO NOT WEAR SHOESOR CLOTHING UNTIL
ABSOLUTELY FREE OF ALL CHEM ODORS. INHAL:REMOVE PATIENT TO FRESH
AIR. ADMIN OXYG IF PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS
(SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. SWEEP UP AND PLACE IN AN APPROPRIATE
CONTAINER. HOLD FOR DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE
ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
UNDER NITROGEN. STORE ONLY W/COMPATIBLE CHEMS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL CHEM/ITS CNTNR. PROD IS FURNISHED FOR LAB USE ONLY! MFR'S
PRODS MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL
PRODS, FOOD AD DITIVES/AS HOUSEHOLD CHEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . USE APPROPRIATE OSHA/MSMA APPROVED SAFETY
EQUIPMENT.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:STOPPED BREATHING ADMINISTER ARTIFICIAL RESPIRATION. IF
PATIENT IS IN CARDIAC ARREST ADMINISTER CPR. CONTINUE LIFE
SUPPORTING MEASURES UNTIL MEDICAL ASSISTANCE HAS ARRIVED. GET
MEDICAL ATTENTION IF NECESSARY. CONTINUE LIFE SUPPORTING MEASURES
UNTIL MED ASSISTANCE HAS ARRIVED. INGEST:CALL MD IMMED .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:2129F,1165C
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:FRUITY, PERFUME LIKE, OR PLEASANT ODOR. BEIGE
CRYSTALLINE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG BASES, STRONG
REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-E-2784A
CAGE:NO367
CAGE:NO367
CAGE:3F338
============= Composition/Information on Ingredients =============
Ingred Name:GLYCOL ETHER (VAPOR PRESSURE 25%)
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: 7.20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLYCOL ETHER (VAPOR PRESSURE 0.1%)
CAS:770-35-4
Fraction by Wt: 1.30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = 1.46 G/L, NON-EXEMPT SOLVENT PER ADJUSTED GALLON.
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: IRRITATION.
INHAL: IRRITATING TO NOSE/THROAT. INGEST:TOXIC.
Effects of Overexposure:INHAL: HEADACHE, NAUSEA, VOMITING, DROWSINESS.
Medical Cond Aggravated by Exposure:HEART CONDITIONS, ASTHMA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 15 MINUTES, GET MED AID. SKIN: WASH
W/SOAP & WATER. REMOVE CONTAIM CLOTHES. INHAL: GET FRESH AIR. OXGEN
IF NEEDED. INGEST: GIVE TWO GLASSES OF WATER. INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMBLE
Extinguishing Media:CO2, FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:COOL CONTAINERS W/WATER STEAM IN EVENT OF
A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN. SOAK UP RESIDUE W/ABSORBENT
MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. PROTECT
FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED.
Ventilation:REQUIRED.
Other Protective Equipment:APRON.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,156C
Vapor Density:>AIR
Evaporation Rate & Reference:VALUE NOT STATED
Solubility in Water:100%
Percent Volatiles by Volume:58.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE & UNIDENTIFIED ORGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN RECKA APPROVED FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DETECT-A-LEAK
Preparer's Name:T. MARAHARA
CAGE:22159
CAGE:22159
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2,2'-IMINODI-; (DIETHANOLAMINE) (SARA III)
CAS:111-42-2
RTECS #:KL2975000
Fraction by Wt: 0.3%
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING TO EYES AND SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:WASH WITH WATER FOR AT LEAST 15 MINUTES, CALL PHYSICIAN.
SKIN:WASH WITH WATER THOROUGHLY. INGEST:CALL MD IMMEDIATELY .
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ ARTIFICIAL
RESP IRATION) .
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB MATERIAL WITH DRY-SORB TYPE ABSORBENT,
EARTH OR SAND. MAY BE WASHED DOWN WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:221F,105C
Spec Gravity:1.01 (H2O=1)
pH:7.8
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, CO, CO2, FROM THERMAL
DECOMPOSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR USE SANITARY LAND FILL. BE SURE
THAT ALL FEDERAL, STATE, AND LOCAL REGULATIONS ARE OBSERVED.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: CRAFT AND FABRIC PAINT,FL1P1-46
Cage: 21546
Resp. Party Other MSDS No.: MSDS #701
=======================================================
Contractor Summary
=======================================================
Cage: 21546
=======================================================
Ingredients
=======================================================
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NONE. NONTOXIC.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: ABRASIVE, CAN SCRATCH EYES.
First Aid: EYE CONTACT: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN CONTACT:
WASH WITH SOAP AND WATER. INGESTION: CALL PHYSICIAN IMMEDIATELY (FP N).
INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OX YGEN OR
ARTIFICIAL RESPIRATION) (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CLEAN UP PROPERLY WITH PAPER TOWELS AND WET SPONGE.
Waste Disposal Methods: PUT PAPER TOWELS IN TRASH AND RINSE OUT SPONGE. DISPOSE
OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: KEEP CONTAINER SEALED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE APPROPRIATE TECHNIQUES AND MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures: NONE. WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: MATERIAL CAN SPATTER ABOVE 212F. POLYMER FILM
CAN BURN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF SPRAYING, DO NOT INHALE MIST. USE RESPIRATOR THAT IS
NIOSH APPROVED FOR SPRAYS AND MISTS.
Ventilation: LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL): RECOMMENDED WHEN
SPRAYING. SPECIAL: USE RESPIRATOR WHEN SPRAYING. OTHER: NONE.
Other Protective Equipment: NONE NEEDED. ANSI APPROVED EMERGENCY EYEWASH AND
DELUGE SHOWER (FP N).
Work Hygienic Practices: GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Vapor Pres: (MM HG) NOT APPLICABLE
Vapor Density: (AIR=1)N/A
Spec Gravity: 1.1 (WATER =1)
PH: 7.0-9.0
Solubility in Water: INSOLUBLE
Appearance and Odor: OPAQUE-COLORED LATEX PAINT.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: CONFORMS TO NONTOXIC ASTMD-4236: PRODUCTS BEARING
THE NONTOXIC PRODUCT SEAL ARE CERTIFIED IN A PROGRAM OF TOXICOLOGICAL
EVALUATION BY A NATIONALLY RECOGNIZED TOXICOLOGIST TO CONTAIN NO MATERIALS IN
SU FFICIENT QUANTITIES TO BE TOXIC OR INJURIOUS TO HUMANS OR TO CAUSE ACUTE
OR CHRONIC HEALTH PROBLEMS. THESE PRODUCTS ARE CERTIFIED TO BE LABELED IN
ACCORDANCE WITH THE VOLUNTARY CHRONIC HAZARD LABELING STANDARD ASTMD-436. IN
ADDITION THERE IS NO PHYSICAL HAZARD AS DEFINED WITHIN 29 CFR PART
1910.1200(C).
=======================================================
Ecological Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: CODES: HEALTH: 0, FIRE: 0, REACTIVITY: 0, PROTECTIVE
EQUIPMENT: G (IF SPRAYING).
=======================================================
HAZCOM Label
=======================================================
Product ID: CRAFT AND FABRIC PAINT,FL1P1-46
Cage: 21546
Company Name: DUNCAN ENTERPRISES
Street: 5673 E SHIELDS AVE
Zipcode: 93727
Label Required IND: Y
Date Of Label Review: 11/03/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: NONE. NONTOXIC. CHRONIC: NONE SPECIFIED BY
MANUFACTURER (FP N).
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: ACCU-LUBE TB (IN THE TUB)
Cage: ITWFL
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0WD64
Cage: ITWFL
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: NO EFFECTS EXPECTED. HOWEVER, LIKE ANY INDUSTRIAL
CHEMICAL PRODUCT, EXERCISE CARE TO AVOID EXCESSIVE EXPOSURE TO PRODUCT.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEE MD (FP
N). SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD (FP N). INHALATION:
REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTI FICIAL
RESPIRATION) (FP N). INGESTION: CALL MD IMMEDIATELY (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NO SPECIAL PROTECTIVE EQUIPMENT IS REQUIRED FOR
CLEANUP PERSONNEL. STOP SPILL AT SOURCE AND DIKE AREA TO PREVENT SPREADING.
PUMP LIQUID TO SALVAGE TANK. ABSORB REMAINING LIQUID ON ABSORBENT MATERIAL A
ND SHOVEL INTO A SUITABLE CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATION IS THE RECOMMENDED DISP METH FOR ALL
NON-HAZ CHEM WASTE, ALTHOUGH MATL MAY BE LANDFILLED I/A/W ALL APPLICABLE
LOCAL, STATE, AND FEDERAL REGULATIONS. THIS PRODUCT, IF DISPOSED OF, IS NOT C
ONSIDERED HAZ WASTE UNDER CURRENT FEDERAL REGS.
Handling And Storage Precautions: NONE SPECIFIED BY MANUFACTURER.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >200F,>93C
Extinguishing Media: WATER FOG, REGULAR FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT, ESPECIALLY IF SPRAYED
INTO CONTRS OF HOT BURNING LIQ.
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >425F,>218C
Vapor Pres: <1 @ 68F
Vapor Density: HVR/AIR
Spec Gravity: 0.85 @ 68F
PH: 6-7
Solubility in Water: INSOLUBLE
Appearance and Odor: LIGHT BLUE SOLID PUSH-UP
Percent Volatiles by Volume: <1/10
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS WILL CAUSE A VIGOROUS REACTION.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ACCU-LUBE TB (IN THE TUB)
Cage: ITWFL
Company Name: ITW FLUID PRODUCTS GROUP
Street: 8501 DELPORT DRIVE
Zipcode: 63114
Label Required IND: Y
Date Of Label Review: 06/07/1995
Status Code: C
Label Date: 06/07/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: NO EFFECTS EXPECTED. HOWEVER, LIKE
ANY INDUSTRIAL CHEMICAL PRODUCT, EXERCISE CARE TO AVOID EXCESSIVE EXPOSURE TO
PRODUCT. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DELTA HARDENER A4
CAGE:92218
CAGE:05820
CAGE:92218
============= Composition/Information on Ingredients =============
Ingred Name:ALKLENEAMINE
Fraction by Wt: >99%
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN CONTACT:IRRITATION. HEATED VAPORS:
IRRITATION OF NOSE,THROAT AND EYES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MIN, CALL A MD. SKIN:WASH WITH SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE
VOMITING, GIVE MILK TO DRINK. SEE MD.
===================== Fire Fighting Measures =====================
Flash Point:335F/168C
Extinguishing Media:FOAM,CO*2,DRY CHEM OF WATER SPRAY
Fire Fighting Procedures:TREAT AS A CLASS B FIRE
Unusual Fire/Explosion Hazard:AVOID EXCESSIVE HEAT,SPARKS OR OPEN
FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN ALL SPILLS THOROUGHLY. FOR SMALL
AMOUNTS,MEK OR ACETONE CAN BE USED. FOR LARGE SPILLS, SCRAPE
UP,THEN WASH.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HEAT & OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCOR WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:APRON IMPERVIOUS TO SOLVENTS
Supplemental Safety and Health
PART B OF A TWO PART KIT. VAPOR PRESSURE <0.001 MM/HG
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:435F/223C
Vapor Density:7.6
Spec Gravity:1.01
Evaporation Rate & Reference:<0.001 (BUAC)
Solubility in Water:COMPLETE
Appearance and Odor:WATER WHITE LIQUID. MILD AMINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
UNCONTROLLED MIXING WITH EPOXY AND STRONG ACIDS.
Hazardous Decomposition Products:CARBON MONOXIDE,ALDEHYDES,ACIDS,AND
NITROGEN COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL CODES
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KD 2 BLITZ
CAGE:KXEST
CAGE:KXEST
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:50 MPPCF
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES OR SKIN WHEN
WORKING WITH POWDER IN MIXED (MORTAR) STATE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . INHALATION:CALL MD. SKIN:WASH
WITH WATER. INGESTION:CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . MATERIAL DOES
NOT BURN.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN-UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN USED IN DRY CONDITION (POWDER) USE NIOSH
APPROVED RESPIRATOR.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . AS REQUIRED WHEN WORKING W/DRY CEMENT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:3.1 (H*2O=1)
Solubility in Water:NOT SOLUBLE
Appearance and Odor:GRAY POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMAL DISPOSAL. OBSERVE CURRENT FEDERAL, STATE
& LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-E-2784
Preparer's Name:ONEY FLEMING
CAGE:EO326
CAGE:EO326
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:EKTASOLVE EEH SOLVENT
CAS:1559-35-9
RTECS #:KK9625000
Fraction by Wt: 3.32%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 3.32%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINOETHANOL LOW VOE
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 0.38%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 92.98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC: 1.8 LB/GL; 211 G/LTR
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE IRRITATION OF RESPIRATORY
PASSAGES.
Effects of Overexposure:INHALATION OF VAPOR OR MIST CAN CAUSE
HEADACHES, NAUSEA, IRRITATION OF NOSE, THROAT, AND LUNGS. EYE
CONTACT CAN CAUSE SLIGHT IRRITATION. PROLONGED OR REPEATED SKIN
CONTACT CAN CAUSE SLIGHT IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASE MAY BE
AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES, CONSULT PHYSICIAN IF IRRITATION PERSISTS. SKIN CONTACT:
WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER. INGESTION: IF
SWALLOWED, GIVE 2 GLASSES OF WATER TO DRINK, CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Autoignition Temp:Autoignition Temp Text:216 F
Lower Limits:NONE
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
(PRESSURE DEMAND MSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 100C. POLYMER
FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY,
USE CARE TO AVOID FALLING. CONTAIN SPILLS WITH INERT MATERIALS
(SAND, EARTH). TRANSFER LIQUIDS AND SOLID DIKING MATERIAL TO
SEPARATE SUITABLE CONTAINERS FO R RECOVERY/DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER SPRAY DURING SPRAY APPLICATION.
Ventilation:NORMAL, SUCH AS A FAN
Other Protective Equipment:EYE WASH STATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 644F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:350F,177C
Vapor Pres:NONE
Vapor Density:> AIR
Spec Gravity:1.01 (WATER=1)
pH:9 MAX
Viscosity:77-95 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:CREAM LIQUID WITH SLIGHT ODOR
Percent Volatiles by Volume:60.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THERE ARE NO KNOWN MATERIALS WHICH ARE INCOMPATIBLE WITH THIS PRODUCT.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD
ACRYLIC MONOMERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP SPILLS AND CLEANING RUN-OFF OUT OF
MUNICIPAL SEWERS AND OPEN BODIES OF WATER. CONSULT FEDERAL, STATE,
OR LOCAL AUTHORITIES FOR PROPER DISPOSAL PROCEDURES CONCERNING
HEALTH AND ENVIRONMENT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METAL CLEANER
CAGE:88952
CAGE:88952
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 30%
OSHA PEL:1 MG/M3;3 STEL
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER; (DISTILLED)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN CONFINED AREAS VAPORS IN HIGH
CONCENTRATIONS ARE ANESTHETIC. OVEREXPOSURE MAY RESULT IN LT-HD AND
STAGGERING GAIT. IRRITANT TO SKIN, EYES, AND UPPER RESPIRATORY
SYSTEM. MIST CAN CAUSE COUGHING, SNE EZING, SALIVATION, AND DFCLT
BRTHG. ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EFTS ON CNS, HEMATOPOIETIC TISSUE,
BLOOD, KIDNEYS, AND LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUBLICATION
NO. 90-118) .
Medical Cond Aggravated by Exposure:MISTS MAY AGGRAVATE PULMONARY
DISEASE. LONG TERM SKIN EXPOSURE MAY AGGRAVATE DERMATOSIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREA THORO W/SOAP AND WATER. REMOVE
CONTAMD CLTHG AND LAUNDER BEFORE RE-USE. IF IRRITATION PERSISTS,
SEEK MED AID. INHAL: REMOVE FROM EXPOSURE AND INTO FRESH AIR.
RESTORE BRTHG, IF STOPPED. KEEP WARM AND QUIET. EYES: FLUSH EYE
AND UNDER LID W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
SEEK MED AID. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY REACT W/SOME METALS INCLUDING
ALUMINUM, MAGNESIUM, AND ZINC RESULTING IN EVOLUTION OF HYDROGEN
GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. ABSORB W/ABSORBENT MATERIAL. FLUSH
SPILL AREA WITH COPIOUS AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80F(27C). KEEP CONTRS
TIGHTLY SEALED. AVOID STORING OR MIXING W/MATERIALS CONTAINING
CHLORINE.
Other Precautions:AVOID EYE AND SKIN CONTACT. AVOID BREATHING MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA FOR EMERGENCY USE.
Ventilation:LOCAL EXHAUST/MECHANICAL(GEN): KEEP BELOW TLV.
Other Protective Equipment:RUBBER APRON OR SUITABLE PROTECTIVE
CLOTHING. SFTY SHOWER AND EYE WASH STATION AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Density:>1
Spec Gravity:1.2(H*2O=1)
Evaporation Rate & Reference:<1(BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS AND MATERIALS CONTAINING CHLORINE.
Hazardous Decomposition Products:OXIDES OF PHOSPHORUS, CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE SOLID WASTE W/DILUTE ALKALINE MATL &
INCINERATE IN APPRVD FACILITY. DISPOSE OF I/A/W LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID,REAGENT
Preparer's Name:DGSC-SHH/HMIS(LEVIEN)
CAGE:KO196
CAGE:13873
CAGE:KO196
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV(CEILING) IS 5PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BURNS ALL EXPOSED TISSUE.INHAL:CAUSES
IRRITATION.MAY CAUSE LUNG DAMAGE.INGEST:SEVERE BURNS TO
MOUTH,ESOPHAGUS,STOMACH.SKIN:CAUSES BURNS.EYES:CAUSES BURNS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INHAL:TOOTH
EROSION,BURNS,CHOKING.INGEST:PAIN,NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.EYES:FLUSH
WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMP T QUALIFIED MEDICAL ATTENTION.IF CONSCIOUS,GIVE 1-2 GLASSES
OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:CONTACT WITH FLUORINE(HALON!) MAY CAUSE
IGNTION ON CONTACT.FIRE CONDITION MAY EVOLVE TOXIC/CORROSIVE FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH SODIUM BICARBONATE OR ,SODA
ASH/SLAKED LIME(50:50);MIX;ADD WATER TO FORM A SLURRY;SCOOP SLURRY
INTO AN APPROPRIATE CONTAINER FOR DISPOSAL.WASH SPILL SITE WITH
SODA ASH SOLUTION.
Neutralizing Agent:SODIUM BICARBONATE OR SODA ASH/SLAKED LIME(50:50).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP SEPERATE FROM
ACIDS AND ALKALIES.
Other Precautions:AVOID CONTACT.DO NOT BREATHE VAPOR.WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
NIOSH/MSHA RESPIRATOR FOR ACID VAPORS.
Ventilation:USE IN A FUME HOOD ONLY.
Other Protective Equipment:FUME HOOD,LAB COAT.PROVIDE A LOCAL EYE WASH
STATION AND QUICK DRENCH SHOWER.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
MSDS GENERATED FOR USE WITH DOD 4160.21-H(PAGE IV-37).MSDS
SOURCE:MSDS/FTSS(CCINFO;93-3).
================== Physical/Chemical Properties ==================
HCC:C1
Vapor Pres:5320
Vapor Density:1.63
Spec Gravity:1.194
pH:0.1@1N
Solubility in Water:MISCIBLE
Appearance and Odor:LIQUID,FUMING;COLORLESS;PUNGENT
Corrosion Rate:CORROSIV
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS,ACIDS,ALKALIES,PROPLYENE OXIDE,ETHYLENE DIAMINE,METAL ACETYLIDES
OR CARBIDES,FLUORINE.
Stability Condition to Avoid:WATER,STEAM.
Hazardous Decomposition Products:HYDROGEN,CORROSIVE/TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GARD ANTI-RUST SAE 15W-40
Preparer's Name:RAYMOND SWAN
CAGE:3K676
CAGE:3K676
============= Composition/Information on Ingredients =============
Ingred Name:HEAVY PARAFFINIC DISTILLATE, SOLVENT EXTRACT
CAS:64742-04-7
RTECS #:PY8042500
Other REC Limits:5 MG/M3 OIL MIST
Ingred Name:ADDITIVE PACKAGE CONTAINING ZINC, SULFUR, CA, PHOSPHORUS
AND NITROGEN.
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS > 5000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE-EYES/SKIN:MILDLY IRRITATING TO
EYES. PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE MILD
IRRITATION AND POSSIBLY DERMATITIS. INHALATION OF MIST MAY CAUSE
CHEMICAL PNEUMONITIS. INGESTION:LOW T OXICITY. HAS LAXATIVE EFFECT.
CHRONIC-NONE GIVEN.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES & SKIN:MILD IRRITATION. INHALATION:MAY
CAUSE PNEUMONITIS.INGESTION:LAXATIVE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.GIVE CPR/OXYGEN IF NEEDED. GET
MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH WATER FOR 15
MINUTES. GET MEDICAL ATTENTION. SKIN:REMOVE & LAUNDER CONTAMINATED
CLOTHING. W ASH SKIN WITH SOAP & WATER. DISCARD SATURATED LEATHER
ARTICLES. INGESTION:DO NOT INDUCE VOMITING. SEEK MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:380F,193C
Autoignition Temp:Autoignition Temp Text:>250C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.DO NOT POINT WATER STREAM DIRECTLY INTO BURNING OIL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:USE OF WATER STREAM OR FOAM MAY CAUSE
FROTHING AND SPREAD FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. ABSORB WITH INERT ABSORBENT
SUCH AS CLAY OR SAND, COMMERCIAL SORBENTS OR RECOVER USING PUMPS.
SCOOP UP USED ABSORBENT INTO DRUMS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,WELL VENTILATED AREA.
AVOID INHALATION & SKIN CONTACT ESPECIALLY WHEN HANDLING USED OIL.
Other Precautions:WASH HANDS BEFORE EATING OR DRINKING. DO NOT REUSE
OIL DRUMS, AS THEY RETAIN SOME OIL. DO NOT CUT OR WELD USED OIL
DRUMS , THEY MAY EXPLODE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NECESSARY. IF MIST GENERATED BY
HEATING, SPRAYING, WEAR APPROVED ORGANIC VAPOR RESPIRATOR SUITABLE
FOR OIL MIST.
Ventilation:MECHANICAL VENTILATION
Other Protective Equipment:EYE WASH STATION. LONG SLEEVE CLOTHING TO
MINIMIZE SKIN CONTACT.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:<0.0001
Vapor Density:>12
Spec Gravity:0.87
Evaporation Rate & Reference:X1000 SLOWER THAN BU AC
Solubility in Water:NIL
Appearance and Odor:AMBER VISCOUS LIQUID WITH HYDROCARBON ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS (PEROXIDES, CHLORINE), STRONG ACIDS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN, PHOSPHORUS
AND SMOKE ON COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL SITE OR A
LICENSED WASTE RECLAMATION FACILITY. DISPOSAL SHOULD BE MADE IN
ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARPET CLEANER (BONBET), 408
CAGE:BETCC
CAGE:BETCC
============= Composition/Information on Ingredients =============
Ingred Name:OPTIC BRIGHTENERS; (OPTICAL BRIGHTENERS)
Fraction by Wt: 0-5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <100%
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10-15%
OSHA PEL:25 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:SULFURIC ACID, MONODODECYL ESTER, SODIUM SALT; (DODECYL
SULFATE, SODIUM SALT)
CAS:151-21-3
RTECS #:WT1050000
Fraction by Wt: 5-10%
Ingred Name:TRIPHOSPHORIC ACID, PENTASODIUM SALT; (SODIUM
TRIPOLYPHOSPHATE) (SARA III)
CAS:7758-29-4
RTECS #:YK4570000
Fraction by Wt: 0-5%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 0-5%
ACGIH TLV:0.05 PPM
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-,(R)-; (CITRUS
TERPENES)
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: 0-5%
Ingred Name:GLYCOLS, POLYETHYLENE, MONO (P-NONYLPHENYL) ETHER;
(NONIONIC SURFACTANT)
CAS:26027-38-3
RTECS #:MD0906000
Fraction by Wt: 0-5%
Ingred Name:PERFUME OILS
Fraction by Wt: 0-5%
Ingred Name:DYE
Fraction by Wt: 0-5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITANT. MAY CAUSE REDDENING,
SWELLING & POSSIBLE SKIN DAMAGE. EYES:IRRITANT. LIQUID & MISTS MAY
DAMAGE EYES, CAUSING CORNEAL INJURY. INHAL:VAPOR MAY BE IRRITATING
TO MUCOUS MEMBRANES IN NOSE, THROAT & LUNGS. HIGH CONC MAY CAUSE
HEADACHE & NAUSEA. INGEST:MAY CAUSE HEADACHE, DIZZINESS,
NAUSEA,(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:& DIARRHEA. ANIMAL STUDIES HAVE
CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS,
HEMATOPOIETIC TISSUE, BLOOD, KIDNEYS & LIVER ASSOCIATED
W/ADMINISTRATION OF ETHYLENE GLYCOL MONOB UTYL ETHER (EGBE).
(EXTRACTED FROM DHHS(NIOSH) PUBLICATION NO. 90-118) .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:FLUSH W/LARGE QUANTITIES OF WATER. SEEK MEDICAL
ATTENTION IF IRRITATION PERSISTS. EYES:FLUSH W/LARGE QUANTITIES OF
WATER FOR AT LEAST 15 MINS. SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS. INHAL :GET TO FRESH AIR. SEEK MEDICAL ATTENTION IF
SYMPTOMS PERSIST. INGEST:DILUTE W/TWO GLASSES OF WATER. SEEK
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR OTHERWISE ABSORB & HOLD FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED DURING STORAGE.
FOR INSTITUTIONAL & INDUSTRIAL USE ONLY. USE WITH ADEQUATE
VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR USE BY TRAINED
PERSONNEL ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL EXHAUST TO KEEP TLV OF INGREDIENTS IN
INGREDIENT SECTION BELOW ACCEPTABLE LIMIT.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:8.5-9.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:20 @ 68F
Vapor Density:>1
Spec Gravity:1.02
pH:SUPDAT
Evaporation Rate & Reference:<1 (WATER=1)
Solubility in Water:100%
Appearance and Odor:THIN BLUE LIQUID W/PLEASANT ODOR.
Percent Volatiles by Volume:>85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE & OXIDES OF SULFUR
POSSIBLE IF BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:ANY METHOD IN ACCORDANCE W/APPLICABLE LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ATOM ARC 7018 0.187 50 LB
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Other REC Limits:5MG/M*3
OSHA PEL:10MG/M*3
ACGIH TLV:5MG/M*3
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:10MG/M*3
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SODIUM SILICATE
CAS:6834-92-0
RTECS #:VV9275000
OSHA PEL:5MG/M*3 (RESP. DUST)
ACGIH TLV:0.1MG/M*3(RESP.DUST)
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:10MG/M*3
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:10MG/M*3
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Other REC Limits:5MG/M*3 (C)
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
OSHA PEL:5MG/M*3 (RESP.DUST)
ACGIH TLV:0.1MG/M*3(RESP.DUST)
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:2.5MG/M*3
OSHA PEL:2.5 MG/M3 (F)
ACGIH TLV:2.5 MG/M3 (F); 8990
Ingred Name:POTASSIUM FELDSPAR
CAS:7789-75-5
Other REC Limits:10MG/M*3(NUISANCE)
OSHA PEL:NOT LISTED
ACGIH TLV:NOT LISTED
Ingred Name:ZIRCON (ZIRCONIUM IV,SILICATE)
CAS:14940-68-2
RTECS #:ZH9000000
Other REC Limits:5MG/M*3
OSHA PEL:5 MG/M3/10 STEL (ZR)
ACGIH TLV:5 MG/M3/10 STEL (ZR)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:ACUTE:METALLIC TASTE,NAUSEA,TIGHTNESS
OF CHEST,FEVER,DIZZINESS,DRYNESS,IRRITATION OF EYES,NOSE,THROAT.
CHRONIC:EXCESSIVE LEVELS MAY CAUSE BRONCHIAL ASTHMA,LUNG
FIBROSIS,SIDEROSIS. ARC RAYS CAN INJURY EYES & BURN SKIN. ELECTRIC
SHOCK CAN KILL.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:AGGRAVATION OF EXISTING RESPIRATORY
OR ALLERGIC CONDITIONS. HIGHER LEVEL OF LUNG RELATED PROBLEMS AMONG
SMOKERS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE & OBTAIN PROMPT MEDICAL ATTENTION. IF
NOT BREATHING,GIVE CPR. IF UNCONSCIOUS,GIVE OXYGEN. EMPLOY FIRE AID
TECHNIQUES RECOMMENDED BY AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:APPROPRIATE FOR SURROUNDING FIRE.
Unusual Fire/Explosion Hazard:WELDING ARCS & SPARKS CAN IGNITE
COMBUSTIBLE PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUE &
PLACE IN APPROPRIATE DISPOSAL CONTAINER.
======================Handling and Storage ======================
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES. AVOID ELECTRICAL SHOCK
BY MAINTAINING DRY WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FUME RESPIRATOR OR AIR SUPPLIED RESPIRATOR IN
CONFINED SPACES OR WHERE VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SUBSTANTIAL DARK CLOTH,ARM
PROTECTOR,APRON,HAT,SHOULDER PROTECTION.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:WELDING RODS 0.187 INCHES DIAMETER BY 14 INCHES
LONG.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FUMES OF METALS & METAL
OXIDES,CO,CO*2,NO*2,O*3,FLUORIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PLY-MASTIC EPOXY COATING(044 LINE), 044054(III)PART A
Kit Part:Y
CAGE:85519
CAGE:85519
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:25085-99-8
Fraction by Wt: 31-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-10%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:MICA - SILICATES (< 1% CRYSTALLINE SILICA)
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: 31-60%
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:3 MG/M3 RDUST; 9495
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST; 9495
Ingred Name:STODDARD SOLVENT; (PETROLEUM DISTILLATE). VP: 2.0 @ 25C.
LEL: 1.0%
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1-10%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (1-METHOXY
2-PROPANOL ACETATE). VP: 3.8 @ 25C.
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT OF RESP TRACT. PRLNG INHAL
MAY LEAD TO FATIGUE, DROW, DIZZ &/OR LT HEAD, HDCH, LACK OF
COORDINATION, NAUS, VOMIT, CNS DEPRESS, ANESTHETIC EFT/NARCOSIS.
SKIN:IRRIT OF SKIN. PRLNG/RPTD CONT CAN CAUSE DERM, DEFATTING.
EYE:IRRIT OFEYES. PRLNG/RPTD CONT CAN CAUSE BLURRED VISION, REDNESS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA:IARC MONOGRAPHS, SUPP. VOL 7, PG
341, 1987: GROUP 2A. NTP 7TH ANNUAL RPT ON CARCIN, 1994: ANTIC TO
BE CARCIN.
Effects of Overexposure:HLTH HAZ:OF EYES, TEARING OF EYES, SEV EYE
IRRIT. INGEST:AMTS INGEST INCIDENTAL TO CONSUMER & INDUS HNDLG ARE
NOT LIKELY TO CAUSE INJURY; HOWEVER, INGEST OF LRG AMTS MAY CAUSE
LUNG INFLAMM & DMG DUE T O ASPIR OF MATRL INTO LUNGS. NOTICE:RPTS
HAVE ASSOC RPTD & PRLNG OCCUP OVER-EXPOS TO SOLV W/PERM BRAIN &
NERV (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN.
SKIN:WASH OFF QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE
CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE REUSE. EYE:FLUSH IMMED
W/LRG AMTS OF H*2O, ESP UNDER LIDS, FOR AT LEAST 15 MIN. OBTAIN
EMER MED TREATMENT. INGESTION:IF SWALLOWED, OBTAIN MEDICAL
TREATMENT IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>105F,>41C
Lower Limits:SEE INGS
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAP CAN FORM EXPLO MIX IN AIR AT ELEVATED TEMPS.
MAY DECOMP UNDER FIRE CNDTNS EMITTING IRRIT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC SPARKS). VENTILATE AREA AND AVOID
BREATHING VAPORS. CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL
USING NON-SPARKING TOOL S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN SUN OR ABOVE 100
DEGREE F.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT WELD/FLAME CUT W/OUT
PROPER VENT TO INSURE AREA IS FREE OF FLAMM VAP. DO NOT CUT,
PUNTURE/WELD ON/NEAR CNTNR. ENTRANCE INTO CLSD STOR TANKS-USE
APPROP RESP/AIRLINE FOR P OSS EXPOS TO SOLV/CHEM FUMES. (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR DESIGNED TO REMOVE A COMBINATION OF PARTICULATE AND
VAPORS (NIOSH/MSHA TC23C OR EQUIVALE NT).
Ventilation:ALL APPLICATION AREAS SHOULD BE VENT IN ACCORDANCE W/OSHA
REGULATION 29 CFR 1910 DURING USE & UNTIL AREA IS FREE OF VAP.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:&/TOX GASES. EFTS OF OVEREXP:SYS DMG. INTENTIONAL MISUSE BY
DELIB CONC & INHALING CONTENTS MAY BE HARMFUL/FATAL. OTHER
PREC:RAGS/WASTE-CNTNG OIL BASED PAINT/VARNISH THAT PRESENT LRG
AIR-TO-O IL INTERFACE WILL OXIDIZE & MAY IGNITE SPONTANEOUSLY &
SHOULD BE PLACED IN METAL CNTNR. KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>230F,>110C
Vapor Pres:SEE INGS
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:0-14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDRAULIC OILS AW 46 ULTRA GUARD
CAGE:FO923
CAGE:FO923
CAGE:0B1N6
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS INGREDIENTS
ACGIH TLV:5MG/M3 OIL MIST(MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)>5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE IRRITATION.
BASED ON DATA FROM OTHER COMPONENTS. SKIN: LUBRICATING OILS ARE
GENERALLY CONSIDERED NO MORE THAN MILDLY IRRITATING TO SKIN.
PROLONGED AND REPEATED CONTACT MAY LEAD T O VARIOUS SKIN DISORDERS,
SUCH AS DERMATITIS, OIL ACNE OR FOLLICULITIS. CHRONIC: SIGNS &
SYMPS OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC EXPOSURE RESEMBLE THOSE OF
ACUTE EXPOSURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYE: FLUSH WITH WATER OR
EYEWASH FOR AT LEAST 15 MINUTES. SEE PHYSICIAN IF IRRITATION
PERSISTS. INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT INDUCE VOMIT.
IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE QTYOF PRODUCT
ARE INGESTED. HOWEVER, GET MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>390F,>199C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM, HALON, WATER
FOG PATTERN.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HIGH HEAT AND OPEN
FLAME.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: RANGE 0.8762-0.878(H*2O=1).
================== Physical/Chemical Properties ==================
Spec Gravity:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER COLOR-LUBE OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME & OXIDIZING
MATERIALS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE IN COMPLIANCE WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IMRON S/S-LAB, 5080U
CAGE:0ERJ7
CAGE:0ERJ7
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER VP: NONE
CAS:25068-63-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE (SARA 313) (CERCLA) VP: 36.70 @ 20C
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, ETHYL ESTER; (ETHYL ACETATE) (CERCLA) VP:
76.00 @ 20C
CAS:141-78-6
RTECS #:AH5425000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL MONOMETHYL ETHER ACETATE) VP: 3.70 @ 20C
CAS:108-65-6
RTECS #:AI8925000
OSHA PEL:N/K
ACGIH TLV:N/K
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:LEAD CHROMATE (VI) OXIDE, VP: NONE
CAS:18454-12-1
RTECS #:OF9800000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MOLYBDATE ORANGE; (LEAD CHROMATE MOLYBDATE) VP: NONE
CAS:12656-85-8
RTECS #:QA4660000
Fraction by Wt: 22%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: TITANIUM DIOXIDE: IN A LIFETIME INHAL TEST, LUNG
CANCERS WERE FOUND IN SOME RATS EXPOSED TO 250 MG/M3 (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: RESP TITANIUM DUST. ANALYSIS OF TITANIUM DIOXIDE
CONCS IN RAT'S LUNGS SHOWED THAT THE LUNG CLEARANCE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: MECHANISM WAS OVERWHELMED & THAT THE RSLTS AT THE
MASSIVE 250 MG/M3 LEVEL ARE NOT RELEVANT TO THE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: WORKPLACE. LEAD CHROMATE/LEAD CHROMATE MOLYBDATE:
OVEREXP TO LEAD MAY CAUSE ADVERSE EFTS TO BLOOD (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: FORMING, NERV, URINARY, REPRO SYS INCL EMBRYOTOX
EFTS. SYMPS MAY INCL LOSS OF APPETITE, ANEMIA, DISTURB (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: OF SLEEP & FATG. LEAD & TOLUENE APPEAR ON THE NAVY
OCCUP CHEM REPRO HAZ LIST. SEEK CONSULT FROM APPROP (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST
INFORMATION & SAFE HANDLING & EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: MOLYBDATE ORANGE: IARC MONOGRAPHS, VOLUME
49, PAGE 49, 1990: GROUP 1.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE NOSE & THROAT
IRRIT, NERV SYS DEPRESS W/HDCH, DIZZ, NAUS, STAG GAIT, CONFUSION,
UNCON. RPTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN &
NERV SYS DMG. MAY CAUSE IRRI T/BURNING OF EYES. RPTD/PRLNG LIQ CONT
MAY CAUSE SKIN IRRIT W/DISCOMFORT & DERM. TOLUENE: RECURRENT (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:LEAD CHROMATE: IARC MONO, VOL 49, PG 49,
1990: GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994: KNOWN TO BE
CARCIN.(ING 16)
Effects of Overexposure:HLTH HAZ: OVEREXP MAY RSLT IN LIVER & KIDNEY
INJURY. HIGH AIRBORNE LEVELS HAVE PRDCED IRREG HEART BEATS IN
ANIMALS & OCCAS PALPITATIONS IN HUMANS. RATS EXPOSED TO VERY HIGH
AIRBORNE LEVELS HAVE EXHIBI TED HIGH FREQUENCY HEARING DEFICITS.
THE SIGNIFICANCE OF THIS TO MAN IN UNKNOWN. ETHYL ACETATE: PRLNG &
RPTD (SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
PREF MOUTH-TO-MOUTH. IF BRTHG DFCLTY PERSISTS/OCCURS LATER, CONSULT
MD. EYE: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. CALL
MD. SKIN: WASH W/SOAP & WATER. IF IRRIT OCCURS, CONT MD. INGEST:
GI DISTRESS. IN THE UNLIKELY EVENT OF INGEST, CALL IMMED & HAVE
NAMES OF INGS AVAIL.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>20F,>-7C
Lower Limits:1.3%
Upper Limits:13.1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO PREVENT PRESSURE
BUILD-UP.
Unusual Fire/Explosion Hazard:WHEN HEATED > FLASH POINT, EMITS
FLAMMABLE VAPS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE
MIST/SPRAYS MAY BE FLAMMABLE AT TEMPERATURES < FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS AND FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING.
Other Precautions:DO NOT STORE ABOVE 120F. DO NOT SAND, FLAME CUT,
BRAZE OR WELD DRY COATING WITHOUT A NIOSH APPROVED RESPIRATOR OR
APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR PROPERLY FITTED
VAP/PARTICULATE RESP APPROVED BY NIOSH (TC-23C) FOR USE W/PAINTS
DURING APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED.
FOLLOW RESP MANUFACT URER'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP
CONTAMINANTS BELOW APPLIC OSHA REQS & OTHER SUGGESTED EXPOSURE
LIMITS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . COVERALLS RECOMMENDED.
Work Hygienic Practices:WASH THORO AFTER HANDLING & BEFORE
EATING/SMOKING. DO NOT USE PROT CREAMS FOR PROT; MAY BE USED FOR
EASE OF CLEAN UP.
Supplemental Safety and Health
EFTS OF OVEREXP: HIGH EXPOS OF LAB ANIMALS RSLTD IN SECONDARY ANEMIA
W/INCR IN WHITE BLOOD CELLS; FATTY DEGENERATION, CLOUDY SWELL &
EXCESS OF BLOOD IN VARIOUS ORGANS. PROPYLENE GLYCOL MONOMETHYL ETHE
R ACETATE: MAY CAUSE MOD EYE BURNING. RECURRENT OVEREXP MAY RSLT IN
LIVER & KIDNEY INJURY. (ING 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>169F,>76C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
VOC Grams/Liter:5.
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SYSTEM IN WATER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:62.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF HEAVY METALS REPORTED IN INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FLEXON, 3459
Preparer's Name:MARCIA
CAGE:3Y342
CAGE:3Y648
CAGE:3Y342
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64475-85-0
RTECS #:PY8240000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:LITHIUM GREASE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, WHITE
CAS:8042-47-5
RTECS #:PY8047000
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPELLANT; (PROPELLANT-8HYDROCARBON)
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: HIGH CONCENTRATIONS MAY CAUSE
DIZZINESS, DROWSINESS AND THROAT IRRITATION. SKIN: PROLONGED
CONTACT MAY IRRITATE/DERMATITIS. INGEST: MAY CAUSE BRONCHOPNEUMONIA
OR PULMONARY EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:DIZZINESS, DROWSINESS AND THROAT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: FRESH AIR. IF BREATHING STOPS, PERFORM CPR. CALL MD.
EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS GET MD ATTENTION. SKIN: WASH WITH SOAP AND WATER. INGEST:
DO NOT INDU CE VOMITING. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:40.0F,4.4C
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES (ABOVE 120F)
CONTAINERS MAY RUPTURE, VENT, OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP BY MOPPING OR ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL CONDITIONS, NO RESPIRATORY
PROTECTION IS REQUIRED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:IF GENERAL VENTILATION IS ADEQUATE, USE LOCAL EXHAUST.
Other Protective Equipment:LONG SLEEVES SHOULD BE WORN. EMERGENCY
EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA.
Work Hygienic Practices:STANDARD INDUSTRIAL PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:55
Spec Gravity:0.769
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK GREEN LIQUID, CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL, STATE AND FEDERAL DISPOSAL
AUTHORITIES FOR APPROVED PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FILTROL CLAY PRODUCTS-GRADE 25
CAGE:KO991
CAGE:KO991
CAGE:9B095
============= Composition/Information on Ingredients =============
Ingred Name:SILICON DIOXIDE,CAS # 7631-86-9,TLV AS TOTAL DUST.
RTECS #:VV7320000
Fraction by Wt: 69%
ACGIH TLV:30 MG/CUM
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 1.75%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:CALCIUM OXIDE,CAS# 1305-78-8
RTECS #:EN3100000
Fraction by Wt: 3.5%
ACGIH TLV:2 MG/CUM
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 6.0%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE IRRITATION TO RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW OR LEAK.AVOID INHALATION.USE
RESPIRATORY PROTECTION.VACUUM UP.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID MATERIAL HANDLING METHODS THAT
CREATE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH OR MSHA APPROVED RESPIRATOR FOR
PARTICULATES.
Ventilation:LOCAL EXHAUST TO CONTROL DUSTY CONDITIONS.
Supplemental Safety and Health
MELT POINT:1100C.PRODUCT MEETS REQUIREMENTS FOR TYPE I UNDER
MIL-D-3464.INGREDIENT INFORMATION PER MFR(KEITH DULANEY.) MAY
29,1984.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.78
Evaporation Rate & Reference:0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CREAM COLORED POWDER-ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:SM & LG SPILL:DEPOSIT IN A POSTED TOXIC
SUBSTANCE LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LC15170 HYDROCHLORIC ACID SOL 1-50% V/V 0.01-6.25N
CAGE:0MX47
CAGE:0MX47
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
Ingred Name:HYDROGEN CHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Minumum % Wt:1.
Maxumum % Wt:50.
OSHA PEL:C7 MG/M3;C5 PPM
ACGIH STEL:C7.5 MG/M3;C5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >90 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: VAPORS ARE IRRITATING, LIQUID
CONTACT MAY RESULT IN CLOUDING OF THE CORNEA, EROSION, CORNEAL
OPACIFICATION & LOSS OF THE EYE. SKIN: SEVERE BURNS & ULCERATION.
INGESTION: SEVERE DIGESTIVE TRACT B URNS & POSSIBLE DEATH. MAY
CAUSE EROSION & PERMANENT TISSUE DESTRUCTION OF THE ESOPHAGUS &
DIGESTIVE TRACT. INHALATION: RESPIRATORY TRACT IRRITATION, BURNING
IN THE NOSE & THROAT, PULMONARY EDEMA. DEL AYED LUNG EDEMA.
PALPITATION, INFLAMMATION, EDEMA OF THE LARYNX & BRONCHI, CHEMICAL
PNEUMONITIS & PULMONARY EDEMA. OVEREXPOSURE MAY RESULT IN DENTAL
EROSION, JAW NECROSIS, RESPIRATORY DISEASE, DERMATI TIS,
CONJUNCTIVITIS, CORNEAL SCARRING.
Effects of Overexposure:IRRITATION, CLOUDING OF THE CORNEA, BURNS,
BROWN-YELLOW SKIN, SCARRING OF SKIN, ABDOMINAL PAIN, VOMITING,
COUGHING, WHEEZING, SHORTNESS OF BREATH, SORE THROAT, INFLAMMATION,
FEVER
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
LIFTING THE UPPER & LOWER LIDS. SKIN: FLUSH W/PLENTY OF SOAP &
WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS,
GIVE 2-4 CUPFUL S OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. INHALATION: MOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR/OXGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
NOTES TO PHYSICIAN: TREAT S YMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:SMALL: DRY CHEMICAL, CO2, WATER
SPRAY/ALCOHOL-RESISTANT FOAM. LARGE: WATER SPRAY,
FOG/ALCOHOL-RESISTANT FOAM
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/ABSORBENT; VERMICULITE, SAND, FULLERS
EARTH & PLACE IN PLASTIC BAGS FOR LATER DISPOSAL. LARGE: NEUTRALIZE
W/DILUTE ALKALINE SOLUTIONS OF SODA ASH/LIME. CLEAN UP IMMEDIATELY,
OBSERVING PRECAUT IONS IN THE PROTECTIVE EQUIPMENT SECTION.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN A WELL VENTILATED AREA.
STORE IN A COOL, DRY AREA. STORE IN A TIGHTLY CLOSED CONTAINER.
Other Precautions:DON'T GET IN EYES, ON SKIN/ON CLOTHING. DON'T
INGEST/INHALE. DON'T ALLOW CONTACT W/WATER. USE CAUTION WHEN
OPENING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATIONS BELOW
THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASH HANDS BEFORE EATING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-227F
Melt/Freeze Pt:=0.C, 32.F
Vapor Pres:14
Vapor Density:0.7
Spec Gravity:1-1.2
pH:<0
Evaporation Rate & Reference:(ETHER=1): >1
Appearance and Odor:COLORLESS LIQUID W/PUNGENT ODOR AT HIGH
CONCENTRATIONS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, ACIDS, ALCOHOLS, GLYCOLS, BUTYL ALCOHOL, ETHANOL,
METHANOL, ETHYLENEGLYCOL, ALDEHYDES, FORMALDEHYDES, CAUSTICS,
AMMONIA, AMIDES, AMINES, ETHERS, CYANIDES, ESTERS, BUTYL ACETATE,
HYDROXIDES, FLUORIDES, H
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:HYDROGEN CHLORIDE, HYDROGEN GAS
===================== Ecological Information =====================
Ecological:SUBSTANCE WILL NEUTRALIZE SOIL CARBONATE-BASED COMPONENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING NAME: HYDROCHLORIC ACID SOLUTION.
UN1789. PACKING GROUP II.
===================== Regulatory Information =====================
SARA Title III Information:CERCLA/SARA SECTION 313: THIS MATERIAL
CONTAINS HYDROGEN CHLORIDE, WHICH IS SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF SARA TITLE III & 40 CFR PART 373.
HYDROGEN CHLORIDE IS CONSIDERED HI GHLY HAZARDOUS BY OSHA.
Federal Regulatory Information:TSCA: HYDROGEN CHLORIDE/WATER IS LISTED
ON THE TSCA INVENTORY LIST.
State Regulatory Information:STATE RIGHT TO KNOW: HYDROGEN CHLORIDE CAN
BE FOUND ON THE FOLLOWING STATE RIGHT TO KNOW LISTS: CALIFORNIA,
NEW JERSEY, FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:451516FB
CAGE:06001
CAGE:06001
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:RESP TK IRRIT;
SKIN/EYE;IRRIT,INFLAM,CHLORACNE; MAY CAUSE LIVER DAMAGE
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR, IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHNG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS CLEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:MATL IS NON-FLAMMABLE BUT MAY GENERATE
TOXIC GASES IN HEAT OF FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC NON-ESSENTL PERSONNEL. VENT SPIL AREA.
WEAR PROTECT EQUIPT. STOP LEAK. SOAK UP LIQUID W/NON-REACTIVE MATL
(SAND, DIRT, ETC) OR RMV BY DIKE &PUMPING OR OTHER SUITABLE MEANS.
CLEAN AREA W/SUITABLE SAFETY SOLVENT. LAUNDER CONTAMINATED CLTHG.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:CHLORODIPHENYLS MAY ATTACK SOME TYPES OF RUBBER AND
PLASTIC. DO NOT USE CONTAMINATED WORK CLOTHING. WASH/SHOWER AFTER
EXPOSURE TO PCB'S.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MESA APPR SCBA/AIR SUPP RESPIR.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:WEAR FULL PROTECTIVE CLOTHING.
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW VISCOUS LIQUID W/HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SEE OTHER PRECAUTIONS
Hazardous Decomposition Products:HYROGEN CHLORIDE, CO, & OTHER
TOXIC/IRRITATING GASES/FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQD. GEN. V.HIGH TEMP
INCINERATION. IAW ALL LOCAL, STATE, & FEDERAL REGULATIONS.
PERMITTED DISPOSAL OPERATOR REQUIRED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HI HEAT ALUMINUM PAINT,1206
CAGE:HO230
CAGE:6F145
CAGE:HO230
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 35%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 21%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN:IRRITATION. VAPOR:CNS
DEPRESSION,COORDINATION LOSS. IMPAIR
JUDGEMENT,STUPOR,UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MINUTES,CALL PHYSICIAN.SKIN:REMOVE
CONTAMINATED CLOTHING,FLUSH AREA WITH WATER UNTIL IRRIT SUBSIDES.
INHALATION:REMOVE FROM EXPOSURE,GIVE ARTIF RESP IF NEEDED,CONSULT
PHYSICIAN . INGESTION:DO NOT INDUCE VOMIT,CALL PHYSICIAN
===================== Fire Fighting Measures =====================
Flash Point:81F/27C
Lower Limits:1.0
Extinguishing Media:DRY CHEMICAL,FOAM,WATER FOG
Fire Fighting Procedures:SELF-CONTAIN BREATH APP, WATER FOG TO COOL
EXPOSED CONTAINER
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE FROM
PRESSURE BUILD UP WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SECURE IGNITION SOURCES,VENTILATE AREA,KEEP
PEOPLE AWAY. RECOVER FREE LIQUID,CONTAIN SPILL.ADD ABSORBENT AND
PICK UP WITH NON-SPARKING TOOLS. AVOID BREATHING VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AWAY FROM HEAT OR FLAME OR STORAGE OXIDIZERS. USE WITH
ADEQUATE VENTILATION,AVOID BREATHING VAPORS.
Other Precautions:GROUND CONTAINERS WHEN POURING,AVOID FREE FALL OF
LIQUID IN EXCESS OF A FEW INCHES. DO NOT SMOKE,EAT, WELD,FLAME CUT
IN AREA OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL/MECHANICAL WITH EXPLOSION PROOF MOTORS.
Other Protective Equipment:FACE SHIELD,CHEM RESISTANT APRON,COVERALLS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:279F/137C
Vapor Density:>1
Evaporation Rate & Reference:<1 (ETHER)
Percent Volatiles by Volume:71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Hazardous Decomposition Products:CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL,STATE AND FEDERAL REGULATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CITREX, FC153
CAGE:0K209
CAGE:0K209
============= Composition/Information on Ingredients =============
Ingred Name:2-PROPANOL, 1-BUTOXY-; (GLYCOL ETHER PNB)
CAS:5131-66-8
RTECS #:UA7700000
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (1-METHYLPYRROLIDONE)
CAS:872-50-4
RTECS #:UY5790000
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-(R)-;
(D-LIMONENE)
CAS:5989-27-5
RTECS #:GW6360000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH LIQUID CAN CAUSE EYE
IRRITATION, REDNESS, AND TEMPORARY CORNEAL CLOUDING. A SINGLE
PROLONGED EXPOSURE TO THE SKIN MAY RESULT IN THE MATERIALS BEING
ABSORBED IN HARMFUL AMOUNTS. PROLONGED SKIN CONTACT MAY CAUSE
REDNESS, IRRITATION & DEFATTING. EXCESSIVE INHALATION OF VAPORS CAN
CAUSE (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: NASAL & RESPIRATORY IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE
UNCONSCIOUSNESS, AND ASPHYXIATION. SWALLOWING LARGE AMOUNTS CAN
CAUSE GASTROINTESTINAL IRRITATION, NA USEA, VOMITING AND DIARRHEA.
ASPIRATIONOF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN, OCCASIONALLY OPEN
UPPER & LOWER LIDS. IF IRRITATION DEVELOPS, CONTACT PHYSICIAN.
SKIN: WASH THOROUGHLY WITH SOAP & WATER, IF IRRITATION DEVELOPS,
CONSULT PH YSICIAN. INHAL: REMOVE TO FRESH AIR, ASSIST BREATHING AS
NECESSARY. INGEST: DO NOT INDUCE VOMITING, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:150F,66C
Lower Limits:1 %
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED POSITIVE-PRESSURE,
SCBA AND FULL PROTECTIVE EQUIPMENT , COOL CONTAINER WITH SPRAY IF
POSSIBLE.
Unusual Fire/Explosion Hazard:AUTO IGNITION TEMPERATURE AROUND 460 F.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK AT SOURCE. CONTAIN AND COLLECT
MATERIAL, ABSORB RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT OR INCOMPATIBLE
CHEMICALS. READ ALL CAUTIONS AND LABELS BEFORE USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC RESPIRATOR IF
EXCESSIVE MIST OR VAPORS ARE CREATED.
Ventilation:LOCAL EXHAUST: MAY BE NECESSARY IN SOME CONDITIONS.
MECHANICAL (GENERAL): SHOULD BE SUFFICIENT.
Other Protective Equipment:BOOTS, COVERALLS, APRONS AS NECESSARY TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:READ ALL CAUTIONS AND LABELS BEFORE USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:340F,171C
Vapor Pres:< 2
Vapor Density:4.5
Spec Gravity:0.86
Evaporation Rate & Reference:<0.1 (BUTYL ACETATE=1)
Solubility in Water:VERY SLIGHT
Appearance and Odor:MILD, AMINE-LIKE ODOR. CLEAR BLEND.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND STRONG ACIDS.
Stability Condition to Avoid:STRONG OXIDIZING AND ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT FEDERAL, STATE, COUNTY OR LOCAL
ENVIRONMENTAL REGULATOR FOR GUIDANCE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WELD-ON 717 FOR PVC PLASTIC PIPE
Preparer's Name:GEORGE BLANCO
CAGE:EO483
CAGE:EO483
CAGE:17510
============= Composition/Information on Ingredients =============
Ingred Name:POLYVINYL CHLORIDE RESIN (PVC); (NON-HAZARDOUS INGREDIENT)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FURAN, TETRAHYDRO-; (TETRAHYDROFURAN (THF)) (CERCLA)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 50-70%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (CERCLA)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 5-100%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC (AS MANUFACTURED): 786 G/L; MAX VOC EMISSION PER SCAQMD
TEST METHOD 316A: 580 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RESP PROT: USE IT ONLY FOR A SINGLE SHORT-TERM EXPOS. FOR
EMER & OTHER CNDTNS WHERE SHORT TERM EXPOS GUIDELINES (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: MAY BE EXCEEDED, USE A NIOSH APPRVD POSITIVE
PRESSURE SCBA.
RTECS #:9999999ZZ
Ingred Name:VENT: BELOW APPLICABLE EXPOSURE LIMITS SET FORTH IN
INGREDIENTS SECTION. USE ONLY EXPLOSION-PROOF VENTILATION
EQUIPMENT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: SEV OVEREXP MAY RSLT IN
NAUS, DIZZ, HDCH. CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES.
SKIN CONT: IRRIT. LIQ CONT MAY REMOVE NATRL SKIN OILS RSLTG IN SKIN
IRRIT. DERM MAY OCCUR W/PRLN G CONT. SKIN ABSORPTION:
PRLNG/WIDESPREAD EXPOS MAY RSLT IN ABSORPTION OF HARMFUL AMTS OF
MATL. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: EYES: OVEREXP MAY RSLT IN SEV INJURY
W/CORNEAL/CONJ INFLAMM ON CONT W/LIQ. VAPS SLIGHTLY UNCOMFORTABLE.
INGEST: MOD TOX. MAY CAUSE NAUS, VOMIT, DIARR, MENTAL SLUGGISHNESS.
CHRONIC: SYMPS OF RESP TRACT IRRIT & DMG TO RESP EPITHELIUM WERE
REPORTED IN RATS EXPOSED TO 5000 PPM THF FOR 90 DAYS. (SUP DAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASE OF THE EYES, SKIN OR RESPIRATORY SYSTEM MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:INHAL: IF OVERCOME BY VAPS, REMOVE TO FRESH AIR & IF BRTHG
STOPPED, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL MD.
EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN & CALL MD. SKIN:
REMOVE C ONTAM CLTHG & SHOES. WASH SKIN W/PLENTYOF WATER FOR AT
LEAST 15 MIN. IF IRRIT DEVELOPS, GET MED ATTN. INGEST: GIVE 1-2
GLASSES OF WATER/MILK. DO NOT INDUCE VOMIT. CALL MD/POIS CTL CTR
IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:6F,-14C
Lower Limits:2.0%
Upper Limits:11.8%
Extinguishing Media:ANSUL "PURPLE K" POTASSIUM BICARBONATE DRY
CHEMICAL, CARBON DIOXIDE, NATIONAL AER-O-FOAM UNIVERSAL ALCOHOL
(SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
EVACUATE ENCLOSED AREAS, STAY UPWIND. USE WATER SPRAY TO COOL
CONTRS, TO FLUSH SPILLS FROM SOURCE OF (SUP DAT)
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT
AND HIGH VOLATILITY. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO
SOURCE OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMIN ALL IGNIT SOURCES. AVOID BRTHG OF VAPS.
KEEP LIQ OUT OF EYES. FLUSH W/LGE AMTS OF WATER. CONTAIN LIQ
W/SAND/EARTH. ABSORB W/SAND/NON-FLAMM ABSORB MATL & TRANSFER INTO
STEEL DRUMS FOR RECOVERY/D ISP. PVNT LIQ FROM ENTERING DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SHADE BETWEEN 40F & 110F.
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT.
AVOID PRLNG BRTHG OF VAP. USE W/ADEQ VENT.
Other Precautions:AVOID CONT W/EYES, SKIN, & CLTHG. TRAIN EMPLOYEES ON
ALL SPECIAL HNDLG PROC BEFORE THEY WORK W/THIS PROD. FOLLOW ALL
PREC INFO GIVEN ON CONTR LABEL, PROD BULLETINS & MFR SOLV CEMENTING
LITERATURE. ALL HNDLG EQUIP SHOULD BE ELEC GROUNDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATM LEVELS SHOULD BE MAINTAINED BELOW
ESTABLISHED EXPOS LIMS. IF AIRBORNE CONCS EXCEED THOSE LIMS, USE OF
NIOSH APPRVD ORG VAP CARTRIDGE RESP W/FULL FACEPIECE IS REC. THE
EFFECTIVENESS OF NIOSH APPRVD AIR-PURIFYING RESP IS LIMITED. (ING
6)
Ventilation:USE ONLY WITH ADEQUATE VENTILATION. PROVIDE SUFFICIENT
VENTILATION IN VOLUME & PATTERN TO KEEP CONTAMINANTS (ING 8)
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . IMPERVIOUS APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: TYPICAL 0.947 +/- 0.040. SOL IN WATER: SOLV PORTION
COMPLETELY SOLUBLE IN WATER; RESIN PORTION SEPARATES OUT. EXTING
MEDIA: RESIST FOAM, WATER SPRAY. FIRE FIGHT PROC: IGNITION & TO
DISPERSE VAPS. EFTS OF OVEREXP: ELEVATION OF SGPT SUGGESTS DISTURB
IN LIVER FUNCTION. THE NOEL WAS REPORTED TO BE 200 PPM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:151F,66C
Vapor Pres:143 @ 20C
Vapor Density:2.49
Spec Gravity:SUP DAT
Evaporation Rate & Reference:>1.0 (BUTYL ACETATE=1)
Solubility in Water:SUP DAT
Appearance and Odor:WHITE, OPAQUE GRAY OR CLEAR, MEDIUM SYRUPY LIQUID;
ETHEREAL ODOR
Percent Volatiles by Volume:80-85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG
OXIDIZERS AND ISOCYANATES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME
AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:WHEN FORCED TO BURN, THIS PRODUCT
GIVES OUT CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND
SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE & FEDERAL REGULATIONS.
CONSULT DISPOSAL EXPERT. CAN BE DISPOSED OF BY INCINERATION.
EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS. EMPTY
CONTAINERS SHOULD BE AIR DRI ED BEFORE DISPOSING. HAZARDOUS WASTE
CODE: 214.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 25-114, DL PERMATEX PUMICE FORMULA FAST (SUPP DATA)
Cage: 7K128
=======================================================
Contractor Summary
=======================================================
Cage: 7K128
Cage: 08028
=======================================================
Ingredients
=======================================================
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 65-75
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68647-72-3
% Wt: 10-15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1332-09-8
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68154-97-2
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 102-71-6
RTECS #: KL9275000
% Wt: 0.1-1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL,RAT) >5,000 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NONE UNDER NORMAL CONDITIONS OF USE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INGEST: DO NOT INDUCE VOMITING. CALL PHYSICIAN IMMEDIATELY. INHAL:
REMOVE TO FRESH AIR. IF SYMPS PERSIST, OBTAIN MEDICAL ATTN. SKIN: FLUSH WITH
WATER. EYE: FLUSH WITH WATER FOR AT LEAST 15 MIN. CALL P HYSICIAN
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RINSE AWAY WITH WATER OR WIPE UP WITH A TOWEL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOLLOW EPA, LOCAL, STATE & FEDERAL REGULATIONS.
DISPOSE OF UNCONTAMINATED MATERIAL THROUGH SEWAGE SYSTEM WITH PERMISSION OF
THE AUTHORITY RESPONSIBLE FOR THAT SYSTEM.
Handling And Storage Precautions: STORAGE: HAND CLEANER SHOULD BE STORED
BETWEEN 40-100F IN ORDER TO ENSURE LONG LIFE OF THE EMULSION.
Other Precautions: HANDLING: FOLLOW ALL GENERAL SAFETY PRECAUTIONS. KEEP AWAY
FROM CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 193F,89C
Extinguishing Media: CO*2 AND DRY CHEMICAL POWDER.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: SOME LOCAL VENTILATION MAY BE DESIRED FOR EXPOSURE IN CONFINED
AREAS.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR TRADE NAME/PART NO: ORANGE NATURAL CITRIS
HAND CLEANER.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.03
PH: 5.5
Solubility in Water: SOLUBLE
Appearance and Odor: WHITE LOTION WITH PUMICE, ORANGE SCENT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: IRRITATING ORGANIC VAPORS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 42029
Product ID: 25-114, DL PERMATEX PUMICE FORMULA FAST (SUPP DATA)
Review Date: 04/26/1994
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: XXX
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: XXX
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: XXX
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: XXX
=======================================================
HAZCOM Label
=======================================================
Product ID: 25-114, DL PERMATEX PUMICE FORMULA FAST (SUPP DATA)
Cage: 7K128
Company Name: LOCTITE CORP
Street: 705 N MT RD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 04/26/1994
Status Code: C
Label Date: 04/26/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: STORE BETWEEN 40F AND 100F. ACUTE: NONE LISTED BY
MANUFACTURER. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-444-1117
Product ID: COUNTER ASSAULT OC-10 (SEE ADDL DATA)
Cage: 082C9
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: PEPPER SPRAY
Unit of Issue: BX
Quantitative Expression: 00000000012EA
UI Container Qty: 0
Type of Container: BOX/CANISTERS
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT PROVIDED
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Effects of Exposure: EYES: PRODUCT IS AN EYE IRRITANT. TEARING AND REDNESS MAY
OCCUR. SKIN: IRRITANT.
Explanation Of Carcinogenicity: NOT PROVIDED
Signs And Symptions Of Overexposure: EYES: PRODUCT IS AN EYE IRRITANT. TEARING
AND REDNESS MAY OCCUR. SKIN: IRRITANT.
Medical Cond Aggravated By Exposure: NOT PROVIDED
First Aid: EYES: REMOVE CONTACT LENSES. FLUSH EYES WITH LARGE QUANTITIES OF
WATER. TIP: IMMERSE FACE AND OPEN EYES IN BASIN OF WATER. SKIN CONTACT: WASH
AFFECTED AREA WITH SOAP AND WATER . AVOID TRANSFER TO MORE SENSITIVE AREAS.
WASH CONTAMINATED CLOTHING BEFORE REUSE. DO NOT APPLY SALVES OR OTHER SKIN
DRESSING WHICH MAY TRAP THE PEPPER AGAINST THE SKIN. INHALATION: MOVE SUBJECT
TO FRESH AIR. INGESTION: SEVE RE HEARTBURN SENSATION MAY CAUSE NAUSEA. IF
IRRITATION PERSISTS, CONSULT A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA. AVOID PROLONGED BREATHING OF VAPORS.
CONFINE SPILL WITH INERT ABSORBERS. WEAR PROTECTIVE EQUIPMENT DURING CLEAN
UP. KEEP OUT OF SEWERS, STORM DRAINS, SURFACE WATER AND SOIL.
Neutralizing Agent: NOT PROVIDED
Waste Disposal Methods: INCINERATE IN AN APPROVED INCINERATOR OR DISPOSE IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, DRY AREA, AWAY FROM HIGH
TEMPERATURES. WHEN STORING LARGE QUANTITIES, STORE IN BUILDING DESIGNED AND
PROTECTED AGAINST FIRE. DO NOT STORE IN DIRECT SUNLIGHT OR ABOVE 120 F.
Other Precautions: DO NOT TAKE INTERNALLY. IF INGESTED, DO NOT INDUCE VOMITING.
CONSULT A PHYSICIAN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONFLAMMABLE
Lower Limits: NOT EST.
Upper Limits: NOT EST.
Extinguishing Media: THIS MATERIAL IS NON-FLAMMABLE. CARBON DIOXIDE,
(ALCOHOL-FOAM), DRY CHEMICAL OR WATER MAY BE INEFFECTIVE. USE WATER TO
DISPERSE FUMES, AND TO DILUTE SPILLS.
Fire Fighting Procedures: IT IS RECOMMENDED THAT FIREFIGHTERS SHOULD WEAR NIOSH
APPROVED, SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
USE WATER SPRAY TO COOL NEARBY CONTAINERS AND STRUCTURES EXPOSED TO FIR E.
Unusual Fire/Explosion Hazard: DO NOT EXPOSE TO HEAT OR FLAME, OR STORE ABOVE
120 DEGREES F (49 DEGREES C) AS HIGH INTERNAL PRESSURES MAY CAUSE CYLINDERS
TO RUPTURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED CHEMICAL/MECHANICAL TYPE FILTER
SYSTEM TO REMOVE A COMBINATION OF PARTICLES, GAS AND VAPORS. USE AIR LINE, IF
NECESSARY.
Ventilation: USE ADEQUATE VENTILATION IN VOLUME & PATTERN TO KEEP PEL/TLV
BELOW RECOMMENDED LEVEL. GENERAL MECHANICAL VENTILATION SHOULD COMPLY WITH
OSHA 1910.94.
Other Protective Equipment: PREVENT PROLONGED SKIN CONTACT TO CONTAMINATED
CLOTHING.
Work Hygienic Practices: NOT PROVIDED
Supplemental Safety and Health: NONE
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V2
NRC/State LIC No: NOT RELEVANT
Boiling Point: -26.5C, -15.7F
B.P. Text: PROPELLANT
M.P/F.P Text: NOT PROVIDED
Decomp Text: NOT PROVIDED
Vapor Pres: APPROX 96 LBS @ 70F
Vapor Density: >1 (AIR=1)
Spec Gravity: <1 (WATER=1)
Viscosity: NOT PROVIDED
Evaporation Rate & Reference: NOT PROVIDED
Solubility in Water: 50% APPROX.
Appearance and Odor: REDDISH BROWN, PUNGENT ODOR.
Percent Volatiles by Volume: 90 APPROX
Corrosion Rate: NOT PROVIDED
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, OPEN FLAMES, WELDING ARC OR OTHER HIGH
TEMPERATURE SOURCES WHICH MAY INDUCE THERMAL DECOMPOSITION.
Materials To Avoid: STRONG ACIDS, ALKALIS, OXIDIZING MATERIALS, SODIUM,
POTASSIUM, AND MAGNESIUM
Hazardous Decomposition Products: NOT PROVIDED
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NOT PROVIDED
=======================================================
Ecological Information
=======================================================
Ecological: ZERO OZONE DEPLETING POTENTIAL (DOES NOT CONTAIN CHLORINE).
NEGLIGIBLE GLOBAL WARMING POTENTIAL.
=======================================================
=======================================================
Transport Information: DOT SHIPPING CLASS: ORM-D CONSUMER COMMODITY.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NOT PROVIDED
Federal Regulatory Information: NOT PROVIDED
State Regulatory Information: NOT PROVIDED
=======================================================
Other Information
=======================================================
Other Information: NONE
=======================================================
Transportation Information
=======================================================
Trans ID NO: 153300
Product ID: COUNTER ASSAULT OC-10 (SEE ADDL DATA)
Review Date: 08/28/2000
Tech Entry NOS Shipping Nm: (SOLVENT, ACTIVE INGREDIENT)
Net Unit Weight: 12 X 15 OZ
Multiple KIT Number: 0
Unit Of Issue: BX
Container QTY: 0
Type Of Container: BOX/CANISTERS
Additional Data: CONTD FROM PRODUCT ID: PSL230. PER 1999 IATA REGULATIONS,
N.O.S. IS NO LONGER USED. DOT CODE PER MSD S.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKD
IMO Proper Shipping Name: AEROSOLS o
IMDG Page Number: 2102
UN Number: 1950
UN Hazard Class: 2(T)
IMO Packaging Group: -
Subsidiary Risk Label: T
EMS Number: 2-13
MED First Aid Guide NUM: 620
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ANB
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, NON-FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.2
IATA Label: NON-FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75 KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ANB
AFI Proper Shipping Name: AEROSOLS, NON-FLAMMABLE, N.O.S.
AFI PSN Modifier: ,(EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.2
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: COUNTER ASSAULT OC-10 (SEE ADDL DATA)
Cage: 082C9
Company Name: COUNTER ASSAULT
Street: 120 INDUSTRY CT
Zipcode: 59901
Label Required IND: Y
Date Of Label Review: 08/28/2000
Status Code: C
MFG Label NO: NOT PROVIDED
Label Date: 02/01/2000
Year Procured: 2000
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: NONE PROVIDED. WARNING: SEVERE IRRITANT
AFFECTING EYES, SKIN AND RESPIRATORY AREAS. KEEP OUT OF REACH OF CHILDREN. IN
CASE OF EXTERNAL CONTACT, FLUSH THOROUGHLY WITH WATER. DO NOT RUB. IF
SYMPTOMS PERSIST AFTER 45 MINUTES, CALL PHYSICIAN. CONTENTS UNDER PRESSURE.
DO NOT STORE ABOVE 120F NOR BELOW 32F. ACTIVE INGREDIENT: 10% OLEORESIN
CAPSICUM, RED PEPPER DERIVATIVE.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:330210 PARA-PAK BUFFERED 10% FORMALIN FIXATIVE
CAGE:8X084
CAGE:8X084
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *96-4*
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 4%
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *96-4*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION:
DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, UNCONSCIOUSNESS, NAUSEA,
VOMITING.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR 15 MINS. INHALATION: REMOVE TO
FRESH AIR. GIVE CPR IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING AREAS.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON PAPER, VERMICULITE.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T EXCEED TLVS. CONTAINERS
POTENTIALLY HAZARDOUS WHEN EMPTY. DON'T REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED RESPIRATOR IF TLVS ARE
EXCEEDED.
Ventilation:GENERAL MECHANICAL VENTILATION IS USUALLY ADEQUATE UNDER
NORAMAL USE.
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
PH: 6.8-7.2.
================== Physical/Chemical Properties ==================
pH:(SUPP)
Solubility in Water:UNLIMITED
Appearance and Odor:COLORLESS LIQUID W/PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Hazardous Decomposition Products:CO2, WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:25150/X3S20 XYLENES 96% MIXED ISOMERS W/ETHYL BENZENE
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *97-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 100%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 4300 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION/DERMATITIS, ABSORPTION IS SLIGHT. INGESTION: CNS
DEPRESSION, KIDNEY & LIVER DAMAGE. GI IRRITATION, ASPIRATION OF
MATERIAL INTO THE LUNGS MAY CAUSE CHEMICAL PN EUMONITIS WHICH CAN
BE FATAL. INHALATION: CNS EFFECTS/RESPIRATORY TRACT IRRITATION,
CHEMICAL PNEUMONITIS/PULMONARY EDEMA
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, DRYNESS, INFLAMMATION,
HEADACHE, EXCITEMENT, FATIGUE, NAUSEA, VOMITING, STUPOR, COMA,
DIARRHEA, DIZZINESS, UNCONSCIOUSNESS, WEAKNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: ASPIRATION HAZARD.
DON'T INDUCE VOMITING. IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF
MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:77F
Lower Limits:1.1
Upper Limits:7
Extinguishing Media:SMALL: DRY CHEMICAL, CO2, WATER
SPRAY/ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS. WEAR A SCBA/MSHA/NIOSH APPROVED/EQUIVALENT & FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:VAPORS CAN TRAVEL TO A SOURCE OF IGNITION
& FLASH BACK. AUTOIGNITION TEMP: 860F.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL THEN PLACE INTO A
CHEMICAL WASTE CONTAINER. REMOVE SOURCES OF IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
STORE IN A COOL, DRY, WELL VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:USE W/ADEQUATE VENTILATION. AVOID CONTACT W/EYES,
SKIN/CLOTHING. AVOID INGESTION & INHALATION. KEEP FROM CONTACT
W/OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR
W/AN ORGANIC VAPOR CARTRIDGE/CANISTER MAY BE PERMISSIBLE WHERE
AIRBORNE CONCENTRATIONS ARE EXPECTED.
Ventilation:GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATIONS BELOW
EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:284F
Melt/Freeze Pt:M.P/F.P Text:-52.6F
Vapor Pres:21
Vapor Density:3.66
Spec Gravity:0.862
Evaporation Rate & Reference:(BU AC = 1): 0.6
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR COLORLESS LIQUID W/AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE MATERIALS, STRONG ACIDS, STRONG OXIDIZERS, PLASTICS,
RUBBER & COATINGS.
Stability Condition to Avoid:HIGH TEMPS, IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IONAC C-267,NA-38
CAGE:76465
CAGE:0RY73
CAGE:76465
============= Composition/Information on Ingredients =============
Ingred Name:SULFONATED COPOLYMER OF STYRENE AND DIVINYLBENZENE
CAS:69011-20-7
Fraction by Wt: 50 - 60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40 - 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE- MAY
CAUSE EYE IRRITATION. SKIN CONTACT MAY CAUSE IRRITATION IN
SENSITIVE INDIVIDUALS. ESSENTIALLY NON-TOXIC BY INGESTION.
INHALATION IS UNLIKELY. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDDENING AND ITCHING OF SKIN
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYE/SKIN:FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALED:UNLIKELY.
ORAL: GET MEDICAL ATTENTION IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. AVOID EYE CONTACT.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP SPILL. AVOID CREATING DUST.
PLACE IN APPROPRIATE CONTAINER FOR DISPOSAL. VENTILATE AREA AND
WASH SPILL SITE AFTER PICKUP IS COMPLETE.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG OXIDIZING
AGENTS. KEEP CONTAINER TIGHTLY CLOSED. AVOID FREEZING OR PROLONGED
STORAGE ABOVE 50C/122F (CONTAINS WATER).
Other Precautions:DO NOT RAISE DUST. AVOID CONTACT WITH EYES, SKIN OR
CLOTHING. AVOID INHALATION OF DUST. WASH THOROUGHLY AFTER HANDLING
MATERIAL. KEEP OUT OF REACH OF SMALL CHILDREN. DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF AIRBORNE
CONCENTRATION IS HIGH, WEAR A NIOSH-APPROVED DUST RESPIRATOR OR
DUST MASK.
Ventilation:ROOM VENTILATION IS SUFFICIENT UNDER NORMAL OFFICE
CONDITIONS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING AND/OR UNIFORM
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
DIFFERENT FORMULA. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:17 (WATER)
Vapor Density:0.62;WATER
Spec Gravity:1.3
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:SPHERICAL BEADS - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRIC ACID
Stability Condition to Avoid:FREEZING, HEATING ABOVE 50C/122F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
STYRENE AND DIVINYLBENZENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. PRODUCT IS NOT HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AS9174000 EA 934NA SYSTEM
Kit Part:Y
CAGE:33150
CAGE:33564
CAGE:33150
============= Composition/Information on Ingredients =============
Ingred Name:DIMER FATTY ACIDS, TALL OIL FATTY ACIDS,
TRIETHYLENETETRAMINE POLYMER
CAS:68082-29-1
Fraction by Wt: 40-70%
Ingred Name:DIETHYLENETRIAMINE, ETHYLENEDIAMINE, N-(2-AMINOETHYL)
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 10-30%
Other REC Limits:4 MG/CUM
ACGIH TLV:1 PPM (SKIN)
Ingred Name:TRIETHYLENETETRAMINE, EPOXY HARDNER
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: 5-10%
Ingred Name:VOLATILE ORGANIC CONTENT: <10 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >2000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. MATERIAL IS
CORROSIVE. BRIEF CONTACT MAY CAUSE CHEMICAL BURNS.
PROLONGED/REPEATED CONTACT MAY RESULT IN BURNS & POSSIBLE ALLERGIC
SENSITIZATION. INHALATION: VAPORS & MISTS WILL IRRITATE NOSE &
THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, IRRITATION, CHEST DISCOMFORT.
Medical Cond Aggravated by Exposure:SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LOTS OF RUNNING WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DRINK PLENTY OF WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, HALON, WATER SPRAY, FOAM/FOG
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING, SUCH AS
TURN OUT GEAR. CARTRIDGE RESPIRATORS DON'T PROVIDE ADEQUATE
PROTECTION FOR FIRE FIGHTERS/EXOTHERM MITIGATION.
Unusual Fire/Explosion Hazard:MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASSES.
================== Accidental Release Measures ==================
GLASSES. ABSORB W/ABSORBENT MATERIAL SUCH AS VERMICULITE/SAND.
SCRAPE UP/SHOVEL INTO DOT-APPROVED WASTE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT MAY BE STORED AT ROOM TEMP FOR
UP TO 12 MONTHS. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:DON'T CUT, GRIND, WELD/DRILL ON/NEAR THIS CONTAINER.
EMPTY CONTAINERS RETAIN PRODUCT RESIDUE, HANDLE EMPTY CONTAINERS AS
IF THEY WERE FULL. AVOID MIXING CURING AGENT IN BATCHES GREATER
THAN 1 POUND. D ON'T HEAT MIXED ADHESIVE >125F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR EQUIPPED W/ORGANIC VAPOR CARTRIDGE
MAY BE APPROPRIATE.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS/CHEMICAL
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:405F
Vapor Pres:0
Vapor Density:>1
Spec Gravity:0.96
Solubility in Water:100%
Appearance and Odor:AMBER LIQUID W/AMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, TEMP >125F.
Hazardous Decomposition Products:CO, NITROGEN OXIDES, ALDEHYDES, ACIDS
& UNDETERMINED ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IN AN EPA APPROVED WASTE
INCINERATOR IS PREFERRED IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACETYLENE, ETHYNE, ETHINE
CAGE:00742
CAGE:00742
CAGE:5H199
============= Composition/Information on Ingredients =============
Ingred Name:ACETYLENE
CAS:74-86-2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:ACETYLENE IS CLASSIFIED AS A SIMPLE
ASPHYXIANT AND HAS NO TLV.
Effects of Overexposure:HEADACHES, DIZZINESS, SHORTNESS OF BREATH, AND
LOSS OF CONSCIOUSNESS MAY OCCUR IF THE GAS IS PRESENT IN
QUANTITIES TO DILUTE THE OXYGEN CONCENTRATION IN AIR. SYMPTOMS OF
ANOXIA OCCUR ONLY WHEN THE G AS CONCENTRATIONS ARE WITHIN THE
FLAMMABLE RANGE & THE MIXTURE HAS NOT IGNITED.
======================= First Aid Measures =======================
First Aid:FIRST DEGREE & MINOR SECOND DEGREE THERMAL BURNS FROM FIRES
SHOULD BE IMMERSEDIN COOL WATER FOR 30 MINUTES.MAJOR BURNS SHOULD
BE COVERED IN CLEANEST MATERIAL AVAILABLE. SEEK IMMEDIATE AID OF
PHYSICI AN.PERSONS SUFFERING FROM LACK OF OXYGENSHOULD BE MOVED TO
AREAS W/NORMAL ATMOSPHERE. ASSISTED RESPIRATION AND SUPPLEMENTAL
OXYGEN SHOULD BE GIVEN IF VICTIM IS NOT BREATHING.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:OF / -18C
Autoignition Temp:Autoignition Temp Text:***
Lower Limits:100
Upper Limits:2.5
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON
Fire Fighting Procedures:STOP GAS FLOW/FIGHT FIRE CONVENTIONALLY. USE
WATER SPRAY TO KEEP CYLINDERS/OTHERCONTAINERS COOL IF EXPOSED TO
FIRE.KEEP PERSONNEL AWAY SINCE CONTNR CAN RUPTURE.
Unusual Fire/Explosion Hazard:IT BURNS W/INTENSELY HOT FLAME.POTENTIAL
EXPLOSION HAZARD EXISTS FROM REIGNITIONIF FIRE IS EXTING. W/O
SHUTTING OFF ACETYLENE SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT FLAMMABLE MIXTURE
FROM FORMING. REMOVE SOURCES OF IGNITION,HEAT,SPARKS, ETC.
CAREFULLY REMOVE CYLINDERS W/SLOW LEAK TO A REMOTE OUTDOOR
LOCATION. AVOID ENTERING AREA OFFLAMMABLE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE SUITABLE HANDTRUCK.ALWAYS
OPEN/CLOSE ACETYLENEVALVES SLOWLY.KEEP CYLINDERS AWAY FROM HEAT
SOURCESTORAGE SHOULD NOT BE IN HEAVY TRAFFIC AREAS.
Other Precautions:SEGREGATE FULL & EMPTY CYLINDERS. KEEP ACETYLENE
CYLINDERS STORAGE AREAS AWAY FROM OXYGEN AND OTHER OXIDIZERS.
AVOID DRAGGING,ROLLING,OR SLIDING CYLINDERS. AVOID EXPOSURE TO
AREAS WHERE SALT OR OT HER CORROSIVE CHEMICAL ARE PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OXYGEN DEFICIENT ATMOSPHERES ARE IN THE
FLAMMABLE RANGE. DO NOT ENTER!! RESPIRATORS WILL NOT
FUNCTION.
Ventilation:NATURAL OR MECHANICAL WHERE GAS IS PRESENT. MECHANICAL
VENTILATION FOR ENCLSD AREA MUST MEET NEC REQMENTS FOR CL1,GRP4.
Other Protective Equipment:LEATHER SLEEVES, LEATHER APRON AND OTHER
STANDARD PROTECTIVEEQUIPMENT FOR CUTTING AND WELDING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:**SEE BELOW
Vapor Pres:590 PSIA
Vapor Density:1 ATM.0681
Spec Gravity:1 ATM 0.906
Solubility in Water:1ATM1.0CUFT/CUFTH2O
Appearance and Odor:PURE: COLORLESS & ODORLESS; IMPURITIES IMPART A
CHARACTERISTIC GARLIC LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
OXYGEN & HALOGENS. FORMS EXPLOSIVE COMPOUNDS W/COPPER,BRASS,COPPER
SALTS, HG & HG SALTS,AG & AG SALTS, & HNO3.
Stability Condition to Avoid:NEVER UTILIZE FREE GAS OUTSIDE CYLINDER AT
PRESS. <15PSIG. AVOID MECH. SHOUCKS TO CONTNR.NEVER EXPOSE
CYLINDER TO HEAT.
Hazardous Decomposition Products:ACETYLENE WILL DECOMPOSE INTO
ELEMENTAL CARBON AND HYDROGEN UNDER THE ABOVE CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIFUAL GASEOUS
ACETYLENE IN CYLINDERS. RETURN TO AIR PRODUCTS FOR DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EP-654 HARDENER
Kit Part:Y
Preparer's Name:RICHARD L. WHEELER
CAGE:IO099
CAGE:22156
CAGE:IO099
============= Composition/Information on Ingredients =============
Ingred Name:MERCAPTAN MIXTURE
Ingred Name:SUPP DATA: VICTIM'S THROAT. KEEP VICTIM'S HEAD BELOW HIPS
WHILE VOMITING. GET MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SPILL TO PVNT SPREADING.PUMP LIQ TO SALVAGE
TANK. REMAINING LIQ SHOULD BE ABSORB W/VERMICULITE, SAND, (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: SWEEPING CMPD/OTHER ABSORB MATL. SHOVEL INTO CLSD
CNTNRS. PVNT RUNOFF TO SEWERS, STREAMS/OTHER BODIES OF (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: WATER. IF RUNOFF OCCURS, NOTIFY PROPER AUTHORITIES
AS REQUIRED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL) <5,000 MM/KG & >500 MM/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: SHORT SINGLE EXPOSURE MAY CAUSE
A SEVERE BURN AND ALSO MAY CAUSE SIGNIFICANT SENSITIZATION OR
ALLERGIC RESPONSE. MAY BE ABSORBED IN MODERATELY TOXIC AMOUNTS.
EYES: MAY CAUSE SEVERE BURN WITH POS SIBLE LOSS OF VISION.
INHALATION: HAS ADISAGREEABLE ODOR. INGESTION: MAY CAUSE BURNS OF
MOUTH, ESOPHAGUS, POSS STOMACH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:WE DO NOT KNOW OF ANY MEDICAL
CONDITIONS THAT MIGHT BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
THIS PRODUCT, AS WITH ANY CHEMICAL, MAY ENHANCE EXISTING ALLERGY
CONDITIONS ON CERTAIN PEOPLE.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH IMMED W/PLENTY OF H*2O,FOLLOWED BY THORO SOAP &
H*2O WASH.REMOVE & WASH CONTAM CLTHG BEFORE REUSE. CONTAM LEATHER
GOODS SHOULD BE DISCARDED AS THEY CANNOT BE DECONTAM. EYE: IMMED
FLUSH W/L RG AMT OF H*2O FOR AT LST 15 MIN, LIFTING UPPER & LOWER
LIDS OCCAS. GET IMMED MED ATTN. INHAL: REMOVE TO FRESH AIR IF EFTS
OCCUR. CONSULT PHYS. INGEST: DO NOT GIVE LIQ IF VICTIM IS
UNCON/VERY (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:CO*2, DRY CHEMICAL AND FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . ADDITIONS OF WATER WILL REDUCE BURNING RATE.
Unusual Fire/Explosion Hazard:NO UNUSUAL HAZARDS KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SML SPILLS:AVOID SKIN CONT.ABSORB LIQ IN
VERMICULITE, SAND, SWEEPING CMPD/OTHER ABSORB MATL & TRANSFER TO
CLSD CNTNR.LRG SPILLS: AVOID SKIN CONT. PERSONS NOT WEARING PROT
CLTHG SHOULD BE EXCLUDED FROM AREA. STOP SPILL AT SOURCE. DIKE
AREA OF (ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. AVOID EXCESSIVE
HEAT OR COLD. AVOID MOISTURE CONTAMINATION.
Other Precautions:DANGER! CAUSES SEVERE SKIN BURNS AND MAY BE HARMFUL
IF ABSORBED THROUGH SKIN. DO NOT GET ON SKIN OR CLOTHING. DANGER!
CAUSES SEVERE EYE BURNS. DO NOT GET IN EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONFINED SPACES, OR EMERGENCIES, A
NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS OR A
FULL-FACE RESPIRATOR IS RECOMMENDED.
Ventilation:PROD HAS AN OBJECTIONABLE ODOR, THEREFORE LOC EXHST IS
PREF. ROOM EXHST IS ACCEPTABLE IF VAP CONC ARE SUCH THAT (SUPDAT)
Other Protective Equipment:CLEAN, BODY COVERING CLTHG, INCL BOOTS
DEPENDING ON EXTENT & SEV OF EXPOS LIKELY.WASHING FACILITIES & EYE
WASH (SUPDAT)
Work Hygienic Practices:WASH THORO AFTER HANDLING. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE. CONTAM LEATHER GOODS SHOULD BE
DISCARDED.
Supplemental Safety and Health
VENT: ODOR IS ACCEPTABLE. OTHER PROT EQUIP: FOUNTAIN SHOULD BE
ACCESSIBLE IN WORK AREA. FIRST AID PROC: DROWSY. OTHERWISE, GIVE NO
MORE THAN 2 GLASSES OF H*2O & INDUCE VOMIT BY GIVING 2 TABLESPOONS
OFSYRUP OF IPECAC. IF IPECAC IS NOT AVAIL, GIVE 2 GLASSES OF H*2O
& INDUCE VOMIT BY TOUCHING FINGER TO BACK OF (ING 2)
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:1.11
Solubility in Water:SLIGHT (0.1 TO 1%)
Appearance and Odor:AMBER LIQUID, MERCAPTAN ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESSIVE HEAT OR MOISTURE CONTAMINATION.
Hazardous Decomposition Products:CO, NO*X, AND SO*X.
Conditions to Avoid Polymerization:WILL REACT EXOTHERMICALLY WHEN MIXED
WITH EPOXY RESINS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1586 SPEEDY DRY COATINGS
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *97-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 45-60%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 0-10%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, DIZZINESS, STAGGERING GAIT,
CONFUSION, UNCONSCIOUSNESS, COMA, IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE, RESTORE BREATHING. EYES:
FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:81F
Lower Limits:0.9
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:WEAR SCBA. WATER COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP, FOG NOZZLES PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM
HEAT & OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDING DESIGNED/PROTECTED FOR STORAGE OF NFPA CLASS
II FLAMMABLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. DON'T
TAKE INTERNALLY. EMPTY CONTAINERS MAY BE HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS: USE BUREAU OF MINES APPROVED
AIRLINE TYPE RESPIRATOR/HOODS.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV/LEL.
CONTACT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244-287F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID
Percent Volatiles by Volume:64-71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, ELECTRICAL EQUIPMENT,
SPARKS/OPEN FLAMES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DGV P-0731
Preparer's Name:KEITH FREY
CAGE:EO374
CAGE:EO374
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 8.00%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE TO ALL BODY TISSUES WHICH IT COMES IN
CONTACT WITH. INHALATION OF MIST/DUST MAY CAUSE DAMAGE TO
RESPIRATORY TRACT. MAY CAUSE PERMANE NT EYE INJURY. MAY CAUSE SKIN
BURNS. INGESTION CAN CAUSE BURNS & TISSUE PERFORATION. CHRONIC-
DERMATITIS, LUNG DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, NAUSEA, VOMITING, TEARING,
PAIN, EYE, LUNG AND SKIN DAMAGE, BLINDNESS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS SUCH AS ALLERGIES, ECZEMA MAY BE MORE SUSCEPTIBLE TO THE
EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET IMMEDIATE MEDICAL HELP FOR ALL CASES OF EXPOSURE.
EYES/SKIN: IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. HOLD
EYELIDS OPEN. INHALED: MOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NECESSARY. ORAL: DO N OT INDUCE VOMITING. IF CONSCIOUS, DRINKLARGE
AMOUNT OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO
PREVENT ASPIRATION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY FORM HYDROGEN GAS IF ALUMINUM OR ZINC
IS PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
ABSORB ON SAND, VERMICULITE OR SIMILAR MATERIAL. PLACE IN AN
APPROPRIATE CONTAINER FOR DISPOSAL. WASH CONTAMINATED SPILL AREA
WITH DILUTE MINERAL ACID AND WA TER. DO NOT FLUSH TO SEWERS OR
WATERWAYS.
Neutralizing Agent:DILUTE SULFURIC, NITRIC, HYDROCHLORIC OR PHOSPHORIC
ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA AWAY FROM
INCOMPATIBLES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DANGER! CORROSIVE. WASH THOROUGHLY WITH SOAP AND
WATER AFTER HANDLING AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT
OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY. DO NOT GET IN EYES OR
ON SKIN. DO NOT INHALE VAPORS OR SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. IF EXCESSIVE MISTING IS
EXPECTED, WEAR NIOSH-APPROVED VAPOR AND MIST RESPIRATOR (REFER TO
29 CFR 1910.134)
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
HCC PER TECHNICAL SUPPORT.
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.12
pH:ALKALI
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR TO YELLOWISH LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, FLAMMABLE LIQUIDS, CERTAIN METALS, ORGANIC HALOGENATED
COMPOUNDS, NITRO COMPOUNDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CONTRACT WITH A LICENSED WASTE DISPOSAL
FACILITY. IT MAY REQUIRE NEUTRALIZATION AND FILTERATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CURING AGENT 235-2
CAGE:22121
CAGE:22121
============= Composition/Information on Ingredients =============
Ingred Name:CURING AGENT; (ALIPHATIC AMINE CURING AGENT)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CORROSIVE. SEVERELY IRRITATING
TO THE EYES. SEVERE IRRRITATION OF SKIN. CHRONIC:PRE-EXISTING SKIN
AND EYE DISODERS MAY BE AGGRAVATED. ROUTES OF EXPOSURE:INHAL:VAPORS
ARE IRRITATING AND MAY CAUSE IRRITATION OF THE RESPIRATORY TRACT.
INGEST:MODERATE TOXICITY. MAY CAUSE BURNS OF MOUTH AND THROAT.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HEALTH HAZARDS:SKIN ABSORPTION:REPEATED OR
PROLONGED EXPOSURE MAY BE HARMFUL. EYE:MODERATE CORNEAL DAMAGE.
SKIN:MAY CAUSE CHEMICAL BURNS. MAY DEVELOP ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND EYE
DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. WASH FROM SKIN WITH SOAP
AND WATER. LAUNDER CLOTHING PRIOR TO RE-USE. EYES:FLUSH WITH WATER
FOR AT LEAST 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION . INHAL:REMOVE VICTIM TO FRESH AIR. ADMINISTER OXYGEN IF
NECESSARY. INGEST:DO NOT INDUCE VOMITING. GIVE LARGE DOSES OF
WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:AVOID BREATHING SMOKE. WEAR NIOSH/MSHA
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT . COOL FIRE EXPOSED
CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH LIQUID AND VAPORS. WIPE
WITH A CLOTH OR COLLECT ON ABSORBENT MATERIAL. LARGE SPILLS:DIKE
AND CONTAIN. PUMP OR SHOVEL INTO SALVAGE VESSELS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA IN TIGHTLY
CLOSED CONTAINERS. AVOID CONTACT WITH SKIN AND EYES. USE WITH
ADEQUATE VENTILATION.
Other Precautions:FOR INDUSTRIAL USE ONLY. CORROSIVE. MAY CAUSE SEVERE
EYE BURNS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXCESSIVE VAPORS OR TO MAINTAIN BELOW TLV
LIMIT. NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS IN
COMPLIANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST:YES. MECHANICAL (GENERAL):YES.
Other Protective Equipment:FOR PROLONGED EXPOSURE, IMPERVIOUS CLOTHING
AND BOOTS TO MINIMIZE PERSONAL CONTACT. EYE-WASH STATION, SAFETY
SHOWER.
Work Hygienic Practices:USE GOOD HYGIENE PRACTICES.
Supplemental Safety and Health
EYE PROT: AND FULL LENGTH FACE SHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>225F,>107C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:0.95 (H*2O=1)
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR VISCOUS LIQUID.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL OR ORGANIC ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:LARGE MIXTURES WITH EPOXY RESINS IN BULK.
CURING PROCESS IS EXOTHERMIC.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE WITH EPOXY RESIN, THEN BURY OR INCINERATE
WHERE PERMITTED BY FEDERAL, STATE AND LOCAL REGULATIONS. REMOVE
SALVAGE VESSELS TO A WASTE DISPOSAL SITE OPERATING IN COMPLIANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TANDEM-R HCG
Kit Part: Y
Cage: FO596
Box: 269006
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: FO596
Assigned Ind: Y
Box: 269006
=======================================================
Contractor Summary
=======================================================
Cage: 63493
Box: 269006
Cage: FO596
Box: 269006
=======================================================
Ingredients
=======================================================
Cas: 26628-22-8
RTECS #: VY8050000
% Wt: 0.1
Other REC Limits: 0.1 PPM
ACGIH TLV: C 0.29 MG/CUM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NONE
First Aid: EYES/SKIN: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH DRAINS W/COPIOUS AMOUNTS OF WATER TO PREVENT
AZIDE ACCUMULATION.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE. REFRIGERATE,
UNLESS OTHERWISE SPECIFIED IN KIT INSERT.
Other Precautions: AZIDE REACTS W/MANY HEAVY METALS SUCH AS LEAD, COPPER,
MERCURY, SILVER & GOLD TO FORM EXPLOSIVE COMPOUNDS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: DRY CHEMICAL
Unusual Fire/Explosion Hazard: CONTACT W/COPPER/LEAD DRAIN PIPES MAY RESULT IN
THE FORMATION OF POTENTIALLY EXPLOSIVE AZIDE DEPOSITS.
=======================================================
Control Measures
=======================================================
Other Protective Equipment: LAB COAT
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.85
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: ACIDS, HEAVY METALS; LEAD, COPPER, BROMINE, CARBON
DISULFIDE, CHROMYCHLORIDE, DIBROMO MALONITRILE, DIMETHYL SULFATE
Hazardous Decomposition Products: SODIUM & OXIDES OF NITROGEN
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TANDEM-R HCG
Cage: FO596
Assigned IND: Y
Company Name: HYBRITECH INCORPORATED
Street: 11095 TORREYANA ROAD
PO Box: 269006
Zipcode: 92126
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: N/K
N/K
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBON TETRACHLORIDE,ACS
CAGE:83628
CAGE:83628
============= Composition/Information on Ingredients =============
Ingred Name:CARBON TETRACHLORIDE (SARA III)
CAS:56-23-5
RTECS #:FG4900000
Fraction by Wt: 100%
OSHA PEL:10 PPM
ACGIH TLV:S,5PPM/10 STEL,A3 93
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Effects of
Overexposure:IRRITATES,EYES,NOSE,THROAT;HEADACHE,DIZZINESS,UPSETS
STOMACH, DERMATITUS
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR,KEEP PRONE &
WARM.INGESTION-INDUCE VOMITING WITH WARM SALT WATER.REPEAT UNTIL
VOMIT IS CLEAR. EYES-WASH WITH PLENTY WARM WATER CALL DOCTOR. GIVE
ARTIFICIAL RESPIRATION I F BREATHING IS DIFFICULT.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON FLAMMABLE:USE MEDIA SUITABLE FOR SURROUNDING
FIRE
Fire Fighting Procedures:SELF-CNTND BRTHG APP;H*2O SPRAY COOL CONT.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF
FIRE;TOXIC FUMES(PHOSGENE) MAY BE GENERATED BY FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. PROVIDE
VENTILATION. STOP LEAK. H*2O SPRAY COOL CONT(IF HOT). SM SPILL:
ABSORB W COMMERCIAL ABSORBENT, SHOVEL INTO METAL DRUMS; LG SPILL:
DIKE W COMMERCIAL ABSORBENT, PUM P INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:MAINTAIN STRICT HYGIENE, AVOID PHYSICAL CONTACT,
REMOVE & WASH CONTAMINATED CLOTHING. DO NOT BREATH FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSD TLV,NIOSH/MESA APPR SELF-CNTND BRTHG
APP (POS PR MODE)
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
ACGIH 1983-4 LIST A2:SUSPECT OF CARCINOGENIC POTENTIAL FOR MAN STORAGE
CODE T4 DESIGNATED DUE TO SUSPECTED RISKS UPON EXPOSURE TO THIS
CHEMICAL(1983-4 ACGIH)
================== Physical/Chemical Properties ==================
HCC:T3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=76.1C, 169.F
Vapor Pres:100
Vapor Density:5.49
Spec Gravity:1.597
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID-HEAVY ETHERAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXCESS WATER
Stability Condition to Avoid:IGNITION SOURCES,HOT SURFACES,OPEN
FLAME,ESCESS MOISTURE.
Hazardous Decomposition Products:PHOSGENE & HYDROCARBON
PRODUCTS;HYDROCHLORIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6294 DENT FILLER, COMPONENT B
Kit Part:Y
Preparer's Name:M WHEELOCK
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:DIBENZOYL PEROXIDE(SARA III)
CAS:94-36-0
RTECS #:DM8575000
Fraction by Wt: 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3--10 HR SHIFT
ACGIH TLV:5 MG/M3--10 HR SHIFT
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE IRRITATION, MINOR SKIN
IRRITATION. CHRONIC: NONE KNOWN.
Effects of Overexposure:EYES: MAY CAUSE EYE IRRITATION. SKIN: PROLONGED
SKIN CONTACT MAY CAUSE SKIN IRRITATION AND REDNESS. INHALATION: MAY
CAUSE IRRITATION OF THE NOSE, THROAT, AND LUNG. INGESTION: MAY
CAUSE TOXIC EFFECTS.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES &
CONTACT A PHYSICIAN. SKIN: WASH IMMEDIATELY WITH SOAP & WATER.
CONSULT A PHYSICIAN IF DISCOMFORT DEVELOPS. INHALATION: REMOVE TO
FRESH AIR. C ONSULT A PHYSICIAN IF DISCOMFORT PERSISTS. INGESTION:
ADMINISTER LARGE QUANTITIES OF WATER IF PERSON IS CONSCIOUS. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. IMMEDIAELY CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:WATER FOG OR SPRAY, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:EVACUATE AREA AND APPLY WATER FROM A SAFE
DISTANCE.
Unusual Fire/Explosion Hazard:PEROXIDES AND DECOMPOSIITON PRODUCTS ARE
FLAMMABLE AND CAN IGNITE WITH EXPLOSIVE FORCE IF CONFINED.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH SKIN. MATERIAL LEFT
UNCOVERED COULD INCREASE FIRE HAZARD DUE TO EVAPORATION OF WATER &
LEACHING OF PLASTICIZER AWAY FROM BENZOYL PEROXIDE. DIKE TO PREVENT
RUNOFF FROM ENTERING DRAIN S, SEWERS, STREAMS, ETC. TRANSFER INTO
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM ALL SOURCES OF HEAT AND
IGNITION SUCH AS RADIATORS, STEAM PIPES AND DIRECT SUNLIGHT. DO NOT
STORE NEAR COMBUSTIBLES.
Other Precautions:DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING. DO NOT
BREATHE VAPORS. KEEP CONTAINERS CLOSED. KEEP FROM FREEZING. EMPTY
CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED IF TLVS ARE EXCEEDED
Ventilation:MECHANICAL
Other Protective Equipment:EYE WASH STATION SHOULD BE AVAILABLE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Decomp Temp:Decomp Text:200F,93C
Spec Gravity:1.2+/- 0.15@77F
Viscosity:250,000 CPS
Solubility in Water:<1% @ 68F
Appearance and Odor:RED, SMOOTH PASTE / SLIGHT SWEET ODOR
Percent Volatiles by Volume:<20
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG ACIDS, STRONG ALKALIES, STRONG OXIDIZERS
Stability Condition to Avoid:AVOID STORAGE ABOVE 100F.
Hazardous Decomposition Products:ON DECOMPOSITION, BENOYL PEROXIDE CAN
PRODUCE FLAMMABLE AND TOXIC VAPORS AND BIPHENYL (TLV=0.2 PPM).
Conditions to Avoid Polymerization:IGNITION SOURCES, TEMPERATURES ABOVE
100F
==================== Disposal Considerations ====================
Waste Disposal Methods:CLEAN UP SMALL SPILLS OR RESIDUE WITH INERT
ABSORBENT. PLACE IN DOUBLE POLYETHYLENE BAGS. DISPOSE IN ACCORDANCE
WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHOTOSONIC SONICBRITE 300, 15 GAL
Preparer's Name:MR. MARSHALL
CAGE:63067
CAGE:63067
============= Composition/Information on Ingredients =============
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >70%
Ingred Name:POTASSIUM PHOSPHATE TRIBASIC, TRIPOTASSIUM PHOSPHATE
CAS:7778-53-2
Fraction by Wt: <30%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, CONJUNCTIVITIS.
SKIN: IRRITATION. INGESTION: IRRITATION TO MOUTH,
THROAT/GASTROINTESTINAL TRACT, NAUSEA, VOMITING/BURNS TO THE
ESOPHAGUS. INHALATION: IRRITATION TO NOSE/THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, CONJUNCTIVITIS. SKIN:
IRRITATION. INGESTION: IRRITATION TO MOUTH, THROAT/GASTROINTESTINAL
TRACT, NAUSEA, VOMITING/BURNS TO THE ESOPHAGUS. INHALATION:
IRRITATION TO NOSE/THROAT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH THE EXPOSED
AREA W/WATER. INGESTION: DRINK 2 TO 3 GLASSES OF WATER OR MILK.
DON'T NEUTRALIZE W/ACID. HEAT OF NEUTRALIZATION MAY GENERATE HEAT
THAT MAY RESULT IN PERFORATION. INHALATION: REMOVE FROM EXPOSURE.
IF BREATHING IS DIFFICULT. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE W/WEAK ACID. DILUTE W/LARGE AMOUNTS
OF WATER (1 + 10 RATIO). SEWER DISPOSAL MAY BE SUITABLE UNDER AN
APPROVED PERMIT.
Neutralizing Agent:WEAK ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE THIS PRODUCT AT ROOM
TEMPERATURE. READ INSTRUCTIONS BEFORE USING PRODUCT.
Other Precautions:CONTACT LENS WEARERS SHOULD WEAR REGULAR GLASSES
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:LOCAL EXHAUST/MECHANICAL: RECOMMENDED
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.22
pH:12.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL REGULATORY AGENCIES FOR
APPROPRIATE WASTE DISPOSAL METHODS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BONDAID ETCHANT S16943
CAGE:LO595
CAGE:97820
CAGE:LO595
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL DIMETHYL ETHER
Fraction by Wt: 86%.
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: 12%.
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SODIUM (SARA III)
CAS:7440-23-5
RTECS #:VY0686000
Fraction by Wt: 2%
===================== Hazards Identification =====================
Effects of Overexposure:HARMFUL IF SWALLOWED. AVOID PROLONGED EXPOSURE
TO SKIN; MAY BE IRRITATING. IRRITATING TO EYES.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD. EYES:IMMEDIATELY FLUSH W/WATER AT LEAST 15
MINUTES. CALL MD. SKIN:WASH THOROUGHLY W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point:158F OC
Extinguishing Media:DRY SODA ASH OR CO*2
Fire Fighting Procedures:DO NOT USE WATER OR CHEMICAL EXTINGUISHERS.
================== Accidental Release Measures ==================
Spill Release Procedures:IF POSSIBEL LEAVE SPILLED MATERIAL EXPOSED TO
AIR. IT WILL REACT W/ATMOSPHERIC MOISTURE AND LOSE STRENGTH. MFR
SUGGESTS WATER CAN BE ADDED CAREFULLY. THERE COULD BE A REACTION
W/SODIUM, CAUSING FLAMES & SPLASHING. WATER WILL RENDER MTRL
HARMLESS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN MOISTURE FREE AREA. DO NOT
STORE NEAR OPEN FLAME.
Other Precautions:CLOSE SCREW CAP TIGHTLY TO PROTECT FROM MOISTURE, TO
PROLONG PRODUCT SHELF LIFE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:GENERAL VENTILATION-YES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:324 F
Vapor Pres:3.
Spec Gravity:1.05
Appearance and Odor:BLACK,MILD COAL TAR-"MOTH BALL" ODOR.
Percent Volatiles by Volume:35.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER
Stability Condition to Avoid:CONTACT W/MOISTURE
==================== Disposal Considerations ====================
Waste Disposal Methods:AFTER BEING FULLY NEUTRALIZED W/WATER IT CAN BE
FLUSHED INTO THE SEWER, W/LARGE QUANTITIES OF WATER SUGGESTS MFR.
CHECK LOCAL EFFLUENT LAWS. DISPOSE IN ACCORDANCE W/LOCAL, STATE,
AND FEDERAL REGULATIO NS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:139 5508,EKTPRNT R-1000 COLR DEVLPR,PART C
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:HYDROXYLAMINE SULFATE;CAS #10039-54-0;(DISSOCIATES TO
SULFURIC ACID 5-10%);% WT 5-10%
CAS:10039-54-0
RTECS #:NC5425000
Fraction by Wt: 7.5%
Ingred Name:AQUEOUS SOLUTION,HAZARD INKNOWN,UNIDENTIFIED;% WT BY
DIFFERENCE 92.5%
Fraction by Wt: 92.5%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:CAUSES IRRITN;SKIN:MAY CAUSE IRRITN;
REPEATD CONTACT W/SKIN MAY CAUSE ALLRGIC REACTION/TOXIC.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O2 IF NEED;EYES:FLUSH W
LG AMTS H2O FOR 15 MIN;SKIN:FLUSH W LG AMTS H2O;INGEST: RINSE
MOUTH.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, FOAM, DRY CHEM.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS: LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:NONE KNOWN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS FM MFR DATED:1/30/79;THIS DATA DESCRIBES PART C OF 3 PART
PRODUCT;SEE P/N IND A & B FOR OTHER PARTS,SAME NSN;STORAGE CODE C1
ASSIGNED BECAUSE SOLN GIVES H2S04 ON DISSOCIATION;PH 3.5. KEY1:J1.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F/100C
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.08
Solubility in Water:COMPLETE
Appearance and Odor:PINK-PURPLE ODORLESS LIQUID.
Percent Volatiles by Volume:91.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PER MFR, NONE
Hazardous Decomposition Products:PER MFR, NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS. MFR NOTES,FLUSH
TO SEWER W/COPIOUS AMTS OF H2O IAW ALL EXISTING REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHCAST 2 CASTING TAPE -2",3",4",5" WIDT
CAGE:28156
CAGE:28156
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS GLASS
CAS:65997-17-3
Fraction by Wt: 55-60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 RDUST Z-3
ACGIH TLV:10 MG/M3(<7 MICRONS)
Ingred Name:ISOCYANATE TERMINATED URETHANE PREPOLYMER
Fraction by Wt: 30-35%
Other REC Limits:NONE SPECIFIED
Ingred Name:MODIFIED 4,4'-DIPHENYLMETHANE DIISOCYANATE (MDI)
CAS:26447-40-5
Fraction by Wt: 5-10%
Other REC Limits:0.02 PPM
Ingred Name:AMINE CATALYST
Fraction by Wt: 0.1-2.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACID CHLORIDE
Fraction by Wt: 0-0.5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTIOXIDANT
Fraction by Wt: 0-0.5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTIFOAM
Fraction by Wt: 0-0.5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 > 5G/KG INGESTION
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: PROLONGED CONTACT CAN CAUSE
SLIGHT IRRITATION. AVOID BREATHING OF VAPOR. MANUFACTURER REPORTS
THAN UNCURED MATERIAL IS NOT EXPECTED TO BE AN IRRITANT WHEN USED
AS DIRECTED. MATERIAL IS NOT EXPECTED TO BE AN
INHALATION/INGESTIONHAZARD; HOWEVER, AVOID BREATHING ISOCYANATE
VAPORS OR UNCURED MATERIAL CONTACT.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION OF EYES/SKIN/RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION:DRINK PLENTY OF WATER. DO NOT INDUCE
VOMIT ING. SEEK MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>220F,>104C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS INCLUDING OXIDES OF
NITROGEN AND CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:CURED PRODUCT MAY BE SCOOPED UP AND DISPOSED
AS ORDINARY SOLID WASTE. SOME UNCURED COMPONENTS MAY BE HAZARDOUS
- HANDLE WITH CARE.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER CLOSED WHEN NOT
IN USE. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:AVOID EXCESSIVE TEMPERATURE OF MATERIAL IN POUCH
(40-83F) RECOMMENDED FOR STORAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
AVOID EYE/SKIN CONTACT WITH UNCURED MATERIAL.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOWISH RESIN IMPREGNATED ON KNIT
FIBERGLASS/SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, WATER, ALKALI, STRONG BASES.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES,
MOISTURE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES AND OTHER POSSIBLE BYPRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CL HD RED PMS-185-HD
Preparer's Name:DICK KARBO
CAGE:KAMDD
CAGE:KAMDD
============= Composition/Information on Ingredients =============
Ingred Name:BENZENESULFONIC ACID,
5-CHLORO-2-(2-HYDROXY-1-NAPHTHALENYL)AZO-4-METHYL-, BARIUM SALT,
PIGMENT RED 53:1
CAS:5160-02-1
RTECS #:DB5500000
Ingred Name:BARIUM (SARA III)
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: 21%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/WATER UNTIL IRRITATION STOPS. SKIN: WASH
AFFECTED AREA W/SOAP & WATER. SEEK MEDICAL ASSISTANCE AS REQUIRED.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:FOR SMALL SPILLS: WIPE UP & STORE WIPERS IN
UNDERWRITERS APPROVED CONTAINERS. FOR LARGE SPILLS: SCOOP MATERIAL
INTO SEALABLE CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN
UNDERWRITERS APPROVED CONTA INERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS. AVOID
CONTACT W/SKIN, EYES, & CLOTHING. WASH HANDS AFTER USE. CHANGE
CLOTHING, IF CONTAMINATED.
Other Precautions:DON'T CONSUME FOOD OR BEVERAGE WHERE PRODUCT IS USED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL OPERATION
Ventilation:LOCAL EXHAUST: DESIRABLE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:DM SERIES
CAGE:4S875
CAGE:0FGN2
CAGE:1U269
CAGE:4S875
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 32-40%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 2140 MG/KG (H2SO4)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION OF
RESPIRATORY TRACT, EYES, SKIN OR GI TRACT. MAY CAUSE BURNS OF SKIN,
EYES, OR GI TRACT. MAY CAUSE CORNEAL DAMAGE OR BLINDNESS. CHRONIC:
TOOTH EROSION, INFLAMMATION OF NOS E, THROAT AND BRONCHIAL TUBES.
Explanation of Carcinogenicity:THE ELECTROLYTE IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: BURNING SENSATION IN NOSE, THROAT
AND LUNGS, COUGHING, WHEEZING, SHORTNESS OF BREATH. EYES: REDNESS,
TEARING, BLURRED VISION, BURNS, SEVERE PAIN. SKIN: SEVERE PAIN,
BURNS, REDNESS, RASH, I TCHING. INGESTION: BURNS OF MOUTH, THROAT,
AND ESOPHAGUS, SEVERE STOMACH PAIN, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE RESPIRATORY TRACT OR
TEETH MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET PROMPT MEDICAL ATTENTION.
SKIN :REMOVE CONTAMINATED CLOTHING. WASH WITHPLENTY OF WATER FOR 15
MINUTES. GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE VOMITING.
GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, FOAM, HALOGEN.
Fire Fighting Procedures:USE OF WATER IN EXTINGUISHING BURNING
BATTERIES MAY CAUSE SPATTERING DUE TO THE PRESENCE OF MOLTEN LEAD.
WEAR SCBA AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:AFTER ELECTROLYTE IS ADDED AND BATTERY IS
BEING CHARGED, HYDROGEN GAS IS PRODUCED. BATTERY MAY EXPLODE IF
HYDROGEN GAS TRAPPED INSIDE THE CASE SHOULD IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOULD A BATTERY BREAK OPEN, ISOLATE AREA.
ELECTROLYTE SHOULD BE ABSORBED WITH A NON-ORGANIC TYPE ABSORBENT
SUCH AS DRY SAND OR EARTH. AVOID DILUTION WITH WATER. LEAD SPILLED
FROM THE BATTERY SHOULD B E VACUUMED, DO NOT SWEEP OR USE
COMPRESSED AIR.
Neutralizing Agent:USE SODA ASH OR BAKING SODA TO NEUTRALIZE THE
ELECTROLYTE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID THE USE OF UNINSULATED TOOLS. IF
THEY ARE REQUIRED, TAKE CARE NOT TO ELECTRICALLY SHORT THE
TERMINALS. REMOVE METAL JEWELRY BEFORE SERVICING.
Other Precautions:UNDER NORMAL CONDITIONS OF USE, EXPOSURE TO LEAD OR
LEAD CONTAINING COMPOUNDS DOES NOT OCCUR. SHOULD A BATTERY BREAK
OPEN AND A LEAD SPILL OCCUR, PRECAUTIONS SHOULD BE TAKEN TO PREVENT
LEAD DUST FROM BECOMING AIR BORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL CONDITIONS OF USE, RESPIRATORY
PROTECTION IS NOT REQUIRED. HOWEVER, IF CONDITIONS ARISE THAT
REQUIRE THEIR USE, USE ONLY NIOSH/MSHA RESPIRATORS APPROVED FOR
DUST, FUME AND MIST.
Ventilation:BATTERY CHARGING AREAS MUST BE ADEQUATELY VENTILATED TO
PREVENT HAZARDOUS CONCENTRATIONS OF FLAMMABLE GAS OR ACID MIST.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE IMPERVIOUS WORK CLOTHING, BOOTS AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS MSDS REFLECTS DIFFERENT MFG PART OR SERIES DESIGNATOR FROM PART A
FOR THIS NSN (CAGE: YUASA). ALSO UPDATES CAGE FOR MANUFACTURER. RQ
FOR CERCLA AND SARA III IS 1000 LBS (ELECTROLYTE). MSDS WRITTE N
FOR ELECTROLYE- IT IS THE PRIMARY HAZARD DURING NORMAL USE AND
HANDLING.
================== Physical/Chemical Properties ==================
HCC:Z4
Boiling Pt:=95.C, 203.F
B.P. Text:203F,95C
Melt/Freeze Pt:M.P/F.P Text:-94F,-70C
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.25-1.29
pH:1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE (ACID)
Appearance and Odor:NO ODOR. BATTERY CASE IS SEALED. ELECTROLYTE IS
CLEAR OILY LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT OF ELECTROLYTE WITH ORGANIC MATERIAL AND COMBUSTIBLES, STRONG
ALKALIS, REDUCING AGENTS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:OVERCHARGING, SOURCES OF IGNITION
Hazardous Decomposition Products:SULFURIC ACID MIST, SULFUR DIOXIDE AND
CARBON MONOXIDE MAY BE RELEASED WHEN ELECTROLYTE DECOMPOSES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BOTH ELECTROLYTE AND SCRAP BATTERIES ARE
REGULATED HAZARDOUS WASTE. SCRAP BATTERIES CONTAIN MATERIALS WHICH
ARE RECYCLABLE AND MUST BE RETURNED TO AUTHORIZED RECYCLER.
ELECTROLYTE SHOULD BE HAULED TO A PERMITTED TREATMENT FACILITY.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: NITRIVER 3 NITRITE REAGENT
Cage: 4T252
Box: 389
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 4T252
Box: 907
=======================================================
Contractor Summary
=======================================================
Cage: 91224
Box: 389
Cage: 4T252
Box: 907
=======================================================
Ingredients
=======================================================
Cas: 36679-96-6
*98-1*
% Wt: 5
------------------------------
Cas: 7778-77-0
% Wt: 85
------------------------------
Cas: 515-74-2
% Wt: 15
------------------------------
Cas: 7790-62-7
% Wt: 10
------------------------------
Cas: 129-96-4
*98-1*
% Wt: 5
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: CORROSIVE, BURNS. SKIN: IRRITATION. INHALATION:
RESPIRATORY TRACT IRRITATION. INGESTION: MODERATELY TOXIC, CNS DEPRESSION
& KIDNEY DAMAGE.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNS, STOMACH DISTURBANCES,
HEARING PROBLEMS.
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN, HEART & KIDNEY
CONDITIONS.
First Aid: EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/PLENTY OF WATER.
INGESTION: DON'T INDUCE VOMITING. GIVE 1-2 GLASSES OF WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE T O FRESH AIR.
GIVE CPR IF NEEDED. OBTAINMEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SCOOP MATERIAL INTO A BEAKER & DISSOLVE W/WATER.
NEUTRALIZE TO A PH BETWEEN 6 & 9. FLUSH NEUTRALIZED WASTE TO DRAIN W/AN
EXCESS OF WATER.
Neutralizing Agent: ALKALI/SODA ASH.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE.
Other Precautions: AVOID CONTACT W/EYES & SKIN. DON'T BREATHE DUST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, CO2, DRY CHEMICAL.
Unusual Fire/Explosion Hazard: MAY EMIT TOXIC FUMES.
=======================================================
Control Measures
=======================================================
Ventilation: ADEQUATE
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: PH OF 5% SOLUTION: 3.2.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 435.2F
Spec Gravity: 3.12
PH: (SUPP)
Solubility in Water: COMPLETE
Appearance and Odor: SOLID WHITE POWDER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, MOISTURE.
Hazardous Decomposition Products: PHOSPHORUS OXIDES.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: NITRIVER 3 NITRITE REAGENT
Cage: 4T252
Company Name: HACH COMPANY
Street: 100 DAYTON RD.
PO Box: 907
Zipcode: 50010
Label Required IND: Y
Date Of Label Review: 08/11/1993
Status Code: C
Label Date: 08/11/1993
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: CORROSIVE TO EYES, WET SKIN & RESPIRATORY TRACT.
CAUSES BURNS TO MOIST TISSUES. MODERATELY TOXIC BY INGESTION. TARGET ORGANS:
EYES, SKIN, & RESPIRATORY TRACT. DIGESTIVE TRACTS,
LIVE R.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PR-1436 G SPRAYABLE #1436G168
Kit Part:Y
Preparer's Name:SEROJE HARTOONIANI
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM DICHROMATE (SARA 313) (CERCLA)
CAS:10588-01-9
RTECS #:HX7700000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 STEL
ACGIH TLV:0.05 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:DIMETHYL ACETAMIDE (VP = 2.0)
CAS:127-19-5
RTECS #:AB7700000
Fraction by Wt: 25.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM SKIN
ACGIH TLV:10 PPM SKIN
Ingred Name:CALCIUM DICHROMATE (SARA 313)
CAS:14307-33-6
RTECS #:HX7630000
Fraction by Wt: 20.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 STEL
ACGIH TLV:0.05 MG/M3 AS CR
Ingred Name:WATER (NON-HAZARDOUS)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: BURN/TEAR/RED/TRANSIENT CORNEA
INJURY. SKIN: HARMFUL/RAPID ABSORPTION. INHAL: LIVER/KIDNEY DAMAGE.
CHRONIC: MAY CAUSE PENETRATING ULCERS TO SKIN/MUCOUS MEMBRANES OF
NOSE/PERFORATION OF CARTILAGIN OUS NASAL SEPTUM
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LUKE WARM WATER FOR 15 MIN. CALL DR. SKIN: WASH
W/SOAP AND WATER. CALL DR. INHAL: REMOVE TO FRESH AIR. GET MED AID.
INGEST: CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE COMPLETE PERSONAL PROTECTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/COVER SPILL W/NONOXIDIZABLE ABSORBENT.
SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON RESIDUE. WORK
INTO RESIDUE. CLEAN AREA W/WATER. CERCLA RQ FOR SODIUM DICHROMATE
IS 10 LBS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN APPLYING IN ANY CIRCUMSTANCES LIKELY TO
PRODUCE AIRBOURNE LEVEL OF HAZARDOUS INGREDIENTS IN EXCESS OF TLV
USE ORGANIC VAPOR CARTRIDGE OR AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL TO MAINTAIN VAPORS BELOW PEL.
IMMERSION. PROTECT SKIN W/NITRILE/BUTYL, RUBBER OR POLYETHYLENE
APRON OR COVERALLS.
Work Hygienic Practices:AVOID ALL SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING/BEFORE SMOKING OR EATING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 331F
Vapor Density:>AIR
Spec Gravity:1.259
pH:NA
Viscosity:20 CP@10 RPM
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:SLIGHT
Appearance and Odor:BROWNISH YELLOW LIQUID
Percent Volatiles by Volume:86.7
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, CHROMIUM
COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA #D007 HAZ WASTE. DISPOSE IN COMPLIANCE
W/FEDERAL & STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBON RAISER 215
CAGE:4E133
CAGE:4E133
============= Composition/Information on Ingredients =============
Ingred Name:CALCINED PETROLEUM COKE
CAS:64743-05-1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DUST MAY BE ABRASIVE &
IRRITATING. INHALATION: OVEREXPOSURE TO DUST MAY RESULT IN CHRONIC
BRONCHITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, STINGING SENSATION, REDNESS,
COUGHING, SHORTNESS OF BREATH
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. EYES: WASH W/WATER TO WASH OUT
DUST. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CHEMICAL TYPE PREFERRED.
Fire Fighting Procedures:VENTILATION MAY BE REQUIRED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP/VACUUM.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED RESPIRATOR FOR NUISANCE DUST.
Ventilation:LOCAL EXHAUST: TO DUST COLLECTOR.
Other Protective Equipment:NONE
Work Hygienic Practices:KEEP WORK AREA CLEAN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.07
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY TO BLACK W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS; PERCHLORATES, PEROXIDES, NITRIC ACID,
ESPECIALLY WHEN HEATED.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO2/CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HEAT SHRINKABLE INTERCONNECTIONS WITH (SUPDAT)
Preparer's Name:DONNA SEID
CAGE:06090
CAGE:06090
============= Composition/Information on Ingredients =============
Ingred Name:BASE POLYMER MATERIALS (INCLUDING INGS 2-8)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYETHYLENE COPOLYMER
CAS:9010-77-9
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OLEFIN COPOLYMER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUOROPOLYMERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHLOROPOLYMERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYAMIDES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICONES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADHESIVE; (ADHESIVES/MASTICS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLDER (CONSISTING OF ING 11)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METALS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:PHOSPHORUS & SULFUR. COMBUST PRODS MAY BE TOX &
SHOULD NOT BE INHALED. AT TEMPS THAT MAY BE REACHED IN (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CASE OF FIRE, DEPENDING ON SOLDER, OXIDE
FUMES/PARTICULATES OF ANTIMONY, BISMUTH, LEAD, SILVER/TIN MAY BE
RELSD.
RTECS #:9999999ZZ
Ingred Name:FIRST AID: BRTHG DFCLTY DEVELOPS, O*2 SHOULD BE ADMIN BY
QUALIFIED PERS. SEEK IMMED MED ATTN. IF NOT BRTHG, (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: IMMED BEGIN ARTF RESP. KEEP WARM & QUIET; SEEK
IMMED MED ATTN.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: IS HEATED TO DECOMP, AS SHOWN BY
DARKENING & BROWNING OF SLEEVE. AVOID CNTCT W/MOLTEN MATL. (ING 17)
RTECS #:9999999ZZ
HANDLED AFTER INSTALLATION.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: FOLLOW APPROP MFR INSTALLATION INSTRUCTIONS &
APPLICATN GUIDES TO ENSURE INSTALLATION IS PERFORMED (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: PROPERLY. ENSURE ANY LOC REQS/LEGISLATION
CONCERNING USE OF HAND-HELD ELEC EQUIP ARE OBSERVED. WHEN (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:USING IR (INFRARED) HEATING DEVICES, OBSERVE
SPECIFIC INSTRUCTIONS. DO NOT TOUCH HOT SURFS ON INSTALLATION
EQUIP.
RTECS #:9999999ZZ
IS NEC TO HANDLE GROSSLY OVERHEATED OR FIRE-DAMAGED (ING 22)
RTECS #:9999999ZZ
CNTCT W/POTENTIALLY CORR INORGANIC ACID RESIDUES.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES/SKIN:CNTCT W/MOLTEN MATL
MAY CAUSE THERMAL BURNS. PROD IS NOT EXPECTED TO BE SKIN IRRITANT.
NO HARMFUL EFTS EXPECTED FROM SKIN ABSORPTION. INGEST:HIGHLY
UNLIKELY. THERE IS INSUFFICIENT INFO AVAIL ON MATL TO PREDICT EFTS
FROM INGEST. INHAL:IN COMMON W/MOST ORG MATLS, THERMAL DEGRADATION
& (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: COMBUST BYPRODS MAY BE TOX & SHOULD
NOT BE INHALED. CHRONIC: NOTE:PROD TESTING HAS SHOWN NO EXPOS TO
METAL FUMES FROM SOLDER PRESENT IN PRODS EVEN @ TEMPS WHERE THERMAL
DEGRADATION OF TUBING OCCURS. OVERHEATING PROD TO CHARRING/BURNING
MAY PRDCE VAPS THAT MAY CAUSE EYE, SKIN, NOSE & THROAT IRRIT.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE, SKIN
OR RESPIRATORY DISORDERS (EG ASTHMA CONDITIONS) MAY BE MORE
SUSCEPTIBLE TO THE EFFECTS OF THESE VAPORS.
======================= First Aid Measures =======================
First Aid:EYES:HOLD EYELIDS APART & FLUSH AFFECTED AREA(S) W/CLEAN
WATER FOR AT LEAST 15 MIN. SEEK MED ATTN. SKIN:AFTER HNDLG, IT IS
GOOD PRACT TO WASH HANDS. IF MOLTEN MATL CNTCTS SKIN, COOL AREA
IMMED IN WATE R. DO NOT ATTEMPT TO REMOVE MATL FROM SKIN. TREAT AS
BURN & SEEK MED ATTN. INGEST:IF SWALLOWED & SYMPS DEVELOP, SEEK MED
ATTN. INHAL:MOVE TO FRESH AIR. IF SYMPS PERSISTS, SEEK MED ATTN. IF
(ING 14)
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, WATER, DRY CHEMICAL, FOAM, DRY
POWDER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY EVOLVE IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND COLLECT IN SUITABLE CONTAINER FOR
DISPOSAL OR REUSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR PRODS CNTNG THERMOCHROMIC TEMP
INDICATOR, DISCONTINUE HEATING AFTER COLOR CHANGES FROM RED TO
COLORLESS. AVOID ANY VAPS GIVEN OFF IF PROD (ING 16)
Other Precautions:AVOID HEATING PRODS BEYOND TEMPS REQD FOR NORM
INSTALLATION. IF PROD CHARS/BURNS, IMMED STOP HEATING. AVOID INHAL
FUMES WHICH MAY EVOLVE UNDER SUCH CIRCUMSTANCES. ALLOW ANY VAPS TO
DISPERSE & VENT BEF ORE CONTINUING WORK IN AREA. (ING 18)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF INSTALLATION OCCURS IN A CONFINED,
UNVENTILATED AREA, NIOSH/MSHA APPROVED RESPIRATORS ARE RECOMMENDED.
Ventilation:IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE PRACTICE, ENSURE
ADEQUATE VENTILATION DURING INSTALLATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
OSHA, ANSI OR NIOSH GUIDELINES SHOULD BE FOLLOWED.
Work Hygienic Practices:DO NOT CONSUME FOOD, BEVERAGES OR TOBACCO IN
IMMED WORK AREA. WASH HANDS BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:SOLDER FOR HIGH TEMP WIRE. HAZ DECOMP
PRODS:COMBUST BYPRODS DEPEND ON BASE POLYMER USED & MAY INCL BUT
ARE NOT LIMITED TO, CO, CO*2, ALDEHYDES, ACETIC ACID, LOW MW
HYDROCARBS, SILICON DIOXIDE, HYDROGEN CHLORIDE, HYDROGEN FLUORIDE,
HYDROGEN BROMIDE, FLUORO-OLEFINS & OXIDES OF NITROGEN, (ING 12)
================== Physical/Chemical Properties ==================
Spec Gravity:6-11
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR OR BLUE TRANSPARENT PLASTIC SLEEVES WITH A
RING OF SOLDER INSERT; NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID OVERHEATING OF PRODUCT.
Hazardous Decomposition Products:AT TEMPS HIGHER THAN RECOM FOR PROPER
INSTALLATION, MOST SIGNIFICANTLY IF PROD BURNS, THERMAL DEGRADATION
& (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP OF I/A/W ALL LOC, STATE & FED REGS. IF
THERE ARE LOC REGS COVERING CONTROLLED INCIN OF HALOGENATED MATLS,
THEN ALL HALOGEN-CNTNG PRODS WILL BE SUBJECT TO SUCH REGS. REFER TO
PROD LITERATURE FOR I DENTIFICATION OF HALOGEN-CNTNG PRODS.
| 1 | eyes_protection_mandatory |